DODGE: ASPEN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Summary:

THE FRONT BRAKE HOSE ROUTING ON THE INVOLVED VEHICLES MAY ALLOW INTERFERENCE BETWEEN THE HOSES AND THE FRONT TIRES DURING EXTREME TURNING ANGLES.

Corrective Summary:

SPECIAL BRAKE HOSE RESTRAINING STRAPS WILL BE INSTALLED ON EACH INVOLVED VEHICLE TO RELOCATE BOTH FRONT HOSES AND ENSURE THAT ADEQUATE HOSE TO TIRE CLEARANCE IS MAINTAINED.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; BRAKE HOSES.CONSEQUENCES OF DEFECT: ABRASION RESULTING FROM SUCH INTERFERENCE COULD CAUSEHOSE FAILURE, LOSS OF FRONT BRAKING CAPABILITY AND AN ACCIDENT.NOTE: THE INSTRUMENT PANEL LIGHT PROVIDES WARNING OF PARTIAL BRAKE FAILURE.

DODGE: ASPEN: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Defect Summary:

ON THE INVOLVED VEHICLES, THE FUEL FILTER INLET, OUTLET, AND VAPOR RETURN FUEL LINE HOSES MAY DETERIORATE IF CONTINUOUSLY EXPOSED TO UNDERHOOD TEMPERATURES GENERATED DURING VEHICLE OPERATION. IF HOSES FAIL, FUEL LEAKAGE COULD OCCUR.

Corrective Summary:

DEALER WILL INSTALL HYPALON RUBBER HOSES TO REPLACE NEOPRENE HOSES, WITHOUT CHARGE TO OWNER.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: FUEL; FUEL H0SE.CONSEQUENCES OF DEFECT: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE,COULD RESULT IN A VEHICLE FIRE AND SERIOUS INJURY TO PASSENGERS.

DODGE: ASPEN: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Defect Summary:

THE INVOLVED VEHICLES MAY HAVE BEEN BUILT WITH A FUEL SUPPLY TUBE, ROUTED IN SUCH A WAY THAT IT INTERFERES WITH THE FRAME CROSSMEMBER BRACKET. THIS TUBE IS LOCATED BETWEEN THE FUEL PUMP AND THE FUEL FILTER.

Corrective Summary:

THE DEALER WILL INSPECT THE INVOLVED VEHICLES TO ENSURE ADEQUATE FUEL TUBE AND FRAME CROSSMEMBER BRACKET CLEARANCE. THE DEALER WILL ALSO MAKE SURE THAT THE TUBE IS SECURELY CLIPPED TO MAINTAIN CLEARANCE TO THE BRACKET AS WELL AS OTHER ENGINE COMPONENTS. IF THE FUEL SUPPLY TUBE IS FOUND TO BE DAMAGED FROM THIS CONTACT WITH THE CROSSMEMBER BRACKET, IT WILL BE REPLACED AT NO CHARGE.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES.SYSTEM: FUEL LINES; FUEL SUPPLY TUBE.CONSEQUENCES OF DEFECT: CONTINUED CONTACT WITH THE BRACKET MAY EVENTUALLYPUNCTURE THE TUBE AND RESULT IN FUEL LEAKAGE AND A POSSIBLE ENGINE COMPARTMENTFIRE. A FIRE MAY PRESENT A SAFETY HAZARD TO VEHICLE OCCUPANTS.

DODGE: ASPEN: LATCHES/LOCKS/LINKAGES:HOOD:LATCH

Defect Summary:

ON THE INVOLVED VEHICLES, THE HOOD SECONDARY CATCH SYSTEM MAY BE MISALIGNED WHICH MAY CAUSE THE SECONDARY CATCH TO MALFUNCTION. CONSEQUENTLY, THE HOOD MAY NOT BE SECURELY LATCHED.

Corrective Summary:

DEALER WILL ADJUST THE CATCH SYSTEM TO FULLY SECURE THE HOOD, WITHOUT CHARGE.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STRUCTURE; HOOD SECONDARY LATCH/STRIKER.CONSEQUENCES OF DEFECT: THE HOOD COULD SPRING OPEN DURING VEHICLE OPERATION,OBSCURING THE DRIVER"S VIEW OF THE ROAD AND, POSSIBLY, CAUSING AN ACCIDENT.NOTE: IF THE VEHICLE WAS PREVIOUSLY RECALLED FOR CORRECTION OF THE SERVICEBRAKE HYDRAULIC SYSTEM, THE SECONDARY HOOD CATCH SERVICE SHOULD ALSO HAVE BEENCOMPLETED.

DODGE: ASPEN: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM

Defect Summary:

POSSIBLE FATIGUE FAILURE CAN OCCUR IN THE FRAME SUPPORT PLATES (FRONT SUSPENSION PIVOT BAR SUPPORT PLATE) THAT CONNECTS A PORTION OF THE FRONT SUSPENSION TO THE VEHICLE FRAME ON THE INVOLVED VEHICLES.

Corrective Summary:

THE DEALER WILL INSPECT SUPPORT PLATES FOR INDICATIONS OF FAILURE AND, IF NECESSARY, WILL REPLACE THE PLATES. ADDITIONAL SUPPORT BRACKETS WILL ALSO BE INSTALLED TO REINFORCE THE SUPPORT PLATE AT THE PIVOT BAR ATTACHMENTS.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; FRAME SUPPORT PLATE.CONSEQUENCES OF DEFECT: UNDER CERTAIN DRIVING CONDITIONS, THIS FAILURE COULDAFFECT VEHICLE DIRECTIONAL CONTROL, PARTICULARLY DURING HEAVY BRAKEAPPLICATION. THIS WILL RESULT IN LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNINGAND A VEHICLE ACCIDENT.

DODGE: ASPEN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Summary:

ON THE INVOLVED VEHICLES, DAMAGE TO THE FRONT WHEEL BRAKE HYDRAULIC SYSTEM COULD OCCUR DUE TO FRONT WHEEL BRAKE LINE TUBE CORROSION. FRONT WHEEL BRAKE HOSES MAY BECOME BRITTLE AND CRACK DUE TO PROLONGED OPERATION IN COLD TEMPERATURES.

Corrective Summary:

THE DEALER WILL REPLACE BOTH FRONT HOSES IF FOUND NECESSARY AND IN ADDITION, WILL INSTALL A PLASTIC SHIELD BETWEEN THE BATTERY THERMO-GUARD AND THE TUBES TO PREVENT CORROSION.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; STEEL BRAKE TUBES.CONSEQUENCES OF DEFECT: LOSS OF FRONT WHEEL BRAKING CAPABILITY COULD RESULTWHICH WOULD INCREASE THE VEHICLE STOPPING DISTANCE AND COULD LEAD TO ANACCIDENT.NOTE: ILLUMINATION OF THE RED WARNING SIGNAL ON THE INSTRUMENT PANEL SHOULDALERT DRIVER THAT BRAKE MALFUNCTION HAS OCCURRED.

DODGE: ASPEN: STEERING:WHEEL AND HANDLE BAR

Defect Summary:

THE COLUMNS MAY CONTAIN STEERING SHAFTS IN WHICH THE STEERING COLUMN COUPLING ROLL PIN RETAINING NOTCH WAS MACHINED TOO DEEP. THIS MAY CAUSE THE STEERING WHEEL SHAFT TO BECOME DISENGAGED FROM THE REST OF THE STEERING ASSEMBLY.

Corrective Summary:

DEALER WILL INSTALL A COTTER PIN THROUGH THE ROLL PIN TO ENSURE RETENTION, AT NO COST TO OWNER.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH TILT STEERING WHEELS.SYSTEM: STEERING ASSEMBLY; STEERING COLUMN COUPLING.CONSEQUENCES OF DEFECT: THIS CONDITION WOULD RESULT IN LOSS OF STEERINGCAPABILITY AND, POSSIBLY, LOSS OF VEHICLE CONTROL AND AN ACCIDENT.

DODGE: ASPEN: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

Defect Summary:

THE REQUIRED MUFFLER TO FLOOR PAN HEAT SHIELDS WERE OMITTED FROM THE INVOLVED VEHICLES. THESE HEAT SHIELDS ARE NECESSARY TO PROTECT THE PASSENGER COMPARTMENT INTERIOR MATERIALS, INCLUDING SEAT BELT WEBBING, FROM HEAT DAMAGE.

Corrective Summary:

THE DEALER WILL INSTALL THE NECESSARY HEAT SHIELDS ON ALL AFFECTED VEHICLES, FREE OF CHARGE.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES (POLICE MODELS).SYSTEM: EHAUST; MUFFLER, RESONATOR.CONSEQUENCES OF DEFECT: PASSENGERS COULD RECEIVE SERIOUS PERSONAL INJURY DUE TOEXCESSIVE HEAT.

DODGE: ASPEN: LATCHES/LOCKS/LINKAGES:HOOD:LATCH

Defect Summary:

ON THE INVOLVED VEHICLES, THE HOOD SECONDARY CATCH SYSTEM MAY BE MISALIGNED WHICH MAY CAUSE THE SECONDARY CATCH TO MALFUNCTION. CONSEQUENTLY, THE HOOD MAY NOT BE SECURELY LATCHED.

Corrective Summary:

DEALER WILL ADJUST THE CATCH SYSTEM TO FULLY SECURE THE HOOD, WITHOUT CHARGE.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STRUCTURE; HOOD SECONDARY LATCH/STRIKER.CONSEQUENCES OF DEFECT: THE HOOD COULD SPRING OPEN DURING VEHICLE OPERATION,OBSCURING THE DRIVER"S VIEW OF THE ROAD AND, POSSIBLY, CAUSING AN ACCIDENT.NOTE: IF THE VEHICLE WAS PREVIOUSLY RECALLED FOR CORRECTION OF THE SERVICEBRAKE HYDRAULIC SYSTEM, THE SECONDARY HOOD CATCH SERVICE SHOULD ALSO HAVE BEENCOMPLETED.

DODGE: ASPEN: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM

Defect Summary:

POSSIBLE FATIGUE FAILURE CAN OCCUR IN THE FRAME SUPPORT PLATES (FRONT SUSPENSION PIVOT BAR SUPPORT PLATE) THAT CONNECTS A PORTION OF THE FRONT SUSPENSION TO THE VEHICLE FRAME ON THE INVOLVED VEHICLES.

Corrective Summary:

THE DEALER WILL INSPECT SUPPORT PLATES FOR INDICATIONS OF FAILURE AND, IF NECESSARY, WILL REPLACE THE PLATES. ADDITIONAL SUPPORT BRACKETS WILL ALSO BE INSTALLED TO REINFORCE THE SUPPORT PLATE AT THE PIVOT BAR ATTACHMENTS.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; FRAME SUPPORT PLATE.CONSEQUENCES OF DEFECT: UNDER CERTAIN DRIVING CONDITIONS, THIS FAILURE COULDAFFECT VEHICLE DIRECTIONAL CONTROL, PARTICULARLY DURING HEAVY BRAKEAPPLICATION. THIS WILL RESULT IN LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNINGAND A VEHICLE ACCIDENT.

DODGE: ASPEN: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

Defect Summary:

ON THE INVOLVED VEHICLES, THE CARBURETOR ACCELERATOR PUMP SEAL CAN BECOME DISTORTED DUE TO CONTACT WITH CERTAIN TYPES OF GASOLINE. NORMALLY, WHEN THE ACCELERATOR PEDAL IS DEPRESSED, THE ACCELERATOR PUMP IS ACTIVATED TO PROVIDE ADDITIONAL GASOLINE REQUIRED FOR ACCELERATION. A DISTORTED SEAL HOWEVER, MAY PREVENT THE PUMP FROM DELIVERING THE PROPER AMOUNT OF FUEL.

Corrective Summary:

THE DEALER WILL REPLACE THE CARBURETOR ACCELERATOR PUMP SEAL WITH A NEW SEAL HAVING IMPROVED DISTORTION RESISTANCE AND WILL ENSURE PROPER ADJUSTMENT. THIS WILL BE DONE FREE OF CHARGE.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: FUEL; CARBURETOR ACCELERATOR PUMP.CONSEQUENCES OF DEFECT: SHOULD STALLING OCCUR IN CERTAIN TRAFFIC SITUATIONS, ANACCIDENT MAY RESULT.

DODGE: ASPEN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Summary:

ON THE INVOLVED VEHICLES, DAMAGE TO THE FRONT WHEEL BRAKE HYDRAULIC SYSTEM COULD OCCUR DUE TO FRONT WHEEL BRAKE LINE TUBE CORROSION. FRONT WHEEL BRAKE HOSES MAY BECOME BRITTLE AND CRACK DUE TO PROLONGED OPERATION IN COLD TEMPERATURES.

Corrective Summary:

THE DEALER WILL REPLACE BOTH FRONT HOSES IF FOUND NECESSARY AND IN ADDITION, WILL INSTALL A PLASTIC SHIELD BETWEEN THE BATTERY THERMO-GUARD AND THE TUBES TO PREVENT CORROSION.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; STEEL BRAKE TUBES.CONSEQUENCES OF DEFECT: LOSS OF FRONT WHEEL BRAKING CAPABILITY COULD RESULTWHICH WOULD INCREASE THE VEHICLE STOPPING DISTANCE AND COULD LEAD TO ANACCIDENT.NOTE: ILLUMINATION OF THE RED WARNING SIGNAL ON THE INSTRUMENT PANEL SHOULDALERT DRIVER THAT BRAKE MALFUNCTION HAS OCCURRED.

DODGE: ASPEN: SEAT BELTS:FRONT:RETRACTOR

Notes:

CHRYSLER CAMPAIGN NO 211.POSSIBILITY THAT THE AUTOMATIC LOCKING LAP BELTRETRACTOR ON FRONT OUTBOARD SEAT BELT ASSEMBLIES MAY INTERMITTENTLY FAIL TOENGAGE IN THE LOCKED POSITION WHEN THE BELT IS EXTRACTED FOR OCCUPANTS USE.IFTHE RETRACTOR FAILS TO LOCK, A BELTED OCCUPANT MAY NOT BE ADEQUATELY RESTRAINEDDURING IMPACT.(CORRECT BY INSPECTING AND INSTALLING SPECIALLY DEVELOPED CLIPTO INCREASE CLUTCH TORQUE OUTPUT TO ENSURE ENGAGEMENT OF THE RETRACTOR LOCKINGPAWL).

DODGE: ASPEN: EQUIPMENT:OTHER:LABELS

Defect Summary:

THE INVOLVED VEHICLES MAY NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS". THE TIRE PRESSURE PLACARDS INCORRECTLY SPECIFY THE FRONT TIRE PRESSURE FOR MAXIMUM LOAD CONDITIONS. AS A RESULT, TIRES COULD FAIL DUE TO OVERLOADING.

Corrective Summary:

THE OWNER WILL BE SENT THE CORRECT PLACARD AND HAS THE OPTION OF INSTALLING IT HIM/HERSELF OR HAVING THE DEALER INSTALL IT, FREE OF CHARGE.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: EQUIPMENT; TIRE INFORMATION PLACARDS.CONSEQUENCES OF DEFECT: IF TIRE FAILURE OCCURS, LOSS OF VEHICLE CONTROL AND ANACCIDENT COULD OCCUR.NOTE: TO ELIMINATE ANY POTENTIAL FOR OVERLOADING OF THE FRONT TIRES, THEINFLATION PRESSURE OF THE FRONT TIRES SHOULD BE SET AT 26 PSI AND MAINTAINED ATTHAT LEVEL.

DODGE: ASPEN: LATCHES/LOCKS/LINKAGES:HOOD:LATCH

Defect Summary:

ON THE INVOLVED VEHICLES, THE HOOD SECONDARY CATCH SYSTEM MAY BE MISALIGNED WHICH MAY CAUSE THE SECONDARY CATCH TO MALFUNCTION. CONSEQUENTLY, THE HOOD MAY NOT BE SECURELY LATCHED.

Corrective Summary:

DEALER WILL ADJUST THE CATCH SYSTEM TO FULLY SECURE THE HOOD, WITHOUT CHARGE.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STRUCTURE; HOOD SECONDARY LATCH/STRIKER.CONSEQUENCES OF DEFECT: THE HOOD COULD SPRING OPEN DURING VEHICLE OPERATION,OBSCURING THE DRIVER"S VIEW OF THE ROAD AND, POSSIBLY, CAUSING AN ACCIDENT.NOTE: IF THE VEHICLE WAS PREVIOUSLY RECALLED FOR CORRECTION OF THE SERVICEBRAKE HYDRAULIC SYSTEM, THE SECONDARY HOOD CATCH SERVICE SHOULD ALSO HAVE BEENCOMPLETED.

DODGE: ASPEN: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM

Defect Summary:

POSSIBLE FATIGUE FAILURE CAN OCCUR IN THE FRAME SUPPORT PLATES (FRONT SUSPENSION PIVOT BAR SUPPORT PLATE) THAT CONNECTS A PORTION OF THE FRONT SUSPENSION TO THE VEHICLE FRAME ON THE INVOLVED VEHICLES.

Corrective Summary:

THE DEALER WILL INSPECT SUPPORT PLATES FOR INDICATIONS OF FAILURE AND, IF NECESSARY, WILL REPLACE THE PLATES. ADDITIONAL SUPPORT BRACKETS WILL ALSO BE INSTALLED TO REINFORCE THE SUPPORT PLATE AT THE PIVOT BAR ATTACHMENTS.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; FRAME SUPPORT PLATE.CONSEQUENCES OF DEFECT: UNDER CERTAIN DRIVING CONDITIONS, THIS FAILURE COULDAFFECT VEHICLE DIRECTIONAL CONTROL, PARTICULARLY DURING HEAVY BRAKEAPPLICATION. THIS WILL RESULT IN LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNINGAND A VEHICLE ACCIDENT.

DODGE: ASPEN: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

Notes:

CHRYSLER CAMPAIGN NO 217.EQUIPPED WITH POWER BRAKES.POSSIBILITY THAT THEPOWER BRAKE BOOSTER MAY CONTAIN SILENCER PAD THAT RESTRICTS INPUT AIR DURINGBRAKE PEDAL APPLICATION DUE TO EXCESSIVE SILENCER MATERIAL DENSITY.IF THISCONDITION EXISTS, IT COULD CAUSE BRAKING ACTION DELAY ON RAPID PEDALAPPLICATION AND INCREASED STOPPING DISTANCE.(CORRECT BY INSPECTING ANDREWORKING SUSPECT BOOSTER AND REMOVING SILENCER PAD).PASSENGER VEHICLE.

DODGE: ASPEN: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

Defect Summary:

ON THE INVOLVED VEHICLES, THE CARBURETOR ACCELERATOR PUMP SEAL CAN BECOME DISTORTED DUE TO CONTACT WITH CERTAIN TYPES OF GASOLINE. NORMALLY, WHEN THE ACCELERATOR PEDAL IS DEPRESSED, THE ACCELERATOR PUMP IS ACTIVATED TO PROVIDE ADDITIONAL GASOLINE REQUIRED FOR ACCELERATION. A DISTORTED SEAL HOWEVER, MAY PREVENT THE PUMP FROM DELIVERING THE PROPER AMOUNT OF FUEL.

Corrective Summary:

THE DEALER WILL REPLACE THE CARBURETOR ACCELERATOR PUMP SEAL WITH A NEW SEAL HAVING IMPROVED DISTORTION RESISTANCE AND WILL ENSURE PROPER ADJUSTMENT. THIS WILL BE DONE FREE OF CHARGE.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: FUEL; CARBURETOR ACCELERATOR PUMP.CONSEQUENCES OF DEFECT: SHOULD STALLING OCCUR IN CERTAIN TRAFFIC SITUATIONS, ANACCIDENT MAY RESULT.

DODGE: ASPEN: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

Notes:

CHRYSLER CAMPAIGN NO 209.VEHICLE EQUIPPED WITH SIX CYLINDER ENGINE HAVINGCALIFORNIA EMISSION PACKAGE.POSSIBILITY THAT FUEL VAPOR RETURN LINE MAY HAVEBEEN MISROUTED IN A MANNER WHICH ALLOWS INTERFERENCE BETWEEN THE LINE ANDALTERNATOR DRIVE BELT.IF THIS CONDITION EXISTS, RETURN LINE ABRASIONRESULTING FROM INTERFERENCE COULD RESULT IN FUEL LEAKAGE, WITH THE POTENTIALFOR AN ENGINE COMPARTMENT FIRE.(CORRECT BY INSPECTING AND RELOCATINGRETURNLINE TO PRECLUDE INTERFERENCE).

DODGE: ASPEN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Defect Summary:

ON THE INVOLVED VEHICLES, DAMAGE TO THE FRONT WHEEL BRAKE HYDRAULIC SYSTEM COULD OCCUR DUE TO FRONT WHEEL BRAKE LINE TUBE CORROSION. FRONT WHEEL BRAKE HOSES MAY BECOME BRITTLE AND CRACK DUE TO PROLONGED OPERATION IN COLD TEMPERATURES.

Corrective Summary:

THE DEALER WILL REPLACE BOTH FRONT HOSES IF FOUND NECESSARY AND IN ADDITION, WILL INSTALL A PLASTIC SHIELD BETWEEN THE BATTERY THERMO-GUARD AND THE TUBES TO PREVENT CORROSION.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; STEEL BRAKE TUBES.CONSEQUENCES OF DEFECT: LOSS OF FRONT WHEEL BRAKING CAPABILITY COULD RESULTWHICH WOULD INCREASE THE VEHICLE STOPPING DISTANCE AND COULD LEAD TO ANACCIDENT.NOTE: ILLUMINATION OF THE RED WARNING SIGNAL ON THE INSTRUMENT PANEL SHOULDALERT DRIVER THAT BRAKE MALFUNCTION HAS OCCURRED.

DODGE: ASPEN: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM

Defect Summary:

ON THE INVOLVED VEHICLES, THE CARBURETOR ACCELERATOR PUMP SEAL CAN BECOME DISTORTED DUE TO CONTACT WITH CERTAIN TYPES OF GASOLINE. NORMALLY, WHEN THE ACCELERATOR PEDAL IS DEPRESSED, THE ACCELERATOR PUMP IS ACTIVATED TO PROVIDE ADDITIONAL GASOLINE REQUIRED FOR ACCELERATION. A DISTORTED SEAL HOWEVER, MAY PREVENT THE PUMP FROM DELIVERING THE PROPER AMOUNT OF FUEL.

Corrective Summary:

THE DEALER WILL REPLACE THE CARBURETOR ACCELERATOR PUMP SEAL WITH A NEW SEAL HAVING IMPROVED DISTORTION RESISTANCE AND WILL ENSURE PROPER ADJUSTMENT. THIS WILL BE DONE FREE OF CHARGE.

Notes:

VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: FUEL; CARBURETOR ACCELERATOR PUMP.CONSEQUENCES OF DEFECT: SHOULD STALLING OCCUR IN CERTAIN TRAFFIC SITUATIONS, ANACCIDENT MAY RESULT.

DODGE: AVENGER: STEERING:COLUMN

Defect Summary:

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence Summary:

A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Corrective Summary:

DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER'S SAFETY RECALL NO. L23.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: SERVICE BRAKES, HYDRAULIC

Defect Summary:

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 CHRYSLER SEBRING; DODGE AVENGER AND NITRO; JEEP LIBERTY, COMMANDER AND GRAND CHEROKEE; AND MODEL YEAR 2009-2010 DODGE RAM TRUCK. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY FORMED OR MISSING BRAKE BOOSTER INPUT ROD RETAINING CLIP.

Consequence Summary:

THIS COULD RESULT IN BRAKE FAILURE WITHOUT WARNING WHICH COULD CAUSE A CRASH.

Corrective Summary:

CHRYSLER WILL REPLACE THE BRAKE BOOSTER INPUT ROD RETAINING CLIP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER'S SAFETY CAMPAIGN NUMBER IS J37.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: STEERING:ELECTRIC POWER ASSIST SYSTEM

Defect Summary:

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 CHRYSLER SEBRING, 300, CHARGER (LX) AND DODGE CHALLENGER (LC), AVENGER (JS), AND JOURNEY (JC), AS WELL AS MODEL YEAR 2011 DODGE RAM LIGHT DUTY PICKUP (DS) VEHICLES. SOME OF THESE VEHICLES MAY EXPERIENCE A SEPARATION AT THE CRIMPED END OF THE POWER STEERING PRESSURE HOSE ASSEMBLY.

Consequence Summary:

LEAKED POWER STEERING FLUID ONTO HOT ENGINE COMPONENTS COULD CAUSE A FIRE.

Corrective Summary:

DEALERS WILL INSPECT AND REPLACE AS NECESSARY THE POWER STEERING PRESSURE HOSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 20, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER'S CAMPAIGN NUMBER IS K26. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM

Defect Summary:

CHRYSLER IS RECALLING 91 MY 2009 SEBRING AND DODGE AVENGER EQUIPPED WITH 2.4L ENGINE PASSENGER VEHICLES. A COMPATIBILITY ISSUE BETWEEN THE INSTRUMENT CLUSTER SOFTWARE AND FUEL PUMP MODULE CAN RESULT IN THE FUEL GAUGE OVERSTATING THE ACTUAL FUEL TANK LEVEL. AS A RESULT, THE VEHICLE MAY RUN OUT OF FUEL WHEN THE GAUGE INDICATES THAT THERE IS STILL FUEL REMAINING IN THE TANK.

Consequence Summary:

THIS COULD CAUSE A CRASH WITHOUT WARNING.

Corrective Summary:

DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MARCH 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER RECALL NO. J02.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

Defect Summary:

CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.

Consequence Summary:

THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.

Corrective Summary:

DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER RECALL NO. H33.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Defect Summary:

ON CERTAIN PASSENGER VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING CAUSING THE DOOR LATCH TO STICK IN THE OPEN POSITION AND NOT BE SECURED TO THE STRIKER.

Consequence Summary:

DURING CERTAIN CRASH CONDITIONS, THE POSSIBILITY OF A DOOR OPENING COULD CAUSE AN UNBELTED PASSENGER TO BE EJECTED, INCREASING THE RISK OF INJURIES.

Corrective Summary:

THIS ACTION IS SUPERSEDED (PLEASE SEE 07-V414.) DEALERS WILL ADD FREE OF CHARGE A SECONDARY FEATURE TO BOTH FRONT DOORS TO PREVENT THE DOOR LATCH CABLE FERRULE FROM BECOMING UNSEATED AT THE INTERIOR FRONT DOOR RELEASE HANDLE HOUSING. THE RECALL BEGAN ON APRIL 30, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. G12.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: ELECTRICAL SYSTEM:WIRING

Defect Summary:

CHRYSLER IS RECALLING 180,963 MY 2007-2008 SEBRING AND DODGE AVENGER VEHICLES EQUIPPED WITH A STANDARD TIRE PRESSURE MONITORING SYSTEM (TPMS). UNUSED ELECTRICAL CONNECTORS FOR THE TPMS MAY BECOME CORRODED AND COULD SHORT CIRCUIT, WHICH CAN CAUSE A VARIETY OF CONDITIONS INCLUDING ENGINE NO-START, DEAD BATTERY, AN INOPERATIVE CRUISE CONTROL OR REMOTE START SYSTEM, AND/OR ENGINE STALLING.

Consequence Summary:

ENGINE STALLING COULD CAUSE A CRASH WITHOUT WARNING.

Corrective Summary:

DEALERS WILL SEAL THE WIRES FOR THE TPMS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 15, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER RECALL NO. H07.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: AIR BAGS:FRONTAL

Defect Summary:

ON CERTAIN PASSENGER VEHICLES, THE FRONT SEAT TRACK POSITION SENSORS UTILIZED FOR THE AIR BAG SYSTEM MAY NOT FUNCTION PROPERLY.

Consequence Summary:

THIS COULD INCREASE THE RISK OF INJURY TO FRONT SEAT OCCUPANTS DURING CERTAIN CRASH CONDITIONS.

Corrective Summary:

DEALERS WILL INSPECT THE FRONT SEAT TRACK POSITION SENSORS AND REPLACE THEM FREE OF CHARGE. THE RECALLBEGAN ON JUNE 18, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. G14.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

Defect Summary:

ON CERTAIN VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE ENGINE COOLANT MAY BE DRAWN INTO THE LEFT RADIATOR COOLING FAN MOTOR CONNECTOR.

Consequence Summary:

THIS CAN CAUSE AN ELECTRICAL SHORT CIRCUIT AND RESULT IN AN ENGINE COMPARTMENT FIRE.

Corrective Summary:

DEALERS WILL INSPECT THE CONNECTOR FOR CONTAMINATION OR DAMAGE, INSTALL A WIRING HARNESS OVERLAY, AND REPLACE THE FAN MOTOR FREE OR CHARGE. THE RECALL BEGAN ON NOVEMBER 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. G39.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Defect Summary:

ON CERTAIN VEHICLES WITH ALL WHEEL DRIVE, THE FUEL TANK STRAPS WERE IMPROPERLY MANUFACTURED AND COULD SEPARATE. THIS CAN CAUSE THE FUEL TANK TO LOOSEN AND LEAK FUEL.

Consequence Summary:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.

Corrective Summary:

DEALERS WILL REPLACE THE FUEL TANK RETENTION STRAPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. G38. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Defect Summary:

ON CERTAIN VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING POSSIBLY CAUSING THE LATCH TO STICK IN THE UNLATCHED POSITION OR THE LOCK FUNCTION TO BECOME INOPERATIVE.

Consequence Summary:

DRIVING A VEHICLE WITH AN UNLATCHED DOOR CAN RESULT IN AN UNBELTED FRONT SEAT OCCUPANT FALLING OUT OF THE VEHICLE OR BEING EJECTED IN A CRASH, CAUSING INCREASED RISK OF INJURY.

Corrective Summary:

DEALERS WILL ADD A SECONDARY RETENTION FEATURE TO BOTH FRONT DOORS. THIS ACTION WILL SUPERSEDE AND EXPAND A PREVIOUS SAFETY RECALL (PLEASE SEE 07V-104). THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. G33.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION;S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Defect Summary:

ON CERTAIN PASSENGER VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING CAUSING THE DOOR LATCH TO STICK IN THE OPEN POSITION AND NOT BE SECURED TO THE STRIKER.

Consequence Summary:

DURING CERTAIN CRASH CONDITIONS, THE POSSIBILITY OF A DOOR OPENING COULD CAUSE AN UNBELTED PASSENGER TO BE EJECTED, INCREASING THE RISK OF INJURIES.

Corrective Summary:

THIS ACTION IS SUPERSEDED (PLEASE SEE 07-V414.) DEALERS WILL ADD FREE OF CHARGE A SECONDARY FEATURE TO BOTH FRONT DOORS TO PREVENT THE DOOR LATCH CABLE FERRULE FROM BECOMING UNSEATED AT THE INTERIOR FRONT DOOR RELEASE HANDLE HOUSING. THE RECALL BEGAN ON APRIL 30, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. G12.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: ELECTRICAL SYSTEM:WIRING

Defect Summary:

CHRYSLER IS RECALLING 180,963 MY 2007-2008 SEBRING AND DODGE AVENGER VEHICLES EQUIPPED WITH A STANDARD TIRE PRESSURE MONITORING SYSTEM (TPMS). UNUSED ELECTRICAL CONNECTORS FOR THE TPMS MAY BECOME CORRODED AND COULD SHORT CIRCUIT, WHICH CAN CAUSE A VARIETY OF CONDITIONS INCLUDING ENGINE NO-START, DEAD BATTERY, AN INOPERATIVE CRUISE CONTROL OR REMOTE START SYSTEM, AND/OR ENGINE STALLING.

Consequence Summary:

ENGINE STALLING COULD CAUSE A CRASH WITHOUT WARNING.

Corrective Summary:

DEALERS WILL SEAL THE WIRES FOR THE TPMS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 15, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER RECALL NO. H07.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

Defect Summary:

ON CERTAIN VEHICLES EQUIPPED WITH 2.4 LITER ENGINES, THE ENGINE COOLANT MAY BE DRAWN INTO THE LEFT RADIATOR COOLING FAN MOTOR CONNECTOR.

Consequence Summary:

THIS CAN CAUSE AN ELECTRICAL SHORT CIRCUIT AND RESULT IN AN ENGINE COMPARTMENT FIRE.

Corrective Summary:

DEALERS WILL INSPECT THE CONNECTOR FOR CONTAMINATION OR DAMAGE, INSTALL A WIRING HARNESS OVERLAY, AND REPLACE THE FAN MOTOR FREE OR CHARGE. THE RECALL BEGAN ON NOVEMBER 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. G39.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Defect Summary:

ON CERTAIN VEHICLES, THE FRONT DOOR LATCH CABLE MAY BECOME PARTIALLY UNSEATED FROM THE INTERIOR RELEASE HANDLE HOUSING POSSIBLY CAUSING THE LATCH TO STICK IN THE UNLATCHED POSITION OR THE LOCK FUNCTION TO BECOME INOPERATIVE.

Consequence Summary:

DRIVING A VEHICLE WITH AN UNLATCHED DOOR CAN RESULT IN AN UNBELTED FRONT SEAT OCCUPANT FALLING OUT OF THE VEHICLE OR BEING EJECTED IN A CRASH, CAUSING INCREASED RISK OF INJURY.

Corrective Summary:

DEALERS WILL ADD A SECONDARY RETENTION FEATURE TO BOTH FRONT DOORS. THIS ACTION WILL SUPERSEDE AND EXPAND A PREVIOUS SAFETY RECALL (PLEASE SEE 07V-104). THE RECALL BEGAN ON OCTOBER 29, 2007. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. G33.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION;S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: EXTERIOR LIGHTING

Defect Summary:

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Summary:

CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.

Consequence Summary:

IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

Corrective Summary:

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

Notes:

AIRTEX RECALL NO. FP072007-1.THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY DAIMLERCHRYSLER OR MITSUBISHI.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: EXTERIOR LIGHTING

Defect Summary:

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Corrective Summary:

TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Notes:

THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Defect Summary:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Consequence Summary:

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Corrective Summary:

DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Notes:

OWNER NOTIFICATION BEGAN MAY 21, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: AVENGER: EXTERIOR LIGHTING

Defect Summary:

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Summary:

CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.

Consequence Summary:

IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

Corrective Summary:

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

Notes:

AIRTEX RECALL NO. FP072007-1.THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY DAIMLERCHRYSLER OR MITSUBISHI.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: EXTERIOR LIGHTING

Defect Summary:

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Corrective Summary:

TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Notes:

THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Defect Summary:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Consequence Summary:

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Corrective Summary:

DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Notes:

OWNER NOTIFICATION BEGAN MAY 21, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: AVENGER: EXTERIOR LIGHTING

Defect Summary:

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Summary:

CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.

Consequence Summary:

IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

Corrective Summary:

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

Notes:

AIRTEX RECALL NO. FP072007-1.THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY DAIMLERCHRYSLER OR MITSUBISHI.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: EXTERIOR LIGHTING

Defect Summary:

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Corrective Summary:

TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Notes:

THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Defect Summary:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Consequence Summary:

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Corrective Summary:

DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Notes:

OWNER NOTIFICATION BEGAN MAY 21, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: AVENGER: VEHICLE SPEED CONTROL

Defect Summary:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DASH PANEL PAD CAN SHIFT INTERFERRING WITH THE THROTTLE CABLE CONTROL.

Consequence Summary:

THE THROTTLE CABLE CONTROL WOULD NOT RETURN TO IDLE INCREASING THE RISK OF A VEHICLE CRASH.

Corrective Summary:

DEALERS WILL REMOVE A PORTION OF THE DASH PANEL PAD SO IT CANNOT INTERFERE WITH THE THROTTLE CABLE CONTROL.

Notes:

OWNER NOTIFICATION BEGAN APRIL 8, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHRYSLER AT 1-800-992-1997. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: AVENGER: EXTERIOR LIGHTING

Defect Summary:

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

Defect Summary:

THE HEADREST GUIDE BRACKET WAS IMPROPERLY WELDED TO THE SEAT BACK FRAME ON THE PASSENGER SIDE SEAT BACK ASSEMBLIES ONLY.

Consequence Summary:

THE HEADREST SUPPORT BRACKET CAN BREAK, INCREASING THE RISK OF PERSONAL INJURY.

Corrective Summary:

DEALERS WILL REPLACE THE PASSENGER SEAT BACK ASSEMBLY WITH A NEW ASSEMBLY.

Notes:

OWNER NOTIFICATION:OWNER NOTIFICATION BEGAN JULY 31, 1997. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

DODGE: AVENGER: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Summary:

CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.

Consequence Summary:

IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

Corrective Summary:

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

Notes:

AIRTEX RECALL NO. FP072007-1.THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY DAIMLERCHRYSLER OR MITSUBISHI.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: EXTERIOR LIGHTING

Defect Summary:

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Corrective Summary:

TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Notes:

THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: AVENGER: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Defect Summary:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Consequence Summary:

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Corrective Summary:

DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Notes:

OWNER NOTIFICATION BEGAN MAY 21, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: AVENGER: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Summary:

CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.

Consequence Summary:

IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

Corrective Summary:

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

Notes:

AIRTEX RECALL NO. FP072007-1.THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY DAIMLERCHRYSLER OR MITSUBISHI.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Defect Summary:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

Consequence Summary:

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.

Corrective Summary:

DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.

Notes:

OWNER NOTIFICATION BEGAN AUGUST 2, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHRYSLER AT 1-800-992-1997.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: AVENGER: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Defect Summary:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Consequence Summary:

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Corrective Summary:

DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Notes:

OWNER NOTIFICATION BEGAN MAY 21, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: AVENGER: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Summary:

CERTAIN AIRTEX FUEL PUMP MODULE ASSEMBLIES, P/N E7081H, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE WALL OF THE FLARED FITTING OF THE FUEL PUMP IS NOT THICK ENOUGH TO PREVENT THE MATING THREADED FITTINGS FROM BOTTOMING OUT BEFORE AN ADEQUATE SEAL IS ACHIEVED. THIS CONDITION MAY RESULT IN LEAKAGE OF FUEL AT THE CONNECTION OF THE VEHICLE FUEL LINE AND THE FUEL PUMP MODULE ASSEMBLY.

Consequence Summary:

IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.

Corrective Summary:

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS CAN CONTACT AIRTEX AUTOMOTIVE AT 800-880-3056.

Notes:

AIRTEX RECALL NO. FP072007-1.THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY DAIMLERCHRYSLER OR MITSUBISHI.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: AVENGER: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Defect Summary:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.

Consequence Summary:

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.

Corrective Summary:

DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.

Notes:

OWNER NOTIFICATION BEGAN AUGUST 2, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHRYSLER AT 1-800-992-1997.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: AVENGER: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Defect Summary:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.

Consequence Summary:

THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.

Corrective Summary:

DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.

Notes:

OWNER NOTIFICATION BEGAN MAY 21, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: B SERIES: SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY

Defect Summary:

THE REAR AXLE SHAFTS MAY CONTAIN BRAKE DRUM/WHEEL STUDS THAT ARE NOT CENTERED WITH THE DRUM PILOT DIAMETER.

Consequence Summary:

THIS COULD PREVENT FULL SEATING OF THE DRUM TO THE SHAFTFLANGE, WHICH MAY RESULT IN WHEEL STUD NUT LOOSENING.

Corrective Summary:

REPLACE AXLE SHAFTS AS NECESSARY.

Notes:

SYSTEM: REAR AXLE SHAFT.VEHICLE DESCRIPTION: PICKUPS, VANS, AND WAGONS EQUIPPED WITH 9 1/4 IN. REARAXLE.

DODGE: B SERIES: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Defect Summary:

CERTAIN BRAKE MASTER CYLINDERS MAY HAVE BEEN OVERSTRESSED AND CRACKED DURING MANUFACTURE. CONSEQUENCE OF DEFECT: A CRACKED CYLINDER MAY FAIL DURING BRAKING, RESULTING IN LOSS OF BRAKING CAPABILITY, WHICH MAY LEAD TO AN ACCIDENT.

Corrective Summary:

REPLACE SUSPECT CYLINDERS.

Notes:

SYSTEM: BRAKE MASTER CYLINDER.VEHICLE DESCRIPTION: LIGHT-DUTY TRUCKS.

DODGE: CALIBER: STEERING:COLUMN

Defect Summary:

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence Summary:

A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Corrective Summary:

DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER'S SAFETY RECALL NO. L23.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CALIBER: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Defect Summary:

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 DODGE CALIBER VEHICLES. SOME VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECT DOOR LOCK ROD IN THE RIGHT FRONT DOOR.

Consequence Summary:

AN UNLATCHED DOOR COULD INCREASE THE RISK OF AN UNBELTED FRONT SEAT PASSENGER BEING EJECTED FROM THE VEHICLE.

Corrective Summary:

DEALERS WILL INSPECT AND REPLACE THE FRONT RIGHT DOOR LOCK ROD AS REQUIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER'S SAFETY RECALL NO. K09.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CALIBER: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

Defect Summary:

CHRYSLER IS RECALLING 712 MY 2009 SEBRING, DODGE CALIBER, AVENGER, JOURNEY, JEEP PATRIOT, AND COMPASS VEHICLES. A NEW ADHESIVE USED IN THE POWER TRAIN CONTROL MODULE (PCM) MANUFACTURING PROCESS CAN CAUSE THE PRINTED CIRCUIT BOARD TO BREAK.

Consequence Summary:

THIS CAN CAUSE THE ENGINE TO STALL AND CAUSE A CRASH WITHOUT WARNING.

Corrective Summary:

DEALERS WILL REPLACE THE PCM FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 10, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER RECALL NO. H33.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CALIBER: VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Defect Summary:

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2007 DODGE CALIBER AND JEEP COMPASS PASSENGER VEHICLES MANUFACTURED FROM MARCH 7 THROUGH MAY 19, 2006. THE PIVOT BUSHINGS IN VEHICLES WITH OVERSIZED ACCELERATOR PEDAL BEARING POCKETS MAY BECOME DISLODGED AND POTENTIALLY CAUSE THE ACCELERATOR PEDAL TO BIND OR STICK.

Consequence Summary:

SHOULD THE PEDAL BIND OR BECOME STUCK, IT CAN BE OVERCOME BY SMART BRAKES WHICH OVERRIDE THE ACCELERATOR PEDAL IN CERTAIN CONDITIONS.

Corrective Summary:

CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL INSPECT AND REPLACE ALL AFFECTED ACCELERATOR PEDAL ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 29, 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.

Notes:

CHRYSLER'S RECALL CAMPAIGN NUMBER IS K11.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CALIBER: SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE

Defect Summary:

ON CERTAIN VEHICLES, THE ANTILOCK BRAKE SYSTEM (ABS) CONTROL MODULE SOFTWARE MAY CAUSE THE REAR BRAKES TO LOCK UP DURING CERTAIN BRAKING CONDITIONS.

Consequence Summary:

THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL AND CAUSE A CRASH WITHOUT WARNING.

Corrective Summary:

DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL UNIT. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. F50.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CALIBER: WHEELS:CAP/COVER/HUB

Defect Summary:

CERTAIN PASSENGER VEHICLES EQUIPPED WITH REAR DISC BRAKES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 135, "LIGHT VEHICLE BRAKE SYSTEMS." THE LENGTH OF THE REAR WHEEL HUB MOUNTING BOLTS MAY PREVENT ACTUATION OF THE PARK BRAKE.

Consequence Summary:

THIS COULD ALLOW UNINTENDED MOVEMENT OF THE VEHICLE UNDER CERTAIN CONDITIONS AND CAUSE A CRASH WITHOUT WARNING.

Corrective Summary:

DEALERS WILL REPLACE THE REAR WHEEL HUB MOUNTING BOLTS AND REPAIR THE PARK BRAKE FREE OF CHARGE. THE RECALL BEGAN ON MAY 8, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. G15.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: SUSPENSION:REAR

Defect Summary:

THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN MOBILITY CONVERSIONS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. DURING CONVERSION, THE CHASSIS WAS RAISED AND THE FLOOR WAS LOWERED TO ACCOMMODATE WHEELCHAIR ACCESSIBILITY FEATURES. IN RAISING THE CHASSIS, THE REAR SPRING HATS COME INTO CLOSER PROXIMITY TO THE REAR TIRES. IN ROUGH OR AGGRESSIVE DRIVING SITUATIONS THE TIRES MAY INTERMITTENTLY CONTACT THE REAR SPRING HATS.

Consequence Summary:

CONTACT BETWEEN THE TIRE SPRING HAT MAY WEAR A HOLE IN THE TIRE OVER TIME. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL IN THE EVENT OF TIRE PRESSURE LOSS INCREASING THE RISK OF A CRASH.

Corrective Summary:

BRAUN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN TOLL-FREE AT 1-800-488-0359.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

Defect Summary:

THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN COMMERCIAL ENTERVANS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. DURING CONVERSION, THE CHASSIS WAS RAISED AND THE FLOOR WAS LOWERED TO ACCOMMODATE WHEELCHAIR ACCESSIBILITY FEATURES. IN RAISING THE CHASSIS, THE FUEL FILL PIPE COMES INTO CLOSER PROXIMITY TO THE LEFT REAR TIRE. IN ROUGH OR AGGRESSIVE DRIVING SITUATIONS, THE TIRE MAY INTERMITTENTLY CONTACT THE FUEL FILL PIPE.

Consequence Summary:

CONTACT BETWEEN THE TIRE AND FUEL FILL PIPE MAY WEAR A HOLE IN ONE OR THE OTHER COMPONENTS OVER TIME. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL IN THE EVENT OF TIRE PRESSURE LOSS, OR A VEHICLE FIRE IN THE EVENT THE FUEL PIPE IS COMPROMISED.

Corrective Summary:

BRAUN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN TOLL-FREE AT 1-800-488-0359.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: SUSPENSION:REAR

Defect Summary:

THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN MOBILITY CONVERSIONS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. DURING CONVERSION, THE CHASSIS WAS RAISED AND THE FLOOR WAS LOWERED TO ACCOMMODATE WHEELCHAIR ACCESSIBILITY FEATURES. IN RAISING THE CHASSIS, THE REAR SPRING HATS COME INTO CLOSER PROXIMITY TO THE REAR TIRES. IN ROUGH OR AGGRESSIVE DRIVING SITUATIONS THE TIRES MAY INTERMITTENTLY CONTACT THE REAR SPRING HATS.

Consequence Summary:

CONTACT BETWEEN THE TIRE SPRING HAT MAY WEAR A HOLE IN THE TIRE OVER TIME. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL IN THE EVENT OF TIRE PRESSURE LOSS INCREASING THE RISK OF A CRASH.

Corrective Summary:

BRAUN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN TOLL-FREE AT 1-800-488-0359.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

Defect Summary:

THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN COMMERCIAL ENTERVANS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. DURING CONVERSION, THE CHASSIS WAS RAISED AND THE FLOOR WAS LOWERED TO ACCOMMODATE WHEELCHAIR ACCESSIBILITY FEATURES. IN RAISING THE CHASSIS, THE FUEL FILL PIPE COMES INTO CLOSER PROXIMITY TO THE LEFT REAR TIRE. IN ROUGH OR AGGRESSIVE DRIVING SITUATIONS, THE TIRE MAY INTERMITTENTLY CONTACT THE FUEL FILL PIPE.

Consequence Summary:

CONTACT BETWEEN THE TIRE AND FUEL FILL PIPE MAY WEAR A HOLE IN ONE OR THE OTHER COMPONENTS OVER TIME. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL IN THE EVENT OF TIRE PRESSURE LOSS, OR A VEHICLE FIRE IN THE EVENT THE FUEL PIPE IS COMPROMISED.

Corrective Summary:

BRAUN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN TOLL-FREE AT 1-800-488-0359.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: SUSPENSION:REAR

Defect Summary:

THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN MOBILITY CONVERSIONS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. DURING CONVERSION, THE CHASSIS WAS RAISED AND THE FLOOR WAS LOWERED TO ACCOMMODATE WHEELCHAIR ACCESSIBILITY FEATURES. IN RAISING THE CHASSIS, THE REAR SPRING HATS COME INTO CLOSER PROXIMITY TO THE REAR TIRES. IN ROUGH OR AGGRESSIVE DRIVING SITUATIONS THE TIRES MAY INTERMITTENTLY CONTACT THE REAR SPRING HATS.

Consequence Summary:

CONTACT BETWEEN THE TIRE SPRING HAT MAY WEAR A HOLE IN THE TIRE OVER TIME. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL IN THE EVENT OF TIRE PRESSURE LOSS INCREASING THE RISK OF A CRASH.

Corrective Summary:

BRAUN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN TOLL-FREE AT 1-800-488-0359.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

Defect Summary:

THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN COMMERCIAL ENTERVANS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. DURING CONVERSION, THE CHASSIS WAS RAISED AND THE FLOOR WAS LOWERED TO ACCOMMODATE WHEELCHAIR ACCESSIBILITY FEATURES. IN RAISING THE CHASSIS, THE FUEL FILL PIPE COMES INTO CLOSER PROXIMITY TO THE LEFT REAR TIRE. IN ROUGH OR AGGRESSIVE DRIVING SITUATIONS, THE TIRE MAY INTERMITTENTLY CONTACT THE FUEL FILL PIPE.

Consequence Summary:

CONTACT BETWEEN THE TIRE AND FUEL FILL PIPE MAY WEAR A HOLE IN ONE OR THE OTHER COMPONENTS OVER TIME. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL IN THE EVENT OF TIRE PRESSURE LOSS, OR A VEHICLE FIRE IN THE EVENT THE FUEL PIPE IS COMPROMISED.

Corrective Summary:

BRAUN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN TOLL-FREE AT 1-800-488-0359.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

EAGLE EYES WILL NOTIFY OWNERS AND OFFER REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER LLC.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: VISIBILITY:GLASS, SIDE/REAR

Defect Summary:

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Consequence Summary:

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Corrective Summary:

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes:

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JUNE 16, 2008. OWNERS MAY CONTACT MAXZONE AT THE FOLLOWING LOCATIONS: 1-888-286-1188 (WA, OR, CA, ID, NV, AZ, MT, WY, UT, CO, KS, NM, OK, TX, AR, LA, AK, HI) 1-877-253-8930 (ME, NH, VT, MA, CT, RI, NY, NJ, PA, MD, DE, WV, VA) 1-800-859-4755 (NC, SC, GA, FL, TN, AL, MS) 1-866-783-6858 (ND, SD, NE, MN, IA, MO, WI, IL, MI, IN, OH, KY).

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.

Consequence Summary:

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Corrective Summary:

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

EAGLE EYES WILL NOTIFY OWNERS AND OFFER REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER LLC.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: VISIBILITY:GLASS, SIDE/REAR

Defect Summary:

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Consequence Summary:

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Corrective Summary:

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes:

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JUNE 16, 2008. OWNERS MAY CONTACT MAXZONE AT THE FOLLOWING LOCATIONS: 1-888-286-1188 (WA, OR, CA, ID, NV, AZ, MT, WY, UT, CO, KS, NM, OK, TX, AR, LA, AK, HI) 1-877-253-8930 (ME, NH, VT, MA, CT, RI, NY, NJ, PA, MD, DE, WV, VA) 1-800-859-4755 (NC, SC, GA, FL, TN, AL, MS) 1-866-783-6858 (ND, SD, NE, MN, IA, MO, WI, IL, MI, IN, OH, KY).

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.

Consequence Summary:

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Corrective Summary:

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Defect Summary:

ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.

Consequence Summary:

DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.

Corrective Summary:

DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. F10.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

Defect Summary:

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.

Consequence Summary:

IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.

Corrective Summary:

CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER'S CAMPAIGN NUMBER IS J38. CHRYSLER HAS NOT DECIDED THAT THIS IS A DEFECT RELATED TO MOTOR VEHICLE SAFETY.HOWEVER, CHRYSLER HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE AT NO COST.

DODGE: CARAVAN: SERVICE BRAKES, HYDRAULIC

Defect Summary:

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Consequence Summary:

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Corrective Summary:

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET NAPA, RAYBESTOS, AC DELCO, AIMCO, CARQUEST, AND BENDIX BRAKE HYDRAULIC MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

Defect Summary:

CERTAIN MINIVANS ARE BEING RECALLED THAT WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE 27 STATES PLUS THE DISTRICT OF COLUMBIA THAT USE GREATER AMOUNTS OF SALT FOR WINTER ROAD DEICING. THE UP-FRONT (UF) AIR BAG SENSORS THAT CONTAIN BRASS BUSHINGS INSTALLED IN THESE VEHICLES MAY CORRODE AND CRACK ALLOWING WATER TO ENTER THE SENSOR. THESE SENSORS PROVIDE ENHANCED AIR BAG PERFORMANCE IN CERTAIN TYPES OF FRONTAL CRASHES.

Consequence Summary:

IN ONE OF THESE CRASHES, WITH ONE OR BOTH OF THE VEHICLE'S UF SENSORS INOPERATIVE, THE OCCUPANTS WILL NOT BENEFIT FROM THE ENHANCED AIR BAG PROTECTION THAT THESE SENSORS WOULD PROVIDE.

Corrective Summary:

FOR VEHICLES REGISTERED IN THE RECALL STATES, DEALERS WILL REPLACE THE ORIGINAL UF AIR BAG SENSORS WITH ONES WITH GREATER CORROSION RESISTANCE. VEHICLES REGISTERED IN OTHER STATES WILL OBTAIN A LIFETIME FREE REPLACEMENT OF ANY UF SENSOR THAT FAILS. THE CAMPAIGN BEGAN ON JULY 2, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER'S CAMPAIGN NOS. G09/X16. DAIMLERCHRYSLER HAS NOT DECIDED THAT THIS IS A DEFECT RELATED TO MOTOR VEHICLE SAFETY.HOWEVER, IT HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE FREE OF CHARGE. CUSTOMERS ALSO MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

EAGLE EYES WILL NOTIFY OWNERS AND OFFER REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER LLC.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: VISIBILITY:GLASS, SIDE/REAR

Defect Summary:

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Consequence Summary:

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Corrective Summary:

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes:

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JUNE 16, 2008. OWNERS MAY CONTACT MAXZONE AT THE FOLLOWING LOCATIONS: 1-888-286-1188 (WA, OR, CA, ID, NV, AZ, MT, WY, UT, CO, KS, NM, OK, TX, AR, LA, AK, HI) 1-877-253-8930 (ME, NH, VT, MA, CT, RI, NY, NJ, PA, MD, DE, WV, VA) 1-800-859-4755 (NC, SC, GA, FL, TN, AL, MS) 1-866-783-6858 (ND, SD, NE, MN, IA, MO, WI, IL, MI, IN, OH, KY).

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.

Consequence Summary:

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Corrective Summary:

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: SEAT BELTS:FRONT:RETRACTOR

Defect Summary:

AFTER PERFORMING THE NCAP TEST, IT WAS DISCOVERED THAT ON CERTAIN MINIVANS EQUIPPED WITHOUT THE AVAILABLE "STOW 'N GO" SEATING OPTION, THE RIGHT FRONT SEAT BELT RETRACTOR ASSEMBLY MAY HAVE BEEN IMPROPERLY ASSEMBLED.

Consequence Summary:

AS A RESULT, THE SEAT BELT MAY NOT PROPERLY RESTRAIN THE OCCUPANT DURING CERTAIN CRASH CONDITIONS, WHICH CAN INCREASE THE RISK OF INJURY.

Corrective Summary:

DEALERS WILL INSPECT THE RETRACTOR ASSEMBLIES AND ANY SEAT BELT ASSEMBLY THAT DOES NOT HAVE THE STAKE WILL BE REPLACED. OWNER NOTIFICATION BEGAN ON FEBRUARY 23, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. D04.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Defect Summary:

ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.

Consequence Summary:

DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.

Corrective Summary:

DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. F10.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

Defect Summary:

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.

Consequence Summary:

IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.

Corrective Summary:

CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes:

CHRYSLER'S CAMPAIGN NUMBER IS J38. CHRYSLER HAS NOT DECIDED THAT THIS IS A DEFECT RELATED TO MOTOR VEHICLE SAFETY.HOWEVER, CHRYSLER HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE AT NO COST.

DODGE: CARAVAN: SERVICE BRAKES, HYDRAULIC

Defect Summary:

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Consequence Summary:

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Corrective Summary:

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET NAPA, RAYBESTOS, AC DELCO, AIMCO, CARQUEST, AND BENDIX BRAKE HYDRAULIC MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

EAGLE EYES WILL NOTIFY OWNERS AND OFFER REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER LLC.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: VISIBILITY:GLASS, SIDE/REAR

Defect Summary:

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Consequence Summary:

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Corrective Summary:

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes:

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: FUEL SYSTEM, GASOLINE

Defect Summary:

CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.

Consequence Summary:

A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.

Corrective Summary:

WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WIX AT 704-864-6711.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER, AND DODGE CARAVAN MINIVANSOR ANY OTHER PRODUCTS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JUNE 16, 2008. OWNERS MAY CONTACT MAXZONE AT THE FOLLOWING LOCATIONS: 1-888-286-1188 (WA, OR, CA, ID, NV, AZ, MT, WY, UT, CO, KS, NM, OK, TX, AR, LA, AK, HI) 1-877-253-8930 (ME, NH, VT, MA, CT, RI, NY, NJ, PA, MD, DE, WV, VA) 1-800-859-4755 (NC, SC, GA, FL, TN, AL, MS) 1-866-783-6858 (ND, SD, NE, MN, IA, MO, WI, IL, MI, IN, OH, KY).

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.

Consequence Summary:

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Corrective Summary:

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS.

Consequence Summary:

IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.

Corrective Summary:

AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18230 AND DATE CODE 0237, 0249, 0251, OR 0304. REPLACEMENT FUEL FILTERS FOR 2001-2004 CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 28871 AND DATE CODE 0249. THESE PART NUMBERS AND DATE CODES APPEAR ON THE GOLD-TONE FILTER. DISTRIBUTORS AND RETAILERS WILL BE NOTIFIED TO ISOLATE AND RETURN AFFECTED INVENTORY. OWNERS WHO HAVE HAD THE FUEL FILTER SERVICED ON ONE OF THE APPLICABLE VEHICLES AFTER SEPTEMBER 17, 2002 SHOULD RETURN THEIR VEHICLE TO THE SERVICE FACILITY TO BE INSPECTED TO SEE IF THE FUEL FILTER THAT WAS INSTALLED IS ONE THAT IS INVOLVED IN THE RECALL. IF SO, THE OWNERS SHOULD HAVE THE FILTER REPLACED. TO RECEIVE A FULL REFUND PLUS THE COST OF POSTAGE, OWNERS SHOULD CUT THE CONNECTORS FROM THE HOSES, RINSE THE CONNECTORS AND RETURN THEM TOGETHER WITH PROOF OF THE AMOUNT PAID FOR THE REPLACEMENT PART AND LABOR, TO INTERCONTINENTAL AT INTERCONTINENTAL AUTO PARTS, INC., P.O. BOX 861, MAHWAH, NJ 07430, ATTN: FUEL FILTER RECALL. INTERCONTINENTAL WILL MAIL A FULL REFUND TO THE OWNER.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER, AND DODGE CARAVAN MINIVANSOR ANY OTHER PRODUCTS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION.CONSUMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Defect Summary:

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

Consequence Summary:

POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.

Corrective Summary:

DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

RECALL NO. D37.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: SERVICE BRAKES, HYDRAULIC

Defect Summary:

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Consequence Summary:

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Corrective Summary:

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET NAPA, RAYBESTOS, AC DELCO, AIMCO, CARQUEST, AND BENDIX BRAKE HYDRAULIC MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

EAGLE EYES WILL NOTIFY OWNERS AND OFFER REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER LLC.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: FUEL SYSTEM, GASOLINE

Defect Summary:

CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.

Consequence Summary:

A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.

Corrective Summary:

WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WIX AT 704-864-6711.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER, AND DODGE CARAVAN MINIVANSOR ANY OTHER PRODUCTS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JUNE 16, 2008. OWNERS MAY CONTACT MAXZONE AT THE FOLLOWING LOCATIONS: 1-888-286-1188 (WA, OR, CA, ID, NV, AZ, MT, WY, UT, CO, KS, NM, OK, TX, AR, LA, AK, HI) 1-877-253-8930 (ME, NH, VT, MA, CT, RI, NY, NJ, PA, MD, DE, WV, VA) 1-800-859-4755 (NC, SC, GA, FL, TN, AL, MS) 1-866-783-6858 (ND, SD, NE, MN, IA, MO, WI, IL, MI, IN, OH, KY).

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.

Consequence Summary:

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Corrective Summary:

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK

Defect Summary:

ON CERTAIN MINIVANS, THE POWER LIFTGATE (PLG) LATCH MAY NOT ENGAGE THE STRIKER ALLOWING THE LIFTGATE TO OPEN WHILE DRIVING.

Consequence Summary:

IN THE EVENT OF A CRASH, AN UNBELTED PASSENGER COULD BE EJECTED FROM THE VEHICLE.

Corrective Summary:

DEALERS WILL REPLACE THE POWER LIFTGATE CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN APRIL 26, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLER RECALL NO. E06. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: STRUCTURE

Defect Summary:

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Consequence Summary:

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Corrective Summary:

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

Notes:

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS.

Consequence Summary:

IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.

Corrective Summary:

AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18230 AND DATE CODE 0237, 0249, 0251, OR 0304. REPLACEMENT FUEL FILTERS FOR 2001-2004 CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 28871 AND DATE CODE 0249. THESE PART NUMBERS AND DATE CODES APPEAR ON THE GOLD-TONE FILTER. DISTRIBUTORS AND RETAILERS WILL BE NOTIFIED TO ISOLATE AND RETURN AFFECTED INVENTORY. OWNERS WHO HAVE HAD THE FUEL FILTER SERVICED ON ONE OF THE APPLICABLE VEHICLES AFTER SEPTEMBER 17, 2002 SHOULD RETURN THEIR VEHICLE TO THE SERVICE FACILITY TO BE INSPECTED TO SEE IF THE FUEL FILTER THAT WAS INSTALLED IS ONE THAT IS INVOLVED IN THE RECALL. IF SO, THE OWNERS SHOULD HAVE THE FILTER REPLACED. TO RECEIVE A FULL REFUND PLUS THE COST OF POSTAGE, OWNERS SHOULD CUT THE CONNECTORS FROM THE HOSES, RINSE THE CONNECTORS AND RETURN THEM TOGETHER WITH PROOF OF THE AMOUNT PAID FOR THE REPLACEMENT PART AND LABOR, TO INTERCONTINENTAL AT INTERCONTINENTAL AUTO PARTS, INC., P.O. BOX 861, MAHWAH, NJ 07430, ATTN: FUEL FILTER RECALL. INTERCONTINENTAL WILL MAIL A FULL REFUND TO THE OWNER.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER, AND DODGE CARAVAN MINIVANSOR ANY OTHER PRODUCTS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION.CONSUMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Defect Summary:

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

Consequence Summary:

POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.

Corrective Summary:

DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

RECALL NO. D37.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Defect Summary:

ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.

Consequence Summary:

THIS COULD RESULT IN A SPEAKER FIRE.

Corrective Summary:

DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLERRECALL NO. D48.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: SERVICE BRAKES, HYDRAULIC

Defect Summary:

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Consequence Summary:

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Corrective Summary:

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET NAPA, RAYBESTOS, AC DELCO, AIMCO, CARQUEST, AND BENDIX BRAKE HYDRAULIC MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

EAGLE EYES WILL NOTIFY OWNERS AND OFFER REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER LLC.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: CHILD SEAT

Defect Summary:

VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.

Consequence Summary:

IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.

Corrective Summary:

OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: FUEL SYSTEM, GASOLINE

Defect Summary:

CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.

Consequence Summary:

A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.

Corrective Summary:

WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WIX AT 704-864-6711.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER, AND DODGE CARAVAN MINIVANSOR ANY OTHER PRODUCTS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JUNE 16, 2008. OWNERS MAY CONTACT MAXZONE AT THE FOLLOWING LOCATIONS: 1-888-286-1188 (WA, OR, CA, ID, NV, AZ, MT, WY, UT, CO, KS, NM, OK, TX, AR, LA, AK, HI) 1-877-253-8930 (ME, NH, VT, MA, CT, RI, NY, NJ, PA, MD, DE, WV, VA) 1-800-859-4755 (NC, SC, GA, FL, TN, AL, MS) 1-866-783-6858 (ND, SD, NE, MN, IA, MO, WI, IL, MI, IN, OH, KY).

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.

Consequence Summary:

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Corrective Summary:

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: STRUCTURE

Defect Summary:

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Consequence Summary:

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Corrective Summary:

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

Notes:

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS.

Consequence Summary:

IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.

Corrective Summary:

AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18230 AND DATE CODE 0237, 0249, 0251, OR 0304. REPLACEMENT FUEL FILTERS FOR 2001-2004 CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 28871 AND DATE CODE 0249. THESE PART NUMBERS AND DATE CODES APPEAR ON THE GOLD-TONE FILTER. DISTRIBUTORS AND RETAILERS WILL BE NOTIFIED TO ISOLATE AND RETURN AFFECTED INVENTORY. OWNERS WHO HAVE HAD THE FUEL FILTER SERVICED ON ONE OF THE APPLICABLE VEHICLES AFTER SEPTEMBER 17, 2002 SHOULD RETURN THEIR VEHICLE TO THE SERVICE FACILITY TO BE INSPECTED TO SEE IF THE FUEL FILTER THAT WAS INSTALLED IS ONE THAT IS INVOLVED IN THE RECALL. IF SO, THE OWNERS SHOULD HAVE THE FILTER REPLACED. TO RECEIVE A FULL REFUND PLUS THE COST OF POSTAGE, OWNERS SHOULD CUT THE CONNECTORS FROM THE HOSES, RINSE THE CONNECTORS AND RETURN THEM TOGETHER WITH PROOF OF THE AMOUNT PAID FOR THE REPLACEMENT PART AND LABOR, TO INTERCONTINENTAL AT INTERCONTINENTAL AUTO PARTS, INC., P.O. BOX 861, MAHWAH, NJ 07430, ATTN: FUEL FILTER RECALL. INTERCONTINENTAL WILL MAIL A FULL REFUND TO THE OWNER.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER, AND DODGE CARAVAN MINIVANSOR ANY OTHER PRODUCTS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION.CONSUMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

Defect Summary:

ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.

Consequence Summary:

POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.

Corrective Summary:

DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

RECALL NO. D37.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Defect Summary:

ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.

Consequence Summary:

THIS COULD RESULT IN A SPEAKER FIRE.

Corrective Summary:

DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

DAIMLERCHRYSLERRECALL NO. D48.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: SERVICE BRAKES, HYDRAULIC

Defect Summary:

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Consequence Summary:

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Corrective Summary:

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET NAPA, RAYBESTOS, AC DELCO, AIMCO, CARQUEST, AND BENDIX BRAKE HYDRAULIC MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

EAGLE EYES WILL NOTIFY OWNERS AND OFFER REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER LLC.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: FUEL SYSTEM, GASOLINE

Defect Summary:

CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.

Consequence Summary:

A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.

Corrective Summary:

WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WIX AT 704-864-6711.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER, AND DODGE CARAVAN MINIVANSOR ANY OTHER PRODUCTS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: EXTERIOR LIGHTING:HEADLIGHTS

Defect Summary:

MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JUNE 16, 2008. OWNERS MAY CONTACT MAXZONE AT THE FOLLOWING LOCATIONS: 1-888-286-1188 (WA, OR, CA, ID, NV, AZ, MT, WY, UT, CO, KS, NM, OK, TX, AR, LA, AK, HI) 1-877-253-8930 (ME, NH, VT, MA, CT, RI, NY, NJ, PA, MD, DE, WV, VA) 1-800-859-4755 (NC, SC, GA, FL, TN, AL, MS) 1-866-783-6858 (ND, SD, NE, MN, IA, MO, WI, IL, MI, IN, OH, KY).

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY CHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.

Consequence Summary:

IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.

Corrective Summary:

CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.

Notes:

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Defect Summary:

VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.

Consequence Summary:

IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.

Corrective Summary:

DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Defect Summary:

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2001 PLYMOUTH VOYAGER, CHRYSLER TOWN & COUNTRY, AND DODGE CARAVAN/GRAND CARAVAN MINI VANS THAT ARE NOT EQUIPPED WITH THE REMOTE KEYLESS ENTRY OPTION. THE SLIDING DOOR LATCHES ON THESE VEHICLES COULD RELEASE DURING CERTAIN SEVERE ACCIDENT CONDITIONS THAT INVOLVE THE SLIDING DOOR.

Consequence Summary:

THIS COULD ALLOW THE SLIDING DOOR TO PARTIALLY OPEN.

Corrective Summary:

DEALER WILL REPLACE BOTH SLIDING DOOR KEY CYLINDER-TO-BELL CRANK LINKS ON THE SLIDING DOORS FREE OF CHARGE (PARTS AND LABOR). DAIMLERCHRYSLER HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO REPLACE THE SLIDING DOOR KEY CYLINDER-TO-BELL CRANK LINKS. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403, CONCERNING THIS PROGRAM.

DODGE: CARAVAN: STRUCTURE

Defect Summary:

CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

Consequence Summary:

THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

Corrective Summary:

DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

Notes:

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: EQUIPMENT

Defect Summary:

AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS.

Consequence Summary:

IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.

Corrective Summary:

AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18230 AND DATE CODE 0237, 0249, 0251, OR 0304. REPLACEMENT FUEL FILTERS FOR 2001-2004 CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 28871 AND DATE CODE 0249. THESE PART NUMBERS AND DATE CODES APPEAR ON THE GOLD-TONE FILTER. DISTRIBUTORS AND RETAILERS WILL BE NOTIFIED TO ISOLATE AND RETURN AFFECTED INVENTORY. OWNERS WHO HAVE HAD THE FUEL FILTER SERVICED ON ONE OF THE APPLICABLE VEHICLES AFTER SEPTEMBER 17, 2002 SHOULD RETURN THEIR VEHICLE TO THE SERVICE FACILITY TO BE INSPECTED TO SEE IF THE FUEL FILTER THAT WAS INSTALLED IS ONE THAT IS INVOLVED IN THE RECALL. IF SO, THE OWNERS SHOULD HAVE THE FILTER REPLACED. TO RECEIVE A FULL REFUND PLUS THE COST OF POSTAGE, OWNERS SHOULD CUT THE CONNECTORS FROM THE HOSES, RINSE THE CONNECTORS AND RETURN THEM TOGETHER WITH PROOF OF THE AMOUNT PAID FOR THE REPLACEMENT PART AND LABOR, TO INTERCONTINENTAL AT INTERCONTINENTAL AUTO PARTS, INC., P.O. BOX 861, MAHWAH, NJ 07430, ATTN: FUEL FILTER RECALL. INTERCONTINENTAL WILL MAIL A FULL REFUND TO THE OWNER.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER, AND DODGE CARAVAN MINIVANSOR ANY OTHER PRODUCTS MANUFACTURED BY DAIMLERCHRYSLER CORPORATION.CONSUMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: SERVICE BRAKES, HYDRAULIC

Defect Summary:

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Consequence Summary:

LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Corrective Summary:

AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET NAPA, RAYBESTOS, AC DELCO, AIMCO, CARQUEST, AND BENDIX BRAKE HYDRAULIC MASTER CYLINDERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: EXTERIOR LIGHTING

Defect Summary:

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .

DODGE: CARAVAN: EQUIPMENT:OTHER:LABELS

Defect Summary:

ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence Summary:

IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.

Corrective Summary:

OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

Notes:

DAIMLERCHRYSLER RECALL NO. C41.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Summary:

CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.

Consequence Summary:

FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.

Corrective Summary:

AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.

Notes:

THIS RECALL ONLY PERTAINS TO AFTERMARKET FUEL PUMP MODULES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES BY DAIMLERCHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: VISIBILITY:GLASS, SIDE/REAR

Defect Summary:

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Consequence Summary:

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Corrective Summary:

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes:

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DODGE: CARAVAN: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

Defect Summary:

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence Summary:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Corrective Summary:

DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes:

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DODGE: CARAVAN: FUEL SYSTEM, GASOLINE