Contact
Andy's Parts Smarts
Cart
Chevrolet Recalls
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2005 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2005 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2004 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2003 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
-->| NHTSA Campaign Number: | 03V328000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3044 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020301 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 41477 |
| Date Owner Notified By Manufacturer: | 20040408 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030912 |
| Record Creation Date: | 20030916 |
Defect Summary:
CERTAIN MINIVANS HAVE AN INTERFERENCE CONDITION BETWEEN THE LOWER BALL JOINT RUBBER BOOT AND THE STEERING KNUCKLE (BOTH LEFT/RIGHT SIDES), WHICH COULD RESULT IN CUTTING OF THE BOOT THAT IS INTENDED TO SEAL THE BALL JOINT. IF THE LOWER BALL JOINT BOOT WERE CUT, CONTAMINATION FROM THE ROAD (SALT, DIRT, WATER, ETC.) COULD ENTER THE BALL SOCKET AREA OF THE BALL JOINT CAUSING THE JOINT TO WEAR OUT TOO QUICKLY.
Consequence Summary:
THE STEERING KNUCKLE COULD SEPARATE FROM THE LOWER CONTROL ARM, DROPPING DOWN THE AFFECTED CORNER OF THE VEHICLE. THE COIL SPRING WOULD PUSH THE CONTROL ARM DOWN INTO CONTACT WITH THE GROUND, CREATING A DRAG THAT WOULD SLOW THE VEHICLE. THE DRIVER COULD HAVE DIFFICULTY IN MAINTAINING THE DIRECTIONAL CONTROL OF THE VEHICLE. IN ADDITION, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE IF FORCES RESULTING FROM THE WHEEL'S DRAGGING ACTION WERE SUFFICIENT TO FRACTURE THE TIE ROD END AND UPPER BALL JOINT CONNECTIONS. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL'S HYDRAULIC BRAKE HOSE, RESULTING IN LOST BRAKING PERFORMANCE FROM THE FRONT BRAKE SYSTEM. VEHICLE STOPPING DISTANCE WOULD INCREASE, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE STEERING KNUCKLES. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 8, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 03044.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 05V099000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 5013 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010301 - 20010831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77055 |
| Date Owner Notified By Manufacturer: | 20050413 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050314 |
| Record Creation Date: | 20050316 |
Defect Summary:
ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
Consequence Summary:
THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05013.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2002 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 05V099000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 5013 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77055 |
| Date Owner Notified By Manufacturer: | 20050413 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050314 |
| Record Creation Date: | 20050316 |
Defect Summary:
ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
Consequence Summary:
THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05013.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2001 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1999 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
-->| NHTSA Campaign Number: | 01V123000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 1036 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WARNING LIGHT/DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950701 - 19990228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 461851 |
| Date Owner Notified By Manufacturer: | 20010627 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010410 |
| Record Creation Date: | 20010424 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence Summary:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Corrective Summary:
DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1998 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: CHILD SEAT
-->| NHTSA Campaign Number: | 99V009000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 98071 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960501 - 19970930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2090 |
| Date Owner Notified By Manufacturer: | 19990121 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990120 |
| Record Creation Date: | 19990127 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 213 |
Defect Summary:
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence Summary:
THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
Notes:
OWNER NOTIFICATION BEGAN JANUARY 21, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
-->| NHTSA Campaign Number: | 03V093000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 3006 |
| Manufacturer Component Description: | VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19980930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 507171 |
| Date Owner Notified By Manufacturer: | 20030424 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030307 |
| Record Creation Date: | 20030318 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence Summary:
IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03006. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
-->| NHTSA Campaign Number: | 01V123000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 1036 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WARNING LIGHT/DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950701 - 19990228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 461851 |
| Date Owner Notified By Manufacturer: | 20010627 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010410 |
| Record Creation Date: | 20010424 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence Summary:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Corrective Summary:
DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1997 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960301 - 19970630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: CHILD SEAT
-->| NHTSA Campaign Number: | 99V009000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 98071 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960501 - 19970930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2090 |
| Date Owner Notified By Manufacturer: | 19990121 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990120 |
| Record Creation Date: | 19990127 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 213 |
Defect Summary:
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence Summary:
THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
Notes:
OWNER NOTIFICATION BEGAN JANUARY 21, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 97V057000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1997 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960301 - 19961130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 18972 |
| Date Owner Notified By Manufacturer: | 19970428 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970408 |
| Record Creation Date: | 19970417 |
Defect Summary:
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence Summary:
IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Corrective Summary:
DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEING LATE-APRIL 1997.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
-->| NHTSA Campaign Number: | 01V123000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 1036 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WARNING LIGHT/DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950701 - 19990228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 461851 |
| Date Owner Notified By Manufacturer: | 20010627 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010410 |
| Record Creation Date: | 20010424 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence Summary:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Corrective Summary:
DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950301 - 19960630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: CHILD SEAT
-->| NHTSA Campaign Number: | 99V009000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 98071 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960501 - 19970930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2090 |
| Date Owner Notified By Manufacturer: | 19990121 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990120 |
| Record Creation Date: | 19990127 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 213 |
Defect Summary:
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED DUAL CHILD SEATS. SOME OF THESE VEHICLES MAY BE MISSING A SEAT BELT RETRACTOR CLUTCH SPRING AND/OR PAWL SPRING IN THE CHILD SEAT. IF THE CLUTCH SPRING WAS MISSING, THE SEAT BELT WOULD LOCK IN THE RETRACTED POSITION AND COULD NOT BE USED. IF THE PAWL SPRING WAS MISSING, THE SEAT BELT RESTRAINT WOULD CONTINUALLY PLAY OUT AND WOULD NOT LOCK.
Consequence Summary:
THESE CONDITIONS COULD INCREASE THE OCCUPANT'S RISK OF INJURY IN THE EVENT OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE SEAT BELTS ON THE CHILD SEATS, AND IF NECESSARY, REPLACE THE CHILD SEAT.
Notes:
OWNER NOTIFICATION BEGAN JANUARY 21, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 97V057000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1996 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950701 - 19960630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 18972 |
| Date Owner Notified By Manufacturer: | 19970428 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970408 |
| Record Creation Date: | 19970417 |
Defect Summary:
THE OUTBOARD SAFETY BELT WEBBING ON THE RIGHT-HAND REAR BUCKET SEAT CAN SEPARATE DURING A VEHICLE CRASH.
Consequence Summary:
IN THE EVENT OF A CRASH, THE VEHICLE OCCUPANT WOULD NOT BE PROPERLY RESTRAINED AND PERSONAL INJURY COULD RESULT.
Corrective Summary:
DEALERS WILL INSTALL A PROTECTOR ON THE REAR SEAT CUSHION FRAME.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEING LATE-APRIL 1997.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
-->| NHTSA Campaign Number: | 01V123000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 1036 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WARNING LIGHT/DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950701 - 19990228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 461851 |
| Date Owner Notified By Manufacturer: | 20010627 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010410 |
| Record Creation Date: | 20010424 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
VEHICLE DESCRIPTION: MINI VANS. SOME OF THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." THE "FASTEN SAFETY-BELT" AUDIBLE WARNING OCCASIONALLY MAY NOT COME ON OR MAY TERMINATE IN LESS THAN FOUR SECONDS AS REQUIRED BY THE STANDARD.
Consequence Summary:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Corrective Summary:
DEALERS WILL INSTALL A NEW ALARM MODULE. OWNER NOTIFICATION BEGAN JUNE 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
-->| NHTSA Campaign Number: | 94V188000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940901 - 19940901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3037 |
| Date Owner Notified By Manufacturer: | 19940921 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19941004 |
| Record Creation Date: | 19941018 |
Defect Summary:
THE FUEL LINES ATTACHED TO THE FUEL TANK WERE NOT PROPERLY TIGHTENED.
Consequence Summary:
THESE FUEL LINES CAN LOOSEN TO THE POINT OF ALLOWING FUEL TO LEAK FROM THE LINES RESULTING IN A VEHICLE FIRE.
Corrective Summary:
DEALERS WILL LOWER THE FUEL TANK AND TIGHTEN THE FUEL TANK LINES TO THE PROPER TORQUE VALUE.
Notes:
SYSTEM: FUEL; FUEL TANK ASSEMBLY.VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH L35 ENGINES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT CHEVROLET TRUCK AT 1-800-222-1020, OR GMC AT 1-810-456-4547. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 06E041000 |
| Vehicle/Equipment Make: | R&B, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 7800 |
| Date Owner Notified By Manufacturer: | 20060504 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | R&B, INC. |
| Report Received Date: | 20060518 |
| Record Creation Date: | 20060518 |
Defect Summary:
CERTAIN R&B, INC. CENTRAL MULTIPORT FUEL INJECTION (CMFI) FUEL RETURN LINES, MODELS HELP 55163, NAPA BALKAMP 700-3270, AND THE CONNECTION 2560001, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL RETURN LINE HAS A MECHANICAL BLEED VALVE WHICH WAS NOT INSTALLED AT THE PROPER TORQUE.
Consequence Summary:
A FUEL LEAK CAN OCCUR AT THE VALVE, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
R&B, INC. WILL NOTIFY OWNERS AND AT THE CUSTOMERS REQUEST, EITHER REPLACE THE FUEL LINE OR OFFER A FULL REFUND. THE RECALL BEGAN ON MAY 4, 2006. OWNERS MAY CONTACT R&B, INC. AT 215-712-5330.
Notes:
THIS RECALL ONLY PERTAINS TO R&B, INC. AFTERMARKET CMFI RETURN FUEL LINES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1995 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940301 - 19951031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: ASTRO: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
-->| NHTSA Campaign Number: | 95V175000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1995 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950801 - 19950801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 69 |
| Date Owner Notified By Manufacturer: | 19950913 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950913 |
| Record Creation Date: | 19950914 |
Defect Summary:
THESE VEHICLES WERE ASSEMBLED WITH THE LEFT-HAND LOWER CONTROL ARM-TO-FRAME REAR NUT NOT TIGHTENED TO THE SPECIFIED TORQUE.
Consequence Summary:
LOW TORQUE CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENTLY FATIGUE AND BREAK. THIS CAN RESULT IN SEPARATION OF THE LEFT-HAND CONTROL ARM FROM THE FRAME INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL TIGHTEN THE LEFT-HAND LOWER CONTROL ARM-TO- FRAME REAR NUT TO THE PROPER TORQUE SPECIFICATION.
Notes:
SYSTEM: SUSPENSION; INDEPENDENT FRONT CONTROL ARM; LOWER.VEHICLE DESCRIPTION: PASSENGER VANS.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1993 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 06E041000 |
| Vehicle/Equipment Make: | R&B, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1993 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 7800 |
| Date Owner Notified By Manufacturer: | 20060504 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | R&B, INC. |
| Report Received Date: | 20060518 |
| Record Creation Date: | 20060518 |
Defect Summary:
CERTAIN R&B, INC. CENTRAL MULTIPORT FUEL INJECTION (CMFI) FUEL RETURN LINES, MODELS HELP 55163, NAPA BALKAMP 700-3270, AND THE CONNECTION 2560001, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL RETURN LINE HAS A MECHANICAL BLEED VALVE WHICH WAS NOT INSTALLED AT THE PROPER TORQUE.
Consequence Summary:
A FUEL LEAK CAN OCCUR AT THE VALVE, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
R&B, INC. WILL NOTIFY OWNERS AND AT THE CUSTOMERS REQUEST, EITHER REPLACE THE FUEL LINE OR OFFER A FULL REFUND. THE RECALL BEGAN ON MAY 4, 2006. OWNERS MAY CONTACT R&B, INC. AT 215-712-5330.
Notes:
THIS RECALL ONLY PERTAINS TO R&B, INC. AFTERMARKET CMFI RETURN FUEL LINES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
-->| NHTSA Campaign Number: | 94V177000 |
| Vehicle/Equipment Make: | SHERRY DESIGNS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1993 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:HEAD RESTRAINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910901 - 19940101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 381 |
| Date Owner Notified By Manufacturer: | 19941223 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SHERRY DESIGNS, INC. |
| Report Received Date: | 19940914 |
| Record Creation Date: | 19940922 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 202 |
Defect Summary:
THE FRONT DRIVER AND PASSENGER SEAT BACK HEIGHT DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 202, "HEAD RESTRAINTS."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: SEAT OCCUPANTS ARE SUBJECT TO INCREASED RISK OF INJURY IN THE EVENT OF A SUDD STOP OR ACCIDENT.
Corrective Summary:
SHERRY DESIGNS WILL PROVIDE AN ATTACHABLE HEADREST FOR THE DEALER OR CUSTOMER TO ADD TO THE SEATS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT HEAD RESTRAINTS.VEHICLE DESCRIPTION: CONVERSION VANS.NOTE: IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE NONCOMPLIANCE, PLEASE CONTACT SHERRY DESIGNS AT 1-219-264-0602. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1992 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 06E041000 |
| Vehicle/Equipment Make: | R&B, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1992 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 7800 |
| Date Owner Notified By Manufacturer: | 20060504 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | R&B, INC. |
| Report Received Date: | 20060518 |
| Record Creation Date: | 20060518 |
Defect Summary:
CERTAIN R&B, INC. CENTRAL MULTIPORT FUEL INJECTION (CMFI) FUEL RETURN LINES, MODELS HELP 55163, NAPA BALKAMP 700-3270, AND THE CONNECTION 2560001, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL RETURN LINE HAS A MECHANICAL BLEED VALVE WHICH WAS NOT INSTALLED AT THE PROPER TORQUE.
Consequence Summary:
A FUEL LEAK CAN OCCUR AT THE VALVE, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
R&B, INC. WILL NOTIFY OWNERS AND AT THE CUSTOMERS REQUEST, EITHER REPLACE THE FUEL LINE OR OFFER A FULL REFUND. THE RECALL BEGAN ON MAY 4, 2006. OWNERS MAY CONTACT R&B, INC. AT 215-712-5330.
Notes:
THIS RECALL ONLY PERTAINS TO R&B, INC. AFTERMARKET CMFI RETURN FUEL LINES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
-->| NHTSA Campaign Number: | 94V177000 |
| Vehicle/Equipment Make: | SHERRY DESIGNS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1992 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:HEAD RESTRAINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910901 - 19940101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 381 |
| Date Owner Notified By Manufacturer: | 19941223 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SHERRY DESIGNS, INC. |
| Report Received Date: | 19940914 |
| Record Creation Date: | 19940922 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 202 |
Defect Summary:
THE FRONT DRIVER AND PASSENGER SEAT BACK HEIGHT DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 202, "HEAD RESTRAINTS."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: SEAT OCCUPANTS ARE SUBJECT TO INCREASED RISK OF INJURY IN THE EVENT OF A SUDD STOP OR ACCIDENT.
Corrective Summary:
SHERRY DESIGNS WILL PROVIDE AN ATTACHABLE HEADREST FOR THE DEALER OR CUSTOMER TO ADD TO THE SEATS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT HEAD RESTRAINTS.VEHICLE DESCRIPTION: CONVERSION VANS.NOTE: IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE NONCOMPLIANCE, PLEASE CONTACT SHERRY DESIGNS AT 1-219-264-0602. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V164000 |
| Vehicle/Equipment Make: | SHERROD VANS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4842 |
| Date Owner Notified By Manufacturer: | 19920604 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SHERROD VANS, INC. |
| Report Received Date: | 19910920 |
| Record Creation Date: | 19910926 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
SEAT BELT ANCHORAGE BAR FOR REAR SOFA FAILED TO SUSTAIN LOADS REQUIRED BY FMVSS 210.
Consequence Summary:
VEHICLES WOULD NOT COMPLY WITH FMVSS 210.
Corrective Summary:
REPLACE NONCOMPLYING SOFA BAR WITH BAR THAT MEETS REQUIREMENTS.
Notes:
SYSTEM: SEAT BELT ANCHORAGE; FMVSS 210.VEHICLE DESCRIPTION: VANS.NOTE: THIS RECALL IS BEING CONDUCTED BY SHERROD VANS, INC.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1991 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEATS
-->| NHTSA Campaign Number: | 93V187000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 604207 |
| Date Owner Notified By Manufacturer: | 19940120 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19931116 |
| Record Creation Date: | 19931129 |
Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT TRACKS, ANCHORS, AND SEATS.VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITHKNOB TYPE RECLINER MECHANISMS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE GMC SERVICE CENTER AT 1-313-456-4547 OR THE CHEVROLET SERVICE CENTERAT 1-800-222-1020. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V102000 |
| Vehicle/Equipment Make: | ASC COLAMCO |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 19910913 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ASC COLAMCO |
| Report Received Date: | 19910614 |
| Record Creation Date: | 19910627 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
THE SEAT BELTS FOR THE FRONT AND MID-SHIP SEATS DID NOT REST ON PELVIS AS REQUIRED BY FMVSS 209.
Consequence Summary:
SEAT BELTS MAY NOT RESTRAIN SEAT OCCUPANT, AND COULDINJURE THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.
Corrective Summary:
RELOCATE SEAT BELT ANCHOR BOLTS TO ADJUST BELTS FOR SEAT LOCATIONS.
Notes:
SYSTEM: SAFETY BELT/FMVSS 209.VEHICLE DESCRIPTION: VAN CONVERSIONS.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1990 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V164000 |
| Vehicle/Equipment Make: | SHERROD VANS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4842 |
| Date Owner Notified By Manufacturer: | 19920604 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SHERROD VANS, INC. |
| Report Received Date: | 19910920 |
| Record Creation Date: | 19910926 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
SEAT BELT ANCHORAGE BAR FOR REAR SOFA FAILED TO SUSTAIN LOADS REQUIRED BY FMVSS 210.
Consequence Summary:
VEHICLES WOULD NOT COMPLY WITH FMVSS 210.
Corrective Summary:
REPLACE NONCOMPLYING SOFA BAR WITH BAR THAT MEETS REQUIREMENTS.
Notes:
SYSTEM: SEAT BELT ANCHORAGE; FMVSS 210.VEHICLE DESCRIPTION: VANS.NOTE: THIS RECALL IS BEING CONDUCTED BY SHERROD VANS, INC.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 90V146000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890601 - 19900401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 30640 |
| Date Owner Notified By Manufacturer: | 19900827 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900813 |
| Record Creation Date: | 19900823 |
Defect Summary:
FUEL RETURN HOSES MAY BREAK AT EITHER CRIMPED COUPLING, CAUSING A LEAKAGE OF FUEL.
Consequence Summary:
IN THE EVENT OF A FUEL RETURN LINE SEPARATION, A FUELLEAK OCCURRING IN THE PRESENCE OF AN IGNITION SOURCE COULD CAUSE A FIRE.
Corrective Summary:
INSTALL A PROPERLY CRIMPED FUEL RETURN HOSE.
Notes:
SYSTEM: FUEL RETURN HOSES.VEHICLE DESCRIPTION: SCHOOL BUSES AND TRUCK VANS EQUIPPED WITH 6.0 L TBI GASENGINE AND 60 GALLON FUEL TANK.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1990 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEATS
-->| NHTSA Campaign Number: | 93V187000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 604207 |
| Date Owner Notified By Manufacturer: | 19940120 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19931116 |
| Record Creation Date: | 19931129 |
Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT TRACKS, ANCHORS, AND SEATS.VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITHKNOB TYPE RECLINER MECHANISMS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE GMC SERVICE CENTER AT 1-313-456-4547 OR THE CHEVROLET SERVICE CENTERAT 1-800-222-1020. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V102000 |
| Vehicle/Equipment Make: | ASC COLAMCO |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 19910913 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ASC COLAMCO |
| Report Received Date: | 19910614 |
| Record Creation Date: | 19910627 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
THE SEAT BELTS FOR THE FRONT AND MID-SHIP SEATS DID NOT REST ON PELVIS AS REQUIRED BY FMVSS 209.
Consequence Summary:
SEAT BELTS MAY NOT RESTRAIN SEAT OCCUPANT, AND COULDINJURE THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.
Corrective Summary:
RELOCATE SEAT BELT ANCHOR BOLTS TO ADJUST BELTS FOR SEAT LOCATIONS.
Notes:
SYSTEM: SAFETY BELT/FMVSS 209.VEHICLE DESCRIPTION: VAN CONVERSIONS.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1989 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V164000 |
| Vehicle/Equipment Make: | SHERROD VANS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4842 |
| Date Owner Notified By Manufacturer: | 19920604 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SHERROD VANS, INC. |
| Report Received Date: | 19910920 |
| Record Creation Date: | 19910926 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
SEAT BELT ANCHORAGE BAR FOR REAR SOFA FAILED TO SUSTAIN LOADS REQUIRED BY FMVSS 210.
Consequence Summary:
VEHICLES WOULD NOT COMPLY WITH FMVSS 210.
Corrective Summary:
REPLACE NONCOMPLYING SOFA BAR WITH BAR THAT MEETS REQUIREMENTS.
Notes:
SYSTEM: SEAT BELT ANCHORAGE; FMVSS 210.VEHICLE DESCRIPTION: VANS.NOTE: THIS RECALL IS BEING CONDUCTED BY SHERROD VANS, INC.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1989 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEATS
-->| NHTSA Campaign Number: | 93V187000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 604207 |
| Date Owner Notified By Manufacturer: | 19940120 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19931116 |
| Record Creation Date: | 19931129 |
Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT TRACKS, ANCHORS, AND SEATS.VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITHKNOB TYPE RECLINER MECHANISMS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE GMC SERVICE CENTER AT 1-313-456-4547 OR THE CHEVROLET SERVICE CENTERAT 1-800-222-1020. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V102000 |
| Vehicle/Equipment Make: | ASC COLAMCO |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 19910913 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ASC COLAMCO |
| Report Received Date: | 19910614 |
| Record Creation Date: | 19910627 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
THE SEAT BELTS FOR THE FRONT AND MID-SHIP SEATS DID NOT REST ON PELVIS AS REQUIRED BY FMVSS 209.
Consequence Summary:
SEAT BELTS MAY NOT RESTRAIN SEAT OCCUPANT, AND COULDINJURE THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.
Corrective Summary:
RELOCATE SEAT BELT ANCHOR BOLTS TO ADJUST BELTS FOR SEAT LOCATIONS.
Notes:
SYSTEM: SAFETY BELT/FMVSS 209.VEHICLE DESCRIPTION: VAN CONVERSIONS.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1988 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1988 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEATS
-->| NHTSA Campaign Number: | 93V187000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1988 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 604207 |
| Date Owner Notified By Manufacturer: | 19940120 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19931116 |
| Record Creation Date: | 19931129 |
Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT TRACKS, ANCHORS, AND SEATS.VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITHKNOB TYPE RECLINER MECHANISMS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE GMC SERVICE CENTER AT 1-313-456-4547 OR THE CHEVROLET SERVICE CENTERAT 1-800-222-1020. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V102000 |
| Vehicle/Equipment Make: | ASC COLAMCO |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1988 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 19910913 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ASC COLAMCO |
| Report Received Date: | 19910614 |
| Record Creation Date: | 19910627 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
THE SEAT BELTS FOR THE FRONT AND MID-SHIP SEATS DID NOT REST ON PELVIS AS REQUIRED BY FMVSS 209.
Consequence Summary:
SEAT BELTS MAY NOT RESTRAIN SEAT OCCUPANT, AND COULDINJURE THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.
Corrective Summary:
RELOCATE SEAT BELT ANCHOR BOLTS TO ADJUST BELTS FOR SEAT LOCATIONS.
Notes:
SYSTEM: SAFETY BELT/FMVSS 209.VEHICLE DESCRIPTION: VAN CONVERSIONS.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1987 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1987 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEATS
-->| NHTSA Campaign Number: | 93V187000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1987 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 604207 |
| Date Owner Notified By Manufacturer: | 19940120 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19931116 |
| Record Creation Date: | 19931129 |
Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT TRACKS, ANCHORS, AND SEATS.VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITHKNOB TYPE RECLINER MECHANISMS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE GMC SERVICE CENTER AT 1-313-456-4547 OR THE CHEVROLET SERVICE CENTERAT 1-800-222-1020. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V102000 |
| Vehicle/Equipment Make: | ASC COLAMCO |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1987 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 19910913 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ASC COLAMCO |
| Report Received Date: | 19910614 |
| Record Creation Date: | 19910627 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
THE SEAT BELTS FOR THE FRONT AND MID-SHIP SEATS DID NOT REST ON PELVIS AS REQUIRED BY FMVSS 209.
Consequence Summary:
SEAT BELTS MAY NOT RESTRAIN SEAT OCCUPANT, AND COULDINJURE THE SEAT OCCUPANT IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.
Corrective Summary:
RELOCATE SEAT BELT ANCHOR BOLTS TO ADJUST BELTS FOR SEAT LOCATIONS.
Notes:
SYSTEM: SAFETY BELT/FMVSS 209.VEHICLE DESCRIPTION: VAN CONVERSIONS.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1986 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEATS
-->| NHTSA Campaign Number: | 93V187000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1986 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 604207 |
| Date Owner Notified By Manufacturer: | 19940120 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19931116 |
| Record Creation Date: | 19931129 |
Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT TRACKS, ANCHORS, AND SEATS.VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITHKNOB TYPE RECLINER MECHANISMS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE GMC SERVICE CENTER AT 1-313-456-4547 OR THE CHEVROLET SERVICE CENTERAT 1-800-222-1020. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1985 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
-->| NHTSA Campaign Number: | 85V160000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1985 |
| Manufacturer Component Description: | STEERING:GEAR BOX (OTHER THAN RACK AND PINION) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19850201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 26741 |
| Date Owner Notified By Manufacturer: | 19860425 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851203 |
| Record Creation Date: | 19851209 |
Defect Summary:
A PART OF THE STEERING GEAR HOUSING WHICH ATTACHES TO THE FRAME MAY BREAK. CONSEQUENCE OF DEFECT: STEERING DIFFICULTIES WILL OCCUR AND THE STEERING GEAR TO THE FRAME MAY FRACTURE RESULTING IN LOSS OF STEERING CONTROL. THIS COULD RESULT IN A VEHICLE CRASH.
Corrective Summary:
REPLACE BROKEN OR CRACKED STEERING GEAR OR INSTALL A BRACE IF STEERING GEAR IS NOT BROKEN OR CRACKED.
Notes:
SYSTEM: STEERING GEAR ATTACHING BOSS. VEHICLE DESCRIPTION: LIGHT DUTY VAN EQUIPPED WITH RPON40 POWER STEERING.
CHEVROLET: ASTRO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1985 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: PARKING BRAKE:DRIVELINE:AIR:CHAMBER
-->| NHTSA Campaign Number: | 85V124000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1985 |
| Manufacturer Component Description: | PARKING BRAKE:DRIVELINE:AIR:CHAMBER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820701 - 19850201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4870 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851007 |
| Record Creation Date: | 19851016 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 121 |
Defect Summary:
THE REAR BRAKE RELEASE TIME MAY BE GREATER THAN THE TIME SPECIFIED IN FMVSS 121, "AIR BRAKE SYSTEM". IN ADDITION, SOME TRACTORS MAY HAVE WARPED PARKING BRAKE APPLY SPRINGS WHICH ALSO EFFECT THE REAR BRAKE RELEASE TIME. CONSEQUENCE OF DEFECT: TRACTORS FAIL TO MEET THE STOPPING DISTANCE SPECIFIED IN FMVSS 121 WHICH IS REQUIRED TO STOP THE TRUCK SAFELY.
Corrective Summary:
INSTALL A QUICK RELEASE VALVE IN THE TRAILER SERVICE AIR LINE AND INCREASE THE DIAMETER OF THE REAR SERVICE BRAKE LINE. ALSO INSPECT REAR SPRING BRAKE CHAMBER AND RELEASE IF NECESSARY.
Notes:
SYSTEM: AIR BRAKES. VEHICLE DESCRIPTION: TRACTORS EQUIPPED WITH RPO RQ3 TRACTOR APPLICATION.
CHEVROLET: ASTRO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1985 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: ASTRO: SEATS
-->| NHTSA Campaign Number: | 93V187000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1985 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 604207 |
| Date Owner Notified By Manufacturer: | 19940120 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19931116 |
| Record Creation Date: | 19931129 |
Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT TRACKS, ANCHORS, AND SEATS.VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITHKNOB TYPE RECLINER MECHANISMS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE GMC SERVICE CENTER AT 1-313-456-4547 OR THE CHEVROLET SERVICE CENTERAT 1-800-222-1020. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: ASTRO: PARKING BRAKE:DRIVELINE:AIR:CHAMBER
-->| NHTSA Campaign Number: | 85V124000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1984 |
| Manufacturer Component Description: | PARKING BRAKE:DRIVELINE:AIR:CHAMBER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820701 - 19850201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4870 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851007 |
| Record Creation Date: | 19851016 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 121 |
Defect Summary:
THE REAR BRAKE RELEASE TIME MAY BE GREATER THAN THE TIME SPECIFIED IN FMVSS 121, "AIR BRAKE SYSTEM". IN ADDITION, SOME TRACTORS MAY HAVE WARPED PARKING BRAKE APPLY SPRINGS WHICH ALSO EFFECT THE REAR BRAKE RELEASE TIME. CONSEQUENCE OF DEFECT: TRACTORS FAIL TO MEET THE STOPPING DISTANCE SPECIFIED IN FMVSS 121 WHICH IS REQUIRED TO STOP THE TRUCK SAFELY.
Corrective Summary:
INSTALL A QUICK RELEASE VALVE IN THE TRAILER SERVICE AIR LINE AND INCREASE THE DIAMETER OF THE REAR SERVICE BRAKE LINE. ALSO INSPECT REAR SPRING BRAKE CHAMBER AND RELEASE IF NECESSARY.
Notes:
SYSTEM: AIR BRAKES. VEHICLE DESCRIPTION: TRACTORS EQUIPPED WITH RPO RQ3 TRACTOR APPLICATION.
CHEVROLET: ASTRO: PARKING BRAKE:DRIVELINE:AIR:CHAMBER
-->| NHTSA Campaign Number: | 85V124000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | ASTRO |
| Model Year: | 1983 |
| Manufacturer Component Description: | PARKING BRAKE:DRIVELINE:AIR:CHAMBER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820701 - 19850201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4870 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851007 |
| Record Creation Date: | 19851016 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 121 |
Defect Summary:
THE REAR BRAKE RELEASE TIME MAY BE GREATER THAN THE TIME SPECIFIED IN FMVSS 121, "AIR BRAKE SYSTEM". IN ADDITION, SOME TRACTORS MAY HAVE WARPED PARKING BRAKE APPLY SPRINGS WHICH ALSO EFFECT THE REAR BRAKE RELEASE TIME. CONSEQUENCE OF DEFECT: TRACTORS FAIL TO MEET THE STOPPING DISTANCE SPECIFIED IN FMVSS 121 WHICH IS REQUIRED TO STOP THE TRUCK SAFELY.
Corrective Summary:
INSTALL A QUICK RELEASE VALVE IN THE TRAILER SERVICE AIR LINE AND INCREASE THE DIAMETER OF THE REAR SERVICE BRAKE LINE. ALSO INSPECT REAR SPRING BRAKE CHAMBER AND RELEASE IF NECESSARY.
Notes:
SYSTEM: AIR BRAKES. VEHICLE DESCRIPTION: TRACTORS EQUIPPED WITH RPO RQ3 TRACTOR APPLICATION.
--CHEVROLET: AVALANCHE 1500: SUSPENSION:REAR:AXLE:SPINDLE
| NHTSA Campaign Number: | 10V643000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE 1500 |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 100426 |
| Manufacturer Component Description: | SUSPENSION:REAR:AXLE:SPINDLE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1262 |
| Date Owner Notified By Manufacturer: | 20110111 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101217 |
| Record Creation Date: | 20101222 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE EXT, CHEVROLET AVALANCHE, SILVERADO LD AND GMC SIERRA LD VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 100426.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: AVALANCHE 1500: SUSPENSION:REAR:AXLE:SPINDLE
| NHTSA Campaign Number: | 11V007000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE 1500 |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 10426A |
| Manufacturer Component Description: | SUSPENSION:REAR:AXLE:SPINDLE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20101118 - 20101220 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 30566 |
| Date Owner Notified By Manufacturer: | 20110111 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20110106 |
| Record Creation Date: | 20110111 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
THIS RECALL CAMPAIGN IS AN EXPANSION TO 10V-643.GM'S SAFETY RECALL NO. 10426A.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: AVALANCHE: EXTERIOR LIGHTING
| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: AVALANCHE: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2002 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
| NHTSA Campaign Number: | 04V129000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 4007 |
| Manufacturer Component Description: | STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001001 - 20020731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3662211 |
| Date Owner Notified By Manufacturer: | 20040918 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040317 |
| Record Creation Date: | 20040322 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence Summary:
ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Corrective Summary:
DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Notes:
GM RECALL NO. 04007.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: AVALANCHE: SERVICE BRAKES, HYDRAULIC:ANTILOCK
| NHTSA Campaign Number: | 05V379000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 5068 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010101 - 20020831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1353718 |
| Date Owner Notified By Manufacturer: | 20050922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050829 |
| Record Creation Date: | 20050829 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Consequence Summary:
THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05068. GM REVISED THE INVOLVED VEHICLES BY AMENDING THE ORIGINAL 573 REPORT ON OCTOBER 4, 2005. GM REVISED THE ORIGINAL 573 REPORT ON DECEMBER 16, 2005, TO INCLUDE ADDITIONAL STATES AND VEHICLE POPULATION.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: EXTERIOR LIGHTING
| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: AVALANCHE: SERVICE BRAKES, HYDRAULIC
| NHTSA Campaign Number: | 04V045000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4004 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030501 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 68875 |
| Date Owner Notified By Manufacturer: | 20040618 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 135 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence Summary:
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective Summary:
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: AVALANCHE: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2003 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
| NHTSA Campaign Number: | 04V129000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4007 |
| Manufacturer Component Description: | STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3662211 |
| Date Owner Notified By Manufacturer: | 20040918 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040317 |
| Record Creation Date: | 20040322 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence Summary:
ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Corrective Summary:
DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Notes:
GM RECALL NO. 04007.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: AVALANCHE: SEAT BELTS:REAR
| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020403 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
| NHTSA Campaign Number: | 03V019000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3002 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20030131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5734 |
| Date Owner Notified By Manufacturer: | 20030220 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030127 |
| Record Creation Date: | 20030205 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, VEHICLES, DURING A 30 DEGREE LEFT ANGLE FRONTAL IMPACT OF SUFFICIENT SEVERITY, A TEAR COULD DEVELOP IN THE MID-FRAME CROSS MEMBER AT ITS ATTACHMENT TO THE LEFT FRAME RAIL. IF THE MID-FRAME CROSS MEMBER TEARS DURING FRONTAL IMPACT AND PRODUCES A SHARP EDGE, CONTACT OF THE SHARP EDGE WITH THE FUEL TANK COULD RESULT IN A PUNCTURE OF THE FUEL TANK AND POSSIBLE FUEL LEAKAGE.
Consequence Summary:
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A FUEL TANK SHIELD. OWNER NOTIFICATION BEGAN FEBRUARY 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03002.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: AVALANCHE: SERVICE BRAKES, HYDRAULIC
| NHTSA Campaign Number: | 04V045000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4004 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030501 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 68875 |
| Date Owner Notified By Manufacturer: | 20040618 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 135 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence Summary:
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective Summary:
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: AVALANCHE: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2004 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
| NHTSA Campaign Number: | 04V129000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4007 |
| Manufacturer Component Description: | STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030301 - 20031130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3662211 |
| Date Owner Notified By Manufacturer: | 20040918 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040317 |
| Record Creation Date: | 20040322 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence Summary:
ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Corrective Summary:
DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Notes:
GM RECALL NO. 04007.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: AVALANCHE: SEAT BELTS:REAR
| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030408 - 20040804 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: SERVICE BRAKES, HYDRAULIC
| NHTSA Campaign Number: | 05V043000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5006 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040201 - 20040831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77411 |
| Date Owner Notified By Manufacturer: | 20050323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050208 |
| Record Creation Date: | 20050208 |
Defect Summary:
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence Summary:
IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05006.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: ENGINE AND ENGINE COOLING
| NHTSA Campaign Number: | 06V289000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 6080 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030401 - 20040831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 38439 |
| Date Owner Notified By Manufacturer: | 20060831 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060803 |
| Record Creation Date: | 20060803 |
Defect Summary:
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence Summary:
IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Notes:
GM RECALL NO. 06080.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: SEAT BELTS:REAR
| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040224 - 20041102 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: SERVICE BRAKES, HYDRAULIC
| NHTSA Campaign Number: | 05V043000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5006 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040401 - 20040930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77411 |
| Date Owner Notified By Manufacturer: | 20050323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050208 |
| Record Creation Date: | 20050208 |
Defect Summary:
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence Summary:
IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05006.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR
| NHTSA Campaign Number: | 05V055000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5023 |
| Manufacturer Component Description: | POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050101 - 20050228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 7194 |
| Date Owner Notified By Manufacturer: | 20050222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050214 |
| Record Creation Date: | 20050215 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 102 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence Summary:
THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Corrective Summary:
DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05023.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: EQUIPMENT:OTHER:LABELS
| NHTSA Campaign Number: | 05V552000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5109 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050901 - 20050907 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 32068 |
| Date Owner Notified By Manufacturer: | 20060331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051207 |
| Record Creation Date: | 20051207 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence Summary:
A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Notes:
GM RECALL NO. 05109.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: AVALANCHE: ELECTRICAL SYSTEM
| NHTSA Campaign Number: | 10V240000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2007 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1365070 |
| Date Owner Notified By Manufacturer: | 20100611 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100604 |
| Record Creation Date: | 20100604 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence Summary:
IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Corrective Summary:
DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: AVALANCHE: ELECTRICAL SYSTEM
| NHTSA Campaign Number: | 08V441000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 8048 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050930 - 20070731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 857735 |
| Date Owner Notified By Manufacturer: | 20080912 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080828 |
| Record Creation Date: | 20080828 |
Defect Summary:
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence Summary:
THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08048. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: AVALANCHE: ELECTRICAL SYSTEM
| NHTSA Campaign Number: | 10V240000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2008 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1365070 |
| Date Owner Notified By Manufacturer: | 20100611 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100604 |
| Record Creation Date: | 20100604 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence Summary:
IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Corrective Summary:
DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: AVALANCHE: ELECTRICAL SYSTEM
| NHTSA Campaign Number: | 08V441000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 8048 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20070430 - 20071130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 857735 |
| Date Owner Notified By Manufacturer: | 20080912 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080828 |
| Record Creation Date: | 20080828 |
Defect Summary:
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence Summary:
THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08048. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: AVALANCHE: ELECTRICAL SYSTEM
| NHTSA Campaign Number: | 10V240000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2009 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1365070 |
| Date Owner Notified By Manufacturer: | 20100611 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100604 |
| Record Creation Date: | 20100604 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence Summary:
IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Corrective Summary:
DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: AVALANCHE: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 09V154000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 8411 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20080601 - 20080930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27188 |
| Date Owner Notified By Manufacturer: | 20090518 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090506 |
| Record Creation Date: | 20090506 |
Defect Summary:
GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.
Consequence Summary:
WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 08411.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: AVALANCHE: EQUIPMENT
| NHTSA Campaign Number: | 10E043000 |
| Vehicle/Equipment Make: | MARATHON SEAT COVERS, INC. |
| Vehicle/Equipment Model: | AVALANCHE |
| Model Year: | 2010 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 294 |
| Date Owner Notified By Manufacturer: | 20100914 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | MARATHON SEAT COVERS, INC. |
| Report Received Date: | 20100903 |
| Record Creation Date: | 20100910 |
Defect Summary:
MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.
Consequence Summary:
AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
Corrective Summary:
MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET MARATHON SEAT COVERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON GENERAL MOTORS, FORD, CHRYSLER, TOYOTA, OR NISSAN VEHICLES.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: AVEO: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 04V407000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVEO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4069 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030901 - 20040731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 32301 |
| Date Owner Notified By Manufacturer: | 20041011 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040817 |
| Record Creation Date: | 20040819 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES, THE REAR SAFETY BELT CAN BECOME TWISTED.
Consequence Summary:
IF THIS OCCURS THE SAFETY BELT RETRACTOR MAY LOCK IN POSITION SO THAT THE BELT CANNOT BE USED. IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO THE SEAT OCCUPANT COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A SAFETY BELT WEBBING GUIDE TO PREVENT THE BELT FROM TWISTING. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438. VEHICLE OWNERS LOCATED IN GUAM SHOULD CONTACT GM CUSTOMER ASSISTANCE AT 1-671-648-8453.
Notes:
GM RECALL NO.04069.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: AVEO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06V398000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | AVEO |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 6133 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20051201 - 20060930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 17676 |
| Date Owner Notified By Manufacturer: | 20061116 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20061017 |
| Record Creation Date: | 20061017 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF WHICH ALLOWED THE FUEL PUMP TO CONTINUE RUNNING AND FUEL LEAKED ONTO THE GROUND.
Consequence Summary:
IF THESE CONDITIONS OCCURRED IN AN ACTUAL CRASH, A VEHICLE FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL REPLACE THE FUSE BLOCK AND INSTALL A NEW SECTION OF FUEL LINE THAT HAS BEEN REDESIGNED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 06133. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: BELAIR: STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT
| NHTSA Campaign Number: | 67V098000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1965 |
| Manufacturer Component Description: | STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1143000 |
| Date Owner Notified By Manufacturer: | 19671023 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19671023 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT, AFTER EXTENDED MILEAGE, THE IDLER ARM ASSEMBLY COULD SEPARATE DURING VEHICLE OPERATION AND RESULT IN A SEVERE PULL TO THE RIGHT AS BRAKES ARE APPLIED AT LOW TO MODERATE SPEED.(INSPECT AND RE- PLACE IDLER ARM ASSEMBLY AS REQUIRED.)
--CHEVROLET: BELAIR: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: BELAIR: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: BELAIR: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: BELAIR: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
-- --CHEVROLET: BELAIR: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: BELAIR: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BELAIR: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: BELAIR: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BELAIR: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: BELAIR: TIRES
| NHTSA Campaign Number: | 69V020000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1969 |
| Manufacturer Component Description: | TIRES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1396 |
| Date Owner Notified By Manufacturer: | 19690214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690220 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT FIRESTONE TIRES (8.25 X 14 WHITE SIDEWALL 4-PLY RATED), MAYNOT MEET MINIMUM STRENGTH REQUIREMENTS.FAILURE IN BODY OF TIRE COULD RESULTIN LOSS OF TIRE PRESSURE.(CORRECT BY RE- PLACING ALL TIRES WITH NEW IMPROVEDTYPE.)
CHEVROLET: BELAIR: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 69V091000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1969 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 24017 |
| Date Owner Notified By Manufacturer: | 19690703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690709 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT FILLER PLATE WAS OMITTED FROM LEFT REAR FLOOR PAN AREA BETWEENBUMPER AND FUEL TANK.IF THIS PLATE IS MISSING IT COULD ALLOW DUST AND, UNDERCERTAIN CONDITIONS, EXHAUST FUMES TO ENTER PASSENGER COMPARTMENT.(CORRECT BYINSPECTING AND INSTALLING FILLER PLATE WHEN NECESSARY.)
CHEVROLET: BELAIR: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BELAIR: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1971 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BELAIR: VEHICLE SPEED CONTROL
| NHTSA Campaign Number: | 70V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1971 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12600 |
| Date Owner Notified By Manufacturer: | 19701125 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19701203 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT THROTTLE ROD TO THROTTLE LEVER RETAINING CLIP ON CARBURETORMAY BE INCORRECTLY INSTALLED.IF THIS CONDITION EXISTS, THROTTLE LEVER COULDBE HELD IN PARTIALLY OPEN POSITION.IF THIS OCCURS WHILE VEHICLE IS IN MOTION,VEHICLE WILL NOT SLOW DOWN WHEN DRIVER'S FOOT IS REMOVED FROM ACCELERATOR.(CORRECT BY REPLACING CLIP WITH IMPROVED DESIGN WHERE NECESSARY.)
CHEVROLET: BELAIR: EQUIPMENT:MECHANICAL:JACKS
| NHTSA Campaign Number: | 71V121000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1971 |
| Manufacturer Component Description: | EQUIPMENT:MECHANICAL:JACKS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6000 |
| Date Owner Notified By Manufacturer: | 19710708 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19710720 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 71-C-11.STATION WAGONS ONLY.POSSIBIL ITY THAT BUMPERJACK LOAD REST LIP MAY NOT BE PROPERLY FORMEDALLOWING IT TO BEND AND VEHICLESLIP FROM JACK LOAD REST.(CO RRECT BY INSTALLING CORRECT JACK CORRECT JACKWHERENECESSARY. )
CHEVROLET: BELAIR: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1972 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BELAIR: SEATS
| NHTSA Campaign Number: | 72V185000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1972 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720501 - 19720501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1699 |
| Date Owner Notified By Manufacturer: | 19720719 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19720719 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 72-C-2.CHEVROLET CAMPAIGN NO 72-C-10.PONTIACCAMPAIGN NO 72-C-4.POSSIBILITY THAT MANUAL FRONT SEAT ADJUSTER MAY NOT HAVEBEEN INSTALLED PROPERLY AND MAY NOT STAY ENGAGED IN ADJUSTER TRACK DURING ANIMPACT, AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.207.(CORRECT BY INSTALLING NEW SEAT ADJUSTER ON PASSENGER SIDE OF FRONT SEAT.)
CHEVROLET: BELAIR: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: BELAIR: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 73V244000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1974 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 9215 |
| Date Owner Notified By Manufacturer: | 19740102 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731219 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTORS CAMPAIGN NO CHEVROLET 74-C-07.STATION WAGON.POSSIBILITY THATTHE REAR BRAKE PIPE WAS IMPROPERLY POSITIONED WHEN ATTACHED TO THE REAR AXLEASSEMBLY.THIS MAY RESULT IN REPEATED CONTACT OF THE PIPE WITH THE UNDERBODY,CAUSING IT TO FLEX UP AND DOWN UNTIL IT BREAKS, RESULTING IN LOSS OF BRAKEFLUID AND LOSS OF REAR BRAKING ACTION.(CORRECT BY INSPECTING AND INSTALLINGBRAKE PIPE PROPERLY)).
CHEVROLET: BELAIR: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
| NHTSA Campaign Number: | 73V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1974 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 782111 |
| Date Owner Notified By Manufacturer: | 19740109 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731227 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 74-C-09.PONTIAC 74-C-2.BUICK 74-C-2.OLDSMOBILE74-C-3.SPRINT 74-C-4.POSSIBILITY THAT THE FRONT UPPER CONTROL ARM INNERBUSHING RETAINER NUTS MAY LOOSEN AND COME OFF DURING NORMAL OPERATINGCONDITIONS.SHOULD THIS OCCUR, THE LOOSE CONTROL ARM MAY MOVE FORWARD ANDCONTACT THE UPPER CONTROL ARM MOUNTING BRACKET ON THE FRAME WHICH RESTRICTS ANYFURTHER FORWARD MOVEMENT.IF THIS VEHICLE IS OPERATED IN THIS CONDITION IT ISPOSSIBLE FOR THE CONTROL ARM CROSS SHAFT TO BREAK.(CORRECT BY INSPECTING ANDINSTALLING NEW BUSHING RETAINERS WHERE NECESSARY.)
CHEVROLET: BELAIR: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1974 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: BELAIR: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1974 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BELAIR: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BELAIR: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
| NHTSA Campaign Number: | 75V214000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 39278 |
| Date Owner Notified By Manufacturer: | 19751223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19751219 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C04, PONTIAC CAMPAIGN NO. 76C7, OLDSMOBILE CAMPAIGN NO.76C1, BUICK CAMPAIGN NO. 76C1.POSSIBILITY THAT THE COMBINATION VALVE, WHICHIS A PART OF THE HYDRAULIC SERVICE BRAKE SYSTEM MAY HAVE BEEN IMPROPERLYMANUFACTURED AND COULD MALFUNCTION.SHOULD THIS CONDITION OCCUR WHILE VEHICLEIS IN MOTION AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED.A VEHICLECRASH COULD OCCUR WITHOUT PRIOR WARNING.(CORRECT BY INSPECTING AND REPLACINGVALVE WHERE NECESSARY.) PASSENGER CARS AND LIGHT TRUCKS.
CHEVROLET: BELAIR: STEERING:WHEEL AND HANDLE BAR
| NHTSA Campaign Number: | 76V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1977 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55564 |
| Date Owner Notified By Manufacturer: | 19760830 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760907 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 77-C-1.POSSIBILITY THAT THE STEERING INTERMEDIATESHAFT MAY HAVE BEEN ASSEMBLED WITH COUPLING RETAINER LOCKING TABS NOT BENT OVERPROPERLY OR ONE OR MORE OF THE LOWER FLEXIBLE COUPLING RIVETS IMPROPERLYPEENED.IF EITHER OF THESE CONDITIONS EXISTS, THE INTERMEDIATE SHAFT ASSEMBLYCOULD SEPARATE CAUSING LOSS OF STEERING CONTROL, AND VEHICLE CRASH MAY OCCURWITHOUT PRIOR WARNING.(CORRECT BY INSPECTING, AND REPLACING SHAFT WHERENECESSARY).PASSENGER VEHICLE.
CHEVROLET: BELAIR: EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
| NHTSA Campaign Number: | 76V175000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BELAIR |
| Model Year: | 1977 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:TURN SIGNAL:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 66632 |
| Date Owner Notified By Manufacturer: | 19761022 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19761103 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Notes:
GENERAL MOTOR CAMPAIGN NO (CHEVROLET) 77C02 (PONTIAC) 77-C-4 (BUICK) 77-C-5.POSSIBILITY THAT THE TURN SIGNAL OPERATING UNIT OR VEHICLES WITH TILT STEERINGCOLUMNS MAY NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.108.THE TURN SIGNAL LEVER ACTUATOR PIVOT PIN WHICH MAY WORK OUT OF THE PIVOT,RESULTING IN NOT BEING ABLE TO USE TURN SIGNAL TO ALERT OTHER DRIVERS OF YOURINTENTIONS TO CHANGE LANES OR TURN, CAUSING POSSIBLE VEHICLE CRASH.(CORRECTBY INSPECTING AND INSTALLING A RETAINER TO PRECLUDE PIVOT PIN DISENGAGEMENT).PASSENGER VEHICLE.
--CHEVROLET: BERETTA: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BERETTA: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
| NHTSA Campaign Number: | 88V039000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1987 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861101 - 19871101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 282052 |
| Date Owner Notified By Manufacturer: | 19880426 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880323 |
| Record Creation Date: | 19880328 |
Defect Summary:
SECONDARY HOOD LATCH ASSEMBLY MAY NOT HAVE BEEN PROPERLY ADJUSTED RESULTING IN LATCH BECOMING BENT.
Consequence Summary:
A BENT SECONDARY HOOD LATCH COULD CAUSE THE PRIMARYLATCH TO MALFUNCTION. IF THIS OCCURED THE HOOD COULD UNEXPECTEDLY OPEN. IFTHIS HAPPENED WHILE VEHICLE IS IN MOTION REDUCTION OF FORWARD VISIBILITY COULDCAUSE A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
INSPECT AND REPLACE SECONDARY HOOD LATCH ASSEMBLIES AS REQUIRED.
Notes:
SYSTEM: HOOD LATCH/SECONDARY.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BERETTA: STRUCTURE:BODY:HOOD
| NHTSA Campaign Number: | 91V135000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1987 |
| Manufacturer Component Description: | STRUCTURE:BODY:HOOD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860601 - 19871101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 290408 |
| Date Owner Notified By Manufacturer: | 19911021 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910819 |
| Record Creation Date: | 19910826 |
Defect Summary:
SECONDARY HOOD LATCH ASSEMBLY ON THESE VEHICLES MAY NOT BE PROPERLY ADJUSTED AND COULD BECOME BENT. THIS WILL LEAD TO A CONDITION WHERE FULL PRIMARY LATCH ENGAGEMENT IS NOT ATTAINED.
Consequence Summary:
A BENT SECONDARY HOOD LATCH COULD LEAD TO THE PRIMARYLATCH NOT BEING FULLY ENGAGED, ALLOWING THE HOOD TO UNEXPECTEDLY OPEN. IF THISWERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, THE HOOD MAY CONTACT THEWINDSHIELD, REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASHCOULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE THE PRIMARY HOOD LATCH ASSEMBLY, THE SECONDARY HOOD LATCH ASSEMBLY, AND THE SUPPORT BRACKET.
Notes:
SYSTEM: HOOD.VEHICLE DESCRIPTION: PASSENGER VEHICLES.
CHEVROLET: BERETTA: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
| NHTSA Campaign Number: | 86V165000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1987 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860801 - 19861101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4844 |
| Date Owner Notified By Manufacturer: | 19861213 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19861215 |
| Record Creation Date: | 19861222 |
Defect Summary:
SECONDARY HOOD LATCH MAY NOT PROPERLY ENGAGE DUE TO CONTACT WITH SUPPORT BRACKET AND/OR THE PRIMARY LATCH RETURN SPRING. CONSEQUENCE OF DEFECT: IF THIS OCCURS WHILE VEHICLE IS IN MOTION, HOOD COULD OPEN AND CONTACT THE WINDSHIELD, AFFECTING THE DRIVERS VISION AREA; THIS COULD RESULT IN A CRASH WITHOUT WARNING.
Corrective Summary:
INSTALL SECONDARY LATCH SKID PLATE ON CORSICA AND BERETTA MODELS. ALSO, INSTALL A REVISED SECONDARY LATCH ASSEMBLY ON BERETTA MODELS.
Notes:
SYSTEM: SECONDARY HOOD LATCH. VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BERETTA: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
| NHTSA Campaign Number: | 87V062000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1987 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861101 - 19861201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2020 |
| Date Owner Notified By Manufacturer: | 19861213 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19870507 |
| Record Creation Date: | 19870511 |
Defect Summary:
LOSS OF SKID PLATE COULD LEAD TO DISENGAGEMENT OF BOTH SECONDARY AND PRIMARY HOOD LATCHES.
Consequence Summary:
HOOD COULD OPEN UNEXPECTANTLY; IF VEHICLE WERE INMOTION, THE HOOD COULD CONTACT THE WINDSHIELD, REDUCE THE DRIVERS VISION AREA,AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
INSTALL A SECONDARY LATCH SKID PLATE AND/OR SECONDARY LATCH SKID PLATE RETAINING SCREWS.
Notes:
SYSTEM: SECONDARY HOOD LATCH.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BERETTA: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
| NHTSA Campaign Number: | 89V225000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1987 |
| Manufacturer Component Description: | STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861001 - 19870801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 170769 |
| Date Owner Notified By Manufacturer: | 19891208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19891218 |
| Record Creation Date: | 19900102 |
Defect Summary:
A DOOR HINGE (UPPER OR LOWER) MAY BREAK WHILE OPENING OR CLOSING THE DOOR MAKING IT DIFFICULT TO REPOSITION AND CLOSE PROPERLY.
Consequence Summary:
HINGE SEPARATION MAY REDUCE THE STRUCTURAL INTEGRITY OFTHE SIDE OF THE CAR AND INCREASE RISK OF INJURY IN CERTAIN TYPES OF ACCIDENTS.
Corrective Summary:
REPLACE DOOR HINGES ON BOTH DOORS.
Notes:
SYSTEM: DOOR HINGES.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BERETTA: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BERETTA: SEAT BELTS
| NHTSA Campaign Number: | 91V206000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1988 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880101 - 19900701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 722884 |
| Date Owner Notified By Manufacturer: | 19911218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911126 |
| Record Creation Date: | 19911126 |
Defect Summary:
THE FRONT SHOULDER BELT RETRACTORS MAY HAVE REDUCED SENSITIVITY OF THE LOCK-UP FEATURE AND WOULD NOT FUNCTION IN A SUDDEN DECELERATION OR CRASH.
Consequence Summary:
FAILURE OF THE SHOULDER BELT RETRACTOR WOULD RESULT INTHE SEAT OCCUPANT ONLY BEING RESTRAINED BY THE LAP BELT IN A CRASH OR SUDDENSTOP, AND AN INCREASED POSSIBILITY OF INJURY.
Notes:
SYSTEM: SAFETY BELTS (PASSIVE RESTRAINT).VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH DOOR MOUNTED SHOULDER AND LAPSAFETY BELT SYSTEMS.CORECTIVE ACTION: REPLACE THE FRONT SHOULDER BELT RETRACTORS AND ASSEMBLIES.
CHEVROLET: BERETTA: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
| NHTSA Campaign Number: | 88V039000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1988 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861101 - 19871101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 282052 |
| Date Owner Notified By Manufacturer: | 19880426 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880323 |
| Record Creation Date: | 19880328 |
Defect Summary:
SECONDARY HOOD LATCH ASSEMBLY MAY NOT HAVE BEEN PROPERLY ADJUSTED RESULTING IN LATCH BECOMING BENT.
Consequence Summary:
A BENT SECONDARY HOOD LATCH COULD CAUSE THE PRIMARYLATCH TO MALFUNCTION. IF THIS OCCURED THE HOOD COULD UNEXPECTEDLY OPEN. IFTHIS HAPPENED WHILE VEHICLE IS IN MOTION REDUCTION OF FORWARD VISIBILITY COULDCAUSE A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
INSPECT AND REPLACE SECONDARY HOOD LATCH ASSEMBLIES AS REQUIRED.
Notes:
SYSTEM: HOOD LATCH/SECONDARY.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BERETTA: STRUCTURE:BODY:HOOD
| NHTSA Campaign Number: | 91V135000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1988 |
| Manufacturer Component Description: | STRUCTURE:BODY:HOOD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860601 - 19871101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 290408 |
| Date Owner Notified By Manufacturer: | 19911021 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910819 |
| Record Creation Date: | 19910826 |
Defect Summary:
SECONDARY HOOD LATCH ASSEMBLY ON THESE VEHICLES MAY NOT BE PROPERLY ADJUSTED AND COULD BECOME BENT. THIS WILL LEAD TO A CONDITION WHERE FULL PRIMARY LATCH ENGAGEMENT IS NOT ATTAINED.
Consequence Summary:
A BENT SECONDARY HOOD LATCH COULD LEAD TO THE PRIMARYLATCH NOT BEING FULLY ENGAGED, ALLOWING THE HOOD TO UNEXPECTEDLY OPEN. IF THISWERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, THE HOOD MAY CONTACT THEWINDSHIELD, REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASHCOULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE THE PRIMARY HOOD LATCH ASSEMBLY, THE SECONDARY HOOD LATCH ASSEMBLY, AND THE SUPPORT BRACKET.
Notes:
SYSTEM: HOOD.VEHICLE DESCRIPTION: PASSENGER VEHICLES.
CHEVROLET: BERETTA: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
| NHTSA Campaign Number: | 89V225000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1988 |
| Manufacturer Component Description: | STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861001 - 19870801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 170769 |
| Date Owner Notified By Manufacturer: | 19891208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19891218 |
| Record Creation Date: | 19900102 |
Defect Summary:
A DOOR HINGE (UPPER OR LOWER) MAY BREAK WHILE OPENING OR CLOSING THE DOOR MAKING IT DIFFICULT TO REPOSITION AND CLOSE PROPERLY.
Consequence Summary:
HINGE SEPARATION MAY REDUCE THE STRUCTURAL INTEGRITY OFTHE SIDE OF THE CAR AND INCREASE RISK OF INJURY IN CERTAIN TYPES OF ACCIDENTS.
Corrective Summary:
REPLACE DOOR HINGES ON BOTH DOORS.
Notes:
SYSTEM: DOOR HINGES.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BERETTA: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
| NHTSA Campaign Number: | 88V189000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19881001 - 19881101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 13095 |
| Date Owner Notified By Manufacturer: | 19890119 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19881206 |
| Record Creation Date: | 19881215 |
Defect Summary:
A FUEL TANK LEAK COULD OCCUR DUE TO SMALL CREASES ON THE TANK UNDERSIDE CRACKING DURING PRESSURE CYCLING WHICH OCCURS DURING NORMAL OPERATION.
Consequence Summary:
IN PRESENCE OF AN IGNITION SOURCE, THIS CONDITION COULDRESULT IN A FIRE.
Corrective Summary:
REPLACE FUEL TANK.
Notes:
SYSTEM: FUEL TANK.VEHICLE DESCRIPTION: PASSENGER CARS WITH 2.0L OR 2.8L ENGINES.
CHEVROLET: BERETTA: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BERETTA: SEAT BELTS
| NHTSA Campaign Number: | 91V206000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880101 - 19900701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 722884 |
| Date Owner Notified By Manufacturer: | 19911218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911126 |
| Record Creation Date: | 19911126 |
Defect Summary:
THE FRONT SHOULDER BELT RETRACTORS MAY HAVE REDUCED SENSITIVITY OF THE LOCK-UP FEATURE AND WOULD NOT FUNCTION IN A SUDDEN DECELERATION OR CRASH.
Consequence Summary:
FAILURE OF THE SHOULDER BELT RETRACTOR WOULD RESULT INTHE SEAT OCCUPANT ONLY BEING RESTRAINED BY THE LAP BELT IN A CRASH OR SUDDENSTOP, AND AN INCREASED POSSIBILITY OF INJURY.
Notes:
SYSTEM: SAFETY BELTS (PASSIVE RESTRAINT).VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH DOOR MOUNTED SHOULDER AND LAPSAFETY BELT SYSTEMS.CORECTIVE ACTION: REPLACE THE FRONT SHOULDER BELT RETRACTORS AND ASSEMBLIES.
CHEVROLET: BERETTA: SEATS
| NHTSA Campaign Number: | 89V087000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890501 - 19890501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 642 |
| Date Owner Notified By Manufacturer: | 19890608 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890522 |
| Record Creation Date: | 19890605 |
Defect Summary:
THE FRONT SEAT FRAME ASSEMBLY MAY CONTAIN AN IMPROPER, MISSING AND/OR MISLOCATED WELD THAT COULD FRACTURE.
Consequence Summary:
THIS COULD CAUSE UNEXPECTED SEAT MOVEMENT AND RESULT INPERSONAL INJURY AND/OR LOSS OF CONTROL OF THE CAR.
Corrective Summary:
REPLACE BOTH FRONT SEAT ASSEMBLIES.
Notes:
SYSTEM: FRONT SEAT FRAME.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BERETTA: SEAT BELTS
| NHTSA Campaign Number: | 89V034000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19881101 - 19881201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 29951 |
| Date Owner Notified By Manufacturer: | 19890330 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890310 |
| Record Creation Date: | 19890322 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
FRONT SEAT BELT LATCH PLATES MAY NOT ENGAGE THE BUCKLE ASSEMBLIES.
Consequence Summary:
IN EVENT OF AN ACCIDENT, UNBELTED OR IMPROPERLY BELTEDOCCUPANTS ARE MORE AT RISK TO INJURY THAN IF BELTS ARE PROPERLY BUCKLED.
Corrective Summary:
REPLACE IMPROPERLY FUNCTIONING BUCKLE ASSEMBLIES.
Notes:
SYSTEM: FRONT SEAT BELT LATCH/FMVSS 209.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BERETTA: SEAT BELTS:REAR
| NHTSA Campaign Number: | 90V065000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890301 - 19890901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 26464 |
| Date Owner Notified By Manufacturer: | 19900419 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900405 |
| Record Creation Date: | 19900411 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
OWNER'S MANUALS WERE PRINTED WITH REAR CENTER SEAT BELT INFORMATION OMITTED.
Consequence Summary:
THIS WOULD NOT COMPLY WITH FMVSS 209.
Corrective Summary:
INSERT MISSING INFORMATION INTO OWNERS MANUAL.
Notes:
SYSTEM: SEAT BELT ASSEMBLIES; FMVSS 209.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BERETTA: SEAT BELTS
| NHTSA Campaign Number: | 91V206000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880101 - 19900701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 722884 |
| Date Owner Notified By Manufacturer: | 19911218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911126 |
| Record Creation Date: | 19911126 |
Defect Summary:
THE FRONT SHOULDER BELT RETRACTORS MAY HAVE REDUCED SENSITIVITY OF THE LOCK-UP FEATURE AND WOULD NOT FUNCTION IN A SUDDEN DECELERATION OR CRASH.
Consequence Summary:
FAILURE OF THE SHOULDER BELT RETRACTOR WOULD RESULT INTHE SEAT OCCUPANT ONLY BEING RESTRAINED BY THE LAP BELT IN A CRASH OR SUDDENSTOP, AND AN INCREASED POSSIBILITY OF INJURY.
Notes:
SYSTEM: SAFETY BELTS (PASSIVE RESTRAINT).VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH DOOR MOUNTED SHOULDER AND LAPSAFETY BELT SYSTEMS.CORECTIVE ACTION: REPLACE THE FRONT SHOULDER BELT RETRACTORS AND ASSEMBLIES.
CHEVROLET: BERETTA: STEERING:WHEEL AND HANDLE BAR
| NHTSA Campaign Number: | 91V083000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1991 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900301 - 19901001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 36364 |
| Date Owner Notified By Manufacturer: | 19910615 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910610 |
| Record Creation Date: | 19910620 |
Defect Summary:
NUT ATTACHING STEERING WHEEL MAY NOT HAVE BEEN PROPERLY TIGHTENED DURING INSTALLATION.
Consequence Summary:
THIS COULD ALLOW STEERING WHEEL TO SEPARATE FROM STEERINGCOLUMN; LOSS OF VEHICLE CONTROL AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
TIGHTEN THE NUT TO THE PROPER TORQUE AS NECESSARY.
Notes:
SYSTEM: STEERING WHEEL NUT.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: BERETTA: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 92V185000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910301 - 19920601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 140661 |
| Date Owner Notified By Manufacturer: | 19930119 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19921224 |
| Record Creation Date: | 19921230 |
Defect Summary:
THE SERVICE BRAKE STOP LAMP SWITCH BECOMES INOPERATIVE.
Consequence Summary:
THE INOPERATIVE STOP LAMP SWITCH WILL NOT ILLUMINATE THESTOP LAMPS WHEN THE BRAKE PEDAL IS DEPRESSED. THIS WOULD NOT ADEQUATELY INFORMOTHER DRIVERS OF THE VEHICLE OPERATOR'S INTENT TO STOP OR SLOW DOWN.
Corrective Summary:
REPLACE THE STOP LAMP SWITCH AND CORRECT THE WIRING IN THE CONNECTOR OF THE STOP LAMP SWITCH WIRING HARNESS.
Notes:
SYSTEM: LIGHTING; STOPLAMPS.VEHICLE DESCRIPTION: PASSENGER CARS.NOTE: IF THE FAILURE OCCURS DURING THREE CONSECUTIVE SERVICE BRAKE APPLICATIONSTHE AMBER ANTI-LOCK BRAKE SYSTEM (ABS) TELLTALE LAMP MAY ILLUMINATE INDICATINGA PROBLEM WITH THE SYSTEM.
CHEVROLET: BERETTA: STRUCTURE:BODY:DOOR
| NHTSA Campaign Number: | 94V176000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1995 |
| Manufacturer Component Description: | STRUCTURE:BODY:DOOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19940801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1604 |
| Date Owner Notified By Manufacturer: | 19940909 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19940920 |
| Record Creation Date: | 19940929 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
THE REINFORCEMENT PANEL THAT SERVES AS A LIFTPOINT FOR THE FRAME WAS OMITTED FROM THE RIGHT SIDE ROCKER ASSEMBLY OF THE FRAME THE VEHICLES DO NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: THE MISSING REINFORCEMENT PANEL REDUCES THE PROTECTION OF THE VEHICLE OCCUPANTS IN THE EVENT OF A SIDE IMPACT COLLISION.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLES FOR THE PRESENCE OF THE RIGHT SIDE ROCKER REINFORCEMENT PANEL. IF THE REINFORCEMENT PANEL IS NOT PRESENT, DEALERS WILL CONTACT CHEVROLET FOR FURTHER INSTRUCTIONS.
Notes:
SYSTEM: STRUCTURE; DOOR ASSEMBLY; FRAME AND PANEL; FMVSS 208.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE NONCOMPLIANCE, PLEASE CONTACT CHEVROLET AT 1-800-222-1020. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BERETTA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BERETTA: INTERIOR LIGHTING
| NHTSA Campaign Number: | 98V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BERETTA |
| Model Year: | 1996 |
| Manufacturer Component Description: | INTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950301 - 19951130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 249420 |
| Date Owner Notified By Manufacturer: | 19980228 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980217 |
| Record Creation Date: | 19980225 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 101 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."
Consequence Summary:
THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300,PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
--CHEVROLET: BISCAYNE: STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT
| NHTSA Campaign Number: | 67V098000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1965 |
| Manufacturer Component Description: | STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1143000 |
| Date Owner Notified By Manufacturer: | 19671023 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19671023 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT, AFTER EXTENDED MILEAGE, THE IDLER ARM ASSEMBLY COULD SEPARATE DURING VEHICLE OPERATION AND RESULT IN A SEVERE PULL TO THE RIGHT AS BRAKES ARE APPLIED AT LOW TO MODERATE SPEED.(INSPECT AND RE- PLACE IDLER ARM ASSEMBLY AS REQUIRED.)
--CHEVROLET: BISCAYNE: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: BISCAYNE: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
-- --CHEVROLET: BISCAYNE: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: BISCAYNE: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: BISCAYNE: TIRES
| NHTSA Campaign Number: | 69V020000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1969 |
| Manufacturer Component Description: | TIRES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1396 |
| Date Owner Notified By Manufacturer: | 19690214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690220 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT FIRESTONE TIRES (8.25 X 14 WHITE SIDEWALL 4-PLY RATED), MAYNOT MEET MINIMUM STRENGTH REQUIREMENTS.FAILURE IN BODY OF TIRE COULD RESULTIN LOSS OF TIRE PRESSURE.(CORRECT BY RE- PLACING ALL TIRES WITH NEW IMPROVEDTYPE.)
--CHEVROLET: BISCAYNE: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 69V091000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1969 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 24017 |
| Date Owner Notified By Manufacturer: | 19690703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690709 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT FILLER PLATE WAS OMITTED FROM LEFT REAR FLOOR PAN AREA BETWEENBUMPER AND FUEL TANK.IF THIS PLATE IS MISSING IT COULD ALLOW DUST AND, UNDERCERTAIN CONDITIONS, EXHAUST FUMES TO ENTER PASSENGER COMPARTMENT.(CORRECT BYINSPECTING AND INSTALLING FILLER PLATE WHEN NECESSARY.)
--CHEVROLET: BISCAYNE: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: BISCAYNE: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1971 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: BISCAYNE: VEHICLE SPEED CONTROL
| NHTSA Campaign Number: | 70V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1971 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12600 |
| Date Owner Notified By Manufacturer: | 19701125 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19701203 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT THROTTLE ROD TO THROTTLE LEVER RETAINING CLIP ON CARBURETORMAY BE INCORRECTLY INSTALLED.IF THIS CONDITION EXISTS, THROTTLE LEVER COULDBE HELD IN PARTIALLY OPEN POSITION.IF THIS OCCURS WHILE VEHICLE IS IN MOTION,VEHICLE WILL NOT SLOW DOWN WHEN DRIVER'S FOOT IS REMOVED FROM ACCELERATOR.(CORRECT BY REPLACING CLIP WITH IMPROVED DESIGN WHERE NECESSARY.)
--CHEVROLET: BISCAYNE: EQUIPMENT:MECHANICAL:JACKS
| NHTSA Campaign Number: | 71V121000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1971 |
| Manufacturer Component Description: | EQUIPMENT:MECHANICAL:JACKS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6000 |
| Date Owner Notified By Manufacturer: | 19710708 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19710720 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 71-C-11.STATION WAGONS ONLY.POSSIBIL ITY THAT BUMPERJACK LOAD REST LIP MAY NOT BE PROPERLY FORMEDALLOWING IT TO BEND AND VEHICLESLIP FROM JACK LOAD REST.(CO RRECT BY INSTALLING CORRECT JACK CORRECT JACKWHERENECESSARY. )
--CHEVROLET: BISCAYNE: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1972 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: BISCAYNE: SEATS
| NHTSA Campaign Number: | 72V185000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1972 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720501 - 19720501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1699 |
| Date Owner Notified By Manufacturer: | 19720719 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19720719 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 72-C-2.CHEVROLET CAMPAIGN NO 72-C-10.PONTIACCAMPAIGN NO 72-C-4.POSSIBILITY THAT MANUAL FRONT SEAT ADJUSTER MAY NOT HAVEBEEN INSTALLED PROPERLY AND MAY NOT STAY ENGAGED IN ADJUSTER TRACK DURING ANIMPACT, AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.207.(CORRECT BY INSTALLING NEW SEAT ADJUSTER ON PASSENGER SIDE OF FRONT SEAT.)
--CHEVROLET: BISCAYNE: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
--CHEVROLET: BISCAYNE: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1974 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
--CHEVROLET: BISCAYNE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
| NHTSA Campaign Number: | 75V214000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BISCAYNE |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 39278 |
| Date Owner Notified By Manufacturer: | 19751223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19751219 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C04, PONTIAC CAMPAIGN NO. 76C7, OLDSMOBILE CAMPAIGN NO.76C1, BUICK CAMPAIGN NO. 76C1.POSSIBILITY THAT THE COMBINATION VALVE, WHICHIS A PART OF THE HYDRAULIC SERVICE BRAKE SYSTEM MAY HAVE BEEN IMPROPERLYMANUFACTURED AND COULD MALFUNCTION.SHOULD THIS CONDITION OCCUR WHILE VEHICLEIS IN MOTION AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED.A VEHICLECRASH COULD OCCUR WITHOUT PRIOR WARNING.(CORRECT BY INSPECTING AND REPLACINGVALVE WHERE NECESSARY.) PASSENGER CARS AND LIGHT TRUCKS.
-- --CHEVROLET: BLAZER: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 04V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4021 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030401 - 20040401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 183922 |
| Date Owner Notified By Manufacturer: | 20040604 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040318 |
| Record Creation Date: | 20040322 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
SOME OF THESE VEHICLES INCLUDE INCORRECT STATEMENTS ON ONE OF THE AIR BAG WARNING LABELS.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECT LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON JUNE 4, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04021.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 04V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4021 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020901 - 20030930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 183922 |
| Date Owner Notified By Manufacturer: | 20040604 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040318 |
| Record Creation Date: | 20040322 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
SOME OF THESE VEHICLES INCLUDE INCORRECT STATEMENTS ON ONE OF THE AIR BAG WARNING LABELS.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECT LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON JUNE 4, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04021.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 08V231000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 1073 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010401 - 20010831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5862 |
| Date Owner Notified By Manufacturer: | 20080617 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080521 |
| Record Creation Date: | 20080522 |
Defect Summary:
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence Summary:
THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Notes:
GM RECALL NO. 01073.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: BLAZER: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 01V364000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 1073 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010401 - 20010831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 506377 |
| Date Owner Notified By Manufacturer: | 20020415 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20011203 |
| Record Creation Date: | 20011213 |
Defect Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence Summary:
THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 01V364000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 1073 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010401 - 20010831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 506377 |
| Date Owner Notified By Manufacturer: | 20020415 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20011203 |
| Record Creation Date: | 20011213 |
Defect Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence Summary:
THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 08V231000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 1073 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5862 |
| Date Owner Notified By Manufacturer: | 20080617 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080521 |
| Record Creation Date: | 20080522 |
Defect Summary:
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence Summary:
THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Notes:
GM RECALL NO. 01073.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: BLAZER: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 01V364000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 1073 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 506377 |
| Date Owner Notified By Manufacturer: | 20020415 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20011203 |
| Record Creation Date: | 20011213 |
Defect Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence Summary:
THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 01V364000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 1073 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 506377 |
| Date Owner Notified By Manufacturer: | 20020415 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20011203 |
| Record Creation Date: | 20011213 |
Defect Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence Summary:
THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: SEAT BELTS
-->| NHTSA Campaign Number: | 00V228003 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 67 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000501 - 20000531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 156305 |
| Date Owner Notified By Manufacturer: | 20000824 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000807 |
| Record Creation Date: | 20000822 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Notes:
OWNER NOTIFICATION BEGAN AUGUST 24, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; CHEVROLET AT 1-800-222-1020; GMC AT 1-800-462-8782; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR SATURN AT 1-800-553-6000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
-->| NHTSA Campaign Number: | 98V053000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 98006 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980101 - 19980131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 72 |
| Date Owner Notified By Manufacturer: | 19980122 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980309 |
| Record Creation Date: | 19980319 |
Defect Summary:
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLE EQUIPPED WITH 4-WHEEL DRIVE OR ALL-WHEEL-DRIVE. ONE OR BOTH OF THE ATTACHING NUTS FOR THE RIGHT-HAND LOWER CONTROL ARM ARE UNDER TORQUED. THIS CAN ALLOW THE ATTACHMENT BOLT TO LOOSEN AND SUBSEQUENT BREAK RESULTING IN SEPARATION OF THE LOWER CONTROL ARM FROM THE FRAME.
Consequence Summary:
THIS CONDITION CAN RESULT IN A LOSS OF VEHICLE CONTROL.
Corrective Summary:
DEALERS WILL INSPECT AND RETIGHTEN THE RIGHT-HAND LOWER CONTROL ARM NUTS TO THE PROPER TORQUE SPECIFICATION.
Notes:
GM RECALL NO. 98006.OWNER/DEALER NOTIFICATION BEGAN JANUARY 22, 1998.THESE VEHICLES WERE IN-TRANSIT OR VERY RECENTLY DELIVERED TO DEALERSHIPS.CUSTOMERS RECEIVING THESE VEHICLES BEFORE JANUARY 22, 1998, WERE CONTACTED BY THE SELLING DEALER TO RETURN THEIR VEHICLE FOR THE SERVICE PROCEDURE.OWNERS WHO WERE NOT CONTACTED BY THEIR DEALER WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1022, OLDSMOBILE AT 1-800-442-6537, OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 00V220000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 43 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19980630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 14279 |
| Date Owner Notified By Manufacturer: | 20000913 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000811 |
| Record Creation Date: | 20000811 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE DAYTIME RUNNING LIGHTS BUILT WITH A CANDELA VALUE GREATER THAN 3,000 CANNOT BE MOUNTED HIGHER THAN 864MM ABOVE THE ROAD SURFACE.
Consequence Summary:
THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Corrective Summary:
DEALERS WILL INSTALL A REVISED WIRING HARNESS THAT CHANGES THE DRL'S FROM HIGH BEAM TO LOW BEAM DRL'S, AND INSTALL NEW LONG-LIFE LOW BEAM BULBS.
Notes:
OWNER NOTIFICATION BEGAN SEPTEMBER 13, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 97V218000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1998 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970301 - 19970831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19716 |
| Date Owner Notified By Manufacturer: | 19971215 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19971124 |
| Record Creation Date: | 19971203 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. A FATIGUE FRACTURE OF THE REAR AXLE RIGHT-HAND BRAKE PIPE CAN OCCUR CAUSING A SLOW BRAKE FLUID LEAK RESULTING IN A SOFT BRAKE PEDAL. IF THE BRAKE PIPE BREAKS, THE DRIVER WOULD EXPERIENCE A SUDDEN DROP IN THE BRAKE PEDAL, THE INSTRUMENT PANEL BRAKE LIGHT WOULD ILLUMINATE, AND THERE WOULD BE A LOSS OF REAR BRAKE PERFORMANCE.
Consequence Summary:
PARTIAL LOSS OF BRAKING AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED COULD RESULT IN A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE BRAKE PIPE.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING DECEMBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: BLAZER: SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
-->| NHTSA Campaign Number: | 01I018000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1997 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Date Owner Notified By Manufacturer: | 20011204 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20011204 |
| Record Creation Date: | 20020107 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1996-1997 4-WHEEL DRIVE CHEVROLET BLAZER, GMC JIMMY, AND OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. SOME OWNERS HAVE HAD TO PAY FOR REPLACEMENT OF THE UPPER BALL JOINTS THAT HAVE SEPARATED. GM IS PROVIDING A SPECIAL POLICY TO THESE OWNERS TO COVER UPPER BALL JOINT REPLACEMENT IF THE CUSTOMER FOLLOWED THE RECOMMENDED MAINTENANCE SCHEDULE FOR THE CHASSIS LUBRICATION AND THE VEHICLE STILL REQUIRED THE REPLACEMENT OF THE UPPER BALL JOINTS DUE TO SEPARATION.
Consequence Summary:
THIS COULD CAUSE A LOSS OF STEERING CONTROL OF THE VEHICLE.
Corrective Summary:
GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO REPLACE THE UPPER BALL JOINTS ON AFFECTED VEHICLES. THIS SPECIAL POLICY IS FOR A PERIOD OF 8 YEARS OR 100,000 MILES, WHICHEVER OCCURS FIRST, FROM THE DATE THE VHEICLE WAS ORIGINALLY PLACED IN SERVICE, REGARDLESS OF OWNERSHIP. THE UPPER BALL JOINT REPLACEMENT, DUE TO SEPARATION, WILL BE MADE AT NO CHARGE TO THE CUSTOMER DURING THIS PERIOD. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-862-4389, OR OLDSMOBILE AT 1-800-442-6537, CONCERNING THIS PROGRAM.
CHEVROLET: BLAZER: SEAT BELTS
-->| NHTSA Campaign Number: | 97V096001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1997 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960301 - 19970630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 586058 |
| Date Owner Notified By Manufacturer: | 19970922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970612 |
| Record Creation Date: | 19970821 |
Defect Summary:
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence Summary:
IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING SEPTEMBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
-->| NHTSA Campaign Number: | 01V200000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 1048 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19961001 - 19961031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 48600 |
| Date Owner Notified By Manufacturer: | 20010904 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010628 |
| Record Creation Date: | 20010702 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. FAILURE OF AN UPPER CONTROL ARM BALL JOINT ASSEMBLY COULD OCCUR DUE TO CORROSION.
Consequence Summary:
THIS CAN RESULT IN IMPAIRED STEERING OR STEERING LOSS, OR A PARTIAL OR COMPLETE COLLAPSE OF THE FRONT SUSPENSION, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE BOTH UPPER BALL JOINTS. OWNER NOTIFICATION BEGAN SEPTEMBER 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
-->| NHTSA Campaign Number: | 03V093000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 3006 |
| Manufacturer Component Description: | VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960301 - 19970630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 507171 |
| Date Owner Notified By Manufacturer: | 20030424 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030307 |
| Record Creation Date: | 20030318 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence Summary:
IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03006. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 03V117000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 3020 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960301 - 19970630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 312715 |
| Date Owner Notified By Manufacturer: | 20030808 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030331 |
| Record Creation Date: | 20030401 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH A DRIVER'S SEAT BELT BUCKLE ASSEMBLY THAT CONTAINS AN ENERGY-ABSORBING LOOP. SUSTAINED LOADS OF SUFFICIENT MAGNITUDE AND DURATION ON THE BELT IN SEVERE CRASHES COULD FULLY DEPLOY THE BUCKLE ENERGY-ABSORBING LOOP, INTRODUCING A TOTAL OF 10 ADDITIONAL INCHES OF WEBBING INTO THE SEAT BELT SYSTEM. THE FREE FALLING LATCH PLATE USED IN THIS SYSTEM MAY ALLOW WEBBING TO DYNAMICALLY DISTRIBUTE BETWEEN THE LAP AND SHOULDER BELT AS THE DRIVER'S POSITION CHANGES DURING A MULTIPLE ROLLOVER EVENT.
Consequence Summary:
IF THE ENERGY-ABSORBING LOOP FULLY DEPLOYS IN A SEVERE MULTIPLE ROLLOVER CRASH, IT IS POSSIBLE THAT A BELTED DRIVER MAY EXPERIENCE PARTIAL OR EVEN COMPLETE EJECTION FROM THE VEHICLE.
Corrective Summary:
DEALERS WILL REPLACE THE ENERGY-ABSORBING SEAT BELT ASSEMBLIES WITH ONE THAT DOES NOT HAVE THE ENERGY-ABSORBING LOOP. OWNER NOTIFICATION BEGAN ON AUGUST 8, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03020.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E023000 |
| Vehicle/Equipment Make: | ANZO USA, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 292000 |
| Date Owner Notified By Manufacturer: | 20060509 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ANZO USA, INC. |
| Report Received Date: | 20060313 |
| Record Creation Date: | 20060314 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: BLAZER: SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
-->| NHTSA Campaign Number: | 01I018000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Date Owner Notified By Manufacturer: | 20011204 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20011204 |
| Record Creation Date: | 20020107 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1996-1997 4-WHEEL DRIVE CHEVROLET BLAZER, GMC JIMMY, AND OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. SOME OWNERS HAVE HAD TO PAY FOR REPLACEMENT OF THE UPPER BALL JOINTS THAT HAVE SEPARATED. GM IS PROVIDING A SPECIAL POLICY TO THESE OWNERS TO COVER UPPER BALL JOINT REPLACEMENT IF THE CUSTOMER FOLLOWED THE RECOMMENDED MAINTENANCE SCHEDULE FOR THE CHASSIS LUBRICATION AND THE VEHICLE STILL REQUIRED THE REPLACEMENT OF THE UPPER BALL JOINTS DUE TO SEPARATION.
Consequence Summary:
THIS COULD CAUSE A LOSS OF STEERING CONTROL OF THE VEHICLE.
Corrective Summary:
GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO REPLACE THE UPPER BALL JOINTS ON AFFECTED VEHICLES. THIS SPECIAL POLICY IS FOR A PERIOD OF 8 YEARS OR 100,000 MILES, WHICHEVER OCCURS FIRST, FROM THE DATE THE VHEICLE WAS ORIGINALLY PLACED IN SERVICE, REGARDLESS OF OWNERSHIP. THE UPPER BALL JOINT REPLACEMENT, DUE TO SEPARATION, WILL BE MADE AT NO CHARGE TO THE CUSTOMER DURING THIS PERIOD. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-862-4389, OR OLDSMOBILE AT 1-800-442-6537, CONCERNING THIS PROGRAM.
CHEVROLET: BLAZER: SEAT BELTS
-->| NHTSA Campaign Number: | 97V096001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950301 - 19960830 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 586058 |
| Date Owner Notified By Manufacturer: | 19970922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970612 |
| Record Creation Date: | 19970821 |
Defect Summary:
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence Summary:
IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING SEPTEMBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
-->| NHTSA Campaign Number: | 01V200000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 1048 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19951101 - 19960630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 48600 |
| Date Owner Notified By Manufacturer: | 20010904 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010628 |
| Record Creation Date: | 20010702 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. FAILURE OF AN UPPER CONTROL ARM BALL JOINT ASSEMBLY COULD OCCUR DUE TO CORROSION.
Consequence Summary:
THIS CAN RESULT IN IMPAIRED STEERING OR STEERING LOSS, OR A PARTIAL OR COMPLETE COLLAPSE OF THE FRONT SUSPENSION, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE BOTH UPPER BALL JOINTS. OWNER NOTIFICATION BEGAN SEPTEMBER 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 98V150001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 98043 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19960531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1557585 |
| Date Owner Notified By Manufacturer: | 19981215 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980701 |
| Record Creation Date: | 19990211 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence Summary:
THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 15, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960601 - 19960831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99I006000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2400000 |
| Date Owner Notified By Manufacturer: | 19991210 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: CERTAIN LIGHT DUTY PICKUP TRUCKS, SPORT UTILITY VEHICLES, OR MINIVANS EQUIPPED WITH 3-SENSOR ABS (ANTILOCK BRAKING SYSTEM) EBC4 UNITS.
Consequence Summary:
THESE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES DURING ABS STOPS ON CERTAIN MULTIPLE SURFACES, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL MODIFY THE COMPUTER PROGRAM WHICH OPERATES THE ABS UNIT ON SOME VEHICLES, OR REPLACE THE COMPUTER ON OTHERS TO IMPROVE THE PERFORMANCE OF THE ABS ON THESE SURFACES.
Notes:
ON VEHICLES WHICH REQUIRED THE COMPUTER PROGRAM TO BE MODIFIED, OWNER NOTIFICATION HAS BEGAN.FOR VEHICLES WHICH REQUIRE A NEW COMPUTER MODULE, GM HAS SCHEDULED OWNER NOTIFICATIION TO BEGIN DURING THE LAST WEEK OF MAY 2000.A PHASED MAILING WILL BE REQUIRED, WITH THE LAST MAILING SCHEDULED TO BE COMPLETED BY DECEMBER 2000.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 99041 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1125749 |
| Date Owner Notified By Manufacturer: | 20000531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence Summary:
IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Notes:
THE FIRST PHASE OF OWNER NOTIFICATION LETTERS BEGAN MAY 31, 2000,WITH THE LAST MAILING COMPLETED BY OCTOBER 2000. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-->| NHTSA Campaign Number: | 96V234000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950301 - 19960731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 432183 |
| Date Owner Notified By Manufacturer: | 19961121 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961114 |
| Record Creation Date: | 19961127 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 301 |
Defect Summary:
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence Summary:
IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION BEGAN DURING LATE NOVEMBER 1996.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E023000 |
| Vehicle/Equipment Make: | ANZO USA, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 292000 |
| Date Owner Notified By Manufacturer: | 20060509 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ANZO USA, INC. |
| Report Received Date: | 20060313 |
| Record Creation Date: | 20060314 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 06E041000 |
| Vehicle/Equipment Make: | R&B, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 7800 |
| Date Owner Notified By Manufacturer: | 20060504 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | R&B, INC. |
| Report Received Date: | 20060518 |
| Record Creation Date: | 20060518 |
Defect Summary:
CERTAIN R&B, INC. CENTRAL MULTIPORT FUEL INJECTION (CMFI) FUEL RETURN LINES, MODELS HELP 55163, NAPA BALKAMP 700-3270, AND THE CONNECTION 2560001, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL RETURN LINE HAS A MECHANICAL BLEED VALVE WHICH WAS NOT INSTALLED AT THE PROPER TORQUE.
Consequence Summary:
A FUEL LEAK CAN OCCUR AT THE VALVE, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
R&B, INC. WILL NOTIFY OWNERS AND AT THE CUSTOMERS REQUEST, EITHER REPLACE THE FUEL LINE OR OFFER A FULL REFUND. THE RECALL BEGAN ON MAY 4, 2006. OWNERS MAY CONTACT R&B, INC. AT 215-712-5330.
Notes:
THIS RECALL ONLY PERTAINS TO R&B, INC. AFTERMARKET CMFI RETURN FUEL LINES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 98V150001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Campaign Number: | 98043 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19960531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1557585 |
| Date Owner Notified By Manufacturer: | 19981215 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980701 |
| Record Creation Date: | 19990211 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence Summary:
THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 15, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 94V242000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19941101 - 19941101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 262 |
| Date Owner Notified By Manufacturer: | 19941114 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19941212 |
| Record Creation Date: | 19950103 |
Defect Summary:
THE BRAKE PEDAL PIVOT BOLT WAS STARTED IN THE WELD NUT, BUT WAS NOT TORQUED CORRECTLY CAUSING THE BOLT TO DISENGAGE FROM THE WELD NUT.
Consequence Summary:
THIS CONDITION CAN RESULT IN A TOTAL LOSS OF BRAKINGCAPABILITY.
Corrective Summary:
DEALERS WILL INSPECT FOR HAND-STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO CORRECT SPECIFICATIONS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; LINKAGE; PEDAL.VEHICLE DESCRIPTION: LIGHT DUTY UTILITY VEHICLES.NOTE: IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN AREASONABLE TIME, PLEASE CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT1-810-456-4547. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
-->| NHTSA Campaign Number: | 95V080000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950101 - 19950101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 271 |
| Date Owner Notified By Manufacturer: | 19950428 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950424 |
| Record Creation Date: | 19950428 |
Defect Summary:
THE UPPER BALL JOINT NUTS WERE UNDER-TORQUED RESULTING IN IMPROPER SEATING IN THE STEERING KNUCKLE.
Consequence Summary:
THIS CONDITION CAN CAUSE THE BALL JOINT STUD TO LOOSEN, AND FRACTURE RESULTING IN A LOSS OF STEERING CONTROL.
Corrective Summary:
DEALERS WILL RETORQUE THE UPPER BALL JOINT NUT ON BOTH SIDES OF THE VEHICLE TO THE CORRECT TORQUE VALUES.
Notes:
SYSTEM: SUSPENSION; FRONT CONTROL ARM; UPPER; BALL JOINT.VEHICLE DESCRIPTION: MULTIPURPOSE VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, PLEASE CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99I006000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2400000 |
| Date Owner Notified By Manufacturer: | 19991210 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: CERTAIN LIGHT DUTY PICKUP TRUCKS, SPORT UTILITY VEHICLES, OR MINIVANS EQUIPPED WITH 3-SENSOR ABS (ANTILOCK BRAKING SYSTEM) EBC4 UNITS.
Consequence Summary:
THESE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES DURING ABS STOPS ON CERTAIN MULTIPLE SURFACES, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL MODIFY THE COMPUTER PROGRAM WHICH OPERATES THE ABS UNIT ON SOME VEHICLES, OR REPLACE THE COMPUTER ON OTHERS TO IMPROVE THE PERFORMANCE OF THE ABS ON THESE SURFACES.
Notes:
ON VEHICLES WHICH REQUIRED THE COMPUTER PROGRAM TO BE MODIFIED, OWNER NOTIFICATION HAS BEGAN.FOR VEHICLES WHICH REQUIRE A NEW COMPUTER MODULE, GM HAS SCHEDULED OWNER NOTIFICATIION TO BEGIN DURING THE LAST WEEK OF MAY 2000.A PHASED MAILING WILL BE REQUIRED, WITH THE LAST MAILING SCHEDULED TO BE COMPLETED BY DECEMBER 2000.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Campaign Number: | 99041 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1125749 |
| Date Owner Notified By Manufacturer: | 20000531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence Summary:
IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Notes:
THE FIRST PHASE OF OWNER NOTIFICATION LETTERS BEGAN MAY 31, 2000,WITH THE LAST MAILING COMPLETED BY OCTOBER 2000. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-->| NHTSA Campaign Number: | 96V234000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940101 - 19950830 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 432183 |
| Date Owner Notified By Manufacturer: | 19961121 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961114 |
| Record Creation Date: | 19961127 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 301 |
Defect Summary:
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence Summary:
IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION BEGAN DURING LATE NOVEMBER 1996.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-->| NHTSA Campaign Number: | 95V180000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940901 - 19941101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 73163 |
| Date Owner Notified By Manufacturer: | 19951004 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950922 |
| Record Creation Date: | 19950925 |
Defect Summary:
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence Summary:
IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
Notes:
SYSTEM: ENGINE COOLING SYSTEM; FAN.VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND UTILITY VEHICLES EQUIPPED WITH AIR-C0NDITIONING AND 4.3L ENGINES.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E023000 |
| Vehicle/Equipment Make: | ANZO USA, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 292000 |
| Date Owner Notified By Manufacturer: | 20060509 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ANZO USA, INC. |
| Report Received Date: | 20060313 |
| Record Creation Date: | 20060314 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1993 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 06E041000 |
| Vehicle/Equipment Make: | R&B, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1993 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 7800 |
| Date Owner Notified By Manufacturer: | 20060504 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | R&B, INC. |
| Report Received Date: | 20060518 |
| Record Creation Date: | 20060518 |
Defect Summary:
CERTAIN R&B, INC. CENTRAL MULTIPORT FUEL INJECTION (CMFI) FUEL RETURN LINES, MODELS HELP 55163, NAPA BALKAMP 700-3270, AND THE CONNECTION 2560001, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL RETURN LINE HAS A MECHANICAL BLEED VALVE WHICH WAS NOT INSTALLED AT THE PROPER TORQUE.
Consequence Summary:
A FUEL LEAK CAN OCCUR AT THE VALVE, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
R&B, INC. WILL NOTIFY OWNERS AND AT THE CUSTOMERS REQUEST, EITHER REPLACE THE FUEL LINE OR OFFER A FULL REFUND. THE RECALL BEGAN ON MAY 4, 2006. OWNERS MAY CONTACT R&B, INC. AT 215-712-5330.
Notes:
THIS RECALL ONLY PERTAINS TO R&B, INC. AFTERMARKET CMFI RETURN FUEL LINES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99I006000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1993 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2400000 |
| Date Owner Notified By Manufacturer: | 19991210 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: CERTAIN LIGHT DUTY PICKUP TRUCKS, SPORT UTILITY VEHICLES, OR MINIVANS EQUIPPED WITH 3-SENSOR ABS (ANTILOCK BRAKING SYSTEM) EBC4 UNITS.
Consequence Summary:
THESE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES DURING ABS STOPS ON CERTAIN MULTIPLE SURFACES, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL MODIFY THE COMPUTER PROGRAM WHICH OPERATES THE ABS UNIT ON SOME VEHICLES, OR REPLACE THE COMPUTER ON OTHERS TO IMPROVE THE PERFORMANCE OF THE ABS ON THESE SURFACES.
Notes:
ON VEHICLES WHICH REQUIRED THE COMPUTER PROGRAM TO BE MODIFIED, OWNER NOTIFICATION HAS BEGAN.FOR VEHICLES WHICH REQUIRE A NEW COMPUTER MODULE, GM HAS SCHEDULED OWNER NOTIFICATIION TO BEGIN DURING THE LAST WEEK OF MAY 2000.A PHASED MAILING WILL BE REQUIRED, WITH THE LAST MAILING SCHEDULED TO BE COMPLETED BY DECEMBER 2000.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1993 |
| Manufacturer Campaign Number: | 99041 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1125749 |
| Date Owner Notified By Manufacturer: | 20000531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence Summary:
IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Notes:
THE FIRST PHASE OF OWNER NOTIFICATION LETTERS BEGAN MAY 31, 2000,WITH THE LAST MAILING COMPLETED BY OCTOBER 2000. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1993 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 94V093000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1993 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19920801 - 19930101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 72664 |
| Date Owner Notified By Manufacturer: | 19941021 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19940516 |
| Record Creation Date: | 19940523 |
Defect Summary:
SIGNIFICANT WEAR CAN DEVELOP ON THE LOW AND REVERSE CLUTCH PREVENTING THE PARK PAWL FROM ENGAGING. THIS CAN PREVENT A "NO PARK" CONDITION TO OCCUR WHILE THE ENGINE IS RUNNING, CAUSING UNINTENTIONAL MOVEMENT OF THE VEHICLE WITHOUT OPERATOR ACTION. (THE "NO PARK" CONDITION WILL NOT OCCUR WHILE THE ENGINE IS OFF.)
Consequence Summary:
UNINTENTIONAL VEHICLE MOVEMENT COULD RESULT IN A VEHICLE ACCIDENT AND INJURY TO PERSONS IN THE PATH OF THE VEHICLE.
Corrective Summary:
DEALERS WILL CHECK THE TRANSMISSION FLUID FOR CONTAMINATION WHICH WILL INDICATE IF THE LOW OR REVERSE CLUTCH IS WORN. IF THE TRANSMISSION FLUID SHOWS CONTAMINATION, THE TRANSMISSION WILL BE REPLACED.
Notes:
SYSTEM: POWERTRAIN; TRANSMISSION; AUTOMATIC.VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. NOTE: THE S SERIES TRUCKS ARE NOT INCLUDED BECAUSE THEY ARE ONLY 2-WHEEL DRIVE.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT CHEVROLET SERVICE CENTER AT 1-800-222-1020; OR GMC SERVICE CENTER AT 1-313-456-4547. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 93V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1992 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 341364 |
| Date Owner Notified By Manufacturer: | 19931108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930802 |
| Record Creation Date: | 19930726 |
Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1992 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 06E041000 |
| Vehicle/Equipment Make: | R&B, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1992 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 7800 |
| Date Owner Notified By Manufacturer: | 20060504 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | R&B, INC. |
| Report Received Date: | 20060518 |
| Record Creation Date: | 20060518 |
Defect Summary:
CERTAIN R&B, INC. CENTRAL MULTIPORT FUEL INJECTION (CMFI) FUEL RETURN LINES, MODELS HELP 55163, NAPA BALKAMP 700-3270, AND THE CONNECTION 2560001, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE FUEL RETURN LINE HAS A MECHANICAL BLEED VALVE WHICH WAS NOT INSTALLED AT THE PROPER TORQUE.
Consequence Summary:
A FUEL LEAK CAN OCCUR AT THE VALVE, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
R&B, INC. WILL NOTIFY OWNERS AND AT THE CUSTOMERS REQUEST, EITHER REPLACE THE FUEL LINE OR OFFER A FULL REFUND. THE RECALL BEGAN ON MAY 4, 2006. OWNERS MAY CONTACT R&B, INC. AT 215-712-5330.
Notes:
THIS RECALL ONLY PERTAINS TO R&B, INC. AFTERMARKET CMFI RETURN FUEL LINES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1992 |
| Manufacturer Campaign Number: | 99041 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1125749 |
| Date Owner Notified By Manufacturer: | 20000531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence Summary:
IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Notes:
THE FIRST PHASE OF OWNER NOTIFICATION LETTERS BEGAN MAY 31, 2000,WITH THE LAST MAILING COMPLETED BY OCTOBER 2000. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1992 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 93V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1991 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 341364 |
| Date Owner Notified By Manufacturer: | 19931108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930802 |
| Record Creation Date: | 19930726 |
Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1991 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1991 |
| Manufacturer Campaign Number: | 99041 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1125749 |
| Date Owner Notified By Manufacturer: | 20000531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence Summary:
IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Notes:
THE FIRST PHASE OF OWNER NOTIFICATION LETTERS BEGAN MAY 31, 2000,WITH THE LAST MAILING COMPLETED BY OCTOBER 2000. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1991 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE:STORAGE
-->| NHTSA Campaign Number: | 91V108000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1991 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900101 - 19910201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 102885 |
| Date Owner Notified By Manufacturer: | 19910703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910621 |
| Record Creation Date: | 19910701 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 301 |
Defect Summary:
VEHICLES HAVE BEEN SHIPPED WITH THE FUEL TANK SENDER SEAL OUT OF POSITION.
Consequence Summary:
IN THE EVENT OF ROLLOVER ACCIDENT, AN OUT OF POSTIONSEAL COULD ALLOW FUEL SPILLAGE IN EXCESS OF THE AMOUNT PRESCRIBED BY FMVSS 301.SPILLED FUEL COULD IGNITE NEAR AN IGNITION SOURCE.
Corrective Summary:
REPLACE SENDER SEALS.
Notes:
SYSTEM: FUEL SYSTEMS; FMVSS 301.VEHICLE DESCRIPTION: LIGHT TRUCKS AND MULTI-PURPOSE VEHICLES.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 96V142000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890901 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 97351 |
| Date Owner Notified By Manufacturer: | 19960925 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960731 |
| Record Creation Date: | 19960731 |
Defect Summary:
THESE VEHICLES EXHIBIT A CONDITION IN WHICH A REAR SEAT BELT BUCKLE RELEASE BUTTON CAN STICK IN THE UNLATCHED (DOWN) POSITION UNDER CERTAIN CONDITIONS BECAUSE THE BUCKLE ASSEMBLY CAN MOVE INSIDE THE SEAT BELT COVER. IF THE COVER MOVES FAR ENOUGH, IT CAN CREATE AN INTERFERENCE CONDITION WITH THE LATCH RELEASE BUTTON. WHEN IT DOES, THE SEAT BELT BUCKLE CANNOT BE LATCHED.
Consequence Summary:
THE REAR BELTS MAY NOT HOLD AN OCCUPANT IN THE EVENT OF A VEHICLE ACCIDENT INCREASING THE RISK OF PESONAL INJURY.
Corrective Summary:
DEALERS WILL REPLACE THE THREE REAR-SEAT BELT BUCKLES (ONE ASSEMBLY) WITH A NEW, REVISED DESIGN.
Notes:
SYSTEM: INTERIOR; SEAT BELTS; REAR. VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN IN AUGUST 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 93V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1990 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 341364 |
| Date Owner Notified By Manufacturer: | 19931108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930802 |
| Record Creation Date: | 19930726 |
Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1990 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1990 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 93V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1989 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 341364 |
| Date Owner Notified By Manufacturer: | 19931108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930802 |
| Record Creation Date: | 19930726 |
Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1989 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1989 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 93V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1988 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 341364 |
| Date Owner Notified By Manufacturer: | 19931108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930802 |
| Record Creation Date: | 19930726 |
Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1988 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1988 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1987 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1987 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1986 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1985 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1985 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1984 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 83V107000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1984 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830701 - 19830801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 13181 |
| Date Owner Notified By Manufacturer: | 19831018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19831013 |
| Record Creation Date: | 19831021 |
Defect Summary:
THE RIGHT FRONT CROSSOVER PIPE, WHICH CARRIES BRAKE HYDRAULIC FLUID, MAY BREAK AND LEAK FLUID. THIS OCCURS WHEN THE RIGHT FRONT FENDER SKIRT CONTACTS THE PIPE AND VIBRATION CAUSES THE PIPE TO WEAR THROUGH.
Corrective Summary:
IF THE POSITION AND CLEARANCE OF THE BRAKE PIPE ARE INCORRECT, THE FENDER SKIRT WILL BE ADJUSTED AND A REPLACEMENT PIPE WILL BE INSTALLED.
Notes:
VEHICLE DESCRIPTION: LIGHT TRUCKS, FOUR WHEEL DRIVE.SYSTEM: SERVICE BRAKES; FRONT BRAKE HYDRAULIC CROSSOVER PIPE.CONSEQUENCES OF DEFECT: FLUID LEAKAGE WILL RESULT IN THE LOSS OF FRONT BRAKING,AND AN INCREASE IN STOPPING DISTANCE. AN ACCIDENT MAY RESULT, PARTICULARLY INSITUATIONS REQUIRING MINIMUM STOPPING DISTANCE.NOTE: AN INCREASE IN BRAKE PEDAL TRAVEL AND ILLUMINATION OF THE BRAKE WARNINGLIGHT MAY INDICATE THE PROBLEM EXISTS.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1984 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1983 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 83V107000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1983 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830701 - 19830801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 13181 |
| Date Owner Notified By Manufacturer: | 19831018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19831013 |
| Record Creation Date: | 19831021 |
Defect Summary:
THE RIGHT FRONT CROSSOVER PIPE, WHICH CARRIES BRAKE HYDRAULIC FLUID, MAY BREAK AND LEAK FLUID. THIS OCCURS WHEN THE RIGHT FRONT FENDER SKIRT CONTACTS THE PIPE AND VIBRATION CAUSES THE PIPE TO WEAR THROUGH.
Corrective Summary:
IF THE POSITION AND CLEARANCE OF THE BRAKE PIPE ARE INCORRECT, THE FENDER SKIRT WILL BE ADJUSTED AND A REPLACEMENT PIPE WILL BE INSTALLED.
Notes:
VEHICLE DESCRIPTION: LIGHT TRUCKS, FOUR WHEEL DRIVE.SYSTEM: SERVICE BRAKES; FRONT BRAKE HYDRAULIC CROSSOVER PIPE.CONSEQUENCES OF DEFECT: FLUID LEAKAGE WILL RESULT IN THE LOSS OF FRONT BRAKING,AND AN INCREASE IN STOPPING DISTANCE. AN ACCIDENT MAY RESULT, PARTICULARLY INSITUATIONS REQUIRING MINIMUM STOPPING DISTANCE.NOTE: AN INCREASE IN BRAKE PEDAL TRAVEL AND ILLUMINATION OF THE BRAKE WARNINGLIGHT MAY INDICATE THE PROBLEM EXISTS.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1983 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SEATS
-->| NHTSA Campaign Number: | 83V046000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1983 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820801 - 19821201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 17312 |
| Date Owner Notified By Manufacturer: | 19830509 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830427 |
| Record Creation Date: | 19830513 |
Defect Summary:
THE INERTIA LOCK MECHANISM MAY NOT FUNCTION, ALLOWING THE SEAT BACK TO FOLD FORWARD, AND THE SEAT TO MOVE FORWARD.
Notes:
VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH FOLDING REAR BENCH SEATS.SYSTEM: INTERIOR SYSTEMS; SEAT BACK INERTIA LOCK.CONSEQUENCES OF DEFECT: IF THE REAR SEAT IS OCCUPIED, THIS COULD CAUSE PERSONALINJURY BY PINNING OCCUPANTS BETWEEN THE REAR SEAT AND THE BACK OF THE FRONTSEAT.NOTE: THIS FAILURE MAY OCCUR UNDER MODERATE BRAKING CONDITIONS.CORRECTIVEACTION: THE DEALER WILL INSTALL A MANUALLY OPERATED LATCH WITH APOSITIVE LOCK AND RELEASE HANDLE AT NO CHARGE.
CHEVROLET: BLAZER: WHEELS:LUGS/NUTS/BOLTS
-->| NHTSA Campaign Number: | 82V128000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1982 |
| Manufacturer Component Description: | WHEELS:LUGS/NUTS/BOLTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19811201 - 19820701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1633 |
| Date Owner Notified By Manufacturer: | 19821210 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19821214 |
| Record Creation Date: | 19821217 |
Defect Summary:
ON THE INVOLVED VEHICLES, THE REAR BRAKE DRUM BALANCE WEIGHTS MAY INTERFERE WITH THE ALUMINUM WHEELS. THIS CONTACT COULD CAUSE THE WHEEL LUG NUTS TO LOOSEN, LEADING TO WHEEL STUD FAILURE. THIS COULD ALLOW SEPARATION OF THE WHEEL AND TIRE FROM THE VEHICLE.
Corrective Summary:
THE DEALER WILL INSPECT AND, IF NECESSARY, MODIFY THE REAR BRAKE DRUM BALANCE WEIGHTS WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH OPTIONAL ALUMINUM WHEELS ANDREAR BRAKE DRUMS.SYSTEM: SERVICE BRAKES; REAR BRAKE DRUM, BALANCE WEIGHTS.CONSEQUENCES OF DEFECT: WHEEL AND TIRE SEPARATION COULD OCCUR WITHOUT PRIORWARNING AND COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1982 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1982 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 80V150000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1981 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19800801 - 19800901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 364 |
| Date Owner Notified By Manufacturer: | 19801117 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19801114 |
| Record Creation Date: | 19801217 |
Defect Summary:
THE INVOLVED VEHICLES MAY HAVE BEEN ASSEMBLED WITHOUT THE RETAINER CLIP FOR THE BRAKE PEDAL PUSH ROD. THE ABSENCE OF THIS RETAINER CLIP COULD ALLOW THE BRAKE PEDAL TO DISENGAGE FROM THE MASTER CYCLINDER PUSH ROD.
Corrective Summary:
THE DEALER WILL INSPECT AND, IF NECESSARY, INSTALL THE RETAINER CLIP ON ALL SUSPECT VEHICLES WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: SERVICE BRAKES; BRAKE PEDAL PUSH ROD RETAINER CLIPS.CONSEQUENCES OF DEFECT: THIS MAY RESULT IN LOSS OF BRAKING ACTION. THISCONDITION COULD OCCUR WITHOUT WARNING WHILE THE VEHICLE IS IN MOTION, AND COULDRESULT IN AN ACCIDENT.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1981 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1981 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1980 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1979 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1978 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1977 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1976 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1974 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: BLAZER: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1974 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: BLAZER: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: BLAZER: SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY
-->| NHTSA Campaign Number: | 71V181000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1972 |
| Manufacturer Component Description: | SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1600 |
| Date Owner Notified By Manufacturer: | 19711011 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711013 |
| Record Creation Date: | 19791012 |
Notes:
CAMPAIGN NO 72-C-1.POSSIBILITY THAT LEFT FRONT SPRING REAR S HACKLE STOP WASIMPROPERLY ADJUSTED DURING PRODUCTION.IF CON DITION EXISTS, COULD ALLOW FRONTAXLE TO SHIFT REARWARD IN EVE NT OF LEFT FRONTSPRING FAILURE AT OR NEAR FRONTSPRING EYE, HA VE AN ADVERSE EFFECT ON STEERING CONTROL.(CORRECT BY INSPECTING AND MAKING NECESSARY ADJUSTMENT.)
CHEVROLET: BLAZER: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
-->| NHTSA Campaign Number: | 69V152000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BLAZER |
| Model Year: | 1969 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 502 |
| Date Owner Notified By Manufacturer: | 19691028 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19691028 |
| Record Creation Date: | 19791012 |
Notes:
REPLACE OUTSIDE REARVIEW MIRROR WITH RECTANGULAR MIRROR.INSTALL TRANSMISSIONTRANSFER CASE SHIFT PATTERN DECAL WHERE NECESSARY.POSSIBILITY THAT FILLERNECK SEAL BETWEEN FUEL FILLER NECK AND BODY PANEL WAS OMITTED IN PRODUCTION.(CORRECT BY INSPECTING AND INSTALL- ING SEALS WHERE NECESSARY.)
--CHEVROLET: BROOKWOOD: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BROOKWOOD |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: BROOKWOOD: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BROOKWOOD |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
-- -- -- -- -- -- -- -- -- -- -- -- -- -- -- -- -- -- -- -- -- -- -- --CHEVROLET: BROOKWOOD: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BROOKWOOD |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: BROOKWOOD: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BROOKWOOD |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: BROOKWOOD: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BROOKWOOD |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: BROOKWOOD: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BROOKWOOD |
| Model Year: | 1971 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: BROOKWOOD: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BROOKWOOD |
| Model Year: | 1972 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: BROOKWOOD: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
| NHTSA Campaign Number: | 75V214000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | BROOKWOOD |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 39278 |
| Date Owner Notified By Manufacturer: | 19751223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19751219 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C04, PONTIAC CAMPAIGN NO. 76C7, OLDSMOBILE CAMPAIGN NO.76C1, BUICK CAMPAIGN NO. 76C1.POSSIBILITY THAT THE COMBINATION VALVE, WHICHIS A PART OF THE HYDRAULIC SERVICE BRAKE SYSTEM MAY HAVE BEEN IMPROPERLYMANUFACTURED AND COULD MALFUNCTION.SHOULD THIS CONDITION OCCUR WHILE VEHICLEIS IN MOTION AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED.A VEHICLECRASH COULD OCCUR WITHOUT PRIOR WARNING.(CORRECT BY INSPECTING AND REPLACINGVALVE WHERE NECESSARY.) PASSENGER CARS AND LIGHT TRUCKS.
-- --CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
-- --CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1970 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
| NHTSA Campaign Number: | 01I004000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1973 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010308 |
| Record Creation Date: | 20010605 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1973-1979 LIGHT DUTY PICKUP TRUCKS AND VANS EQUIPPED WITH FLEXIBLE ENGINE COOLING FANS. THE FLEX FANS WERE INSTALLED ON VEHICLES EQUIPPED WITH A HEAVY COOLING SYSTEM AND WITHOUT AIR CONDITIONING. OVER TIME, CRACKS CAN DEVELOP IN THE FAN BLADE DUE TO FATIGUE, ENGINE MODIFICATIONS, OR VEHICLE CRASHES.
Consequence Summary:
THIS COULD RESULT IN SEPARATION OF THE FAN BLADES, INCREASING THE RISK OF INJURY OR DEATH.
Corrective Summary:
OWNERS ARE BEING ASKED TO INSPECT THE FAN ASSEMBLY TO CONFIRM IF IT IS EQUIPPED WITH THE FAN IN QUESTION. THE FAN ASSEMBLY HAS SEVEN FAN BLADES AND IS IDENTIFIED BY PART NUMBER 336032 ON EACH FAN BLADE. IF THE VEHICLE IS EQUIPPED WITH THE FLEXIBLE FAN ASSEMBLY, YOU SHOULD REPLACE THE FAN. A NEW FOUR-BLADE FIXED PITCH FAN (PART NUMBER 461317) WILL BE AVAILABLE WITHIN THE NEXT FEW WEEKS. GM RECOMMENDS THAT YOU NEVER STAND IN LINE WITH OR NEAR THE ENGINE COOLING FAN WHEN REVVING THE ENGINE. FOR THE OWNER'S PROTECTION, THE HOOD SHOULD BE CLOSED WHEN REVVING THE ENGINE. GM HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO ADVISE OWNERS TO REPLACE THE FAN ASSEMBLY. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
| NHTSA Campaign Number: | 01I004000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1974 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010308 |
| Record Creation Date: | 20010605 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1973-1979 LIGHT DUTY PICKUP TRUCKS AND VANS EQUIPPED WITH FLEXIBLE ENGINE COOLING FANS. THE FLEX FANS WERE INSTALLED ON VEHICLES EQUIPPED WITH A HEAVY COOLING SYSTEM AND WITHOUT AIR CONDITIONING. OVER TIME, CRACKS CAN DEVELOP IN THE FAN BLADE DUE TO FATIGUE, ENGINE MODIFICATIONS, OR VEHICLE CRASHES.
Consequence Summary:
THIS COULD RESULT IN SEPARATION OF THE FAN BLADES, INCREASING THE RISK OF INJURY OR DEATH.
Corrective Summary:
OWNERS ARE BEING ASKED TO INSPECT THE FAN ASSEMBLY TO CONFIRM IF IT IS EQUIPPED WITH THE FAN IN QUESTION. THE FAN ASSEMBLY HAS SEVEN FAN BLADES AND IS IDENTIFIED BY PART NUMBER 336032 ON EACH FAN BLADE. IF THE VEHICLE IS EQUIPPED WITH THE FLEXIBLE FAN ASSEMBLY, YOU SHOULD REPLACE THE FAN. A NEW FOUR-BLADE FIXED PITCH FAN (PART NUMBER 461317) WILL BE AVAILABLE WITHIN THE NEXT FEW WEEKS. GM RECOMMENDS THAT YOU NEVER STAND IN LINE WITH OR NEAR THE ENGINE COOLING FAN WHEN REVVING THE ENGINE. FOR THE OWNER'S PROTECTION, THE HOOD SHOULD BE CLOSED WHEN REVVING THE ENGINE. GM HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO ADVISE OWNERS TO REPLACE THE FAN ASSEMBLY. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
| NHTSA Campaign Number: | 01I004000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1975 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010308 |
| Record Creation Date: | 20010605 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1973-1979 LIGHT DUTY PICKUP TRUCKS AND VANS EQUIPPED WITH FLEXIBLE ENGINE COOLING FANS. THE FLEX FANS WERE INSTALLED ON VEHICLES EQUIPPED WITH A HEAVY COOLING SYSTEM AND WITHOUT AIR CONDITIONING. OVER TIME, CRACKS CAN DEVELOP IN THE FAN BLADE DUE TO FATIGUE, ENGINE MODIFICATIONS, OR VEHICLE CRASHES.
Consequence Summary:
THIS COULD RESULT IN SEPARATION OF THE FAN BLADES, INCREASING THE RISK OF INJURY OR DEATH.
Corrective Summary:
OWNERS ARE BEING ASKED TO INSPECT THE FAN ASSEMBLY TO CONFIRM IF IT IS EQUIPPED WITH THE FAN IN QUESTION. THE FAN ASSEMBLY HAS SEVEN FAN BLADES AND IS IDENTIFIED BY PART NUMBER 336032 ON EACH FAN BLADE. IF THE VEHICLE IS EQUIPPED WITH THE FLEXIBLE FAN ASSEMBLY, YOU SHOULD REPLACE THE FAN. A NEW FOUR-BLADE FIXED PITCH FAN (PART NUMBER 461317) WILL BE AVAILABLE WITHIN THE NEXT FEW WEEKS. GM RECOMMENDS THAT YOU NEVER STAND IN LINE WITH OR NEAR THE ENGINE COOLING FAN WHEN REVVING THE ENGINE. FOR THE OWNER'S PROTECTION, THE HOOD SHOULD BE CLOSED WHEN REVVING THE ENGINE. GM HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO ADVISE OWNERS TO REPLACE THE FAN ASSEMBLY. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
| NHTSA Campaign Number: | 01I004000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1976 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010308 |
| Record Creation Date: | 20010605 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1973-1979 LIGHT DUTY PICKUP TRUCKS AND VANS EQUIPPED WITH FLEXIBLE ENGINE COOLING FANS. THE FLEX FANS WERE INSTALLED ON VEHICLES EQUIPPED WITH A HEAVY COOLING SYSTEM AND WITHOUT AIR CONDITIONING. OVER TIME, CRACKS CAN DEVELOP IN THE FAN BLADE DUE TO FATIGUE, ENGINE MODIFICATIONS, OR VEHICLE CRASHES.
Consequence Summary:
THIS COULD RESULT IN SEPARATION OF THE FAN BLADES, INCREASING THE RISK OF INJURY OR DEATH.
Corrective Summary:
OWNERS ARE BEING ASKED TO INSPECT THE FAN ASSEMBLY TO CONFIRM IF IT IS EQUIPPED WITH THE FAN IN QUESTION. THE FAN ASSEMBLY HAS SEVEN FAN BLADES AND IS IDENTIFIED BY PART NUMBER 336032 ON EACH FAN BLADE. IF THE VEHICLE IS EQUIPPED WITH THE FLEXIBLE FAN ASSEMBLY, YOU SHOULD REPLACE THE FAN. A NEW FOUR-BLADE FIXED PITCH FAN (PART NUMBER 461317) WILL BE AVAILABLE WITHIN THE NEXT FEW WEEKS. GM RECOMMENDS THAT YOU NEVER STAND IN LINE WITH OR NEAR THE ENGINE COOLING FAN WHEN REVVING THE ENGINE. FOR THE OWNER'S PROTECTION, THE HOOD SHOULD BE CLOSED WHEN REVVING THE ENGINE. GM HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO ADVISE OWNERS TO REPLACE THE FAN ASSEMBLY. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
| NHTSA Campaign Number: | 01I004000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1977 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010308 |
| Record Creation Date: | 20010605 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1973-1979 LIGHT DUTY PICKUP TRUCKS AND VANS EQUIPPED WITH FLEXIBLE ENGINE COOLING FANS. THE FLEX FANS WERE INSTALLED ON VEHICLES EQUIPPED WITH A HEAVY COOLING SYSTEM AND WITHOUT AIR CONDITIONING. OVER TIME, CRACKS CAN DEVELOP IN THE FAN BLADE DUE TO FATIGUE, ENGINE MODIFICATIONS, OR VEHICLE CRASHES.
Consequence Summary:
THIS COULD RESULT IN SEPARATION OF THE FAN BLADES, INCREASING THE RISK OF INJURY OR DEATH.
Corrective Summary:
OWNERS ARE BEING ASKED TO INSPECT THE FAN ASSEMBLY TO CONFIRM IF IT IS EQUIPPED WITH THE FAN IN QUESTION. THE FAN ASSEMBLY HAS SEVEN FAN BLADES AND IS IDENTIFIED BY PART NUMBER 336032 ON EACH FAN BLADE. IF THE VEHICLE IS EQUIPPED WITH THE FLEXIBLE FAN ASSEMBLY, YOU SHOULD REPLACE THE FAN. A NEW FOUR-BLADE FIXED PITCH FAN (PART NUMBER 461317) WILL BE AVAILABLE WITHIN THE NEXT FEW WEEKS. GM RECOMMENDS THAT YOU NEVER STAND IN LINE WITH OR NEAR THE ENGINE COOLING FAN WHEN REVVING THE ENGINE. FOR THE OWNER'S PROTECTION, THE HOOD SHOULD BE CLOSED WHEN REVVING THE ENGINE. GM HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO ADVISE OWNERS TO REPLACE THE FAN ASSEMBLY. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
| NHTSA Campaign Number: | 01I004000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1978 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010308 |
| Record Creation Date: | 20010605 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1973-1979 LIGHT DUTY PICKUP TRUCKS AND VANS EQUIPPED WITH FLEXIBLE ENGINE COOLING FANS. THE FLEX FANS WERE INSTALLED ON VEHICLES EQUIPPED WITH A HEAVY COOLING SYSTEM AND WITHOUT AIR CONDITIONING. OVER TIME, CRACKS CAN DEVELOP IN THE FAN BLADE DUE TO FATIGUE, ENGINE MODIFICATIONS, OR VEHICLE CRASHES.
Consequence Summary:
THIS COULD RESULT IN SEPARATION OF THE FAN BLADES, INCREASING THE RISK OF INJURY OR DEATH.
Corrective Summary:
OWNERS ARE BEING ASKED TO INSPECT THE FAN ASSEMBLY TO CONFIRM IF IT IS EQUIPPED WITH THE FAN IN QUESTION. THE FAN ASSEMBLY HAS SEVEN FAN BLADES AND IS IDENTIFIED BY PART NUMBER 336032 ON EACH FAN BLADE. IF THE VEHICLE IS EQUIPPED WITH THE FLEXIBLE FAN ASSEMBLY, YOU SHOULD REPLACE THE FAN. A NEW FOUR-BLADE FIXED PITCH FAN (PART NUMBER 461317) WILL BE AVAILABLE WITHIN THE NEXT FEW WEEKS. GM RECOMMENDS THAT YOU NEVER STAND IN LINE WITH OR NEAR THE ENGINE COOLING FAN WHEN REVVING THE ENGINE. FOR THE OWNER'S PROTECTION, THE HOOD SHOULD BE CLOSED WHEN REVVING THE ENGINE. GM HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO ADVISE OWNERS TO REPLACE THE FAN ASSEMBLY. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.
--CHEVROLET: C SERIES: EQUIPMENT:MECHANICAL:CARRIER/RACK
| NHTSA Campaign Number: | 78V177000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1978 |
| Manufacturer Component Description: | EQUIPMENT:MECHANICAL:CARRIER/RACK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 237693 |
| Date Owner Notified By Manufacturer: | 19780815 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19780815 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE NUT ON THE CARRIER SUPPORT BOLT ASSEMBLY MAY BREAK WHICH WOULD ALLOW THE ENTIRE WHEEL AND TIRE ASSEMBLY TO SEPARATE FROM THE VEHICLE.
Corrective Summary:
DEALER WILL REPLACE THE TIRE AND WHEEL CARRIER BOLT ASSEMBLY AT NO CHARGE.
Notes:
VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: EQUIPMENT; SPARE TIRE MOUNT.CONSEQUENCES OF DEFECT: IF THE SPARE TIRE AND WHEEL SEPARATES FROM THE VEHICLE,IT COULD ROLL FREE AND ENDANGER OTHER VEHICLES ON THE ROAD.
--CHEVROLET: C SERIES: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
| NHTSA Campaign Number: | 01I004000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1979 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010308 |
| Record Creation Date: | 20010605 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1973-1979 LIGHT DUTY PICKUP TRUCKS AND VANS EQUIPPED WITH FLEXIBLE ENGINE COOLING FANS. THE FLEX FANS WERE INSTALLED ON VEHICLES EQUIPPED WITH A HEAVY COOLING SYSTEM AND WITHOUT AIR CONDITIONING. OVER TIME, CRACKS CAN DEVELOP IN THE FAN BLADE DUE TO FATIGUE, ENGINE MODIFICATIONS, OR VEHICLE CRASHES.
Consequence Summary:
THIS COULD RESULT IN SEPARATION OF THE FAN BLADES, INCREASING THE RISK OF INJURY OR DEATH.
Corrective Summary:
OWNERS ARE BEING ASKED TO INSPECT THE FAN ASSEMBLY TO CONFIRM IF IT IS EQUIPPED WITH THE FAN IN QUESTION. THE FAN ASSEMBLY HAS SEVEN FAN BLADES AND IS IDENTIFIED BY PART NUMBER 336032 ON EACH FAN BLADE. IF THE VEHICLE IS EQUIPPED WITH THE FLEXIBLE FAN ASSEMBLY, YOU SHOULD REPLACE THE FAN. A NEW FOUR-BLADE FIXED PITCH FAN (PART NUMBER 461317) WILL BE AVAILABLE WITHIN THE NEXT FEW WEEKS. GM RECOMMENDS THAT YOU NEVER STAND IN LINE WITH OR NEAR THE ENGINE COOLING FAN WHEN REVVING THE ENGINE. FOR THE OWNER'S PROTECTION, THE HOOD SHOULD BE CLOSED WHEN REVVING THE ENGINE. GM HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO ADVISE OWNERS TO REPLACE THE FAN ASSEMBLY. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.
--CHEVROLET: C SERIES: EQUIPMENT:OTHER:LABELS
| NHTSA Campaign Number: | 89V149000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 1989 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890101 - 19890101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 585 |
| Date Owner Notified By Manufacturer: | 19891017 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890908 |
| Record Creation Date: | 19890926 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 120 |
Defect Summary:
TRUCKS MAY HAVE BEEN PRODUCED WITH INCORRECT OR MISSING
Consequence Summary:
TRUCKS WOULD NOT CONFORM TO REQUIREMENTS OF FMVSS 120.
Corrective Summary:
INSTALL CORRECT CERTIFICATION LABEL.
Notes:
SYSTEM:TIRE CERTIFICATION LABELS/FMVSS 120.VEHICLE DESCRIPTION:LIGHT-DUTY TRUCKS.VEHICLE CERTIFICATION LABELS.
--CHEVROLET: C SERIES (MEDIUM): STEERING:LINKAGES:TIE ROD ASSEMBLY
| NHTSA Campaign Number: | 01V044009 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES (MEDIUM) |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 1030 |
| Manufacturer Component Description: | STEERING:LINKAGES:TIE ROD ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19990701 - 19990731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6386 |
| Date Owner Notified By Manufacturer: | 20010424 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010417 |
| Record Creation Date: | 20010502 |
Defect Summary:
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS EQUIPPED WITH TIE ROD ASSEMBLIES CONTAINING 24-DL MODEL BALL SOCKETS AND MANUFACTURED BY TRW. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.
Consequence Summary:
IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE PARTIAL CONTROL OF THE RIGHT FRONT WHEEL, POSSIBLY RESULTING IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE DEFECTIVE BALL SOCKETS AND/OR DRAG LINKS. OWNER NOTIFICATION BEGAN APRIL 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 01030.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
--CHEVROLET: C SERIES (MEDIUM): STEERING:LINKAGES:TIE ROD ASSEMBLY
| NHTSA Campaign Number: | 01V140001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES (MEDIUM) |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 1030 |
| Manufacturer Component Description: | STEERING:LINKAGES:TIE ROD ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19990701 - 19990731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6386 |
| Date Owner Notified By Manufacturer: | 20010424 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010410 |
| Record Creation Date: | 20010426 |
Defect Summary:
VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS EQUIPPED WITH AXLE ASSEMBLIES WHICH MAY HAVE BEEN MANUFACTURED WITH TRW MODEL 20EDL BALL SOCKETS. THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW SPECIFICATION CASE DEPTH AND/OR HARDNESS WHICH CAN LEAD TO PREMATURE WEAR OUT OF THE SOCKET IN SOME APPLICATIONS.
Consequence Summary:
IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE STEERING CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE BALL SOCKET ASSEMBLIES. OWNER NOTIFICATION BEGAN APRIL 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
--CHEVROLET: C SERIES: FUEL SYSTEM, OTHER
| NHTSA Campaign Number: | 01I016000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 2001 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010901 |
| Record Creation Date: | 20020107 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2001 CHEVROLET AND GMC C-SERIES MEDIUM DUTY VEHICLES EQUIPPED WITH AN IMPCO LIQUEFIED PETROLEUM GAS (LPG) CONVERSION KIT. THE ENGINE COULD BACKFIRE CAUSING THE INLET ELBOW TO SEPARATE FROM ITS THROTTLE BODY.
Consequence Summary:
IF THIS WERE TO OCCUR, THE INLET ELBOW WOULD BE RETAINED BUT THE VEHICLE WOULD STOP RUNNING DUE TO INADEQUATE FUEL SUPPLY.
Corrective Summary:
DEALER WILL INSTALL A NEW ALUMINUM INLET ELBOW AT NO CHARGE TO THE CONSUMER.
Notes:
GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO INSTALL A NEW ALUMINUM INLET ELBOW ON AFFECTED VEHICLES.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-862-4389, CONCERNING THIS PROGRAM.
--CHEVROLET: C SERIES: SEAT BELTS:FRONT:RETRACTOR
| NHTSA Campaign Number: | 01V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 1043 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:RETRACTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000901 - 20001031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 9196 |
| Date Owner Notified By Manufacturer: | 20010702 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010517 |
| Record Creation Date: | 20010522 |
Defect Summary:
VEHICLE DESCRIPTION: PICKUP AND UTILITY TRUCKS. SOME OF THESE VEHICLES HAVE AN INTERNAL COMPONENT IN THE OUTBOARD SEAT BELT RETRACTORS FOR THE 2ND AND 3RD ROW OF SEATS THAT COULD BE CRACKED. WITH REPEATED ACTUATION OF THE LOCKING MECHANISM, THE CRACK COULD SPREAD TO THE POINT SUCH THAT THE SEAT BELT WOULD NO LONGER LOCK.
Consequence Summary:
IN A CRASH, INCREASED OCCUPANT INJURY COULD RESULT FROM THE NO-LOCK CONDITION.
Corrective Summary:
DEALERS WILL INSPECT THE OUTBOARD SEAT BELTS FOR SPECIFIC LOT NUMBERS AND REPLACE THE BELTS IF NECESSARY. GM IS ENCLOSING AN INSPECTION PROCEDURE FOR THE OWNERS TO USE OR THEY CAN HAVE THEIR DEALERS DO THE INSPECTIONS. OWNER NOTIFICATION BEGAN JULY 2, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
--CHEVROLET: C SERIES (MEDIUM): FUEL SYSTEM, OTHER
| NHTSA Campaign Number: | 01V080000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | C SERIES (MEDIUM) |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 1019 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001201 - 20010331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 187 |
| Date Owner Notified By Manufacturer: | 20010521 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010309 |
| Record Creation Date: | 20010321 |
Defect Summary:
VEHICLE DESCRIPTION: MEDIUM DUTY C SERIES VEHICLES EQUIPPED WITH AN IMPCO LIQUEFIED PETROLEUM GAS (LPG) CONVERSION KIT. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE ENGINE COULD BACKFIRE AND FRACTURE THE PLASTIC INLET ELBOW WITHIN THE ENGINE COMPARTMENT.
Consequence Summary:
IF THIS WERE TO OCCUR, AND THE HOOD OF THE VEHICLE WERE OPEN, PLASTIC FRAGMENTS FROM THE ELBOW COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. IN ADDITION, THE VEHICLE WILL STOP RUNNING DUE TO INADEQUATE FUEL SUPPLY.
Corrective Summary:
DEALERS WILL INSTALL A TEMPORARY INLET ELBOW THAT IS REINFORCED WITH A FIBERGLASS WRAP. THE INSTALLATION OF THIS TEMPORARY ELBOW WILL ELIMINATE THE SAFETY CONDITION. FOR THE PERMANENT REPAIR, DEALERS WILL INSTALL ALUMINUM INLET ELBOWS. A PRELIMINARY OWNER NOTIFICATION WAS MAILED TO CONSUMERS DURING MAY 2001. OWNER NOTIFICATION BEGAN MAY 21, 2001. A SEPARATE OWNER NOTIFICATION WILL BE MAILED WHEN PARTS ARE AVAILABLE FOR THE PERMANENT REPAIR. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
-- --CHEVROLET: CAMARO: ELECTRICAL SYSTEM:BATTERY:CABLES
-->| NHTSA Campaign Number: | 09V155000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 2010 |
| Manufacturer Campaign Number: | 9121 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:BATTERY:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20090201 - 20090430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1243 |
| Date Owner Notified By Manufacturer: | 20090506 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090506 |
| Record Creation Date: | 20090506 |
Defect Summary:
GM IS RECALLING 1,243 MY 2010 CHEVROLET CAMARO EQUIPPED WITH A V8 ENGINE. THE POSITIVE BATTERY CABLE MAY CONTACT THE STARTER MOTOR HOUSING AND CAUSE WEAR ON THE CABLE INSULATION. IF THE INSULATION WEARS THROUGH TO THE CABLE, IT COULD CREATE A SHORT.
Consequence Summary:
A SHORT COULD RESULT IN A NO START CONDITION, CAUSE THE VEHICLE TO STALL WITHOUT THE ABILITY TO RESTART, OR RESULT IN AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REROUTE THE POSITIVE BATTERY CABLE TO ENSURE ADEQUATE CLEARANCE. THE RECALL BEGAN ON MAY 6, 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09121.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: STRUCTURE:FRAME AND MEMBERS
-->| NHTSA Campaign Number: | 01V381000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 1072 |
| Manufacturer Component Description: | STRUCTURE:FRAME AND MEMBERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20011001 - 20011130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 897 |
| Date Owner Notified By Manufacturer: | 20011226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20011212 |
| Record Creation Date: | 20020102 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION," AND NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES MAY HAVE WELDS NEAR THE LOWER DRIVER'S SIDE DOOR HINGE THAT DO NOT MEET SPECIFICATIONS.
Consequence Summary:
IN A CRASH, AN OCCUPANT COULD RECEIVE SEVERE INJURIES.
Corrective Summary:
DEALERS WILL INSTALL STRUCTURAL RIVETS. OWNER NOTIFICATION BEGAN DECEMBER 26, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: POWER TRAIN:CLUTCH ASSEMBLY
-->| NHTSA Campaign Number: | 99V239000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 99056 |
| Manufacturer Component Description: | POWER TRAIN:CLUTCH ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19990601 - 19990630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 69 |
| Date Owner Notified By Manufacturer: | 19990908 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990827 |
| Record Creation Date: | 19990830 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS. THE CLUTCH MASTER CYLINDER MAY HAVE BEEN BUILT WITH AN INCORRECT RETAINING RING.
Consequence Summary:
THIS MAY NOT ALLOW THE CLUTCH SYSTEM TO DISENGAGE THE CLUTCH WHEN THE CLUTCH PEDAL IS DEPRESSED, RESULTING IN UNINTENTIONAL VEHICLE MOVEMENT, INCREASED STOPPING DISTANCES, ENGINE STALLS, AND DIFFICULTY IN SHIFTING.
Corrective Summary:
DEALERS WILL REPLACE THE HYDRAULIC CLUTCH MASTER CYLINDER WITH A NEW CYLINDER.
Notes:
GM RECALL NO. 99056.OWNER NOTIFICATION BEGAN SEPTEMBER 8, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: SEAT BELTS:FRONT:RETRACTOR
-->| NHTSA Campaign Number: | 96V219000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1997 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:RETRACTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960601 - 19960930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1573 |
| Date Owner Notified By Manufacturer: | 19961120 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961104 |
| Record Creation Date: | 19961107 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
THESE VEHICLES WERE MANUFACTURED WITH SEAT BELT RETRACTORS OUT OF DESIGN POSITION WHICH CAN CAUSE THE RETRACTOR TO LOCK-UP ON SLOPES LESS SEVERE THAN THE FMVSS REQUIREMENT. THIS DOES NOT COMPLY WITH FMVSS NO. 209, "SEAT BELT ASSEMBLIES."
Consequence Summary:
IN THE EVENT OF A VEHICLE COLLISION, UNBELTED OCCUPANTS ARE MORE AT RISK OF INJURY THAN THOSE USING SEAT BELTS.
Corrective Summary:
DEALERS WILL INSPECT THE SEAT BELTS FOR PROPER FRONT SEAT BELT RETRACTOR POSITION. RETRACTORS FOUND TO BE IMPROPERLY POSITIONED WILL BE REINSTALLED CORRECTLY.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION BEGAN IN OCTOBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1997 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1996 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
-->| NHTSA Campaign Number: | 95V046000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1995 |
| Manufacturer Component Description: | STEERING:GEAR BOX (OTHER THAN RACK AND PINION) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950201 - 19950201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 362 |
| Date Owner Notified By Manufacturer: | 19950308 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950322 |
| Record Creation Date: | 19950322 |
Defect Summary:
THE STEERING INTERMEDIATE SHAFT COULD HAVE BEEN IMPROPERLY ASSEMBLED CAUSING THE SHAFT LOWER COUPLING TO LOOSEN AND ROTATE ON THE STEERING GEAR INPUT SHAFT.
Consequence Summary:
THIS CONDITION CAN RESULT IN A LOSS OF STEERING CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL INSPECT THE INTERMEDIATE STEERING SHAFT FOR THE CORRECT LOWER COUPLING AND REPLACE IT AS REQUIRED.
Notes:
SYSTEM: STEERING: GEAR BOX.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, PLEASE CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1995 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1993 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1993 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1992 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
-->| NHTSA Campaign Number: | 94V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1992 |
| Manufacturer Campaign Number: | 92C36 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19891001 - 19920801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 232988 |
| Date Owner Notified By Manufacturer: | 19940609 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19940425 |
| Record Creation Date: | 19940503 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 301 |
Defect Summary:
THE FUEL FILLER NECK SOLDER JOINT CAN DEVELOP CRACKS OR PIN HOLE LEAKS, WHICH DOES NOT COMPLY WITH FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE CRACKS AND HOLES CAN ALLOW FUEL VAPOR AND FUEL LEAKAGE.
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: GASOLINE VAPORS AND FUEL LEAKS CAN RESULT IN A FIRE IF EXPOSED TO A SOURCE OF IGNITION.
Corrective Summary:
DEALERS WILL INSPECT THE FUEL TANK ASSEMBLY AND REPLACE THOSE WHICH EXHIBIT THE CRACKS OR PIN HOLE LEAKS.
Notes:
SYSTEM: FUEL; FUEL TANK ASSEMBLY; PIPE; FILLER; NECK; FMVSS 301.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIME OR THE REMEDY DOES NOT CORRECT THE NONCOMPLIANCE, PLEASE CONTACT CHEVROLET AT1-800-222-1020 OR PONTIAC AT 1-800-762-2737. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1992 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 92V154000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1992 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19920201 - 19920801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 43413 |
| Date Owner Notified By Manufacturer: | 19921103 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19921023 |
| Record Creation Date: | 19921102 |
Defect Summary:
THE AUTOMATIC TRANSMISSION SHIFT CONTROL CABLE CAN SEPARATE.
Consequence Summary:
SEPARATION OF THE TRANSMISSION SHIFT CABLE CAN PREVENTTHE TRANSMISSION FROM BEING SHIFTED INTO THE PROPER POSITION. THIS CONDITION CANCAUSE UNEXPECTED VEHICLE MOVEMENT WHEN THE TRANSIMISSION INDICATOR IS IN PARK ORNEUTRAL POSITION AND THE TRANSMISSION IS IN A DRIVE MODE; THIS COULD RESULT INA VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
THE DEALER WILL REPLACE THE SHIFT CABLE.
Notes:
SYSTEM: TRANSMISSION.VEHICLE DESCRIPTION: PASSENGER CARS WITH AUTOMATIC TRANSMISSIONS.
CHEVROLET: CAMARO: SEATS:FRONT ASSEMBLY:RECLINER
-->| NHTSA Campaign Number: | 91V074000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910401 - 19910401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 173 |
| Date Owner Notified By Manufacturer: | 19910506 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910503 |
| Record Creation Date: | 19910520 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 207 |
Defect Summary:
THE FRONT SEAT UPPER HINGE COVER SCREWS ARE TOO LONG, AND INTERFERE WITH THE SEAT BACK INERTIA LOCK. THIS PREVENTS THE SEAT BACK FROM LOCKING PROPERLY.
Consequence Summary:
IN THE EVENT OF A SUDDEN STOP OR VEHICLE IMPACT, ANUNLOCKED SEAT BACK WOULD INCREASE THE RISK OF INJURY TO THE SEAT OCCUPANT.
Corrective Summary:
REPLACE SCREWS SECURING UPPER HINGE TRIM COVER WITH CORRECT LENGTH SCREWS.
Notes:
SYSTEM: FRONT BUCKET SEAT LATCH; FMVSS 207.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1991 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
-->| NHTSA Campaign Number: | 94V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1991 |
| Manufacturer Campaign Number: | 92C36 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19891001 - 19920801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 232988 |
| Date Owner Notified By Manufacturer: | 19940609 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19940425 |
| Record Creation Date: | 19940503 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 301 |
Defect Summary:
THE FUEL FILLER NECK SOLDER JOINT CAN DEVELOP CRACKS OR PIN HOLE LEAKS, WHICH DOES NOT COMPLY WITH FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE CRACKS AND HOLES CAN ALLOW FUEL VAPOR AND FUEL LEAKAGE.
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: GASOLINE VAPORS AND FUEL LEAKS CAN RESULT IN A FIRE IF EXPOSED TO A SOURCE OF IGNITION.
Corrective Summary:
DEALERS WILL INSPECT THE FUEL TANK ASSEMBLY AND REPLACE THOSE WHICH EXHIBIT THE CRACKS OR PIN HOLE LEAKS.
Notes:
SYSTEM: FUEL; FUEL TANK ASSEMBLY; PIPE; FILLER; NECK; FMVSS 301.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIME OR THE REMEDY DOES NOT CORRECT THE NONCOMPLIANCE, PLEASE CONTACT CHEVROLET AT1-800-222-1020 OR PONTIAC AT 1-800-762-2737. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1991 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V067000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 40696 |
| Date Owner Notified By Manufacturer: | 19910508 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910422 |
| Record Creation Date: | 19910425 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
THE METAL LATCHPLATES MAY NOT ENGAGE THE BUCKLE ASSEMBLIES, CAUSING A "NO LATCH" CONDITION. MOVEMENT OF THE SEAT OCCUPANT IN THIS CONDITION COULD CAUSE LATCHPLATE RELEASE FROM THE BUCKLE.
Consequence Summary:
UNBELTED OR INCORRECTLY BELTED SEAT OCCUPANTS ARESUBJECTED TO INCREASED RISK OF INJURY IN THE EVENT OF SUDDEN STOP OR ACCIDENT.
Corrective Summary:
REPLACE THE RETRACTOR ASSEMBLY FOR THE SAFETY BELT (FRONT AND REAR IN COUPES AND FRONT ONLY IN CONVERTIBLES).
Notes:
SYSTEM: SAFETY BELT ASSEMBLY; FMVSS 209.VEHICLE DESCRIPTION: PASSENGER CARS; COUPES AND CONVERTIBLES.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: VISIBILITY:WINDSHIELD
-->| NHTSA Campaign Number: | 91V031000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1991 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19901201 - 19901201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 21 |
| Date Owner Notified By Manufacturer: | 19901207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910219 |
| Record Creation Date: | 19910228 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 212 |
Defect Summary:
POOR BOND ADHESION BETWEEN THE WINDSHIELD GLASS AND THE MOUNTING, WHICH COULD ALLOW THE WINDSHIELD TO SEPARATE FROM THE VEHICLE DURING A COLLISION. THIS FAILS TO CONFORM WITH FMVSS 212.
Consequence Summary:
IF WINDSHIELD SEPARATION OCCURS IN A COLLISION, ANUNBELTED OCCUPANT COULD BE EJECTED FROM THE VEHICLE, AND PERSONAL INJURY COULDOCCUR.
Corrective Summary:
REMOVE ALL SEALER FROM WINDSHIELD AND MOUNTING; APPLY NEW BONDING AND SEALANT MATERIAL, AND REINSTALL WINDSHIELD.
Notes:
SYSTEM: WINDSHIELD MOUNTING; FMVSS 212.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 90V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830901 - 19900601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1500000 |
| Date Owner Notified By Manufacturer: | 19910307 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900514 |
| Record Creation Date: | 19900626 |
Defect Summary:
PLASTIC COMPONENTS OF SEAT BELT BUCKLE ASSEMBLIES DO NOT CONTAIN AN ULTRA VIOLET STABILIZER, AND EXPOSURE TO DIRECT SUNLIGHT AND ELEVATED INTERIOR TEMPERATURES COULD WEAKEN THE PLASTIC COMPONENTS.
Consequence Summary:
THIS COULD RESULT IN BREAKAGE OF PLASTIC COMPONENTS WHICHCOULD PREVENT BUCKLE FROM LATCHING AND PROTECTING OCCUPANT IN A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE OR REPAIR SEAT BELT BUCKLE.
Notes:
SYSTEM: SEAT BELT BUCKLE.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1990 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 90V114000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890901 - 19891001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 10297 |
| Date Owner Notified By Manufacturer: | 19900720 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900612 |
| Record Creation Date: | 19900619 |
Defect Summary:
FUEL RETURN HOSES MAY BREAK AT EITHER CRIMPED COUPLING.
Consequence Summary:
IF THIS COUPLING SEPARATED, ALLOWING GASOLINE TO LEAK,AND AN IGNITION SOURCE WAS PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
INSTALL A PROPERLY CRIMPED FUEL RETURN HOSE.
Notes:
SYSTEM: FUEL RETURN HOSES.VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH 5.0 L AND 5.7 L V-8 ENGINES.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1990 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 90V115000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880401 - 19890601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 29331 |
| Date Owner Notified By Manufacturer: | 19900720 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900612 |
| Record Creation Date: | 19900619 |
Defect Summary:
FUEL FEED HOSES MAY PULL OUT OF THE CRIMPED COUPLING AT THE ENGINE END OF THE HOSE ASSEMBLY.
Consequence Summary:
IF THIS COUPLING SEPARATED, ALLOWING GASOLINE TO LEAK,AND AN IGNITION SOURCE IS PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
INSTALL A REDESIGNED FUEL FEED HOSE.
Notes:
SYSTEM: FUEL FEED HOSES.VEHICLE DESCRIPTION: PASSENGER CARS WITH 2.8L V6 ENGINES.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 90V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830901 - 19900601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1500000 |
| Date Owner Notified By Manufacturer: | 19910307 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900514 |
| Record Creation Date: | 19900626 |
Defect Summary:
PLASTIC COMPONENTS OF SEAT BELT BUCKLE ASSEMBLIES DO NOT CONTAIN AN ULTRA VIOLET STABILIZER, AND EXPOSURE TO DIRECT SUNLIGHT AND ELEVATED INTERIOR TEMPERATURES COULD WEAKEN THE PLASTIC COMPONENTS.
Consequence Summary:
THIS COULD RESULT IN BREAKAGE OF PLASTIC COMPONENTS WHICHCOULD PREVENT BUCKLE FROM LATCHING AND PROTECTING OCCUPANT IN A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE OR REPAIR SEAT BELT BUCKLE.
Notes:
SYSTEM: SEAT BELT BUCKLE.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: SEAT BELTS
-->| NHTSA Campaign Number: | 88V191000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880901 - 19880901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 34 |
| Date Owner Notified By Manufacturer: | 19881213 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19881213 |
| Record Creation Date: | 19881219 |
Defect Summary:
WEBBING ON THE BUCKLE PORTION OF THE REAR LAP/SHOULDER BELTS MAY BE TOO LONG.
Consequence Summary:
IN THE EVENT OF A SEVERE VEHICLE CRASH, THE EFFECTIVENESSOF THE LAP/SHOULDER BELT MAY BE REDUCED.
Corrective Summary:
REPLACE REAR INBOARD SEAT BELTS WITH BELTS OF THE PROPER LENGTH.
Notes:
SYSTEM: REAR INBOARD SEAT BELT.VEHICLE DESCRIPTION: CONVERTIBLE TOP PASSENGER CARS.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1989 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1989 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 90V115000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880401 - 19890601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 29331 |
| Date Owner Notified By Manufacturer: | 19900720 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900612 |
| Record Creation Date: | 19900619 |
Defect Summary:
FUEL FEED HOSES MAY PULL OUT OF THE CRIMPED COUPLING AT THE ENGINE END OF THE HOSE ASSEMBLY.
Consequence Summary:
IF THIS COUPLING SEPARATED, ALLOWING GASOLINE TO LEAK,AND AN IGNITION SOURCE IS PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
INSTALL A REDESIGNED FUEL FEED HOSE.
Notes:
SYSTEM: FUEL FEED HOSES.VEHICLE DESCRIPTION: PASSENGER CARS WITH 2.8L V6 ENGINES.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 90V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1988 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830901 - 19900601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1500000 |
| Date Owner Notified By Manufacturer: | 19910307 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900514 |
| Record Creation Date: | 19900626 |
Defect Summary:
PLASTIC COMPONENTS OF SEAT BELT BUCKLE ASSEMBLIES DO NOT CONTAIN AN ULTRA VIOLET STABILIZER, AND EXPOSURE TO DIRECT SUNLIGHT AND ELEVATED INTERIOR TEMPERATURES COULD WEAKEN THE PLASTIC COMPONENTS.
Consequence Summary:
THIS COULD RESULT IN BREAKAGE OF PLASTIC COMPONENTS WHICHCOULD PREVENT BUCKLE FROM LATCHING AND PROTECTING OCCUPANT IN A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE OR REPAIR SEAT BELT BUCKLE.
Notes:
SYSTEM: SEAT BELT BUCKLE.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1988 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1988 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 90V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1987 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830901 - 19900601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1500000 |
| Date Owner Notified By Manufacturer: | 19910307 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900514 |
| Record Creation Date: | 19900626 |
Defect Summary:
PLASTIC COMPONENTS OF SEAT BELT BUCKLE ASSEMBLIES DO NOT CONTAIN AN ULTRA VIOLET STABILIZER, AND EXPOSURE TO DIRECT SUNLIGHT AND ELEVATED INTERIOR TEMPERATURES COULD WEAKEN THE PLASTIC COMPONENTS.
Consequence Summary:
THIS COULD RESULT IN BREAKAGE OF PLASTIC COMPONENTS WHICHCOULD PREVENT BUCKLE FROM LATCHING AND PROTECTING OCCUPANT IN A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE OR REPAIR SEAT BELT BUCKLE.
Notes:
SYSTEM: SEAT BELT BUCKLE.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1987 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1987 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: PARKING BRAKE:CONVENTIONAL
-->| NHTSA Campaign Number: | 91V055000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1986 |
| Manufacturer Component Description: | PARKING BRAKE:CONVENTIONAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810301 - 19860701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 179036 |
| Date Owner Notified By Manufacturer: | 19910701 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910411 |
| Record Creation Date: | 19910411 |
Defect Summary:
PARKING BRAKE ADJUSTER FAILS TO OPERATE AND DO NOT WORK AFTER BRAKE PAD WEAR.
Consequence Summary:
PARKING BRAKES WILL NOT COMPLETELY HOLD A PARKED VEHICLEWHEN PARKED ON A SLOPE, CAUSING UNINTENDED VEHICLE ROLLAWAY WHICH COULD RESULTIN A VEHICLE ACCIDENT.
Corrective Summary:
REPLACE NONFUNCTIONING PARKING BRAKE ADJUSTERS.
Notes:
SYSTEM: PARKING BRAKE.VEHICLE DESCRIPTION: PASSENGER CARS; FIREBIRDS AND CAMAROS WITH MANUALTRANSMISSIONS AND REAR DISK BRAKES AND FIEROS WITH MANUAL TRANSMISSIONS.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 90V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1986 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830901 - 19900601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1500000 |
| Date Owner Notified By Manufacturer: | 19910307 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900514 |
| Record Creation Date: | 19900626 |
Defect Summary:
PLASTIC COMPONENTS OF SEAT BELT BUCKLE ASSEMBLIES DO NOT CONTAIN AN ULTRA VIOLET STABILIZER, AND EXPOSURE TO DIRECT SUNLIGHT AND ELEVATED INTERIOR TEMPERATURES COULD WEAKEN THE PLASTIC COMPONENTS.
Consequence Summary:
THIS COULD RESULT IN BREAKAGE OF PLASTIC COMPONENTS WHICHCOULD PREVENT BUCKLE FROM LATCHING AND PROTECTING OCCUPANT IN A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE OR REPAIR SEAT BELT BUCKLE.
Notes:
SYSTEM: SEAT BELT BUCKLE.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
-->| NHTSA Campaign Number: | 86V131000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860301 - 19860401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 106111 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860919 |
| Record Creation Date: | 19860930 |
Defect Summary:
THE PUSH PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS AND TRUCKS/ VANS.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1986 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
-->| NHTSA Campaign Number: | 86V056000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19850901 - 19851101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 93317 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860428 |
| Record Creation Date: | 19860501 |
Defect Summary:
THE PUSH-PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. NOTE: ALSO, SEE NHTSA CAMPAIGN NUMBER 86V131000.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS, TRUCKS AND VANS.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1986 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: PARKING BRAKE:CONVENTIONAL
-->| NHTSA Campaign Number: | 91V055000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1985 |
| Manufacturer Component Description: | PARKING BRAKE:CONVENTIONAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810301 - 19860701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 179036 |
| Date Owner Notified By Manufacturer: | 19910701 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910411 |
| Record Creation Date: | 19910411 |
Defect Summary:
PARKING BRAKE ADJUSTER FAILS TO OPERATE AND DO NOT WORK AFTER BRAKE PAD WEAR.
Consequence Summary:
PARKING BRAKES WILL NOT COMPLETELY HOLD A PARKED VEHICLEWHEN PARKED ON A SLOPE, CAUSING UNINTENDED VEHICLE ROLLAWAY WHICH COULD RESULTIN A VEHICLE ACCIDENT.
Corrective Summary:
REPLACE NONFUNCTIONING PARKING BRAKE ADJUSTERS.
Notes:
SYSTEM: PARKING BRAKE.VEHICLE DESCRIPTION: PASSENGER CARS; FIREBIRDS AND CAMAROS WITH MANUALTRANSMISSIONS AND REAR DISK BRAKES AND FIEROS WITH MANUAL TRANSMISSIONS.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 90V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1985 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830901 - 19900601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1500000 |
| Date Owner Notified By Manufacturer: | 19910307 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900514 |
| Record Creation Date: | 19900626 |
Defect Summary:
PLASTIC COMPONENTS OF SEAT BELT BUCKLE ASSEMBLIES DO NOT CONTAIN AN ULTRA VIOLET STABILIZER, AND EXPOSURE TO DIRECT SUNLIGHT AND ELEVATED INTERIOR TEMPERATURES COULD WEAKEN THE PLASTIC COMPONENTS.
Consequence Summary:
THIS COULD RESULT IN BREAKAGE OF PLASTIC COMPONENTS WHICHCOULD PREVENT BUCKLE FROM LATCHING AND PROTECTING OCCUPANT IN A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE OR REPAIR SEAT BELT BUCKLE.
Notes:
SYSTEM: SEAT BELT BUCKLE.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:WEBBING
-->| NHTSA Campaign Number: | 85V169000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1985 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WEBBING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19821001 - 19850301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 738485 |
| Date Owner Notified By Manufacturer: | 19860418 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851220 |
| Record Creation Date: | 19860110 |
Defect Summary:
DISLOCATION OF A SPRING COVER WILL NOT ALLOW THE SHOULDER BELT TO RETRACT AFTER BEING EXTENDED. CONSEQUENCE OF DEFECT: ALTHOUGH INERTIAL FEATURE THAT LOCKS THE LAP BELT AND SHOULDER BELT IN THE EVENT OF AN ACCIDENT ARE NOT AFFECTED, IF SLACK IS MORE THAN RECOMMENDED IN OWNERS MANUAL, INJURIES TO UPPER BODY AND HEAD WOULD BE INCREASED IN AN ACCIDENT.
Corrective Summary:
INSTALL RETAINING SPRINGS ON SPRING COVER OF FRONT SHOULDER BELT RETRACTOR AND, WHEN REQUIRED, RETRACTORS WILL BE REPLACED.
Notes:
SYSTEM: SHOULDER SEAT BELT RETRACTOR. VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1985 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1985 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1985 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: PARKING BRAKE:CONVENTIONAL
-->| NHTSA Campaign Number: | 91V055000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1984 |
| Manufacturer Component Description: | PARKING BRAKE:CONVENTIONAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810301 - 19860701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 179036 |
| Date Owner Notified By Manufacturer: | 19910701 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910411 |
| Record Creation Date: | 19910411 |
Defect Summary:
PARKING BRAKE ADJUSTER FAILS TO OPERATE AND DO NOT WORK AFTER BRAKE PAD WEAR.
Consequence Summary:
PARKING BRAKES WILL NOT COMPLETELY HOLD A PARKED VEHICLEWHEN PARKED ON A SLOPE, CAUSING UNINTENDED VEHICLE ROLLAWAY WHICH COULD RESULTIN A VEHICLE ACCIDENT.
Corrective Summary:
REPLACE NONFUNCTIONING PARKING BRAKE ADJUSTERS.
Notes:
SYSTEM: PARKING BRAKE.VEHICLE DESCRIPTION: PASSENGER CARS; FIREBIRDS AND CAMAROS WITH MANUALTRANSMISSIONS AND REAR DISK BRAKES AND FIEROS WITH MANUAL TRANSMISSIONS.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 90V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830901 - 19900601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1500000 |
| Date Owner Notified By Manufacturer: | 19910307 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900514 |
| Record Creation Date: | 19900626 |
Defect Summary:
PLASTIC COMPONENTS OF SEAT BELT BUCKLE ASSEMBLIES DO NOT CONTAIN AN ULTRA VIOLET STABILIZER, AND EXPOSURE TO DIRECT SUNLIGHT AND ELEVATED INTERIOR TEMPERATURES COULD WEAKEN THE PLASTIC COMPONENTS.
Consequence Summary:
THIS COULD RESULT IN BREAKAGE OF PLASTIC COMPONENTS WHICHCOULD PREVENT BUCKLE FROM LATCHING AND PROTECTING OCCUPANT IN A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE OR REPAIR SEAT BELT BUCKLE.
Notes:
SYSTEM: SEAT BELT BUCKLE.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:WEBBING
-->| NHTSA Campaign Number: | 85V169000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WEBBING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19821001 - 19850301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 738485 |
| Date Owner Notified By Manufacturer: | 19860418 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851220 |
| Record Creation Date: | 19860110 |
Defect Summary:
DISLOCATION OF A SPRING COVER WILL NOT ALLOW THE SHOULDER BELT TO RETRACT AFTER BEING EXTENDED. CONSEQUENCE OF DEFECT: ALTHOUGH INERTIAL FEATURE THAT LOCKS THE LAP BELT AND SHOULDER BELT IN THE EVENT OF AN ACCIDENT ARE NOT AFFECTED, IF SLACK IS MORE THAN RECOMMENDED IN OWNERS MANUAL, INJURIES TO UPPER BODY AND HEAD WOULD BE INCREASED IN AN ACCIDENT.
Corrective Summary:
INSTALL RETAINING SPRINGS ON SPRING COVER OF FRONT SHOULDER BELT RETRACTOR AND, WHEN REQUIRED, RETRACTORS WILL BE REPLACED.
Notes:
SYSTEM: SHOULDER SEAT BELT RETRACTOR. VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1984 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1984 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: SEATS:FRONT ASSEMBLY:RECLINER
-->| NHTSA Campaign Number: | 84V011000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830701 - 19830901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 76586 |
| Date Owner Notified By Manufacturer: | 19840224 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840206 |
| Record Creation Date: | 19840222 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 207 |
Defect Summary:
SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Corrective Summary:
INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
CHEVROLET: CAMARO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 84V093000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1984 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840101 - 19840201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 30868 |
| Date Owner Notified By Manufacturer: | 19840915 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840817 |
| Record Creation Date: | 19840911 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 106 |
Defect Summary:
REAR BRAKE HOSES WERE NOT PROPERLY MANUFACTURED AND DO NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 106, "BRAKE HOSES". HOSES COULD COME LOOSE FROM THE END FITTINGS WHEN SUBJECTED TO A PULLING FORCE.
Corrective Summary:
A NEW HOSE WILL BE INSTALLED IF NECESSARY. IN ADDITION, BRAKES WILL BE SERVICED.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; REAR BRAKE HOSE.CONSEQUENCES OF DEFECT: SEPARATION OF THE HOSE FROM ITS METAL END FITTING WOULDRESULT IN LOSS OF BRAKE FLUID AND LOSS OF SOME BRAKE ACTION. AN ACCIDENT COULDRESULT UNDER CIRCUMSTANCES REQUIRING MINIMUM STOPPING DISTANCE.
CHEVROLET: CAMARO: PARKING BRAKE:CONVENTIONAL
-->| NHTSA Campaign Number: | 91V055000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1983 |
| Manufacturer Component Description: | PARKING BRAKE:CONVENTIONAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810301 - 19860701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 179036 |
| Date Owner Notified By Manufacturer: | 19910701 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910411 |
| Record Creation Date: | 19910411 |
Defect Summary:
PARKING BRAKE ADJUSTER FAILS TO OPERATE AND DO NOT WORK AFTER BRAKE PAD WEAR.
Consequence Summary:
PARKING BRAKES WILL NOT COMPLETELY HOLD A PARKED VEHICLEWHEN PARKED ON A SLOPE, CAUSING UNINTENDED VEHICLE ROLLAWAY WHICH COULD RESULTIN A VEHICLE ACCIDENT.
Corrective Summary:
REPLACE NONFUNCTIONING PARKING BRAKE ADJUSTERS.
Notes:
SYSTEM: PARKING BRAKE.VEHICLE DESCRIPTION: PASSENGER CARS; FIREBIRDS AND CAMAROS WITH MANUALTRANSMISSIONS AND REAR DISK BRAKES AND FIEROS WITH MANUAL TRANSMISSIONS.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:WEBBING
-->| NHTSA Campaign Number: | 85V169000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1983 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WEBBING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19821001 - 19850301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 738485 |
| Date Owner Notified By Manufacturer: | 19860418 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851220 |
| Record Creation Date: | 19860110 |
Defect Summary:
DISLOCATION OF A SPRING COVER WILL NOT ALLOW THE SHOULDER BELT TO RETRACT AFTER BEING EXTENDED. CONSEQUENCE OF DEFECT: ALTHOUGH INERTIAL FEATURE THAT LOCKS THE LAP BELT AND SHOULDER BELT IN THE EVENT OF AN ACCIDENT ARE NOT AFFECTED, IF SLACK IS MORE THAN RECOMMENDED IN OWNERS MANUAL, INJURIES TO UPPER BODY AND HEAD WOULD BE INCREASED IN AN ACCIDENT.
Corrective Summary:
INSTALL RETAINING SPRINGS ON SPRING COVER OF FRONT SHOULDER BELT RETRACTOR AND, WHEN REQUIRED, RETRACTORS WILL BE REPLACED.
Notes:
SYSTEM: SHOULDER SEAT BELT RETRACTOR. VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1983 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: STRUCTURE:BODY:HOOD
-->| NHTSA Campaign Number: | 83V049000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1983 |
| Manufacturer Component Description: | STRUCTURE:BODY:HOOD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830101 - 19830101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4393 |
| Date Owner Notified By Manufacturer: | 19830506 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830502 |
| Record Creation Date: | 19830513 |
Defect Summary:
THE INNER AND OUTER PANELS OF THE FIBERGLASS HOOD COULD SEPARATE DURING VEHICLE OPERATION.
Corrective Summary:
DEALER WILL INSPECT THE HOOD AND, IF NECESSARY, INSTALL A NEW ONE AT NO CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 5 LITER ENGINES.SYSTEM: STRUCTURE; FIBERGLASS HOODS.CONSEQUENCES OF DEFECT: IF THIS SEPARATION OCCURS WHILE THE VEHICLE IS INMOTION, THE OUTER PANEL MAY FOLD BACK AND BLOCK THE DRIVER"S VIEW. THIS COULDCAUSE A LOSS OF CONTROL WITHOUT PRIOR WARNING, POSSIBLY RESULTING IN ANACCIDENT.
CHEVROLET: CAMARO: PARKING BRAKE:CONVENTIONAL
-->| NHTSA Campaign Number: | 91V055000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1982 |
| Manufacturer Component Description: | PARKING BRAKE:CONVENTIONAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810301 - 19860701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 179036 |
| Date Owner Notified By Manufacturer: | 19910701 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910411 |
| Record Creation Date: | 19910411 |
Defect Summary:
PARKING BRAKE ADJUSTER FAILS TO OPERATE AND DO NOT WORK AFTER BRAKE PAD WEAR.
Consequence Summary:
PARKING BRAKES WILL NOT COMPLETELY HOLD A PARKED VEHICLEWHEN PARKED ON A SLOPE, CAUSING UNINTENDED VEHICLE ROLLAWAY WHICH COULD RESULTIN A VEHICLE ACCIDENT.
Corrective Summary:
REPLACE NONFUNCTIONING PARKING BRAKE ADJUSTERS.
Notes:
SYSTEM: PARKING BRAKE.VEHICLE DESCRIPTION: PASSENGER CARS; FIREBIRDS AND CAMAROS WITH MANUALTRANSMISSIONS AND REAR DISK BRAKES AND FIEROS WITH MANUAL TRANSMISSIONS.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1982 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 82V089000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1982 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19811001 - 19820601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 172863 |
| Date Owner Notified By Manufacturer: | 19820922 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19820921 |
| Record Creation Date: | 19820924 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES". THE NON-COMPLIANCE EXISTS BECAUSE THE REAR SEAT BELT ANCHORAGES MAY PULL THROUGH THE UNDERBODY OF THE VEHICLE IF ENOUGH FORCE IS APPLIED.
Consequence Summary:
CONSEQUENCE OF DEFECT: IN THE EVENT OF AN ACCIDENT, PERSONAL INJURY OR DEATH MAY RESULT FROM A FAILURE OF BELT TO ADEQUATELY RESTRAIN OCCUPANTS.
Corrective Summary:
UPON INSPECTION, DEALER WILL INSTALL A REAR SEAT BELT ANCHORAGE REINFORCEMENT KIT TO ENSURE PROPER ANCHORING OF SEAT BELTS WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: INTERIOR; SEAT BELT ASSEMBLY.
CHEVROLET: CAMARO: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-->| NHTSA Campaign Number: | 82V076000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1982 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810701 - 19820701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 24455 |
| Date Owner Notified By Manufacturer: | 19820722 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19820729 |
| Record Creation Date: | 19820806 |
Defect Summary:
FUEL TANK VENTILATOR VALVE IN THE FUEL SYSTEM MAY PRODUCE A LOUD AND PERSISTENT "WHISTLE" DURING VENTING OF THE TANK. IF THE FUEL FILLER CAP IS REMOVED WHILE THIS CONDITION EXISTS AND THE TANK IS MORE THAN 3/4 FULL, GASOLINE MAY BE FORCED OUT OF THE FILLER NECK ONTO BYSTANDERS.
Consequence Summary:
CONSEQUENCE OF DEFECT: FIRE AND PERSONAL INJURY COULD RESULT IF INTRODUCED TO AN IGNITION SOURCE.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE FUEL TANK VENTILATOR AND PRESSURE CONTROL VALVES WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FUEL INJECTION ENGINES.YSTEM: FUEL; FUEL TANK VENTILATOR VALVE.: FIRE AND PERSONAL INJURY COULD RESULT IN THE PRESENCEOF AN IGNITION SOURCE.
CHEVROLET: CAMARO: SEAT BELTS:FRONT:RETRACTOR
-->| NHTSA Campaign Number: | 81V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1981 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:RETRACTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19800801 - 19800901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55238 |
| Date Owner Notified By Manufacturer: | 19810528 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810519 |
| Record Creation Date: | 19810602 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
ON CERTAIN VEHICLES, THE SEAT BELT RETRACTORS IN THE REAR SEATING POSITIONS CONTAIN FIRST LOCK POSITIONS WHICH WILL NOT LOCK WHEN USED BY SMALLER PASSENGERS. THIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION".
Corrective Summary:
ALL OWNERS WILL BE SENT A PRE-PAID POSTAGE CARD THAT IS TO BE FILLED OUT AND SENT BACK. THE CARD WILL INDICATE WHETHER THE SEAT BELTS ARE FUNCTIONING PROPERLY. IF DEALER INSPECTS SEAT BELTS, THE SEAT BELT RETRACTORS WILL BE REPLACED, IF NECESSARY, WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: INTERIOR; SEAT BELT RETRACTORS.CONSEQUENCES OF DEFECT: IN THE EVENT OF A COLLISION, IF PASSENGERS ARE NOTSECURELY RESTRAINED, THE POSSIBILITY OF PERSONAL INJURY AND DEATH WOULD BEINCREASED.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1981 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 80V049000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1980 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19791001 - 19791001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16 |
| Date Owner Notified By Manufacturer: | 19800501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19800428 |
| Record Creation Date: | 19800502 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
VEHICLES MAY FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS". PLACARD ON REAR EDGE OF LEFT DOOR MAY SHOW AN INCORRECT VEHICLE CAPACITY WEIGHT INSTEAD OF THE CORRECT FIGURE OF 800 LBS.
Corrective Summary:
DEALER WILL INSTALL THE CORRECT LABEL FREE OF CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: EQUIPMENT; TIRE INFORMATION LABELS.CONSEQUENCES OF DEFECT: IMPROPER LOADING COULD OCCUR, LEADING TO UNDESIRABLEHANDLING CHARACTERISTICS DUE TO OVERLOADING OF THE TIRES. THIS COULD CAUSE ANACCIDENT.
CHEVROLET: CAMARO: STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM
-->| NHTSA Campaign Number: | 80V108000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1980 |
| Manufacturer Component Description: | STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790801 - 19800201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 85325 |
| Date Owner Notified By Manufacturer: | 19800825 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19800819 |
| Record Creation Date: | 19800826 |
Defect Summary:
ON CERTAIN VEHICLES, THE LOWER CONTROL ARM BALL JOINT TO STEERING KNUCKLE ATTACHING NUT MAY NOT HAVE BEEN TORQUED TO SPECIFICATIONS. THIS CONDITION COULD CAUSE THE NUT TO BACK OFF, RESULTING IN JOINT SEPARATION.
Corrective Summary:
THE DEALER WILL PERFORM A TORQUE CHECK OF THE ATTACHING NUT, AND, IF NECESSARY, TIGHTEN IT. IN SOME CASES AN INADEQUATE TORQUE LEVEL MAY HAVE CAUSED BALL STUD OR STEERING KNUCKLE DAMAGE; IF SO, THE AFFECTED COMPONENTS WILL BE REPLACED AT NO CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STEERING; LOWER CONTROL ARM BALL JOINT TO STEERING KNUCKLE ATTACHMENTNUT.CONSEQUENCES OF DEFECT: IF JOINT SEPARATION WERE TO OCCUR DRUING VEHICLEOPERATION, IT COULD AFFECT DIRECTIONAL CONTROL, WHICH COULD RESULT IN A VEHICLEACCIDENT WITHOUT PRIOR WARNING.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1980 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM
-->| NHTSA Campaign Number: | 80V108000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1979 |
| Manufacturer Component Description: | STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790801 - 19800201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 85325 |
| Date Owner Notified By Manufacturer: | 19800825 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19800819 |
| Record Creation Date: | 19800826 |
Defect Summary:
ON CERTAIN VEHICLES, THE LOWER CONTROL ARM BALL JOINT TO STEERING KNUCKLE ATTACHING NUT MAY NOT HAVE BEEN TORQUED TO SPECIFICATIONS. THIS CONDITION COULD CAUSE THE NUT TO BACK OFF, RESULTING IN JOINT SEPARATION.
Corrective Summary:
THE DEALER WILL PERFORM A TORQUE CHECK OF THE ATTACHING NUT, AND, IF NECESSARY, TIGHTEN IT. IN SOME CASES AN INADEQUATE TORQUE LEVEL MAY HAVE CAUSED BALL STUD OR STEERING KNUCKLE DAMAGE; IF SO, THE AFFECTED COMPONENTS WILL BE REPLACED AT NO CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STEERING; LOWER CONTROL ARM BALL JOINT TO STEERING KNUCKLE ATTACHMENTNUT.CONSEQUENCES OF DEFECT: IF JOINT SEPARATION WERE TO OCCUR DRUING VEHICLEOPERATION, IT COULD AFFECT DIRECTIONAL CONTROL, WHICH COULD RESULT IN A VEHICLEACCIDENT WITHOUT PRIOR WARNING.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1979 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 79V142000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1979 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19781201 - 19790101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15328 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790606 |
| Record Creation Date: | 19791012 |
Defect Summary:
ON THE INVOLVED VEHICLES THE BRAKE STOPLIGHT AND CRUISE CONTROL SWITCH WHICH IS OPERATED BY THE BRAKE PEDAL MAY HAVE BEEN ASSEMBLED WITH AN INCORRECT LUBRICANT ON THE ACTUATING PLUNGER. THIS CAN CAUSE THE REAR BRAKE STOPLIGHTS TO BECOME INOPERATIVE AND THE CRUISE CONTROL, IF ACTIVATED, TO STAY ELECTRICALLY ENGAGED.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE BRAKE STOPLIGHT AND CRUISE CONTROL SWITCH AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: LIGHTING AND COMMUNICATIONS; SWITCH BUTTON RING, BRAKE LIGHTS.CONSEQUENCES OF DEFECT: WITH INOPERATIVE BRAKE LIGHTS, A VEHICLE APPROACHINGFROM THE REAR WOULD NOT BE AWARE THAT BRAKES WERE BEING APPLIED. ALSO, IF THECRUISE CONTROL FAILS TO AUTOMATICALLY DISENGAGE THROUGH BRAKE PEDAL OPERATION,VEHICLE MAY ACCELERATE WHEN THE BRAKE PEDAL IS RELEASED. EITHER CONDITION COULDRESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.NOTE: OWNER IS ADVISED NOT TO ENGAGE THE CRUISE CONTROL UNTIL IT HAS BEENINSPECTED BY DEALER.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1978 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: STEERING:WHEEL AND HANDLE BAR
-->| NHTSA Campaign Number: | 76V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1977 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55564 |
| Date Owner Notified By Manufacturer: | 19760830 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760907 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 77-C-1.POSSIBILITY THAT THE STEERING INTERMEDIATESHAFT MAY HAVE BEEN ASSEMBLED WITH COUPLING RETAINER LOCKING TABS NOT BENT OVERPROPERLY OR ONE OR MORE OF THE LOWER FLEXIBLE COUPLING RIVETS IMPROPERLYPEENED.IF EITHER OF THESE CONDITIONS EXISTS, THE INTERMEDIATE SHAFT ASSEMBLYCOULD SEPARATE CAUSING LOSS OF STEERING CONTROL, AND VEHICLE CRASH MAY OCCURWITHOUT PRIOR WARNING.(CORRECT BY INSPECTING, AND REPLACING SHAFT WHERENECESSARY).PASSENGER VEHICLE.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1977 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: WHEELS:CENTER SECTION
-->| NHTSA Campaign Number: | 77V074000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1977 |
| Manufacturer Component Description: | WHEELS:CENTER SECTION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15246 |
| Date Owner Notified By Manufacturer: | 19770513 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19770516 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE CENTER (SPIDER) SECTION OF WHEELS INSTALLED ON THESE VEHICLES MAY HAVE BEEN MANUFACTURED FROM AN INCORRECT GRADE OF STEEL. THE CENTER SECTION MAY FATIGUE AND SEPARATE FROM THE WHEEL RIM.
Corrective Summary:
DEALER WILL INSPECT AND WILL REPLACE DEFECTIVE WHEELS WITH WHEELS MADE FROM THE CORRECT GRADE OF STEEL, WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: WHEELS; CENTER DISC SPIDER.CONSEQUENCES OF DEFECT: IF SEPARATION OCCURS DURING VEHICLE OPERATION, LOSS OFVEHICLE CONTROL AND AN ACCIDENT COULD RESULT.
CHEVROLET: CAMARO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
-->| NHTSA Campaign Number: | 76V088000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 80 |
| Date Owner Notified By Manufacturer: | 19760622 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760622 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 105 |
Notes:
CHEVROLET CAMPAIGN NO 76C16.POSSIBILITY THAT AN INCORRECT BRAKE COMBINATIONVALVE WAS INSTALLED DURING PRODUCTION.IF THIS CONDITION EXISTS, IT MAYDECREASE THE STOPPING ABILITY AND THUS INCREASE THE POSSIBILITY OF A VEHICLECRASH WHEN BRAKING.SITUATION REQUIRES MINIMUM STOPPING DISTANCE.ALSO,BRAKING SYSTEM MAY NOT MEET PERFORMANCE REQUIREMENT OF FMVSS 105.(CORRECT BYINSPECTING AND REPLACING VALVE WITH PROPER TYPE VALVE NECESSARY).
CHEVROLET: CAMARO: STEERING:WHEEL AND HANDLE BAR
-->| NHTSA Campaign Number: | 76V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1976 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55564 |
| Date Owner Notified By Manufacturer: | 19760830 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760907 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 77-C-1.POSSIBILITY THAT THE STEERING INTERMEDIATESHAFT MAY HAVE BEEN ASSEMBLED WITH COUPLING RETAINER LOCKING TABS NOT BENT OVERPROPERLY OR ONE OR MORE OF THE LOWER FLEXIBLE COUPLING RIVETS IMPROPERLYPEENED.IF EITHER OF THESE CONDITIONS EXISTS, THE INTERMEDIATE SHAFT ASSEMBLYCOULD SEPARATE CAUSING LOSS OF STEERING CONTROL, AND VEHICLE CRASH MAY OCCURWITHOUT PRIOR WARNING.(CORRECT BY INSPECTING, AND REPLACING SHAFT WHERENECESSARY).PASSENGER VEHICLE.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1976 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-->| NHTSA Campaign Number: | 75V087000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1975 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 31073 |
| Date Owner Notified By Manufacturer: | 19750514 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19750513 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 75-C-11.EQUIPPED WITH 350 CID V8 ENGINE ANDAIR-CONDITIONING.POSSIBILITY OF FAILURE OF THE FLEXBLE FAN BLADE.THEFAILURE IS THE RESULT OF FAN BLADE RESONANCE WHICH OCCURS AT 42 CYCLES PERSECOND OR AT APPROXIMATELY 630 ENGINE RPM.FAILURE OF THE FAN BLADE COULDRESULT IN A HAZARD TO TUNE-UP PERSONNEL SHOULD FAILURE OCCUR WITH THE ENGINERUNNING AND THE HOOD OPEN.(CORRECT BY INSPECTING AND REPLACING FAN BLADE).
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: STEERING:WHEEL AND HANDLE BAR
-->| NHTSA Campaign Number: | 75V094000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1975 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3069 |
| Date Owner Notified By Manufacturer: | 19750516 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19750521 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 75-C-13.BUICK CAMPAIGN NO 75-C-9.POSSIBILITY THATUNITS MAY HAVE BEEN ASSEMBLED WITH INSUFFICIENT TORQUE ON THE STEERING POTJOINT CLAMP BOLT/NUT WHICH SECURES THE INTERMEDIATE STEERING SHAFT TO THE UPPERSTEERING SHAFT.IF THIS CONDITION EXISTS, IT MAY ALLOW THE SHAFTS TO SEPARATEAND RESULT IN LOSS OF STEERING CONTROL.(CORRECT BY INSPECTING AND PROPERLYTORQUING THE STEERING CONNECTIONS WHREE NECESSARY.)
CHEVROLET: CAMARO: ELECTRICAL SYSTEM:WIRING
-->| NHTSA Campaign Number: | 73V232000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1974 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:WIRING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 22215 |
| Date Owner Notified By Manufacturer: | 19731212 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731210 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTORS CAMPAIGN NO CHEVROLET 74-C-06.PONTIAC 74-C-1.POSSIBILITYTHAT THE DRIVER'S SEAT INBOARD SEAT ADJUSTER LOCK BAR MAY NOT HAVE SUFFICIENTCLEARANCE AT THE IGNITION INTERLOCK AND/OR POWER WINDOW WIRE HARNESS.IF THISCONDITION EXISTS AND REPEATED ADJUSTMENTS TO THE SEAT ARE MADE, IT COULD RESULTIN WEARING THROUGH OF THE WIRING.THIS COULD RESULT IN INABILITY TO START CAROR AFFECT THE SEAT BELT STARTER INTERLOCK AND POWER WINDOWS.(CORRECT BYINSPECTING AND PROVIDING NECESSARY CLEARANCE.)
CHEVROLET: CAMARO: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
-->| NHTSA Campaign Number: | 73V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1974 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 782111 |
| Date Owner Notified By Manufacturer: | 19740109 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731227 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 74-C-09.PONTIAC 74-C-2.BUICK 74-C-2.OLDSMOBILE74-C-3.SPRINT 74-C-4.POSSIBILITY THAT THE FRONT UPPER CONTROL ARM INNERBUSHING RETAINER NUTS MAY LOOSEN AND COME OFF DURING NORMAL OPERATINGCONDITIONS.SHOULD THIS OCCUR, THE LOOSE CONTROL ARM MAY MOVE FORWARD ANDCONTACT THE UPPER CONTROL ARM MOUNTING BRACKET ON THE FRAME WHICH RESTRICTS ANYFURTHER FORWARD MOVEMENT.IF THIS VEHICLE IS OPERATED IN THIS CONDITION IT ISPOSSIBLE FOR THE CONTROL ARM CROSS SHAFT TO BREAK.(CORRECT BY INSPECTING ANDINSTALLING NEW BUSHING RETAINERS WHERE NECESSARY.)
CHEVROLET: CAMARO: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1974 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: CAMARO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1974 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAMARO: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: CAMARO: PARKING BRAKE:CONVENTIONAL:MECHANICAL
-->| NHTSA Campaign Number: | 72V304000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1973 |
| Manufacturer Component Description: | PARKING BRAKE:CONVENTIONAL:MECHANICAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19721101 - 19721101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2083 |
| Date Owner Notified By Manufacturer: | 19721209 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19721211 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 73-C-04.POSSIBILITY THAT PARKING BRAKE PAWL WASIMPROPERLY HEAT-TREATED.IF CONDITION EXISTS, "SOFT" PAWL CAUSES PAWL TO BENDOR BREAK, WHICH WOULD AFFECT HOLD ABILITY OF PARKING BRAKE.(CORRECT BYINSPECTING AND REPLACING PAWL WHERE NECESSARY).
CHEVROLET: CAMARO: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 70V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1971 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12600 |
| Date Owner Notified By Manufacturer: | 19701125 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19701203 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT THROTTLE ROD TO THROTTLE LEVER RETAINING CLIP ON CARBURETORMAY BE INCORRECTLY INSTALLED.IF THIS CONDITION EXISTS, THROTTLE LEVER COULDBE HELD IN PARTIALLY OPEN POSITION.IF THIS OCCURS WHILE VEHICLE IS IN MOTION,VEHICLE WILL NOT SLOW DOWN WHEN DRIVER'S FOOT IS REMOVED FROM ACCELERATOR.(CORRECT BY REPLACING CLIP WITH IMPROVED DESIGN WHERE NECESSARY.)
CHEVROLET: CAMARO: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: CAMARO: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 68V085000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1968 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 310290 |
| Date Owner Notified By Manufacturer: | 19680909 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19680917 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT CARBURETOR THROTTLE LEVER MAY INTERFERE WITH THROTTLE RETAINING CLIP.IF THIS OCCURS, CAN CAUSE THROTTLE LEVER TO BE HELD PARTIALLY OPEN,PREVENTING ITS RETURN TO IDLE POSITION. POSSIBLE THIS WILL MAKE VEHICLE DIFFICULT TO STOP.(CORRECT WHERE NECESSARY WITH IMPROVED TYPE THROTTLE RODCLIP.)
CHEVROLET: CAMARO: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: CAMARO: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAMARO |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: CAPRICE: STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT
| NHTSA Campaign Number: | 67V098000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1965 |
| Manufacturer Component Description: | STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1143000 |
| Date Owner Notified By Manufacturer: | 19671023 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19671023 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT, AFTER EXTENDED MILEAGE, THE IDLER ARM ASSEMBLY COULD SEPARATE DURING VEHICLE OPERATION AND RESULT IN A SEVERE PULL TO THE RIGHT AS BRAKES ARE APPLIED AT LOW TO MODERATE SPEED.(INSPECT AND RE- PLACE IDLER ARM ASSEMBLY AS REQUIRED.)
--CHEVROLET: CAPRICE: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: CAPRICE: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: CAPRICE: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: CAPRICE: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
-- --CHEVROLET: CAPRICE: WHEELS:LUGS/NUTS/BOLTS
-->| NHTSA Campaign Number: | 96V245000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1996 |
| Manufacturer Component Description: | WHEELS:LUGS/NUTS/BOLTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950801 - 19950831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 21582 |
| Date Owner Notified By Manufacturer: | 19961202 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961210 |
| Record Creation Date: | 19961219 |
Defect Summary:
THE WHEEL LUG NUTS WERE NOT TIGHTENED TO THE PROPER SPECIFICATION DURING ASSEMBLY.
Consequence Summary:
THIS CONDITION COULD RESULT IN A FRACTURE OF THE WHEEL STUDS CAUSING THE WHEEL TO SEPARATE FROM THE VEHICLE.
Corrective Summary:
DEALERS WILL TIGHTEN THE VEHICLE'S WHEEL LUG NUTS TO THE PROPER SPECIFICATION.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING DECEMBER 1996.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, OR CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: AIR BAGS
-->| NHTSA Campaign Number: | 95V215000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1996 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940901 - 19950801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 8946 |
| Date Owner Notified By Manufacturer: | 19951208 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19951103 |
| Record Creation Date: | 19951109 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
THESE VEHICLES WERE SHIPPED WITH BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT CAUTION LABEL AND A ROOF RACK CAUTION LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.
Corrective Summary:
A NEW ROOF RACK CAUTION LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
Notes:
SYSTEM: INTERIOR SYSTEMS: PASSIVE RESTRAINTS; AIR BAG; FMVSS NO.208.VEHICLE DESCRIPTION: STATION WAGONS. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300 OR CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAPRICE: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 96V020000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1996 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900401 - 19951001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 154214 |
| Date Owner Notified By Manufacturer: | 19960222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960131 |
| Record Creation Date: | 19960201 |
Defect Summary:
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence Summary:
THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
Notes:
SYSTEM: SUSPENSION; SINGLE AXLE; REAR; CONTROL ARM. VEHICLE DESCRIPTION: POLICE (SEO 9C1) VEHICLES AND TAXI CABS (SEO 9C6). NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
-->| NHTSA Campaign Number: | 96V018000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1996 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940401 - 19950901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 102403 |
| Date Owner Notified By Manufacturer: | 19960222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960130 |
| Record Creation Date: | 19960201 |
Defect Summary:
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence Summary:
THE LOWER CONTROL ARM BALL JOINT CAN LOOSEN, FATIGUE, AND SEPARATE FROM THE FRONT SUSPENSION KNUCKLE RESULTING IN A LOSS OF VEHICLE CONTROL.
Corrective Summary:
DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
Notes:
SYSTEM: SUSPENSION; INDEPENDENT FRONT CONTROL ARM; LOWER; BALL JOINT. VEHICLE DESCRIPTION: POLICE VEHICLES, TAXI CABS, HEARSE AND LIMOUSINE. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020; BUICK AT 1-800-521-7300; OR CADILLAC AT 1-800-458-8006. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: WHEELS:LUGS/NUTS/BOLTS
-->| NHTSA Campaign Number: | 96V245000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | WHEELS:LUGS/NUTS/BOLTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950801 - 19950831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 21582 |
| Date Owner Notified By Manufacturer: | 19961202 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961210 |
| Record Creation Date: | 19961219 |
Defect Summary:
THE WHEEL LUG NUTS WERE NOT TIGHTENED TO THE PROPER SPECIFICATION DURING ASSEMBLY.
Consequence Summary:
THIS CONDITION COULD RESULT IN A FRACTURE OF THE WHEEL STUDS CAUSING THE WHEEL TO SEPARATE FROM THE VEHICLE.
Corrective Summary:
DEALERS WILL TIGHTEN THE VEHICLE'S WHEEL LUG NUTS TO THE PROPER SPECIFICATION.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING DECEMBER 1996.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, OR CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: AIR BAGS
-->| NHTSA Campaign Number: | 95V215000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940901 - 19950801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 8946 |
| Date Owner Notified By Manufacturer: | 19951208 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19951103 |
| Record Creation Date: | 19951109 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
THESE VEHICLES WERE SHIPPED WITH BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT CAUTION LABEL AND A ROOF RACK CAUTION LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.
Corrective Summary:
A NEW ROOF RACK CAUTION LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
Notes:
SYSTEM: INTERIOR SYSTEMS: PASSIVE RESTRAINTS; AIR BAG; FMVSS NO.208.VEHICLE DESCRIPTION: STATION WAGONS. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300 OR CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAPRICE: VEHICLE SPEED CONTROL:SPRINGS
-->| NHTSA Campaign Number: | 95V082000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:SPRINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940401 - 19941201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87039 |
| Date Owner Notified By Manufacturer: | 19950531 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950424 |
| Record Creation Date: | 19950501 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 124 |
Defect Summary:
THESE VEHICLES FAIL TO CONFORM TO FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS." AT LOW TEMPERATURES, EXCESSIVE FRICTION CAN OCCUR IN THE ACCELERATOR PEDAL ASSEMBLY.
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A FAILURE OF THE TROTTLE RETURN SPRING, IF THERE IS EXCESSIVE FRICTION IN THE PEDAL ASSEMBLY, THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY.
Notes:
SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL; RETURN SPRING; FMVSS NO. 124.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, PLEASE CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300, OR CADILLAC AT 1-800-458-8006. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
-->| NHTSA Campaign Number: | 96V019000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19930301 - 19941201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 308 |
| Date Owner Notified By Manufacturer: | 19960223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960130 |
| Record Creation Date: | 19960201 |
Defect Summary:
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence Summary:
IF THE LOWER CONTROL ARM BALL JOINT LOOSENS, FATIGUES AND SEPARATES FROM THE FRONT SUSPENSION KNUCKLE, IT COULD CAUSE LOSS OF VEHICLE CONTROL.
Corrective Summary:
DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED FROM THE KNUCKLE, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
Notes:
SYSTEM: SUSPENSION; INDEPENDENT FRONT CONTROL ARM; LOWER; BALL JOINT. VEHICLE DESCRIPTION: PASSENGER VEHICLES EXPORTED TO GUAM AND PUERTO RICO. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1022, BUICK AT 1-800-521-7300, OR CADILLAC AT 1-800-458-8006. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 95V221000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19941101 - 19950801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 83400 |
| Date Owner Notified By Manufacturer: | 19951213 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19951116 |
| Record Creation Date: | 19951129 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 114 |
Defect Summary:
THESE VEHICLES WERE PRODUCED WITH AN IMPROPERLY ADJUSTED TRANSMISSION SHIFT CONTROL LINKAGE. THIS DOES NOT MEET WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: IT MAY BE POSSIBLE TO SHIFT FROM THE "PARK" POSITION WITH THE IGNITION KEY REMOVED INCREASING THE RISK OF A VEHICLE ACCIDENT RESULTING FROM THE UNINTENDED MOVEMENT OF A PARKED VEHICLE.
Corrective Summary:
DEALERS WILL ADJUST THE SHIFT CONTROL LINKAGE SYSTEM.
Notes:
SYSTEM: POWERTRAIN; AUTOMATIC TRANSMISSION; AUTOMATIC; LEVER AND LINKAGE; COLUMN, FMVSS NO. 114.VEHICLE DESCRIPTION:PASSENGER VEHICLES.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006; CHEVROLET AT 1-800-222-1020; OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAPRICE: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 96V020000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900401 - 19951001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 154214 |
| Date Owner Notified By Manufacturer: | 19960222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960131 |
| Record Creation Date: | 19960201 |
Defect Summary:
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence Summary:
THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
Notes:
SYSTEM: SUSPENSION; SINGLE AXLE; REAR; CONTROL ARM. VEHICLE DESCRIPTION: POLICE (SEO 9C1) VEHICLES AND TAXI CABS (SEO 9C6). NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
-->| NHTSA Campaign Number: | 96V018000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1995 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940401 - 19950901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 102403 |
| Date Owner Notified By Manufacturer: | 19960222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960130 |
| Record Creation Date: | 19960201 |
Defect Summary:
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence Summary:
THE LOWER CONTROL ARM BALL JOINT CAN LOOSEN, FATIGUE, AND SEPARATE FROM THE FRONT SUSPENSION KNUCKLE RESULTING IN A LOSS OF VEHICLE CONTROL.
Corrective Summary:
DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
Notes:
SYSTEM: SUSPENSION; INDEPENDENT FRONT CONTROL ARM; LOWER; BALL JOINT. VEHICLE DESCRIPTION: POLICE VEHICLES, TAXI CABS, HEARSE AND LIMOUSINE. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020; BUICK AT 1-800-521-7300; OR CADILLAC AT 1-800-458-8006. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1993 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAPRICE: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 96V020000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1993 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900401 - 19951001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 154214 |
| Date Owner Notified By Manufacturer: | 19960222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960131 |
| Record Creation Date: | 19960201 |
Defect Summary:
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence Summary:
THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
Notes:
SYSTEM: SUSPENSION; SINGLE AXLE; REAR; CONTROL ARM. VEHICLE DESCRIPTION: POLICE (SEO 9C1) VEHICLES AND TAXI CABS (SEO 9C6). NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAPRICE: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
-->| NHTSA Campaign Number: | 91V186000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19891001 - 19910801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 224588 |
| Date Owner Notified By Manufacturer: | 19911031 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911029 |
| Record Creation Date: | 19911030 |
Defect Summary:
SECONDARY HOOD LATCH ASSEMBLIES CAN CORRODE, CAUSING A HIGH LATCH RELEASE EFFORT AND POSSIBLY PREVENTING THE HOOD FROM LATCHING PROPERLY WHEN IT IS CLOSED.
Consequence Summary:
IF THE SECONDARY HOOD LATCH IS NOT PROPERLY ENGAGED, ANDTHE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN AND CONTACT THEWINDSHIELD WHILE THE VEHICLE WAS IN MOTION, REDUCING THE FORWARD VISION AREA OFTHE DRIVER AND RESULTING IN A POSSIBLE VEHICLE ACCIDENT WITHOUT PRIOR WARNING.
Corrective Summary:
INSTALL A NEW SECONDARY HOOD LATCH ASSEMBLY.
Notes:
SYSTEM: SECONDARY HOOD LATCH.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 97V217000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910801 - 19920731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 56701 |
| Date Owner Notified By Manufacturer: | 19980115 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19971124 |
| Record Creation Date: | 19971126 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ANTILOCK BRAKE SYSTEM (ABS) MODULATOR CAN CORRODE AND LEAK FLUID FROM THE FRONT BRAKE CIRCUIT.
Consequence Summary:
BRAKE FLUID LEAKAGE CAN REDUCE BRAKE EFFECTIVENESS AND INCREASE STOPPING DISTANCES.
Corrective Summary:
DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE ABS MODULATOR.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING JANUARY 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, OLDSMOBILE AT 1-800-442-6537, OR CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: WHEELS
-->| NHTSA Campaign Number: | 92V089000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | WHEELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910301 - 19920301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 34717 |
| Date Owner Notified By Manufacturer: | 19920717 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19920624 |
| Record Creation Date: | 19920626 |
Defect Summary:
THE STEEL WHEELS EXHIBIT FATIGUE CRACKING AROUND THE CIRCUMFERENCE OF THE WHEEL LUG NUT MOUNTING SURFACE DUE TO WHEEL BENDING CAUSED BY FREQUENT MISUSE OF TIRE MOUNTING EQUIPMENT, LUG NUT OVERTORQUING, AND THE UNUSUAL OPERATING CONDITIONS EXPERIENCED BY POLICE VEHICLES.
Consequence Summary:
THE CRACKING CAN CAUSE WHEEL FRACTURING AND SUBSEQUENTSEPARATION FROM THE AXLE, WHICH COULD RESULT IN A VEHICLE ACCIDENT.
Corrective Summary:
REPLACE THE DEFECTIVE WHEELS WITH REDESIGNED STEEL WHEELS.
Notes:
SYSTEM: WHEELS.VEHICLE DESCRIPTION: POLICE CARS EQUIPPED WITH SPECIAL POLICE PACKAGE WHICHINCLUDES 15 INCH BY 7 INCH STEEL WHEELS WITH WHEEL CODE RDL.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAPRICE: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 96V020000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900401 - 19951001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 154214 |
| Date Owner Notified By Manufacturer: | 19960222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960131 |
| Record Creation Date: | 19960201 |
Defect Summary:
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence Summary:
THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
Notes:
SYSTEM: SUSPENSION; SINGLE AXLE; REAR; CONTROL ARM. VEHICLE DESCRIPTION: POLICE (SEO 9C1) VEHICLES AND TAXI CABS (SEO 9C6). NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: FUEL SYSTEM, GASOLINE:DELIVERY
-->| NHTSA Campaign Number: | 93V010000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910701 - 19920701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1771 |
| Date Owner Notified By Manufacturer: | 19930226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930119 |
| Record Creation Date: | 19930129 |
Defect Summary:
THE ENGINE MOUNTED FUEL FEED AND RETURN PIPES MAY FRACTURE DUE TO CONTACT WITH THE ENGINE FRAME DURING OPERATION.
Consequence Summary:
IF THE FUEL PIPE FRACTURES, GASOLINE WILL BE FORCED ATPRESSURE FROM THE FUEL PIPES INTO THE ENGINE COMPARTMENT, RESULTING IN ANUNDERHOOD FIRE IF THE GASOLINE IS EXPOSED TO A SOURCE OF IGNITION.
Corrective Summary:
REPLACE THE FUEL FEED AND RETURN PIPES USING NEW PIPE ASSEMBLIES.
Notes:
SYSTEM: FUEL SYSTEM.VEHICLE DESCRIPTION: PASSENGER CARS WITH 4.3 L ENGINES (RPO LB4).
CHEVROLET: CAPRICE: ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
-->| NHTSA Campaign Number: | 93V018000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1992 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910701 - 19920701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 20000 |
| Date Owner Notified By Manufacturer: | 19930323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930209 |
| Record Creation Date: | 19930223 |
Defect Summary:
SYSTEM: ELECTRICAL.VEHICLE DESCRIPTION: SEQ 9C1 POLICE CARS IN CORROSION AREAS OF THE US AND CANADA ONLY. NOTE: VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEWJERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WISCONSIN. A ELECTRICAL GROUND-OUT CONDITION MAY EXIST BETWEEN THE 12 VOLT JUNCTION BLOCK AND THE METAL INNER FENDER SKIRT.
Consequence Summary:
THIS CONDITION CAN CAUSE A MELTED JUNCTION BLOCK, SMOKE,AND BURNED UNDERHOOD WIRING RESULTING IN A DISABLED VEHICLE OR A VEHICLE FIRE.THIS CONDITION CAN OCCUR WHILE THE VEHICLE IS IN OPERATION OR WHILE THE VEHICLEIS PARKED AND THE IGNITION IS IN THE "OFF" POSITION.
Corrective Summary:
INSTALL A SHIELDING INSULATOR UNDER THE JUNCTION BLOCK.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAPRICE: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
-->| NHTSA Campaign Number: | 91V186000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1991 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19891001 - 19910801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 224588 |
| Date Owner Notified By Manufacturer: | 19911031 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911029 |
| Record Creation Date: | 19911030 |
Defect Summary:
SECONDARY HOOD LATCH ASSEMBLIES CAN CORRODE, CAUSING A HIGH LATCH RELEASE EFFORT AND POSSIBLY PREVENTING THE HOOD FROM LATCHING PROPERLY WHEN IT IS CLOSED.
Consequence Summary:
IF THE SECONDARY HOOD LATCH IS NOT PROPERLY ENGAGED, ANDTHE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN AND CONTACT THEWINDSHIELD WHILE THE VEHICLE WAS IN MOTION, REDUCING THE FORWARD VISION AREA OFTHE DRIVER AND RESULTING IN A POSSIBLE VEHICLE ACCIDENT WITHOUT PRIOR WARNING.
Corrective Summary:
INSTALL A NEW SECONDARY HOOD LATCH ASSEMBLY.
Notes:
SYSTEM: SECONDARY HOOD LATCH.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: SEAT BELTS
-->| NHTSA Campaign Number: | 92V094000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900301 - 19910701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 219571 |
| Date Owner Notified By Manufacturer: | 19920717 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19920701 |
| Record Creation Date: | 19920709 |
Defect Summary:
THE SHOULDER BELT GUIDE LOOP PLASTIC COVERING MAY CRACK AND EXPOSE THE STEEL SUB-PLATE.
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE EXPOSED STEELSUB-PLATE CAN CUT THE SAFETY BELT WEBBING RESULTING IN INCREASED POSSIBILITYAND/OR SEVERITY OF INJURY TO THE AFFECTED SEAT OCCUPANT.
Corrective Summary:
INSTALL NEW SHOULDER BELT GUIDE LOOPS.
Notes:
SYSTEM: ACTIVE SAFETY BELT.VEHICLE DESCRIPTION: PASSENGER CARS; GENERAL MOTORS "B" SERIES.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1991 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: WHEELS
-->| NHTSA Campaign Number: | 92V089000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1991 |
| Manufacturer Component Description: | WHEELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910301 - 19920301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 34717 |
| Date Owner Notified By Manufacturer: | 19920717 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19920624 |
| Record Creation Date: | 19920626 |
Defect Summary:
THE STEEL WHEELS EXHIBIT FATIGUE CRACKING AROUND THE CIRCUMFERENCE OF THE WHEEL LUG NUT MOUNTING SURFACE DUE TO WHEEL BENDING CAUSED BY FREQUENT MISUSE OF TIRE MOUNTING EQUIPMENT, LUG NUT OVERTORQUING, AND THE UNUSUAL OPERATING CONDITIONS EXPERIENCED BY POLICE VEHICLES.
Consequence Summary:
THE CRACKING CAN CAUSE WHEEL FRACTURING AND SUBSEQUENTSEPARATION FROM THE AXLE, WHICH COULD RESULT IN A VEHICLE ACCIDENT.
Corrective Summary:
REPLACE THE DEFECTIVE WHEELS WITH REDESIGNED STEEL WHEELS.
Notes:
SYSTEM: WHEELS.VEHICLE DESCRIPTION: POLICE CARS EQUIPPED WITH SPECIAL POLICE PACKAGE WHICHINCLUDES 15 INCH BY 7 INCH STEEL WHEELS WITH WHEEL CODE RDL.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAPRICE: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 96V020000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1991 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900401 - 19951001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 154214 |
| Date Owner Notified By Manufacturer: | 19960222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960131 |
| Record Creation Date: | 19960201 |
Defect Summary:
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence Summary:
THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
Notes:
SYSTEM: SUSPENSION; SINGLE AXLE; REAR; CONTROL ARM. VEHICLE DESCRIPTION: POLICE (SEO 9C1) VEHICLES AND TAXI CABS (SEO 9C6). NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAPRICE: ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
-->| NHTSA Campaign Number: | 93V018000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1991 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910701 - 19920701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 20000 |
| Date Owner Notified By Manufacturer: | 19930323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930209 |
| Record Creation Date: | 19930223 |
Defect Summary:
SYSTEM: ELECTRICAL.VEHICLE DESCRIPTION: SEQ 9C1 POLICE CARS IN CORROSION AREAS OF THE US AND CANADA ONLY. NOTE: VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEWJERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WISCONSIN. A ELECTRICAL GROUND-OUT CONDITION MAY EXIST BETWEEN THE 12 VOLT JUNCTION BLOCK AND THE METAL INNER FENDER SKIRT.
Consequence Summary:
THIS CONDITION CAN CAUSE A MELTED JUNCTION BLOCK, SMOKE,AND BURNED UNDERHOOD WIRING RESULTING IN A DISABLED VEHICLE OR A VEHICLE FIRE.THIS CONDITION CAN OCCUR WHILE THE VEHICLE IS IN OPERATION OR WHILE THE VEHICLEIS PARKED AND THE IGNITION IS IN THE "OFF" POSITION.
Corrective Summary:
INSTALL A SHIELDING INSULATOR UNDER THE JUNCTION BLOCK.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1990 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: FUEL SYSTEM, GASOLINE:STORAGE
-->| NHTSA Campaign Number: | 90V096000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890301 - 19900401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 21415 |
| Date Owner Notified By Manufacturer: | 19900521 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900518 |
| Record Creation Date: | 19900531 |
Defect Summary:
PLASTIC FUEL FILTER ASSEMBLIES MAY DEVELOP LEAKS.
Consequence Summary:
FUEL LEAKS COULD RESULT IN A VEHICLE FIRE DUE TO STATICCHARGE BUILD UPS FOUND IN THE PLASTIC FUEL LINES AND FUEL FILTER WHICH MAY ACTAS AN IGNITION SOURCE.
Corrective Summary:
REPLACE PLASTIC ASSEMBLY WITH METAL FUEL FILTER AND BRACKET.
Notes:
SYSTEM: PLASTIC FUEL FILTER.VEHICLE DESCRIPTION: POLICE AND TAXI MODEL PASSENGER CARS.
CHEVROLET: CAPRICE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1989 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 89V102000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1988 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830801 - 19880201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755897 |
| Date Owner Notified By Manufacturer: | 19890720 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890616 |
| Record Creation Date: | 19890725 |
Defect Summary:
A SMALL NYLON BUSHING IN THE CRUISE CONTROL SERVO BAIL MAY SLIP OUT OF PLACE, CAUSING INTERMITTENT AND UNEXPECTED INCREASES IN ENGINE SPEED OR DIESELING (ENGINE RUN ON WITH IGNITION OFF).
Consequence Summary:
SERVO ROD ASSEMBLY COULD CATCH ON ENGINE COMPONENTS ANDRESULT IN A STUCK THROTTLE WITH POTENTIAL FOR A VEHICLE CRASH.
Corrective Summary:
INSTALL A NEW BUSHING IN CRUISE CONTROL SERVO BAIL.
Notes:
SYSTEM:CRUISE CONTROL.VEHICLE DESCRIPTION:PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL ANDCERTAIN GASOLINE AND DIESEL ENGINES.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1988 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 89V102000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1987 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830801 - 19880201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755897 |
| Date Owner Notified By Manufacturer: | 19890720 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890616 |
| Record Creation Date: | 19890725 |
Defect Summary:
A SMALL NYLON BUSHING IN THE CRUISE CONTROL SERVO BAIL MAY SLIP OUT OF PLACE, CAUSING INTERMITTENT AND UNEXPECTED INCREASES IN ENGINE SPEED OR DIESELING (ENGINE RUN ON WITH IGNITION OFF).
Consequence Summary:
SERVO ROD ASSEMBLY COULD CATCH ON ENGINE COMPONENTS ANDRESULT IN A STUCK THROTTLE WITH POTENTIAL FOR A VEHICLE CRASH.
Corrective Summary:
INSTALL A NEW BUSHING IN CRUISE CONTROL SERVO BAIL.
Notes:
SYSTEM:CRUISE CONTROL.VEHICLE DESCRIPTION:PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL ANDCERTAIN GASOLINE AND DIESEL ENGINES.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1987 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-->| NHTSA Campaign Number: | 87V168000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1987 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870601 - 19870701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 11936 |
| Date Owner Notified By Manufacturer: | 19871125 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19871026 |
| Record Creation Date: | 19871104 |
Defect Summary:
MANUAL VALVE LINK IN THE TRANSMISSION MAY HAVE BEEN IMPROPERLY FORMED.
Consequence Summary:
THE VALVE LINK COULD SEPARATE RESULTING IN A GEARSELECTION DIFFERENT FROM WHAT THE DRIVER SELECTS. ALSO, CAR COULD BE STARTEDWITH TRANSMISSION IN GEAR ALLOWING VEHICLE TO MOVE IN AN UNANTICIPATEDDIRECTION.
Corrective Summary:
REPLACE THE MANUAL VALVE DETENT LEVER LINK.
Notes:
SYSTEM: TRANSMISSIONVEHICLE DESCRIPTION: PASSENGER CARS AND WAGONS WITH 200 4R TRANSMISSIONS.
CHEVROLET: CAPRICE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1986 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 89V102000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1986 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830801 - 19880201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755897 |
| Date Owner Notified By Manufacturer: | 19890720 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890616 |
| Record Creation Date: | 19890725 |
Defect Summary:
A SMALL NYLON BUSHING IN THE CRUISE CONTROL SERVO BAIL MAY SLIP OUT OF PLACE, CAUSING INTERMITTENT AND UNEXPECTED INCREASES IN ENGINE SPEED OR DIESELING (ENGINE RUN ON WITH IGNITION OFF).
Consequence Summary:
SERVO ROD ASSEMBLY COULD CATCH ON ENGINE COMPONENTS ANDRESULT IN A STUCK THROTTLE WITH POTENTIAL FOR A VEHICLE CRASH.
Corrective Summary:
INSTALL A NEW BUSHING IN CRUISE CONTROL SERVO BAIL.
Notes:
SYSTEM:CRUISE CONTROL.VEHICLE DESCRIPTION:PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL ANDCERTAIN GASOLINE AND DIESEL ENGINES.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1986 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: ELECTRICAL SYSTEM:BATTERY:CABLES
-->| NHTSA Campaign Number: | 85V153000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1985 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:BATTERY:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840401 - 19850401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27942 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851119 |
| Record Creation Date: | 19851203 |
Defect Summary:
THE POSITIVE BATTERY CABLE MAY CONTACT THE UPPER CONTROL ARM OR EXHAUST MANIFOLD SHIELD AND EVENTUALLY WEAR THROUGH THE INSULATION AND GROUND THE CABLE. CONSEQUENCE OF DEFECT: THIS COULD RESULT IN AN UNDERHOOD FIRE WHICH COULD CAUSE BURN INJURIES TO OCCUPANTS.
Corrective Summary:
INSTALL A POSITIVE BATTERY SERVICE KIT.
Notes:
SYSTEM: ELECTRICAL, BATTERY CABLE.VEHICLE DESCRIPTION: FULL-SIZE PASSENGER CARS WITH 4.3L V6 ENGINES.
CHEVROLET: CAPRICE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1985 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 89V102000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1985 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830801 - 19880201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755897 |
| Date Owner Notified By Manufacturer: | 19890720 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890616 |
| Record Creation Date: | 19890725 |
Defect Summary:
A SMALL NYLON BUSHING IN THE CRUISE CONTROL SERVO BAIL MAY SLIP OUT OF PLACE, CAUSING INTERMITTENT AND UNEXPECTED INCREASES IN ENGINE SPEED OR DIESELING (ENGINE RUN ON WITH IGNITION OFF).
Consequence Summary:
SERVO ROD ASSEMBLY COULD CATCH ON ENGINE COMPONENTS ANDRESULT IN A STUCK THROTTLE WITH POTENTIAL FOR A VEHICLE CRASH.
Corrective Summary:
INSTALL A NEW BUSHING IN CRUISE CONTROL SERVO BAIL.
Notes:
SYSTEM:CRUISE CONTROL.VEHICLE DESCRIPTION:PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL ANDCERTAIN GASOLINE AND DIESEL ENGINES.
CHEVROLET: CAPRICE: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 85V151000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1985 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840401 - 19850401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27942 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851119 |
| Record Creation Date: | 19851202 |
Defect Summary:
THE FUEL FEED AND FUEL RETURN PIPE ASSEMBLIES INCLUDES A HOSE WHICH MAY CONTACT THE POINTED END OF THE RADIATOR SHROUD ATTACHING SCREW. THIS COULD CAUSE A GASOLINE LEAK. CONSEQUENCE OF DEFECT: IF FUEL LEAK DEVELOPS IT COULD RESULT IN AN UNDERHOOD FIRE AND BURN INJURIES TO OCCUPANTS.
Corrective Summary:
REPOSITION FUEL LINES TO PRECLUDE CONTACT WITH RADIATOR SHROUD ATTACHING SCREW.
Notes:
SYSTEM: FUEL.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1985 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 89V102000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1984 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830801 - 19880201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755897 |
| Date Owner Notified By Manufacturer: | 19890720 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890616 |
| Record Creation Date: | 19890725 |
Defect Summary:
A SMALL NYLON BUSHING IN THE CRUISE CONTROL SERVO BAIL MAY SLIP OUT OF PLACE, CAUSING INTERMITTENT AND UNEXPECTED INCREASES IN ENGINE SPEED OR DIESELING (ENGINE RUN ON WITH IGNITION OFF).
Consequence Summary:
SERVO ROD ASSEMBLY COULD CATCH ON ENGINE COMPONENTS ANDRESULT IN A STUCK THROTTLE WITH POTENTIAL FOR A VEHICLE CRASH.
Corrective Summary:
INSTALL A NEW BUSHING IN CRUISE CONTROL SERVO BAIL.
Notes:
SYSTEM:CRUISE CONTROL.VEHICLE DESCRIPTION:PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL ANDCERTAIN GASOLINE AND DIESEL ENGINES.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1984 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1983 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1982 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
-->| NHTSA Campaign Number: | 82V012000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1982 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810801 - 19811101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 79686 |
| Date Owner Notified By Manufacturer: | 19820218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19820103 |
| Record Creation Date: | 19820208 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATING CONDITIONS, THE GOVERNOR WEIGHT RETAINER IN THE INJECTION PUMP MAY FAIL. THE THROTTLE VALVE COULD STICK, PREVENTING RETURN TO IDLE AND SHUT DOWN OF THE ENGINE BY THE DRIVER.
Corrective Summary:
DEALER WILL REPLACE THE GOVERNOR WEIGHT ASSEMBLY IN THE INJECTION PUMP AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 5.7 V8 ENGINES.SYSTEM: FUEL; THROTTLE VALVE.CONSEQUENCES OF DEFECT: THIS COULD RESULT IN LOSS OF VEHICLE CONTROL AND AVEHICLE ACCIDENT.NOTE: IF THROTTLE STICKING OCCURS BEFORE THE VEHICLE HAS RECEIVED THE NECESSARYMODIFICATIONS, THE DRIVER SHOULD SHIFT THE TRANSMISSION TO NEUTRAL, APPLY THESERVICE BRAKES TO BRING THE VEHICLE TO A SAFE STOP, THE IGNITION SHOULD BETURNED OFF AND THE NEAREST DEALERSHIP SHOULD BE CALLED FOR ASSISTANCE.
CHEVROLET: CAPRICE: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 80V125000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1981 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19800801 - 19800801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4615 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19800925 |
| Record Creation Date: | 19801210 |
Defect Summary:
THE INVOLVED VEHICLES MAY HAVE BEEN ASSEMBLED WITH A BRAKE PEDAL SUPPORT BRACKET WHICH WAS DESIGNED FOR USE IN DIESEL ENGINE VEHICLES. THE INCORRECT BRACKET MAY CAUSE THE SERVICE BRAKES TO REMAIN PARTIALLY APPLIED, RESULTING IN BRAKE OVERHEATING AND REDUCED BRAKING EFFECTIVENESS.
Corrective Summary:
DEALER WILL INSPECT VEHICLES AND, IF NECESSARY, REPLACE THE PEDAL SUPPORT BRACKET AT NO CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH GASOLINE ENGINES.SYSTEM: SERVICE BRAKES; BRAKE PEDAL, SUPPORT BRACKET.CONSEQUENCES OF DEFECT: THIS DEFECT COULD CAUSE AN ACCIDENT, ESPECIALLY INSITUATIONS WHICH REQUIRE A MINIMUM VEHICLE STOPPING DISTANCE.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1981 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 80V135000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1980 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790801 - 19800301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 24719 |
| Date Owner Notified By Manufacturer: | 19801015 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19801015 |
| Record Creation Date: | 19801209 |
Defect Summary:
THE INVOLVED VEHICLES MAY HAVE INSUFFICIENT CLEARANCE BETWEEN THE FRONT BRAKE PIPE AND THE ENGINE OIL PAN. THIS CONDITION COULD CAUSE THE BRAKE PIPE TO CONTACT THE LEFT HAND FRONT EDGE OF THE OIL PAN, RESULTING IN WEAR AND, EVENTUALLY, DAMAGE TO THE BRAKE PIPE. THIS COULD LEAD TO A LOSS OF BRAKE FLUID AND SUBSEQUENT LOSS OF BRAKES.
Corrective Summary:
DEALER WILL REPLACE THE BRAKE PIPE, IF NECESSARY, FREE OF CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 3.8 LITER CID V-6ENGINES.SYSTEM: SERVICE BRAKES; HYDRAULIC LINES, METALLIC.CONSEQUENCES OF DEFECT: LOSS OF FRONT BRAKING AT A TIME WHEN MINIMUM VEHICLESTOPPING DISTANCE IS REQUIRED COULD RESULT IN AN ACCIDENT.NOTE: THE DRIVER MAY BE ALERTED TO BRAKE FLUID LOSS BY ILLUMINATION OF THEBRAKE WARNING LIGHT.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1980 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 80V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1980 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790801 - 19791001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 85158 |
| Date Owner Notified By Manufacturer: | 19801008 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19801014 |
| Record Creation Date: | 19801112 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
VEHICLES MAY NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS". THE TIRE RIM SIZE WAS OMITTED ON THE EXISTING LABEL.
Corrective Summary:
THE OWNER HAS THE OPTION OF AFFIXING THE CORRECT INFORMATION LABEL HIM/HERSELF OR HAVING THE DEALER DO IT AT NO CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: EQUIPMENT; TIRE INFORMATION LABELS.CONSEQUENCES OF DEFECT: LACK OF INFORMATION COULD LEAD TO THE SELECTION OFINCORRECT RIMS AS REPLACEMENT PARTS. THIS WOULD CREATE AN UNSAFE SITUATION THATCOULD RESULT IN AN ACCIDENT.
CHEVROLET: CAPRICE: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-->| NHTSA Campaign Number: | 79V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1979 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19790201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 476245 |
| Date Owner Notified By Manufacturer: | 19790703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790702 |
| Record Creation Date: | 19791012 |
Defect Summary:
A CHILD COULD OPEN THE REAR SIDE COMPARTMENT DOOR AND ENTER THIS COMPARTMENT. THE CHILD COULD BECOME ENTRAPPED IF THE DOOR WERE TO CLOSE, AS IT CANNOT BE UNLATCHED FROM THE INSIDE.
Corrective Summary:
DEALER WILL REPLACE THE ORIGINAL COMPARTMENT DOOR LATCH, WHICH CAN BE LATCHED WITHOUT A KEY, WITH A NEW ASSEMBLY THAT REQUIRES A KEY TO LATCH AS WELL AS LOCK THE DOOR.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STRUCTURE; STORAGE COMPARTMENT.CONSEQUENCES OF DEFECT: IN THE ABSENCE OF OUTSIDE HELP, THE CHILD WOULDSUFFOCATE.NOTE: THE OWNER IS ADVISED TO KEEP THIS COMPARTMENT LOCKED EXCEPT WHILE EITHERLOADING OR UNLOADING IT.
CHEVROLET: CAPRICE: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 79V247000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1979 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19780901 - 19791001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1326404 |
| Date Owner Notified By Manufacturer: | 19791112 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19791113 |
| Record Creation Date: | 19800205 |
Defect Summary:
THE HEADS MAY BREAK OFF THE FRONT OUTBOARD SEAT BELT ANCHOR BOLTS DURING NORMAL VEHICLE OPERATION EVEN UNDER NO LOAD CONDITIONS. THIS IS DUE TO THE COMBINATION OF BOLTS USED, HIGH INSTALLATION TORQUE AND ARRANGEMENT OF THE BODY ANCHORAGE.
Corrective Summary:
DEALER WILL REPLACE ALL ORIGINAL EQUIPMENT FRONT OUTBOARD SEAT BELT ANCHOR BOLTS ON THE AFFECTED VEHICLES AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: INTERIOR; SEAT BELT ANCHORS.CONSEQUENCES OF DEFECT: IN THE EVENT OF AN ACCIDENT, FAILURE OF A SEAT BELTANCHORAGE WILL INCREASE THE RISK OF INJURY TO THE WEARER.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1979 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 79V142000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1979 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19781201 - 19790101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15328 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790606 |
| Record Creation Date: | 19791012 |
Defect Summary:
ON THE INVOLVED VEHICLES THE BRAKE STOPLIGHT AND CRUISE CONTROL SWITCH WHICH IS OPERATED BY THE BRAKE PEDAL MAY HAVE BEEN ASSEMBLED WITH AN INCORRECT LUBRICANT ON THE ACTUATING PLUNGER. THIS CAN CAUSE THE REAR BRAKE STOPLIGHTS TO BECOME INOPERATIVE AND THE CRUISE CONTROL, IF ACTIVATED, TO STAY ELECTRICALLY ENGAGED.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE BRAKE STOPLIGHT AND CRUISE CONTROL SWITCH AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: LIGHTING AND COMMUNICATIONS; SWITCH BUTTON RING, BRAKE LIGHTS.CONSEQUENCES OF DEFECT: WITH INOPERATIVE BRAKE LIGHTS, A VEHICLE APPROACHINGFROM THE REAR WOULD NOT BE AWARE THAT BRAKES WERE BEING APPLIED. ALSO, IF THECRUISE CONTROL FAILS TO AUTOMATICALLY DISENGAGE THROUGH BRAKE PEDAL OPERATION,VEHICLE MAY ACCELERATE WHEN THE BRAKE PEDAL IS RELEASED. EITHER CONDITION COULDRESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.NOTE: OWNER IS ADVISED NOT TO ENGAGE THE CRUISE CONTROL UNTIL IT HAS BEENINSPECTED BY DEALER.
CHEVROLET: CAPRICE: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-->| NHTSA Campaign Number: | 79V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1978 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19790201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 476245 |
| Date Owner Notified By Manufacturer: | 19790703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790702 |
| Record Creation Date: | 19791012 |
Defect Summary:
A CHILD COULD OPEN THE REAR SIDE COMPARTMENT DOOR AND ENTER THIS COMPARTMENT. THE CHILD COULD BECOME ENTRAPPED IF THE DOOR WERE TO CLOSE, AS IT CANNOT BE UNLATCHED FROM THE INSIDE.
Corrective Summary:
DEALER WILL REPLACE THE ORIGINAL COMPARTMENT DOOR LATCH, WHICH CAN BE LATCHED WITHOUT A KEY, WITH A NEW ASSEMBLY THAT REQUIRES A KEY TO LATCH AS WELL AS LOCK THE DOOR.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STRUCTURE; STORAGE COMPARTMENT.CONSEQUENCES OF DEFECT: IN THE ABSENCE OF OUTSIDE HELP, THE CHILD WOULDSUFFOCATE.NOTE: THE OWNER IS ADVISED TO KEEP THIS COMPARTMENT LOCKED EXCEPT WHILE EITHERLOADING OR UNLOADING IT.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1978 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: WHEELS:LUGS/NUTS/BOLTS
-->| NHTSA Campaign Number: | 77V200000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1978 |
| Manufacturer Component Description: | WHEELS:LUGS/NUTS/BOLTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4504 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19771116 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE REAR WHEEL MOUNTING BOLTS ON THE AFFECTED VEHICLES, ARE BRITTLE AND THEREFORE MAY FRACTURE. THIS BRITTLENESS IS DUE TO IMPROPER HEAT TREATMENT DURING MANUFACTURE. IF THE BOLTS BREAK, THE TIRE AND WHEEL ASSEMBLY MAY SEPARATE FROM THE VEHICLE.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, WILL REPLACE DEFECTIVE BOLTS ON ALL AXLES AND THE TEN REAR AXLE WHEEL MOUNTING BOLTS, FREE OF CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; REAR WHEEL MOUNTING BOLTS.CONSEQUENCES OF DEFECT: IF SEPARATION OCCURS UNDER VEHICLE OPERATION, LOSS OFVEHICLE CONTROL WITHOUT PRIOR WARNING AND AN ACCIDENT COULD RESULT.
CHEVROLET: CAPRICE: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-->| NHTSA Campaign Number: | 79V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1977 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19790201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 476245 |
| Date Owner Notified By Manufacturer: | 19790703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790702 |
| Record Creation Date: | 19791012 |
Defect Summary:
A CHILD COULD OPEN THE REAR SIDE COMPARTMENT DOOR AND ENTER THIS COMPARTMENT. THE CHILD COULD BECOME ENTRAPPED IF THE DOOR WERE TO CLOSE, AS IT CANNOT BE UNLATCHED FROM THE INSIDE.
Corrective Summary:
DEALER WILL REPLACE THE ORIGINAL COMPARTMENT DOOR LATCH, WHICH CAN BE LATCHED WITHOUT A KEY, WITH A NEW ASSEMBLY THAT REQUIRES A KEY TO LATCH AS WELL AS LOCK THE DOOR.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STRUCTURE; STORAGE COMPARTMENT.CONSEQUENCES OF DEFECT: IN THE ABSENCE OF OUTSIDE HELP, THE CHILD WOULDSUFFOCATE.NOTE: THE OWNER IS ADVISED TO KEEP THIS COMPARTMENT LOCKED EXCEPT WHILE EITHERLOADING OR UNLOADING IT.
CHEVROLET: CAPRICE: STEERING:WHEEL AND HANDLE BAR
-->| NHTSA Campaign Number: | 76V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1977 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55564 |
| Date Owner Notified By Manufacturer: | 19760830 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760907 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 77-C-1.POSSIBILITY THAT THE STEERING INTERMEDIATESHAFT MAY HAVE BEEN ASSEMBLED WITH COUPLING RETAINER LOCKING TABS NOT BENT OVERPROPERLY OR ONE OR MORE OF THE LOWER FLEXIBLE COUPLING RIVETS IMPROPERLYPEENED.IF EITHER OF THESE CONDITIONS EXISTS, THE INTERMEDIATE SHAFT ASSEMBLYCOULD SEPARATE CAUSING LOSS OF STEERING CONTROL, AND VEHICLE CRASH MAY OCCURWITHOUT PRIOR WARNING.(CORRECT BY INSPECTING, AND REPLACING SHAFT WHERENECESSARY).PASSENGER VEHICLE.
CHEVROLET: CAPRICE: EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
-->| NHTSA Campaign Number: | 76V175000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1977 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:TURN SIGNAL:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 66632 |
| Date Owner Notified By Manufacturer: | 19761022 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19761103 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Notes:
GENERAL MOTOR CAMPAIGN NO (CHEVROLET) 77C02 (PONTIAC) 77-C-4 (BUICK) 77-C-5.POSSIBILITY THAT THE TURN SIGNAL OPERATING UNIT OR VEHICLES WITH TILT STEERINGCOLUMNS MAY NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.108.THE TURN SIGNAL LEVER ACTUATOR PIVOT PIN WHICH MAY WORK OUT OF THE PIVOT,RESULTING IN NOT BEING ABLE TO USE TURN SIGNAL TO ALERT OTHER DRIVERS OF YOURINTENTIONS TO CHANGE LANES OR TURN, CAUSING POSSIBLE VEHICLE CRASH.(CORRECTBY INSPECTING AND INSTALLING A RETAINER TO PRECLUDE PIVOT PIN DISENGAGEMENT).PASSENGER VEHICLE.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1977 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1976 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
-->| NHTSA Campaign Number: | 75V214000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 39278 |
| Date Owner Notified By Manufacturer: | 19751223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19751219 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C04, PONTIAC CAMPAIGN NO. 76C7, OLDSMOBILE CAMPAIGN NO.76C1, BUICK CAMPAIGN NO. 76C1.POSSIBILITY THAT THE COMBINATION VALVE, WHICHIS A PART OF THE HYDRAULIC SERVICE BRAKE SYSTEM MAY HAVE BEEN IMPROPERLYMANUFACTURED AND COULD MALFUNCTION.SHOULD THIS CONDITION OCCUR WHILE VEHICLEIS IN MOTION AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED.A VEHICLECRASH COULD OCCUR WITHOUT PRIOR WARNING.(CORRECT BY INSPECTING AND REPLACINGVALVE WHERE NECESSARY.) PASSENGER CARS AND LIGHT TRUCKS.
CHEVROLET: CAPRICE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 73V244000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1974 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 9215 |
| Date Owner Notified By Manufacturer: | 19740102 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731219 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTORS CAMPAIGN NO CHEVROLET 74-C-07.STATION WAGON.POSSIBILITY THATTHE REAR BRAKE PIPE WAS IMPROPERLY POSITIONED WHEN ATTACHED TO THE REAR AXLEASSEMBLY.THIS MAY RESULT IN REPEATED CONTACT OF THE PIPE WITH THE UNDERBODY,CAUSING IT TO FLEX UP AND DOWN UNTIL IT BREAKS, RESULTING IN LOSS OF BRAKEFLUID AND LOSS OF REAR BRAKING ACTION.(CORRECT BY INSPECTING AND INSTALLINGBRAKE PIPE PROPERLY)).
CHEVROLET: CAPRICE: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
-->| NHTSA Campaign Number: | 73V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1974 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 782111 |
| Date Owner Notified By Manufacturer: | 19740109 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731227 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 74-C-09.PONTIAC 74-C-2.BUICK 74-C-2.OLDSMOBILE74-C-3.SPRINT 74-C-4.POSSIBILITY THAT THE FRONT UPPER CONTROL ARM INNERBUSHING RETAINER NUTS MAY LOOSEN AND COME OFF DURING NORMAL OPERATINGCONDITIONS.SHOULD THIS OCCUR, THE LOOSE CONTROL ARM MAY MOVE FORWARD ANDCONTACT THE UPPER CONTROL ARM MOUNTING BRACKET ON THE FRAME WHICH RESTRICTS ANYFURTHER FORWARD MOVEMENT.IF THIS VEHICLE IS OPERATED IN THIS CONDITION IT ISPOSSIBLE FOR THE CONTROL ARM CROSS SHAFT TO BREAK.(CORRECT BY INSPECTING ANDINSTALLING NEW BUSHING RETAINERS WHERE NECESSARY.)
CHEVROLET: CAPRICE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1974 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAPRICE: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: CAPRICE: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
-->| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1972 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAPRICE: SEATS
-->| NHTSA Campaign Number: | 72V185000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1972 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720501 - 19720501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1699 |
| Date Owner Notified By Manufacturer: | 19720719 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19720719 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 72-C-2.CHEVROLET CAMPAIGN NO 72-C-10.PONTIACCAMPAIGN NO 72-C-4.POSSIBILITY THAT MANUAL FRONT SEAT ADJUSTER MAY NOT HAVEBEEN INSTALLED PROPERLY AND MAY NOT STAY ENGAGED IN ADJUSTER TRACK DURING ANIMPACT, AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.207.(CORRECT BY INSTALLING NEW SEAT ADJUSTER ON PASSENGER SIDE OF FRONT SEAT.)
CHEVROLET: CAPRICE: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
-->| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1971 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAPRICE: EQUIPMENT:MECHANICAL:JACKS
-->| NHTSA Campaign Number: | 71V121000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1971 |
| Manufacturer Component Description: | EQUIPMENT:MECHANICAL:JACKS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6000 |
| Date Owner Notified By Manufacturer: | 19710708 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19710720 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 71-C-11.STATION WAGONS ONLY.POSSIBIL ITY THAT BUMPERJACK LOAD REST LIP MAY NOT BE PROPERLY FORMEDALLOWING IT TO BEND AND VEHICLESLIP FROM JACK LOAD REST.(CO RRECT BY INSTALLING CORRECT JACK CORRECT JACKWHERENECESSARY. )
CHEVROLET: CAPRICE: TIRES:TREAD/BELT
-->| NHTSA Campaign Number: | 71V125000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1971 |
| Manufacturer Component Description: | TIRES:TREAD/BELT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1672 |
| Date Owner Notified By Manufacturer: | 19710726 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19710726 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 109 |
Notes:
CHEVROLET CAMPAIGN NO 71-C-17.PONTIAC CAMPAIGN NO 71-C-4.S TATION WAGONS.EQUIPPED WITH L-78-15 FASTRAK W.S.POSSIBIL ITY THAT TIRE MAY BE SUSCEPTIBLETO EARLY TREAD SEPARATION, AN D MAY NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETYSTANDARD NO. 109.THIS TYPE TREAD SEPARATION WILL NOT CAUSE DEFLATION OFBUT MAY CAUSE NOTICEABLE ROUGHNESS IN RIDE AND HANDLING OF CA R OF CAR ANDPOSSIBLE LOSS OF PORTIONS OF TREAD STOCK.REPLAC ING TIRE WHERE NECESSARY).
CHEVROLET: CAPRICE: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: CAPRICE: TIRES
-->| NHTSA Campaign Number: | 69V020000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1969 |
| Manufacturer Component Description: | TIRES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1396 |
| Date Owner Notified By Manufacturer: | 19690214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690220 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT FIRESTONE TIRES (8.25 X 14 WHITE SIDEWALL 4-PLY RATED), MAYNOT MEET MINIMUM STRENGTH REQUIREMENTS.FAILURE IN BODY OF TIRE COULD RESULTIN LOSS OF TIRE PRESSURE.(CORRECT BY RE- PLACING ALL TIRES WITH NEW IMPROVEDTYPE.)
CHEVROLET: CAPRICE: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
-->| NHTSA Campaign Number: | 69V091000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1969 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 24017 |
| Date Owner Notified By Manufacturer: | 19690703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690709 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT FILLER PLATE WAS OMITTED FROM LEFT REAR FLOOR PAN AREA BETWEENBUMPER AND FUEL TANK.IF THIS PLATE IS MISSING IT COULD ALLOW DUST AND, UNDERCERTAIN CONDITIONS, EXHAUST FUMES TO ENTER PASSENGER COMPARTMENT.(CORRECT BYINSPECTING AND INSTALLING FILLER PLATE WHEN NECESSARY.)
CHEVROLET: CAPRICE: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-->| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAPRICE: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: CAPRICE: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-->| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAPRICE: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: CAPRICE: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-->| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAPRICE |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: CAVALIER: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2005 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 04V300000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4056 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040401 - 20040430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 37 |
| Date Owner Notified By Manufacturer: | 20040823 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040623 |
| Record Creation Date: | 20040629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE PASSENGER-SIDE REAR SAFETY BELT MAY HAVE BEEN INSTALLED WITH AN INCORRECT NUT AND BOLT.
Consequence Summary:
IN A SEVERE CRASH, THE UPPER SEAT BELT ANCHORAGE MAY SEPARATE. THE EFFECTIVENESS OF THE SEAT BELT COULD THEN BE REDUCED AND THE OCCUPANT COULD RECEIVE GREATER INJURIES.
Corrective Summary:
DEALERS ARE TO INSPECT THE SAFETY BELT ANCHORAGE AND INSTALL A NEW NUT AND BOLT, IF NECESSARY. THE RECALL BEGAN ON AUGUST 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 04056. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2004 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:TURN SIGNAL
-->| NHTSA Campaign Number: | 04V524000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4083 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:TURN SIGNAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20030831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 256025 |
| Date Owner Notified By Manufacturer: | 20050118 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20041101 |
| Record Creation Date: | 20041103 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES, THE REAR LAMPS THAT PROVIDE STOP AND TURN SIGNALS AND TAIL LAMP FUNCTIONS STOP WORKING BECAUSE OF INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET. IN ADDITION, IF ONE BULBS WERE TO BECOME INOPERATIVE WHILE THE VEHICLE WAS OPERATING IN CRUISE CONTROL, THE CRUISE CONTROL WOULD DISENGAGE WHEN THE REMAINING BULB WAS ACTIVATED. IF BOTH LAMPS WERE TO BECOME INOPERATIVE, THE CRUISE CONTROL WOULD NOT ENGAGE.
Consequence Summary:
AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY GREASE OR REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO.04083.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2003 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2002 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2002 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: ELECTRICAL SYSTEM:IGNITION:SWITCH
-->| NHTSA Campaign Number: | 04V036000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 4002 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:IGNITION:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1415231 |
| Date Owner Notified By Manufacturer: | 20040301 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040127 |
| Record Creation Date: | 20040205 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence Summary:
IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Corrective Summary:
DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
Notes:
GM RECALL NO. 04002.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2001 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2001 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: ELECTRICAL SYSTEM:IGNITION:SWITCH
-->| NHTSA Campaign Number: | 04V036000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 4002 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:IGNITION:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980301 - 19990630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1415231 |
| Date Owner Notified By Manufacturer: | 20040301 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040127 |
| Record Creation Date: | 20040205 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence Summary:
IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Corrective Summary:
DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
Notes:
GM RECALL NO. 04002.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1999 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1999 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: INTERIOR LIGHTING
-->| NHTSA Campaign Number: | 99V218000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 99047 |
| Manufacturer Component Description: | INTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19990501 - 19990831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6584 |
| Date Owner Notified By Manufacturer: | 19990902 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990811 |
| Record Creation Date: | 19990817 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 101 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION." THE INSTRUMENT PANEL BACKLIGHTING MAY NOT FUNCTION AFTER ADJUSTING THE INTERIOR LIGHT INTENSITY.
Consequence Summary:
IF THE INSTRUMENT PANEL IS NOT LIT AT NIGHT, THE DRIVER MAY NOT BE ABLE TO SEE THE CONTROLS AND DISPLAYS.
Corrective Summary:
DEALERS WILL TEST THE BODY CONTROL MODULE, AND IF NECESSARY, REPLACE IT.
Notes:
OWNER NOTIFICATION BEGAN SEPTEMBER 2, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: WHEELS:LUGS/NUTS/BOLTS
-->| NHTSA Campaign Number: | 97V219000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Component Description: | WHEELS:LUGS/NUTS/BOLTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19971101 - 19971111 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 24 |
| Date Owner Notified By Manufacturer: | 19971121 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19971124 |
| Record Creation Date: | 19971203 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WHEEL LUG NUTS WERE NOT TIGHTENED SECURELY RESULTING IN A FRACTURE OF THE WHEEL STUDS.
Consequence Summary:
THE WHEEL COULD SEPARATE FROM THE VEHICLE. IF THE VEHICLE WERE IN MOTION, A VEHICLE CRASH COULD RESULT.
Corrective Summary:
DEALERS WILL INSPECT THE TORQUE OF ALL WHEEL NUTS AND, IF NECESSARY, TIGHTEN ANY THAT MAY BE BELOW REQUIRED TORQUE.
Notes:
DEALER NOTIFICATION BEGAN NOVEMBER 21, 1997. ALL VEHICLES ARE STILL AT DEALERS.NO OWNERS ARE INVOLVED.
CHEVROLET: CAVALIER: ELECTRICAL SYSTEM:IGNITION:SWITCH
-->| NHTSA Campaign Number: | 04V036000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 4002 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:IGNITION:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970301 - 19980930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1415231 |
| Date Owner Notified By Manufacturer: | 20040301 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040127 |
| Record Creation Date: | 20040205 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence Summary:
IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Corrective Summary:
DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
Notes:
GM RECALL NO. 04002.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: STEERING:RACK AND PINION
-->| NHTSA Campaign Number: | 02V286000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 2049 |
| Manufacturer Component Description: | STEERING:RACK AND PINION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19971031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1159156 |
| Date Owner Notified By Manufacturer: | 20030124 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20021104 |
| Record Creation Date: | 20021106 |
Defect Summary:
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence Summary:
IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 02049.ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 00V053000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 2 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970901 - 19980930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 391 |
| Date Owner Notified By Manufacturer: | 20000317 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000228 |
| Record Creation Date: | 20000229 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH BI-FUEL COMPRESSED NATURAL GAS (CNG) VEHICLES. THE CNG FUEL LINE AND THE CNG HIGH PRESSURE REGULATOR COOLANT LINES CAN CONTACT OTHER FUEL (GASOLINE) AND BRAKE LINES ON THE VEHICLE. ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH.
Consequence Summary:
ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH. A BRAKE FLUID LEAK COULD DISABLE A PORTION OF THE BRAKE SYSTEM, CAUSING LONGER STOPPING DISTANCES. GASOLINE LEAKING FROM A FUEL PIPE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD CAUSE A VEHICLE FIRE.
Corrective Summary:
DEALERS WILL INSPECT AND REPOSITION THE CNG FUEL AND COOLANT PIPES AND REPOSITION/REPAIR ANY DAMAGED FUEL OR BRAKE PIPES AS NECESSARY.
Notes:
OWNER NOTIFICATION BEGAN MARCH 17, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-->| NHTSA Campaign Number: | 07E015000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1998 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3124 |
| Date Owner Notified By Manufacturer: | 20070320 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070226 |
| Record Creation Date: | 20070226 |
Defect Summary:
CERTAIN DELPHI AFTERMARKET FUEL PUMP MODULES / MODULE RESERVOIR ASSEMBLIES (MRA) THAT WERE SOLD FOR USE ON THE ABOVE LISTED VEHICLES. DURING PRODUCTION THE MRAS VENT AND FUEL RETURN TUBES WERE REVERSED. THIS CONDITION CAN RESULT IN THE VEHICLE NOT RUNNING CORRECTLY (IDLE ROUGH AND/OR STALL) DUE TO AN OVERLY RICH FUEL BLEND OR THE VEHICLE'S EVAPORATIVE EMISSION CARBON CANISTER MAY LEAK FUEL.
Consequence Summary:
A STALLED VEHICLE CAN INCREASE THE RISK OF A VEHICLE CRASH. A FUEL LEAK CAN RESULT IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE MRAS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2007. OWNERS CAN CONTACT DELPHI AT 1-877-335-7443.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PUMP MODULES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 98V319000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960601 - 19970331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27083 |
| Date Owner Notified By Manufacturer: | 19981228 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19981215 |
| Record Creation Date: | 19981217 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ONE OF THE REAR SUSPENSION TRAILING ARM BOLTS CAN FATIGUE AND BREAK.
Consequence Summary:
IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A LOSS OF VEHICLE CONTROL CAN OCCUR, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE REAR SUSPENSION TRAILING ARM FASTENERS.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 28, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: STRUCTURE:BODY
-->| NHTSA Campaign Number: | 98V032000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | STRUCTURE:BODY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19970430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 8 |
| Date Owner Notified By Manufacturer: | 19980315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980225 |
| Record Creation Date: | 19980225 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 214 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH MIS-LOCATED WELDS AT THE JOINT BETWEEN THE LEFT ROCKER PANEL INNER REINFORCEMENT AND THE BODY SIDE RING. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 214, "SIDE DOOR STRENGTH."
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE SHEET METAL STRUCTURE WOULD NOT PERFORM AS DESIRED INCREASING THE RISK OF PERSONAL INJURY.
Corrective Summary:
DEALERS WILL INSPECT THE WELDS AND, IF NECESSARY, PLACE FIVE WELDS BETWEEN THE INVOLVED PANELS AND APPLY PRIMER AND TOPCOAT FINISH MATERIALS.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: AIR BAGS
-->| NHTSA Campaign Number: | 98V146000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960701 - 19970531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 675302 |
| Date Owner Notified By Manufacturer: | 19980811 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980629 |
| Record Creation Date: | 19980630 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.
Consequence Summary:
AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.
Corrective Summary:
DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.
Notes:
OWNER NOTIFICATION BEGAN DURING AUGUST 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1022 OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4326).
CHEVROLET: CAVALIER: ELECTRICAL SYSTEM:IGNITION:SWITCH
-->| NHTSA Campaign Number: | 02V070000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 2008 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:IGNITION:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960701 - 19970731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1589948 |
| Date Owner Notified By Manufacturer: | 20020327 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020306 |
| Record Creation Date: | 20020325 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence Summary:
IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Corrective Summary:
DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: STEERING:RACK AND PINION
-->| NHTSA Campaign Number: | 02V286000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 2049 |
| Manufacturer Component Description: | STEERING:RACK AND PINION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960701 - 19970731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1159156 |
| Date Owner Notified By Manufacturer: | 20030124 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20021104 |
| Record Creation Date: | 20021106 |
Defect Summary:
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence Summary:
IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 02049.ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 96V160000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960801 - 19960831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 50 |
| Date Owner Notified By Manufacturer: | 19960829 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960829 |
| Record Creation Date: | 19960903 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 104 |
Defect Summary:
THESE VEHICLES WERE BUILT WITH AN INCORRECT WIPER BLADE ASSEMBLY (17" LONG INSTEAD OF 22" LONG) ON THE DRIVER'S SIDE. THIS DOES NOT COMPLY WITH FMVSS NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS."
Consequence Summary:
THE AREA AND PATTERN WIPED ON THE WINDSHIELD WILL BE REDUCED AND COULD AFFECT THE DRIVER'S VIEW IN WET WEATHER INCREASING THE RISK OF A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL INSPECT FOR THE CORRECT WIPER BLADE ASSEMBLY AND INSTALL A CORRECT LENGTH WIPER BLADE ASSEMBLY.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION BEGAN AUGUST 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: WHEELS:SPACE SAVER WHEEL
-->| NHTSA Campaign Number: | 97V106000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | WHEELS:SPACE SAVER WHEEL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19970430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 652 |
| Date Owner Notified By Manufacturer: | 19970715 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970628 |
| Record Creation Date: | 19970630 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE COMPACT SPARE TIRE ASSEMBLIES WERE ASSEMBLED WITH INCORRECT RIMS. IF THE SPARE TIRE IS UNDERINFLATED, THE BEAD CAN SEPARATE FROM THE RIM CAUSING A RAPID LOSS OF AIR. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 110, "TIRE SELECTION AND RIMS."
Consequence Summary:
A RAPID LOSS OF AIR CAN INCREASE THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE RIM ON THE COMPACT SPARE TIRE ASSEMBLY. OWNERS ARE REQUESTED NOT TO USE THE SPARE TIRE UNTIL THE RIM HAS BEEN REPLACED.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING JULY 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-->| NHTSA Campaign Number: | 07E015000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1997 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3124 |
| Date Owner Notified By Manufacturer: | 20070320 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070226 |
| Record Creation Date: | 20070226 |
Defect Summary:
CERTAIN DELPHI AFTERMARKET FUEL PUMP MODULES / MODULE RESERVOIR ASSEMBLIES (MRA) THAT WERE SOLD FOR USE ON THE ABOVE LISTED VEHICLES. DURING PRODUCTION THE MRAS VENT AND FUEL RETURN TUBES WERE REVERSED. THIS CONDITION CAN RESULT IN THE VEHICLE NOT RUNNING CORRECTLY (IDLE ROUGH AND/OR STALL) DUE TO AN OVERLY RICH FUEL BLEND OR THE VEHICLE'S EVAPORATIVE EMISSION CARBON CANISTER MAY LEAK FUEL.
Consequence Summary:
A STALLED VEHICLE CAN INCREASE THE RISK OF A VEHICLE CRASH. A FUEL LEAK CAN RESULT IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE MRAS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2007. OWNERS CAN CONTACT DELPHI AT 1-877-335-7443.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PUMP MODULES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 98V319000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960601 - 19970331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27083 |
| Date Owner Notified By Manufacturer: | 19981228 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19981215 |
| Record Creation Date: | 19981217 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ONE OF THE REAR SUSPENSION TRAILING ARM BOLTS CAN FATIGUE AND BREAK.
Consequence Summary:
IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A LOSS OF VEHICLE CONTROL CAN OCCUR, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE REAR SUSPENSION TRAILING ARM FASTENERS.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 28, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 95V201000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950901 - 19950901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 360 |
| Date Owner Notified By Manufacturer: | 19951019 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19951023 |
| Record Creation Date: | 19951101 |
Defect Summary:
THE ACCELERATOR CONTROL CABLE COULD HAVE BEEN KINKED DURING ASSEMBLY CAUSING HIGH ACCELERATOR PEDAL EFFORT, STICKING ACCELERATOR CONTROL CABLE, OR A BROKEN ACCELERATOR CONTROL CABLE.
Consequence Summary:
IF THE ACCELERATOR CONTROL CABLE STICKS OR BREAKS, UNWANTED ACCELERATION AND/OR LOSS OF THROTTLE CONTROL CAN RESULT INCREASING THE RISK OF A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL REPLACE THE ACCELERATOR CONTROL CABLE ASSEMBLY.
Notes:
SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PONTIAC AT 1-800-762-2737 OR CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: AIR BAGS
-->| NHTSA Campaign Number: | 98V146000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950401 - 19960831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 675302 |
| Date Owner Notified By Manufacturer: | 19980811 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980629 |
| Record Creation Date: | 19980630 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.
Consequence Summary:
AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.
Corrective Summary:
DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.
Notes:
OWNER NOTIFICATION BEGAN DURING AUGUST 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1022 OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4326).
CHEVROLET: CAVALIER: ELECTRICAL SYSTEM:IGNITION:SWITCH
-->| NHTSA Campaign Number: | 02V070000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 2008 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:IGNITION:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19941101 - 19960831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1589948 |
| Date Owner Notified By Manufacturer: | 20020327 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020306 |
| Record Creation Date: | 20020325 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence Summary:
IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Corrective Summary:
DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: STEERING:RACK AND PINION
-->| NHTSA Campaign Number: | 02V286000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 2049 |
| Manufacturer Component Description: | STEERING:RACK AND PINION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960101 - 19960731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1159156 |
| Date Owner Notified By Manufacturer: | 20030124 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20021104 |
| Record Creation Date: | 20021106 |
Defect Summary:
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence Summary:
IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 02049.ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS
-->| NHTSA Campaign Number: | 96V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950701 - 19950831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 270014 |
| Date Owner Notified By Manufacturer: | 19970130 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961217 |
| Record Creation Date: | 19961220 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Corrective Summary:
DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING JANUARY 1997. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAVALIER: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: INTERIOR LIGHTING
-->| NHTSA Campaign Number: | 98V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | INTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950401 - 19960131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 249420 |
| Date Owner Notified By Manufacturer: | 19980228 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980217 |
| Record Creation Date: | 19980225 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 101 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."
Consequence Summary:
THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300,PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-->| NHTSA Campaign Number: | 07E015000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3124 |
| Date Owner Notified By Manufacturer: | 20070320 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070226 |
| Record Creation Date: | 20070226 |
Defect Summary:
CERTAIN DELPHI AFTERMARKET FUEL PUMP MODULES / MODULE RESERVOIR ASSEMBLIES (MRA) THAT WERE SOLD FOR USE ON THE ABOVE LISTED VEHICLES. DURING PRODUCTION THE MRAS VENT AND FUEL RETURN TUBES WERE REVERSED. THIS CONDITION CAN RESULT IN THE VEHICLE NOT RUNNING CORRECTLY (IDLE ROUGH AND/OR STALL) DUE TO AN OVERLY RICH FUEL BLEND OR THE VEHICLE'S EVAPORATIVE EMISSION CARBON CANISTER MAY LEAK FUEL.
Consequence Summary:
A STALLED VEHICLE CAN INCREASE THE RISK OF A VEHICLE CRASH. A FUEL LEAK CAN RESULT IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE MRAS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2007. OWNERS CAN CONTACT DELPHI AT 1-877-335-7443.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PUMP MODULES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: STRUCTURE:FRAME AND MEMBERS
-->| NHTSA Campaign Number: | 95V141000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1995 |
| Manufacturer Component Description: | STRUCTURE:FRAME AND MEMBERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19940801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16 |
| Date Owner Notified By Manufacturer: | 19950719 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950726 |
| Record Creation Date: | 19950727 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
SOME WELDS WERE OMITTED FROM THE BODY LOCK PILLAR, OR "B" PILLAR. THIS DOES NOT COMPLY WITH FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: IF A VEHICLE CRASH SHOULD OCCUR, OCCUPANT PROTECTION LEVELS COULD BE REDUCED.
Corrective Summary:
ALL VEHICLES IN THIS RECALL CAMPAIGN HAVE BEEN REPURCHASED AND REPLACED WITH A COMPARABLE VEHICLE.
Notes:
SYSTEM: STRUCTURE; FRAME; MEMBERS AND BODY; FMVSS NO.208.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: ALL VEHICLES HAVE BEEN REPURCHASED.NO OTHER OWNERS WILL BE CONTACTED.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: ELECTRICAL SYSTEM:IGNITION:SWITCH
-->| NHTSA Campaign Number: | 02V070000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1995 |
| Manufacturer Campaign Number: | 2008 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:IGNITION:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940301 - 19950831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1589948 |
| Date Owner Notified By Manufacturer: | 20020327 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020306 |
| Record Creation Date: | 20020325 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence Summary:
IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Corrective Summary:
DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS
-->| NHTSA Campaign Number: | 96V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950701 - 19950831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 270014 |
| Date Owner Notified By Manufacturer: | 19970130 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961217 |
| Record Creation Date: | 19961220 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Corrective Summary:
DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING JANUARY 1997. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAVALIER: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1995 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
-->| NHTSA Campaign Number: | 95V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1995 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940201 - 19950101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 21340 |
| Date Owner Notified By Manufacturer: | 19950215 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950216 |
| Record Creation Date: | 19950221 |
Defect Summary:
THESE VEHICLES HAVE BEEN BUILT WITH WELDS MISSING FROM THE FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES CAUSING EXCESSIVE LOADS ON THE EXISTING WELDS.
Consequence Summary:
THIS CONDITION CAN RESULT IN SEPARATION OF THE FRONTBUSHING SLEEVE SUBASSEMBLY FROM THE CONTROL ARM INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT BOTH LEFT-HAND AND RIGHT-HAND FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES AND REPLACE ALL CONTROL ARM ASSEMBLIES FOUND WITH OMITTED WELDS.
Notes:
SYSTEM: SUSPENSION; INDEPENDENT FRONT CONTROL ARM; LOWER.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CAVALIER: COMMUNICATIONS:HORN ASSEMBLY
-->| NHTSA Campaign Number: | 96I001000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1993 |
| Manufacturer Component Description: | COMMUNICATIONS:HORN ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19930401 - 19940701 |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 417000 |
| Date Owner Notified By Manufacturer: | 19960328 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960123 |
| Record Creation Date: | 19960327 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. THESE VEHICLES WERE BUILT WITH INSUFFICIENT RETENTION OF THE HORN PAD.
Consequence Summary:
THE HORN PAD CAN SEPARATE FROM THE STEERING WHEEL FALLING BETWEEN THE STEERING WHEEL SPOKES. THE HORN PAD COULD BECOME JAMMED BETWEEN THE STEERING WHEEL SPOKES AND THE TURN SIGNAL LEVER, RESULTING IN DAMAGE TO THE TURN SIGNAL LEVER, HORN PAD, AND HORN WIRING.
Corrective Summary:
DEALERS WILL MODIFY THE HORN PAD RETENTION CLIPS, INSTALL HORN PAD RETENTION BRACKETS TO THE STEERING WHEEL, REINSTALL THE HORN PAD AND ASSURE THAT THE HORN PAD IS PROPERLY RETAINED.
Notes:
NOTE:GENERAL MOTORS HAS DECIDED TO CONDUCT A SAFETY IMPROVEMENT CAMPAIGN TO MODIFY THE HORN PAD ON THESE VEHICLES.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020.
CHEVROLET: CAVALIER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 93V121000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1993 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19930401 - 19930401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2848 |
| Date Owner Notified By Manufacturer: | 19930810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930721 |
| Record Creation Date: | 19930727 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 106 |
Defect Summary:
THE BRAKE HOSES WERE MANUFACTURED INCORRECTLY, AND DO NOT COMPLY WITH FMVSS 106, "BRAKE HOSES."
Consequence Summary:
THE IMPROPERLY MANUFACTURED BRAKE HOSES CAN CAUSEREDUCED BRAKE EFFECTIVENESS AND/OR UNEVEN BRAKING, WHICH COULD RESULT IN ANACCIDENT.
Corrective Summary:
REPLACE THE RIGHT FRONT BRAKE HOSE ASSEMBLY ON CIERA AND CENTURY MODELS, AND BOTH REAR BRAKE HOSES ON CAVALIER AND SUNBIRD MODELS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; HOSE.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED SERVICEDATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME WITHOUT CHARGE ORTHE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE APPROPRIATE SERVICE CENTER ( BUICK AT 1-800-458-8006, PONTIAC AT1-800-763-2737; OLDSMOBILE AT 1-800-442-6537; OR CHEVROLET AT 1-800-222-1020 ).ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETYHOTLINE AT 1-800-424-9393.
CHEVROLET: CAVALIER: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
-->| NHTSA Campaign Number: | 91V166000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1992 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910801 - 19910801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3212 |
| Date Owner Notified By Manufacturer: | 19910905 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910923 |
| Record Creation Date: | 19910925 |
Defect Summary:
THE SECONDARY HOOD LATCH SPRING IS IMPROPERLY INSTALLED OR MISSING, LEADING TO A CONDITION WHERE THE SECONDARY HOOD LATCH DOES NOT ENGAGE THE SECONDARY STRIKER.
Consequence Summary:
IF THE SECONDARY HOOD LATCH IS NOT ENGAGED, AND THEPRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY. IFTHIS OCCURS WHILE THE VEHICLE IS IN MOTION, THE HOOD MAY CONTACT THE WINDSHIELD,REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASH COULD OCCUR.
Corrective Summary:
INSPECT HOOD LATCH ASSEMBLIES AND, WHERE NECESSARY, INSTALL A NEW SECONDARY HOOD LATCH SPRING.
Notes:
SYSTEM: HOOD, LATCH.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAVALIER: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
-->| NHTSA Campaign Number: | 91V165000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1991 |
| Manufacturer Component Description: | STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19901201 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 41718 |
| Date Owner Notified By Manufacturer: | 19910930 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910923 |
| Record Creation Date: | 19910925 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
FRONT DOOR INTERLOCK STRIKER MAY FAIL, CAUSING DOOR FRAME COLLAPSE AND INSUFFICIENT STRENGTH FOR THE SHOULDER BELT ANCHORAGE.
Consequence Summary:
THE DOOR FRAME WOULD COLLAPSE. VEHICLE DOES NOT COMPLYWITH FMVSS 210.
Corrective Summary:
REPLACE THE PASSIVE RESTRAINT INTERLOCK STRIKER STUDS ON FRONT DOORS.
Notes:
SYSTEM: SEAT BELT ANCHORAGE; FMVSS 210.VEHICLE DESCRIPTION: PASSENGER VEHICLES.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1991 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: SEAT BELTS
-->| NHTSA Campaign Number: | 92V003000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900201 - 19910201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 347866 |
| Date Owner Notified By Manufacturer: | 19920131 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19920110 |
| Record Creation Date: | 19920123 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
THE FRONT DOOR SHOULDER BELT GUIDE LOOPS MAY BE CRACKED AND ARE NOT IN COMPLIANCE WITH FMVSS 208.
Consequence Summary:
THE SEAT OCCUPANT FACES INCREASED RISK OF INJURY IN THEEVENT OF A SUDDEN STOP OR ACCIDENT.
Corrective Summary:
INSTALL REINFORCING PLATES ON THE CRACKED SHOULDER BELT GUIDES.
Notes:
SYSTEM: SAFETY BELTS; FMVSS 208.DESCRIPTION OF VEHICLES: PASSENGER VEHICLES; 1991 GM "J" AND "W" MODEL CARS.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-->| NHTSA Campaign Number: | 88V189000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19881001 - 19881101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 13095 |
| Date Owner Notified By Manufacturer: | 19890119 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19881206 |
| Record Creation Date: | 19881215 |
Defect Summary:
A FUEL TANK LEAK COULD OCCUR DUE TO SMALL CREASES ON THE TANK UNDERSIDE CRACKING DURING PRESSURE CYCLING WHICH OCCURS DURING NORMAL OPERATION.
Consequence Summary:
IN PRESENCE OF AN IGNITION SOURCE, THIS CONDITION COULDRESULT IN A FIRE.
Corrective Summary:
REPLACE FUEL TANK.
Notes:
SYSTEM: FUEL TANK.VEHICLE DESCRIPTION: PASSENGER CARS WITH 2.0L OR 2.8L ENGINES.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: VISIBILITY:WINDSHIELD
-->| NHTSA Campaign Number: | 88V121000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1988 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880501 - 19880501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 33 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880725 |
| Record Creation Date: | 19880804 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 212 |
Defect Summary:
THERE MAY BE POOR BOND ADHESION BETWEEN WINDSHIELD GLASS AND MOUNTING.
Consequence Summary:
WINDSHIELD COULD SEPARATE DURING A 30 MPH FRONTAL BARRIERTEST REQUIRED BY FMVSS 212. SUCH SEPARATION DURING AN ACCIDENT COULD RESULT INAN UNBELTED OCCUPANT BEING EJECTED AND INJURIED.
Corrective Summary:
REINSTALL WINDSHIELD ASSURING PROPER ADHESION.
Notes:
SYSTEM: WINDSHIELD/FMVSS 212.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK
-->| NHTSA Campaign Number: | 88V095000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1988 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870401 - 19871001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 14840 |
| Date Owner Notified By Manufacturer: | 19880628 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880614 |
| Record Creation Date: | 19880617 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
REAR LAMP WIRING HARNESS MAY CONTAIN OPEN OR INTERMITTENT CIRCUITS AFFECTING BACK UP LAMP OR LICENSE PLATE LAMP OPERATION.
Consequence Summary:
LAMPS WOULD FLASH OR BE INOPERATIVE; CARS WOULD NOTCOMPLY WITH FMVSS 108.
Corrective Summary:
INSTALL NEW WIRING HARNESS.
Notes:
SYSTEM: REAR LAMP WIRING HARNESS/FMVSS 108.VEHICLE DESCRIPTION: COUPE AND CONVERTIBLE PASSENGER CARS.
CHEVROLET: CAVALIER: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 87V011000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1987 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860501 - 19861101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 65594 |
| Date Owner Notified By Manufacturer: | 19870219 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19870209 |
| Record Creation Date: | 19870213 |
Defect Summary:
ACCELERATOR CONTROL CABLE MAY CONTAIN WATER WHICH COULD FREEZE WHILE VEHICLE IS PARKED CAUSING TRAVEL OF ACCELERATOR CONTROL CABLE TO BECOME RESTRICTED WHEN THROTTLE IS INITIALLY OPENED.
Consequence Summary:
ENGINE SPEED MAY NOT DECREASE WHICH COULD RESULT IN LOSSOF ACCELERATOR CONTROL AND A CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE ACCELERATOR CONTROL CABLE.
Notes:
SYSTEM: ACCELERATOR CONTROL CABLE.VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 2.0L ENGINES.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: PARKING BRAKE:CONVENTIONAL:MECHANICAL
-->| NHTSA Campaign Number: | 86V128000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1987 |
| Manufacturer Component Description: | PARKING BRAKE:CONVENTIONAL:MECHANICAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860801 - 19860801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1470 |
| Date Owner Notified By Manufacturer: | 19860918 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860915 |
| Record Creation Date: | 19860919 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 105 |
Defect Summary:
PARKING BRAKE LEVER MECHANISMS MAY NOT PROPERLY ENGAGE WHEN APPLIED AS REQUIRED BY FMVSS 105. CONSEQUENCE OF DEFECT: VEHICLE COULD UNEXPECTEDLY ROLL AWAY UNCONTROLLED, WHICH COULD RESULT IN A VEHICLE CRASH.
Corrective Summary:
REPLACE PARKING BRAKE LEVER ASSEMBLY.
Notes:
SYSTEM: BRAKES/FMVSS 105. VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
-->| NHTSA Campaign Number: | 86V131000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860301 - 19860401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 106111 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860919 |
| Record Creation Date: | 19860930 |
Defect Summary:
THE PUSH PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS AND TRUCKS/ VANS.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1986 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
-->| NHTSA Campaign Number: | 86V056000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19850901 - 19851101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 93317 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860428 |
| Record Creation Date: | 19860501 |
Defect Summary:
THE PUSH-PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. NOTE: ALSO, SEE NHTSA CAMPAIGN NUMBER 86V131000.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS, TRUCKS AND VANS.
CHEVROLET: CAVALIER: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 85V042000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1985 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19841001 - 19850101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 34331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850412 |
| Record Creation Date: | 19850416 |
Defect Summary:
THE ENGINE AIR CLEANER PLASTIC TRIM COVER COULD DETACH FROM THE AIR CLEANER ASSEMBLY AND FALL FORWARD ON THE EXHAUST MANIFOLD. CONSEQUENCE OF DEFECT: IF THE CAR IS BEING OPERATED AT THE TIME OF DETACHMENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR WITHOUT WARNING.
Corrective Summary:
REMOVE THE TRIM COVER AND DISCARD.
Notes:
VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH RPO LQ5 2.0L L4 ENGINESWITHOUT AN UNDERHOOD INSULATION BLANKET. SYSTEM: ENGINE AIR CLEANER COVER.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1985 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 86V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1985 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19841001 - 19850101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87174 |
| Date Owner Notified By Manufacturer: | 19860619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860528 |
| Record Creation Date: | 19860606 |
Defect Summary:
THE ENGINE AIR CLEANER PLASTIC TRIM COVER COULD FALL OFF THE AIR CLEANER ASSEMBLY AND LAND ON THE EXHAUST MANIFOLD CREATING A FIRE HAZARD. CONSEQUENCE OF DEFECT: IF THE CAR IS BEING OPERATED AT THE TIME THAT THE PLASTIC TRIM COVER FALLS OFF, AN ENGINE COMPARTMENT FIRE COULD OCCUR WITHOUT WARNING.
Corrective Summary:
REMOVE THE TRIM COVER AND DISCARD.
Notes:
SYSTEM: ENGINE AIR CLEANER COVER. VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH RPO LQ5 2.0 ENGINES.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1984 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: SEATS:FRONT ASSEMBLY:RECLINER
-->| NHTSA Campaign Number: | 84V011000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830701 - 19830901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 76586 |
| Date Owner Notified By Manufacturer: | 19840224 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840206 |
| Record Creation Date: | 19840222 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 207 |
Defect Summary:
SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Corrective Summary:
INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
CHEVROLET: CAVALIER: SEATS
-->| NHTSA Campaign Number: | 87V079000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820601 - 19841001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1136407 |
| Date Owner Notified By Manufacturer: | 19870624 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19870507 |
| Record Creation Date: | 19870601 |
Defect Summary:
THE METAL FLOOR PAN ANCHOR BAR COULD FATIGUE AND BREAK AROUND THE LEFT FRONT OUTER SEAT ADJUSTER STUD OF THE DRIVERS SEAT, ALLOWING THE STUD TO SEPARATE FROM THE FLOOR PAN ANCHOR BAR.
Consequence Summary:
DRIVERS SEAT COULD TIP REARWARD UNEXPECTEDLY; THIS COULDRESULT IN LOSS OF CONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
INSTALL A REINFORCEMENT BRACKET ON THE FLOOR PAN ANCHOR BAR AT THE LEFT FRONT OUTER SEAT ADJUSTER POSITION OF THE DRIVERS SEAT.
Notes:
SYSTEM: DRIVERS SEAT.VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH MANUALLY ADJUSTABLE DRIVERSSEAT.
CHEVROLET: CAVALIER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
-->| NHTSA Campaign Number: | 83V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1983 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19821001 - 19830501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 352036 |
| Date Owner Notified By Manufacturer: | 19831020 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19831013 |
| Record Creation Date: | 19831021 |
Defect Summary:
THE BRAKE PROPORTIONER VALVES MAY BREAK AND SEPARATE FROM THE MASTER CYLINDER. THIS WOULD ALLOW BRAKE FLUID TO LEAK AND WOULD RESULT IN A PARTIAL LOSS OF THE BRAKE SYSTEM.
Corrective Summary:
THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE ALL SUSPECT VALVES.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; BRAKE PROPORTIONER VALVES.CONSEQUENCES OF DEFECT: SINCE THIS IS A DUAL BRAKE SYSTEM, PART OF THE SYSTEMWILL STILL WORK AND ALLOW THE VEHICLE TO BE STOPPED, BUT OVER A GREATERDISTANCE. PARTIAL LOSS OF THE BRAKING SYSTEM AT A TIME WHEN MINIMUM STOPPINGDISTANCE IS REQUIRED COULD RESULT IN A VEHICLE ACCIDENT WITHOUT PRIOR WARNING.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
-->| NHTSA Campaign Number: | 82V096000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1983 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820801 - 19820901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12721 |
| Date Owner Notified By Manufacturer: | 19821011 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19821007 |
| Record Creation Date: | 19821015 |
Defect Summary:
POSSIBLE FUEL LEAKAGE COULD OCCUR AT THE THROTTLE BODY INJECTION FUEL FEED PIPE CONNECTION ON THE INVOLVED VEHICLES.
Corrective Summary:
THE FUEL FEED LINE FITTING BOLT AND TWO WASHERS WILL BE REPLACED BY THE DEALER AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 2.0 LITER ENGINES.SYSTEM: FUEL; FUEL FEED PIPE CONNECTION.CONSEQUENCES OF DEFECT: IF AN IGNITION SOURCE IS PRESENT WHEN FUEL LEAKAGEOCCURS, A FIRE COULD START AND COULD SPREAD TO THE PASSENGER COMPARTMENT,CAUSING SERIOUS PERSONAL INJURY TO PASSENGERS.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1983 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CAVALIER: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
-->| NHTSA Campaign Number: | 83V042000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1983 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820901 - 19820901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 312 |
| Date Owner Notified By Manufacturer: | 19830427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830419 |
| Record Creation Date: | 19830509 |
Defect Summary:
THE LEFT FRONT SUSPENSION CONTROL ARM WHICH SUPPORTS THE FRONT WHEEL, BRAKE AND STEERING ASSEMBLY, MAY COME LOOSE AT ITS MOUNTING BRACKET. THIS IS DUE TO POSSIBLE INADEQUATE WELDING OF THE BRACKET.
Corrective Summary:
DEALER WILL INSPECT THE VEHICLE AND, IF NECESSARY, REPLACE THE LEFT FRONT SUSPENSION SUPPORT ASSEMBLY AT NO COST.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; LEFT FRONT SUSPENSION CONTROL ARM.CONSEQUENCES OF DEFECT: IF THESE WELDS BREAK, LOSS OF STEERING CONTROL, BRAKEMALFUNCTION AND A VEHICLE ACCIDENT COULD RESULT.NOTE: IN THE EVENT OF WELD SEPARATION, THE CONTROL ARM WILL MAKE A LOUDCLUNKING NOISE WHICH WILL BE PARTICULARLY NOTICEABLE DURING BRAKE APPLICATIONAND ACCELERATION. IF THESE NOISES ARE IGNORED, THE CONTROL ARM MAY EVENTUALLYFAIL AND AN ACCIDENT COULD FOLLOW.
CHEVROLET: CAVALIER: SEATS
-->| NHTSA Campaign Number: | 87V079000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1983 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820601 - 19841001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1136407 |
| Date Owner Notified By Manufacturer: | 19870624 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19870507 |
| Record Creation Date: | 19870601 |
Defect Summary:
THE METAL FLOOR PAN ANCHOR BAR COULD FATIGUE AND BREAK AROUND THE LEFT FRONT OUTER SEAT ADJUSTER STUD OF THE DRIVERS SEAT, ALLOWING THE STUD TO SEPARATE FROM THE FLOOR PAN ANCHOR BAR.
Consequence Summary:
DRIVERS SEAT COULD TIP REARWARD UNEXPECTEDLY; THIS COULDRESULT IN LOSS OF CONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
INSTALL A REINFORCEMENT BRACKET ON THE FLOOR PAN ANCHOR BAR AT THE LEFT FRONT OUTER SEAT ADJUSTER POSITION OF THE DRIVERS SEAT.
Notes:
SYSTEM: DRIVERS SEAT.VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH MANUALLY ADJUSTABLE DRIVERSSEAT.
CHEVROLET: CAVALIER: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
-->| NHTSA Campaign Number: | 87V165000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1983 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820801 - 19830501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 126319 |
| Date Owner Notified By Manufacturer: | 19871117 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19871026 |
| Record Creation Date: | 19871103 |
Defect Summary:
INTERNAL CORROSION OF PULSAIR CHECK VALVE ASSEMBLY COULD PERMIT EXHAUST GAS TO MELT THE PLASTIC SHUT OFF VALVE AND DRAW VALVE PIECES INTO THE AIR CLEANER AND THROTTLE BODY.
Consequence Summary:
IF VALVE PIECES LODGE AGAINST THROTTLE PLATE, ENGINE MAYNOT RETURN TO IDLE RESULTING IN LOSS ACCELERATOR CONTROL AND POSSIBLY A CRASH.
Corrective Summary:
REPLACE PULSAIR CHECK VALVE AND SHUT OFF VALVE WITH NEWLY DESIGNED VALVES.
Notes:
SYSTEM: PULSAIR CHECK VALVEVEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH 2.0L ENGINES.
CHEVROLET: CAVALIER: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
-->| NHTSA Campaign Number: | 82V021000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CAVALIER |
| Model Year: | 1982 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810201 - 19820101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 519329 |
| Date Owner Notified By Manufacturer: | 19820315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19820308 |
| Record Creation Date: | 19820312 |
Defect Summary:
UNDER CERTAAIN CONDITIONS, THE HOSE CLAMPS ON THE FUEL TANK FILLER PIPE AND FUEL TANK FILLER VENT PIPE COULD FRACTURE. THE FRACTURE OF THESE CLAMPS COULD CAUSE FUEL LEAKAGE AT ANY OF THE FOUR PIPE TO HOSE CONNECTIONS. LEAKAGE CAN OCCUR DURING REFUELING, OR WHILE DRIVING, IF THE FUEL TANK IS ABOVE 3/4 FULL.
Corrective Summary:
DEALER WILL INSPECT AND REPLACE THE HOSE CLAMPS ON THE FUEL TANK FILLER PIPE AND VENT PIPE AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: FUEL; FUEL TANK, FILLER AND VENT PIPES.CONSEQUENCES OF DEFECT: IF AN IGNITION SOURCE IS PRESENT WHEN FUEL LEAKAGEOCCURS, A FIRE COULD START AND CAUSE VEHICLE DAMAGE AND SERIOUS PERSONALINJURY.NOTE: UNTIL THE VEHICLE CAN BE INSPECTED AND THE NECESSARY MODIFICATIONS AREMADE, THE FUEL TANK SHOULD NOT BE FILLED MORE THAN 3/4 FULL. ALSO, THE DEALERSHOULD BE CONTACTED IMMEDIATELY IF ANY FUEL LEAKAGE IS DETECTED.
--CHEVROLET: CELEBRITY: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
| NHTSA Campaign Number: | 82V021000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1982 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810201 - 19820101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 519329 |
| Date Owner Notified By Manufacturer: | 19820315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19820308 |
| Record Creation Date: | 19820312 |
Defect Summary:
UNDER CERTAAIN CONDITIONS, THE HOSE CLAMPS ON THE FUEL TANK FILLER PIPE AND FUEL TANK FILLER VENT PIPE COULD FRACTURE. THE FRACTURE OF THESE CLAMPS COULD CAUSE FUEL LEAKAGE AT ANY OF THE FOUR PIPE TO HOSE CONNECTIONS. LEAKAGE CAN OCCUR DURING REFUELING, OR WHILE DRIVING, IF THE FUEL TANK IS ABOVE 3/4 FULL.
Corrective Summary:
DEALER WILL INSPECT AND REPLACE THE HOSE CLAMPS ON THE FUEL TANK FILLER PIPE AND VENT PIPE AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: FUEL; FUEL TANK, FILLER AND VENT PIPES.CONSEQUENCES OF DEFECT: IF AN IGNITION SOURCE IS PRESENT WHEN FUEL LEAKAGEOCCURS, A FIRE COULD START AND CAUSE VEHICLE DAMAGE AND SERIOUS PERSONALINJURY.NOTE: UNTIL THE VEHICLE CAN BE INSPECTED AND THE NECESSARY MODIFICATIONS AREMADE, THE FUEL TANK SHOULD NOT BE FILLED MORE THAN 3/4 FULL. ALSO, THE DEALERSHOULD BE CONTACTED IMMEDIATELY IF ANY FUEL LEAKAGE IS DETECTED.
CHEVROLET: CELEBRITY: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 83V007000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1982 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820501 - 19820601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15495 |
| Date Owner Notified By Manufacturer: | 19830127 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830101 |
| Record Creation Date: | 19830204 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 106 |
Defect Summary:
REAR BRAKE HOSES MAY HAVE BEEN MANUFACTURED INCORRECTLY WHEN THE METAL END FITTINGS WERE INSTALLED. SOME REAR BRAKE HOSES MAY SEPARATE FROM THE METAL END FITTINGS WHEN SUBJECTED TO THE PULLING FORCE SPECIFIED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD 106, "BRAKE HOSES".
Corrective Summary:
THE DEALER WILL INSPECT AND REPLACE, IF NECESSARY, THE REAR BRAKE HOSES AT NO CHARGE TO OWNERS.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; REAR BRAKE HOSES.CONSEQUENCES OF DEFECT: A SEPARATION MAY RESULT IN A LOSS OF BRAKE FLUID AND APARTIAL LOSS OF BRAKING ACTION. A PARTIAL LOSS OF BRAKING ACTION COULD RESULTIN A VEHICLE CRASH IN SITUATIONS IN WHICH A MINIMUM STOPPING DISTANCE ISREQUIRED.
CHEVROLET: CELEBRITY: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
| NHTSA Campaign Number: | 83V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1983 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19821001 - 19830501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 352036 |
| Date Owner Notified By Manufacturer: | 19831020 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19831013 |
| Record Creation Date: | 19831021 |
Defect Summary:
THE BRAKE PROPORTIONER VALVES MAY BREAK AND SEPARATE FROM THE MASTER CYLINDER. THIS WOULD ALLOW BRAKE FLUID TO LEAK AND WOULD RESULT IN A PARTIAL LOSS OF THE BRAKE SYSTEM.
Corrective Summary:
THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE ALL SUSPECT VALVES.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; BRAKE PROPORTIONER VALVES.CONSEQUENCES OF DEFECT: SINCE THIS IS A DUAL BRAKE SYSTEM, PART OF THE SYSTEMWILL STILL WORK AND ALLOW THE VEHICLE TO BE STOPPED, BUT OVER A GREATERDISTANCE. PARTIAL LOSS OF THE BRAKING SYSTEM AT A TIME WHEN MINIMUM STOPPINGDISTANCE IS REQUIRED COULD RESULT IN A VEHICLE ACCIDENT WITHOUT PRIOR WARNING.
CHEVROLET: CELEBRITY: PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE
| NHTSA Campaign Number: | 83V092000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1983 |
| Manufacturer Component Description: | PARKING BRAKE:CONVENTIONAL:MECHANICAL:LINKAGE AND CABLE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19821201 - 19830101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 29 |
| Date Owner Notified By Manufacturer: | 19830920 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830914 |
| Record Creation Date: | 19831013 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 105 |
Defect Summary:
PARKING BRAKE CABLES CONTAIN INCORRECT SPRINGS. THESE SPRINGS FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC BRAKE SYSTEMS".
Corrective Summary:
DEALER WILL INSPECT AND INSTALL NEW REAR PARKING BRAKE CABLE IF NECESSARY.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: PARKING BRAKES; HYDRAULIC BRAKE SYSTEMS.CONSEQUENCES OF DEFECT: WHEN ADJUSTED TO PROPER SPECIFICATIONS, THE INCORRECTSPRINGS CAN CAUSE REAR BRAKE DRAG. THIS MAY RESULT IN POOR FUEL ECONOMY,PREMATURE LINING WEAR, OVERHEATING OF THE BRAKE DRUMS, AND GRABBING OR UNEVENBRAKE ACTION WHICH CAN CONTRIBUTE TO AN ACCIDENT.
CHEVROLET: CELEBRITY: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1984 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CELEBRITY: POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/LINKAGE
| NHTSA Campaign Number: | 84V052000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1984 |
| Manufacturer Component Description: | POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/LINKAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830801 - 19840101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 357 |
| Date Owner Notified By Manufacturer: | 19840427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840423 |
| Record Creation Date: | 19840508 |
Defect Summary:
THE VEHICLES WERE ASSEMBLED WITHOUT THE RETAINING CLIP WHICH IS NEEDED TO KEEP THE CLUTCH CABLE FROM CONTACTING THE MASTER CYLINDER BRAKE PIPE. OVER AN EXTENDED TIME, THE CLUTCH CABLE COULD RUB THROUGH THE MASTER CYLINDER BRAKE PIPE, RESULTING IN A BRAKE FLUID LEAK AND LOSS OF FRONT BRAKES.
Corrective Summary:
THE MISSING CLUTCH CABLE CLIP WILL BE INSTALLED AND THE BRAKE PIPE WILL BE REPLACED, IF NECESSARY, AT NO COST TO THE OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS.SYSTEM: POWER TRAIN; CLUTCH CABLE CLIP.CONSEQUENCES OF DEFECT: THE REMAINING PORTION OF THE DUAL BRAKING SYSTEM WILLENABLE THE VEHICLE TO STOP, BUT THE STOPPING DISTANCE WILL BE INCREASED WITHOUTPRIOR WARNING. THIS COULD RESULT IN AN ACCIDENT.
CHEVROLET: CELEBRITY: SEATS:FRONT ASSEMBLY:RECLINER
| NHTSA Campaign Number: | 84V011000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830701 - 19830901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 76586 |
| Date Owner Notified By Manufacturer: | 19840224 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840206 |
| Record Creation Date: | 19840222 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 207 |
Defect Summary:
SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Corrective Summary:
INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
CHEVROLET: CELEBRITY: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 85V034000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1984 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830801 - 19831201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121095 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850329 |
| Record Creation Date: | 19850401 |
Defect Summary:
THE FUEL SYSTEM MAY LEAK AT THE THROTTLE BODY INJECTION FUEL FEED PIPE CONNECTION. CONSEQUENCE OF DEFECT: THIS LEAKAGE COULD RESULT IN AN UNDERHOOD FIRE WHICH COULD SPREAD TO THE PASSENGER COMPARTMENT AND CAUSE BURN INJURIES TO OCCUPANTS.
Corrective Summary:
REPLACE THE FUEL FEED PIPE.
Notes:
VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH 2.5L L4 ENGINES.SYSTEM: FUEL.
CHEVROLET: CELEBRITY: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1985 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CELEBRITY: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 85V135000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1985 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19850101 - 19850501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 294 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851023 |
| Record Creation Date: | 19851104 |
Defect Summary:
CLUTCH CABLE IS NOT PROPERLY SECURED CAUSING THE CABLE TO CONTACT THE MASTER CYLINDER BRAKE PIPE. CONSEQUENCE OF DEFECT: OVER A PERIOD OF TIME THIS MAY CAUSE WEAR THROUGH, BRAKE FLUID LEAK AND PARTIAL LOSS OF BRAKING ACTION WHICH COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
SECURE CLUTCH CABLE TO PRECLUDE CONTACT WITH MASTER CYLINDER BRAKE PIPE. ALSO, REPLACE BRAKE PIPE IF IT SHOWS ANY SIGN OF WEAR.
Notes:
SYSTEM: CLUTCH CABLE AND MASTER CYLINDER BRAKE PIPE.VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH FOUR SPEED MANUAL TRANSMISSIONS.
CHEVROLET: CELEBRITY: VEHICLE SPEED CONTROL:SPRINGS
| NHTSA Campaign Number: | 84V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1985 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:SPRINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19840901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2130 |
| Date Owner Notified By Manufacturer: | 19841023 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19841016 |
| Record Creation Date: | 19841107 |
Defect Summary:
THE THROTTLE LINKAGE MAY BIND BECAUSE DURING NORMAL OPERATION, THE THROTTLE BODY CASE MAY INTERFERE WITH THE LINKAGE. THIS INTERFERENCE COULD PREVENT THE THROTTLE FROM CLOSING EVEN THOUGH THE DRIVER HAS REMOVED HIS FOOT FROM THE ACCELERATOR PEDAL.
Corrective Summary:
THE DEALER WILL INSPECT VEHICLES AND IMPROVE THE CLEARANCE BETWEEN THE ACCELERATOR LINKAGE AND THROTTLE BODY CASING IF NEEDED, AT NO CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 2.8 LITER MULTIPORT FUELINJECTED V6 ENGINES.SYSTEM: FUEL; THROTTLE LINKAGE.CONSEQUENCES OF DEFECT: LOSS OF ACCELERATOR CONTROL WITHOUT PRIOR WARNING COULDRESULT IN AN ACCIDENT.
CHEVROLET: CELEBRITY: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
| NHTSA Campaign Number: | 86V131000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860301 - 19860401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 106111 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860919 |
| Record Creation Date: | 19860930 |
Defect Summary:
THE PUSH PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS AND TRUCKS/ VANS.
CHEVROLET: CELEBRITY: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1986 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CELEBRITY: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
| NHTSA Campaign Number: | 86V056000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19850901 - 19851101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 93317 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860428 |
| Record Creation Date: | 19860501 |
Defect Summary:
THE PUSH-PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. NOTE: ALSO, SEE NHTSA CAMPAIGN NUMBER 86V131000.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS, TRUCKS AND VANS.
CHEVROLET: CELEBRITY: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CELEBRITY: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CELEBRITY: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 88V164000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19871001 - 19871101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27369 |
| Date Owner Notified By Manufacturer: | 19881215 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19881018 |
| Record Creation Date: | 19881028 |
Defect Summary:
FUEL FEED HOSE COULD LEAK AT THE COUPLING ON THE ENGINE END OF THE HOSE ASSEMBLY.
Consequence Summary:
FUEL LEAKAGE INTO THE ENGINE COMPARTMENT COULD RESULT INAN ENGINE COMPARTMENT FIRE THAT COULD SPREAD TO THE PASSENGER COMPARTMENT.
Corrective Summary:
INSTALL NEW FUEL FEED HOSE ASSEMBLY.
Notes:
SYSTEM: FUEL FEED HOSE.VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH A 2.8L V6 ENGINE.
CHEVROLET: CELEBRITY: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
| NHTSA Campaign Number: | 88V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1988 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19871101 - 19871101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3428 |
| Date Owner Notified By Manufacturer: | 19880420 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880401 |
| Record Creation Date: | 19880411 |
Defect Summary:
FRONT SUSPENSION LOWER CONTROL ARM BRACKET COULD DEVELOP METAL CRACKS.
Consequence Summary:
THESE CRACKS MAY RESULT IN DISENGAGEMENT OF THE LOWERCONTROL ARM. IF THIS OCCURS WHILE VEHICLE IS IN MOTION, IT COULD RESULT INLOSS OF STEERING CONTROL AND A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
INSPECT ALL VEHICLES AND REPLACE ENGINE CRADLE ASSEMBLY ON ALL SUSPECT VEHICLES.
Notes:
SYSTEM: SUSPENSION/LOWER CONTROL FRONT ARM BRACKET.VEHICLE DESCRIPTION: PASSENGER CAR
CHEVROLET: CELEBRITY: SEAT BELTS:FRONT:ANCHORAGE
| NHTSA Campaign Number: | 95V173000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880301 - 19900731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2216325 |
| Date Owner Notified By Manufacturer: | 19951019 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950915 |
| Record Creation Date: | 19950912 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
THESE VEHICLES WERE ASSEMBLED WITH REAR OUTBOARD SAFETY BELT ANCHORAGES THAT MAY NOT WITHSTAND THE REQUIRED LOAD. THIS DOES NOT COMPLY WITH FMVSS NO.210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: IN A COLLISON, STRESS CAN CAUSE THE ATTACHMENT METAL TO TEAR AND ALLOW THE ANCHORAGE TO SEPARATE FROM THE BODY OF THE VEHICLE. THE SAFETY BELT MAY NOT PROTECT AN OCCUPANT IN THE EVENT OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE EXISTING ANCHOR BOLTS WITH A NEW SHOULDER BOLT AND THREAD LOCKING ADHESIVE. ADDITIONALLY, NOISE CONTROL PATCHES WILL BE APPLIED AT EACH ANCHORAGE.
Notes:
SYSTEM: INTERIOR; ACTIVE RESTRAINTS; BELT ANCHOR AND ATTACHMENT; FMVSS NO.210.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; CHEVROLET AT 1-800-222-1020; PONTIAC AT 1-800-762-2737; OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CELEBRITY: SEATS:FRONT ASSEMBLY:RECLINER
| NHTSA Campaign Number: | 92V124000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890801 - 19910701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 319181 |
| Date Owner Notified By Manufacturer: | 19920924 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19920901 |
| Record Creation Date: | 19920904 |
Defect Summary:
THE POWER SEAT OR RECLINER WIRING HARNESS CAN BE PINCHED OR CAN CHAFE ON THE SEAT FRAME OR SPRING SUPPORT ROD, WEARING THROUGH THE WIRE INSULATION AND CAUSING AN ELECTRICAL SHORT.
Consequence Summary:
THE HIGH CURRENT CAUSED BY THE ELECTRICAL SHORT WELDS THECIRCUIT BREAKER ELEMENTS TOGETHER IN THE CLOSED POSITION, LEAVING THE CIRCUITUNPROTECTED AND GENERATING SUFFICIENT HEAT TO BURN THE WIRE INSULATION ANDIGNITE THE SEAT CUSHION MATERIAL.
Corrective Summary:
REPAIR ANY ABRADED WIRING AND REROUTE THE WIRING HARNESS USING A WIRING HARNESS CLIP.
Notes:
SYSTEM: INTERIOR: SEATING.VEHICLE DESCRIPTION: PASSENGER CARS WITH 6 WAY POWER SEATS OR POWER RECLINERS.
CHEVROLET: CELEBRITY: SEAT BELTS:FRONT:ANCHORAGE
| NHTSA Campaign Number: | 95V173000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CELEBRITY |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880301 - 19900731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2216325 |
| Date Owner Notified By Manufacturer: | 19951019 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950915 |
| Record Creation Date: | 19950912 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
THESE VEHICLES WERE ASSEMBLED WITH REAR OUTBOARD SAFETY BELT ANCHORAGES THAT MAY NOT WITHSTAND THE REQUIRED LOAD. THIS DOES NOT COMPLY WITH FMVSS NO.210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: IN A COLLISON, STRESS CAN CAUSE THE ATTACHMENT METAL TO TEAR AND ALLOW THE ANCHORAGE TO SEPARATE FROM THE BODY OF THE VEHICLE. THE SAFETY BELT MAY NOT PROTECT AN OCCUPANT IN THE EVENT OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE EXISTING ANCHOR BOLTS WITH A NEW SHOULDER BOLT AND THREAD LOCKING ADHESIVE. ADDITIONALLY, NOISE CONTROL PATCHES WILL BE APPLIED AT EACH ANCHORAGE.
Notes:
SYSTEM: INTERIOR; ACTIVE RESTRAINTS; BELT ANCHOR AND ATTACHMENT; FMVSS NO.210.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; CHEVROLET AT 1-800-222-1020; PONTIAC AT 1-800-762-2737; OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
--CHEVROLET: CHEVELLE: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
| NHTSA Campaign Number: | 76V160000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1966 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19650801 - 19660301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 811180 |
| Date Owner Notified By Manufacturer: | 19761007 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19761012 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO.66C12.BUICK CAMPAIGN NO.66C1.POSSIBILITY THAT THEFUEL INLET PLUG ON ROCHESTER QUADRAJET CARBURETOR MAY FAIL WHICH COULD RESULTIN ENGINE COMPARTMENT FIRE.THIS CONDITION, IF IT EXISTS, COULD CAUSE INJURYFROM FIRE OR FROM LOSS OF VEHICLE CONTROL.(CORRECT BY INSPECTING ANDINSTALLING A SPECIAL BRACKET ON THE CARBURETOR TO PREVENT LOSS OF FUEL INLETPLUG).PASSENGER VEHICLE.
-- --CHEVROLET: CHEVELLE: STEERING:WHEEL AND HANDLE BAR
| NHTSA Campaign Number: | 66V032001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1967 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 138878 |
| Date Owner Notified By Manufacturer: | 19661110 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19660119 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT STEERING SHAFT MAY HAVE BEEN IMPROPERLY INSTALLED.THIS COULD CAUSE A BINDING CONDITION WHICH, EVEN THOUGH NOT NOTICABLE TO THE OWNER ,MIGHT SUBJECT THE SHAFT TO ABNORMAL STRESSES UNDER CERTAIN CONDITIONS.SHOULD THESE STRESSES BE SEVERE ENOUGH OR EXTEND OVER A SUFFICIENT PERIOD OF TIME, THE STEERING SHAFT COULD BREAK WITH RESULTANT LOSS OF STEERING.(REPLACE ALL SHAFTS WITH IMPROVED DESIGN.)
--CHEVROLET: CHEVELLE: VEHICLE SPEED CONTROL
| NHTSA Campaign Number: | 68V085000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1968 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 310290 |
| Date Owner Notified By Manufacturer: | 19680909 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19680917 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT CARBURETOR THROTTLE LEVER MAY INTERFERE WITH THROTTLE RETAINING CLIP.IF THIS OCCURS, CAN CAUSE THROTTLE LEVER TO BE HELD PARTIALLY OPEN,PREVENTING ITS RETURN TO IDLE POSITION. POSSIBLE THIS WILL MAKE VEHICLE DIFFICULT TO STOP.(CORRECT WHERE NECESSARY WITH IMPROVED TYPE THROTTLE RODCLIP.)
--CHEVROLET: CHEVELLE: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
| NHTSA Campaign Number: | 68V003000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1968 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 382 |
| Date Owner Notified By Manufacturer: | 19680111 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19680112 |
| Record Creation Date: | 19791012 |
Notes:
VEHICLES EQUIPPED WITH POWER DISC BRAKE OPTION MAY HAVE BEEN ASSEMBLED WITH THE BRAKE PUSH ROD TO CLEVIS JAM LOCKNUT MISSING.THIS COULD CAUSE THREAD WEAR BETWEEN THE CLEVIS AND THE PUSH ROD AND IN EXTREME CASE COULD ALLOW THE BRAKE PEDAL TO BOTTOM ON THE FLOOR PAN BEFORE BRAKES ARE FULLY APPLIED.(CORRECT BY INSTALLING A JAM LOCK NUT.)
--CHEVROLET: CHEVELLE: VEHICLE SPEED CONTROL
| NHTSA Campaign Number: | 68V038000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1968 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 355 |
| Date Owner Notified By Manufacturer: | 19680418 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19680419 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT THE CRUISE MASTER ACCELERATOR CHAIN, WHICH CONTROLS THE CARBURETOR THROTTLE OPENING, COULD CATCH ON THE SECONDARY THROTTLE SHAFT.IF THIS OCCURS, THE THROTTLE WILL NOT RETURN THE ENGINE TO LOW SPEED OPERATION ANDTHE VEHICLE MAY BE DIFFICULT TO CONTROL.(CORRECT BY INSPECTION AND MAKING NECESSARY CORRECTION TO ACCELERATOR CHAIN.)
--CHEVROLET: CHEVELLE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 68V004000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1968 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 64913 |
| Date Owner Notified By Manufacturer: | 19680111 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19680112 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBLE INSUFFICIENT CLEARANCE BETWEEN THE BRAKE PIPE AND THE ENGINE OILPAN AND/OR TRANSMISSION OIL COOLER LINES.INTERFERENCE COULD CAUSE BRAKE LINE CHAFING AND WEAR THROUGH LINES.THIS WOULD RESULT IN LOSS OF FRONT WHEEL BRAKING ACTION.(CORRECT BY REFORMING BRAKE PIPE FOR ADEQUATE CLEARANCE.)
--CHEVROLET: CHEVELLE: EQUIPMENT:OTHER:LABELS
| NHTSA Campaign Number: | 70V032000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1970 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16712 |
| Date Owner Notified By Manufacturer: | 19700326 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19700403 |
| Record Creation Date: | 19791012 |
Notes:
INCORRECT TIRE-INFORMATION DECAL MAY HAVE BEEN INSTALLED.(CORRECT BYINSTALLING WHERE NECESSARY.)
--CHEVROLET: CHEVELLE: VEHICLE SPEED CONTROL
| NHTSA Campaign Number: | 70V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1971 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12600 |
| Date Owner Notified By Manufacturer: | 19701125 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19701203 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT THROTTLE ROD TO THROTTLE LEVER RETAINING CLIP ON CARBURETORMAY BE INCORRECTLY INSTALLED.IF THIS CONDITION EXISTS, THROTTLE LEVER COULDBE HELD IN PARTIALLY OPEN POSITION.IF THIS OCCURS WHILE VEHICLE IS IN MOTION,VEHICLE WILL NOT SLOW DOWN WHEN DRIVER'S FOOT IS REMOVED FROM ACCELERATOR.(CORRECT BY REPLACING CLIP WITH IMPROVED DESIGN WHERE NECESSARY.)
--CHEVROLET: CHEVELLE: SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
| NHTSA Campaign Number: | 72V303000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1973 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WARNING LIGHT/DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 693 |
| Date Owner Notified By Manufacturer: | 19721206 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19721211 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 73-C-05.POSSIBILITY THAT SEAT BELT WARNING SYSTEMMAY BE RENDERED INOPERATIVE DUE TO MISMATING OF RELAY JUMPER WIRE ASSEMBLY ATPARKING BRAKE ALARM SWITCH.(CORRECT BY INSPECTING AND INSTALLING JUMPER WIREWITH TERMINAL AND CONNECTORS THAT MATE PROPERLY.)
--CHEVROLET: CHEVELLE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
| NHTSA Campaign Number: | 73V152000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720801 - 19730601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3094 |
| Date Owner Notified By Manufacturer: | 19730712 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730716 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO.73-C-15, PONTIAC CAMPAIGN NO 73-C-6, BUICK CAMPAIGN NO73-C-2, GMC CAMPAIGN NO 73-C-20.POSSIBILITY THAT THE GASKET BETWEEN THEMASTER CYLINDER AND THEFORWARD SIDE OF THE DASH, AND THE BOOT WHICH COVERS THEREAR OPENING OF THE MASTER CYLINDER IN THE DRIVER'S COMPARTMENT WEREOMITTED INASSEMBLY.IF THIS CONDITION EXISTS IT COULD CAUSE CORROSION OF THE CYLINDERBORE AND DAMAGE PISTON SEAL RESULTINGIN LOSS OF BRAKE FLUID AND IMPAIREDBRAKING.(CORRECT BY INSPECTING AND REPLACING GASKET AND BOOT.)
--CHEVROLET: CHEVELLE: STEERING:LINKAGES
| NHTSA Campaign Number: | 72V275000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1973 |
| Manufacturer Component Description: | STEERING:LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720801 - 19720901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 155418 |
| Date Owner Notified By Manufacturer: | 19721110 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19721114 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO (CHEVROLET 73-C-03, PONTIAC 73-C-1, BUICK 73-C-1,OLDSMOBILE 73-C-2, AND GMC 73-C-1).POSSIBILITY THAT STEERING LINKAGE MAYOVER-TRAVEL AND CAUSE SEVERE FRONT WHEEL TOE-IN.CONDITION CAN OCCUR WHENSTEERING WHEEL IS TURNED TO EXTREME LEFT POSITION WHILE VEHICLE IS IN REVERSEAND RIGHT FRONT TIRE STRIKES OBJECT SUCH AS CURB OR PARKING BLOCK.OPERATIONOF VEHICLE IN THIS CONDITION CAN DAMAGE RIGHT HAND INNER TIE ROD END ASSEMBLYWHICH EVENTUALLY COULD RESULT IN LOSS OF STEERING CONTROL OF RIGHT FRONT WHEEL.(CORRECT BY INSPECTING AND INSTALLING IDLER ARM STOP BRACKET WHERE NECESSARY.)
--CHEVROLET: CHEVELLE: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
| NHTSA Campaign Number: | 73V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1974 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 782111 |
| Date Owner Notified By Manufacturer: | 19740109 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731227 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 74-C-09.PONTIAC 74-C-2.BUICK 74-C-2.OLDSMOBILE74-C-3.SPRINT 74-C-4.POSSIBILITY THAT THE FRONT UPPER CONTROL ARM INNERBUSHING RETAINER NUTS MAY LOOSEN AND COME OFF DURING NORMAL OPERATINGCONDITIONS.SHOULD THIS OCCUR, THE LOOSE CONTROL ARM MAY MOVE FORWARD ANDCONTACT THE UPPER CONTROL ARM MOUNTING BRACKET ON THE FRAME WHICH RESTRICTS ANYFURTHER FORWARD MOVEMENT.IF THIS VEHICLE IS OPERATED IN THIS CONDITION IT ISPOSSIBLE FOR THE CONTROL ARM CROSS SHAFT TO BREAK.(CORRECT BY INSPECTING ANDINSTALLING NEW BUSHING RETAINERS WHERE NECESSARY.)
--CHEVROLET: CHEVELLE: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
| NHTSA Campaign Number: | 75V032000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1975 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 220982 |
| Date Owner Notified By Manufacturer: | 19750220 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19750219 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE AND BUICK CAMPAIGN NO 75-C-7.CHEVROLET CAMPAIGN NO 75-C-08.PONTIAC CAMPAIGN NO 75-C-9.DATES OF MANUFACTURE FOR CHEVROLET, BUICK,OLDSMOBILE AND GMC ARE SEPT THRU NOV 1974.PONTIAC DATES ARE SEPT 1974 THRUJAN 1975.NO STATION WAGONS ARE INVOLVED.POSSIBILITY THAT THE REAR AXLE WASASSEMBLED WITH REAR AXLE SHAFT OUTER BEARING (REAR WHEEL BEARING) WITH THRUSTPLATES THAT WERE NOT HEAT TREATED.IF THE INNER OR OUTER THRUST PLATES OFTHESE BEARINGS ARE NOT HARDENED, THE ROLLERS CAN WEAR THROUGH AND ALLOW THEREAR AXLE SHAFT TO MOVE WITH RESPECT TO AXLE HOUSING.(CORRECT BY INSPECTINGAND REPLACING AXLE ASSEMBLIES WHERE NECESSARY.)
--CHEVROLET: CHEVELLE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
| NHTSA Campaign Number: | 76V038000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16 |
| Date Owner Notified By Manufacturer: | 19760315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760311 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C09.POSSIBILITY THAT THE SERVICE BRAKE SYSTEM DOESNOT COMPLY WITH BRAKE PERFORMANCE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETYSTANDARD 105.THE FAILURE TO COMPLY IS DUE TO INSTALLATION OF INCORRECT BRAKECOMBINATION VALVE.IF THIS CONDITION EXISTS, IT WILL DECREASE THE STOPPINGABILITY AND COULD RESULT IN VEHICLE CRASH WITHOUT PRIOR WARNING IN A SITUATIONREQUIRING MINIMUM STOPPING DISTANCE.(CORRECT BY INSPECTING AND REPLACINGVALVE WHERE NECESSARY).
--CHEVROLET: CHEVELLE: STEERING:WHEEL AND HANDLE BAR
| NHTSA Campaign Number: | 76V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVELLE |
| Model Year: | 1977 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55564 |
| Date Owner Notified By Manufacturer: | 19760830 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760907 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 77-C-1.POSSIBILITY THAT THE STEERING INTERMEDIATESHAFT MAY HAVE BEEN ASSEMBLED WITH COUPLING RETAINER LOCKING TABS NOT BENT OVERPROPERLY OR ONE OR MORE OF THE LOWER FLEXIBLE COUPLING RIVETS IMPROPERLYPEENED.IF EITHER OF THESE CONDITIONS EXISTS, THE INTERMEDIATE SHAFT ASSEMBLYCOULD SEPARATE CAUSING LOSS OF STEERING CONTROL, AND VEHICLE CRASH MAY OCCURWITHOUT PRIOR WARNING.(CORRECT BY INSPECTING, AND REPLACING SHAFT WHERENECESSARY).PASSENGER VEHICLE.
-- --CHEVROLET: CHEVETTE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 76V022000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 66276 |
| Date Owner Notified By Manufacturer: | 19760228 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760212 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C06.POSSIBILITY FOR ONE OR BOTH OF THE FRONT BRAKEHOSES TO BECOME HOOKED ON THE REAR END OF THE UPPER CONTROL ARM CROSS SHAFTWHICH IS PART OF THE FRONT WHEEL SUSPENSION.IF THIS OCCURS, THE HOSE WILL RUBAGAINST THE END OF THE CROSS SHAFT WHICH CAN EVENTUALLY RESULT IN RUPTURE OFBRAKE HOSE, LOSS OF BRAKE FLUID AND CONSEQUENT LOSS OF FRONT BRAKES.(CORRECTBY INSPECTING AND REPLACING HOSE WHERE NECESSARY.ALSO INSTALL A SHIELD ONREAR END OF BOTH RIGHT AND LEFT UPPER CONTROL ARM CROSS SHAFTS TO PREVENT HOSEFROM BECOMING HOOKED).
--CHEVROLET: CHEVETTE: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
| NHTSA Campaign Number: | 76V197000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1976 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 174769 |
| Date Owner Notified By Manufacturer: | 19761209 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19761206 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 301 |
Notes:
POSSIBILITY THAT THE FUEL TANK CAP MAY NOT SEAL PROPERLY ON FILLER NECK.THISCONDITION CAN RESULT IN EXCESS FUEL SPILLAGE DURING THE FEDERAL MOTOR VEHICLESAFETY STANDARD 301 TEST. (CORRECT BY INSPECTING AND INSTALLING A THICKER ORING CAP SEAL.)
--CHEVROLET: CHEVETTE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 75V175000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4107 |
| Date Owner Notified By Manufacturer: | 19750924 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19750926 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76-C-01.POSSIBILITY THAT THE RIGHT REAR BRAKE PIPE ATTHE CONNECTOR TO THE JUNCTION BLOCK LOCATED ON THE REAR AXLE DIFFERENTIAL COVERMAY BE SUBJECT TO FATIGUE FAILURE.ON BUMPY TERRAIN, IT IS POSSIBLE FOR THEBRAKE PIPE TO VIBRATE AND FAIL (CRACK OR BREAK) ALLOWING LOSS OF HYDRAULICBRAKE FLUID AND REAR BRAKING ACTION.IF THIS CONDITION EXISTS IT COULD RESULTIN VEHICLE CRASH DUE TO INCREASED NORMAL STOPPING DISTANCE.(CORRECT BYINSPECTING AND ADDING AN ADDITIONAL RETAINING CLIP).
--CHEVROLET: CHEVETTE: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
| NHTSA Campaign Number: | 78V248000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1976 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19750901 - 19770701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 320000 |
| Date Owner Notified By Manufacturer: | 19790402 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19781116 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 301 |
Defect Summary:
THE FUEL SYSTEM MAY NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY". IN THE EVENT OF A VEHICLE COLLISION FROM THE REAR, EXCESSIVE FUEL SPILLAGE MAY OCCUR.
Corrective Summary:
DEALER WILL INSTALL PLASTIC SHIELDS AROUND THE FRONT CORNERS OF THE FUEL TANK, AND LARGER WASHERS ON CERTAIN REAR SUSPENSION PARTS TO ENSURE COMPLIANCE WITH THE SAFETY STANDARD. THIS WILL BE PERFORMED WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: FUEL; FUEL TANK ASSEMBLY.CONSEQUENCES OF DEFECT: FUEL LEAKAGE FOLLOWING AN IMPACT COULD LEAD TO AVEHICLE FIRE AND SERIOUS INJURIES TO PASSENGERS.
--CHEVROLET: CHEVETTE: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
| NHTSA Campaign Number: | 78V248000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1977 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19750901 - 19770701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 320000 |
| Date Owner Notified By Manufacturer: | 19790402 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19781116 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 301 |
Defect Summary:
THE FUEL SYSTEM MAY NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY". IN THE EVENT OF A VEHICLE COLLISION FROM THE REAR, EXCESSIVE FUEL SPILLAGE MAY OCCUR.
Corrective Summary:
DEALER WILL INSTALL PLASTIC SHIELDS AROUND THE FRONT CORNERS OF THE FUEL TANK, AND LARGER WASHERS ON CERTAIN REAR SUSPENSION PARTS TO ENSURE COMPLIANCE WITH THE SAFETY STANDARD. THIS WILL BE PERFORMED WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: FUEL; FUEL TANK ASSEMBLY.CONSEQUENCES OF DEFECT: FUEL LEAKAGE FOLLOWING AN IMPACT COULD LEAD TO AVEHICLE FIRE AND SERIOUS INJURIES TO PASSENGERS.
--CHEVROLET: CHEVETTE: SEAT BELTS:FRONT:RETRACTOR
| NHTSA Campaign Number: | 81V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1980 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:RETRACTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19800801 - 19800901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55238 |
| Date Owner Notified By Manufacturer: | 19810528 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810519 |
| Record Creation Date: | 19810602 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
ON CERTAIN VEHICLES, THE SEAT BELT RETRACTORS IN THE REAR SEATING POSITIONS CONTAIN FIRST LOCK POSITIONS WHICH WILL NOT LOCK WHEN USED BY SMALLER PASSENGERS. THIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION".
Corrective Summary:
ALL OWNERS WILL BE SENT A PRE-PAID POSTAGE CARD THAT IS TO BE FILLED OUT AND SENT BACK. THE CARD WILL INDICATE WHETHER THE SEAT BELTS ARE FUNCTIONING PROPERLY. IF DEALER INSPECTS SEAT BELTS, THE SEAT BELT RETRACTORS WILL BE REPLACED, IF NECESSARY, WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: INTERIOR; SEAT BELT RETRACTORS.CONSEQUENCES OF DEFECT: IN THE EVENT OF A COLLISION, IF PASSENGERS ARE NOTSECURELY RESTRAINED, THE POSSIBILITY OF PERSONAL INJURY AND DEATH WOULD BEINCREASED.
--CHEVROLET: CHEVETTE: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
| NHTSA Campaign Number: | 83V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1980 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790801 - 19810701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 491736 |
| Date Owner Notified By Manufacturer: | 19821112 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830304 |
| Record Creation Date: | 19830311 |
Defect Summary:
THE CARBURETOR FUEL PLUG MAY COME OUT AND FUEL COULD LEAK FROM THE CARBURETOR.
Corrective Summary:
THE DEALER WILL INSTALL A RETAINING CLIP ON THE CARBURETOR INLET PLUG TO PREVENT IT FROM DISLODGING, AT NO CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.6 LITER ENGINES ANDCALIFORNIA EMISSION SYSTEMS.SYSTEM: FUEL SYSTEMS, CARBURETOR FUEL INLET HOUSING PLUG.CONSEQUENCES OF DEFECT: WHEN A FUEL LEAK OCCURS IN THE PRESENCE OF A SOURCE OFIGNITION, A FIRE COULD OCCUR WITHOUT WARNING.
--CHEVROLET: CHEVETTE: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
| NHTSA Campaign Number: | 82V106000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1980 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19791001 - 19820301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 106651 |
| Date Owner Notified By Manufacturer: | 19821112 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19821101 |
| Record Creation Date: | 19821103 |
Defect Summary:
THE CARBURETOR FUEL INLET HOUSING PLUG IN THE SIDE OF THE CARBURETOR MAY COME OUT.
Corrective Summary:
THE DEALER WILL INSTALL A RETAINING CLIP ON THE CARBURETOR INLET PLUG TO PREVENT FUEL LEAKAGE, WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.6 LITER ENGINES.SYSTEM: FUEL; CARBURETOR FUEL INLET PLUG.CONSEQUENCES OF DEFECT: FUEL WOULD LEAK FROM THE CARBURETOR AND, UNDER CERTAINCIRCUMSTANCES COULD START AN UNDERHOOD FIRE WHICH COULD SPREAD TO THE REST OFTHE VEHICLE. THIS COULD CAUSE BURN INJURIES TO VEHICLE PASSENGERS.
--CHEVROLET: CHEVETTE: SEAT BELTS:FRONT:RETRACTOR
| NHTSA Campaign Number: | 81V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1981 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:RETRACTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19800801 - 19800901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55238 |
| Date Owner Notified By Manufacturer: | 19810528 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810519 |
| Record Creation Date: | 19810602 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
ON CERTAIN VEHICLES, THE SEAT BELT RETRACTORS IN THE REAR SEATING POSITIONS CONTAIN FIRST LOCK POSITIONS WHICH WILL NOT LOCK WHEN USED BY SMALLER PASSENGERS. THIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION".
Corrective Summary:
ALL OWNERS WILL BE SENT A PRE-PAID POSTAGE CARD THAT IS TO BE FILLED OUT AND SENT BACK. THE CARD WILL INDICATE WHETHER THE SEAT BELTS ARE FUNCTIONING PROPERLY. IF DEALER INSPECTS SEAT BELTS, THE SEAT BELT RETRACTORS WILL BE REPLACED, IF NECESSARY, WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: INTERIOR; SEAT BELT RETRACTORS.CONSEQUENCES OF DEFECT: IN THE EVENT OF A COLLISION, IF PASSENGERS ARE NOTSECURELY RESTRAINED, THE POSSIBILITY OF PERSONAL INJURY AND DEATH WOULD BEINCREASED.
--CHEVROLET: CHEVETTE: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
| NHTSA Campaign Number: | 83V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1981 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790801 - 19810701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 491736 |
| Date Owner Notified By Manufacturer: | 19821112 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830304 |
| Record Creation Date: | 19830311 |
Defect Summary:
THE CARBURETOR FUEL PLUG MAY COME OUT AND FUEL COULD LEAK FROM THE CARBURETOR.
Corrective Summary:
THE DEALER WILL INSTALL A RETAINING CLIP ON THE CARBURETOR INLET PLUG TO PREVENT IT FROM DISLODGING, AT NO CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.6 LITER ENGINES ANDCALIFORNIA EMISSION SYSTEMS.SYSTEM: FUEL SYSTEMS, CARBURETOR FUEL INLET HOUSING PLUG.CONSEQUENCES OF DEFECT: WHEN A FUEL LEAK OCCURS IN THE PRESENCE OF A SOURCE OFIGNITION, A FIRE COULD OCCUR WITHOUT WARNING.
--CHEVROLET: CHEVETTE: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
| NHTSA Campaign Number: | 82V106000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1981 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19791001 - 19820301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 106651 |
| Date Owner Notified By Manufacturer: | 19821112 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19821101 |
| Record Creation Date: | 19821103 |
Defect Summary:
THE CARBURETOR FUEL INLET HOUSING PLUG IN THE SIDE OF THE CARBURETOR MAY COME OUT.
Corrective Summary:
THE DEALER WILL INSTALL A RETAINING CLIP ON THE CARBURETOR INLET PLUG TO PREVENT FUEL LEAKAGE, WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.6 LITER ENGINES.SYSTEM: FUEL; CARBURETOR FUEL INLET PLUG.CONSEQUENCES OF DEFECT: FUEL WOULD LEAK FROM THE CARBURETOR AND, UNDER CERTAINCIRCUMSTANCES COULD START AN UNDERHOOD FIRE WHICH COULD SPREAD TO THE REST OFTHE VEHICLE. THIS COULD CAUSE BURN INJURIES TO VEHICLE PASSENGERS.
--CHEVROLET: CHEVETTE: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
| NHTSA Campaign Number: | 83V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1982 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790801 - 19810701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 491736 |
| Date Owner Notified By Manufacturer: | 19821112 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830304 |
| Record Creation Date: | 19830311 |
Defect Summary:
THE CARBURETOR FUEL PLUG MAY COME OUT AND FUEL COULD LEAK FROM THE CARBURETOR.
Corrective Summary:
THE DEALER WILL INSTALL A RETAINING CLIP ON THE CARBURETOR INLET PLUG TO PREVENT IT FROM DISLODGING, AT NO CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.6 LITER ENGINES ANDCALIFORNIA EMISSION SYSTEMS.SYSTEM: FUEL SYSTEMS, CARBURETOR FUEL INLET HOUSING PLUG.CONSEQUENCES OF DEFECT: WHEN A FUEL LEAK OCCURS IN THE PRESENCE OF A SOURCE OFIGNITION, A FIRE COULD OCCUR WITHOUT WARNING.
--CHEVROLET: CHEVETTE: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
| NHTSA Campaign Number: | 82V106000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1982 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19791001 - 19820301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 106651 |
| Date Owner Notified By Manufacturer: | 19821112 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19821101 |
| Record Creation Date: | 19821103 |
Defect Summary:
THE CARBURETOR FUEL INLET HOUSING PLUG IN THE SIDE OF THE CARBURETOR MAY COME OUT.
Corrective Summary:
THE DEALER WILL INSTALL A RETAINING CLIP ON THE CARBURETOR INLET PLUG TO PREVENT FUEL LEAKAGE, WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.6 LITER ENGINES.SYSTEM: FUEL; CARBURETOR FUEL INLET PLUG.CONSEQUENCES OF DEFECT: FUEL WOULD LEAK FROM THE CARBURETOR AND, UNDER CERTAINCIRCUMSTANCES COULD START AN UNDERHOOD FIRE WHICH COULD SPREAD TO THE REST OFTHE VEHICLE. THIS COULD CAUSE BURN INJURIES TO VEHICLE PASSENGERS.
--CHEVROLET: CHEVETTE: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
| NHTSA Campaign Number: | 88V050000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1983 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820701 - 19851201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 370831 |
| Date Owner Notified By Manufacturer: | 19880411 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880404 |
| Record Creation Date: | 19880412 |
Defect Summary:
THE AUTOMATIC TRANSMISSION SHIFT LEVER BUTTON MECHANISM MAY WEAR TO THE POINT THAT THE BUTTON ON THE SHIFT LEVER NO LONGER NEEDS TO BE DEPRESSED TO SHIFT GEARS.
Consequence Summary:
A LEVER WITH THIS CONDITION COULD BE INADVERTENTLY BUMPEDOR MOVED FROM DRIVE TO REVERSE BY THE DRIVER OR A PASSENGER WHILE THE VEHICLEIS BEING DRIVEN. A SUDDEN UNEXPECTED SHIFTING COULD CAUSE LOSS OF VEHICLECONTROL AND A VEHICLE CRASH.
Corrective Summary:
A NEWLY DESIGNED TRANSMISSION SHIFT LEVER WILL BE INSTALLED ON ALL VEHICLES.
Notes:
SYSTEM: TRANSMISSION/SHIFT LEVER.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: CHEVETTE: SEATS:FRONT ASSEMBLY:RECLINER
| NHTSA Campaign Number: | 84V011000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830701 - 19830901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 76586 |
| Date Owner Notified By Manufacturer: | 19840224 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840206 |
| Record Creation Date: | 19840222 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 207 |
Defect Summary:
SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Corrective Summary:
INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
--CHEVROLET: CHEVETTE: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
| NHTSA Campaign Number: | 88V050000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1984 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820701 - 19851201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 370831 |
| Date Owner Notified By Manufacturer: | 19880411 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880404 |
| Record Creation Date: | 19880412 |
Defect Summary:
THE AUTOMATIC TRANSMISSION SHIFT LEVER BUTTON MECHANISM MAY WEAR TO THE POINT THAT THE BUTTON ON THE SHIFT LEVER NO LONGER NEEDS TO BE DEPRESSED TO SHIFT GEARS.
Consequence Summary:
A LEVER WITH THIS CONDITION COULD BE INADVERTENTLY BUMPEDOR MOVED FROM DRIVE TO REVERSE BY THE DRIVER OR A PASSENGER WHILE THE VEHICLEIS BEING DRIVEN. A SUDDEN UNEXPECTED SHIFTING COULD CAUSE LOSS OF VEHICLECONTROL AND A VEHICLE CRASH.
Corrective Summary:
A NEWLY DESIGNED TRANSMISSION SHIFT LEVER WILL BE INSTALLED ON ALL VEHICLES.
Notes:
SYSTEM: TRANSMISSION/SHIFT LEVER.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: CHEVETTE: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
| NHTSA Campaign Number: | 88V050000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1985 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820701 - 19851201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 370831 |
| Date Owner Notified By Manufacturer: | 19880411 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880404 |
| Record Creation Date: | 19880412 |
Defect Summary:
THE AUTOMATIC TRANSMISSION SHIFT LEVER BUTTON MECHANISM MAY WEAR TO THE POINT THAT THE BUTTON ON THE SHIFT LEVER NO LONGER NEEDS TO BE DEPRESSED TO SHIFT GEARS.
Consequence Summary:
A LEVER WITH THIS CONDITION COULD BE INADVERTENTLY BUMPEDOR MOVED FROM DRIVE TO REVERSE BY THE DRIVER OR A PASSENGER WHILE THE VEHICLEIS BEING DRIVEN. A SUDDEN UNEXPECTED SHIFTING COULD CAUSE LOSS OF VEHICLECONTROL AND A VEHICLE CRASH.
Corrective Summary:
A NEWLY DESIGNED TRANSMISSION SHIFT LEVER WILL BE INSTALLED ON ALL VEHICLES.
Notes:
SYSTEM: TRANSMISSION/SHIFT LEVER.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: CHEVETTE: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
| NHTSA Campaign Number: | 86V131000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860301 - 19860401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 106111 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860919 |
| Record Creation Date: | 19860930 |
Defect Summary:
THE PUSH PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS AND TRUCKS/ VANS.
--CHEVROLET: CHEVETTE: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
| NHTSA Campaign Number: | 86V056000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19850901 - 19851101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 93317 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860428 |
| Record Creation Date: | 19860501 |
Defect Summary:
THE PUSH-PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. NOTE: ALSO, SEE NHTSA CAMPAIGN NUMBER 86V131000.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS, TRUCKS AND VANS.
--CHEVROLET: CHEVETTE: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
| NHTSA Campaign Number: | 88V050000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CHEVETTE |
| Model Year: | 1986 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820701 - 19851201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 370831 |
| Date Owner Notified By Manufacturer: | 19880411 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880404 |
| Record Creation Date: | 19880412 |
Defect Summary:
THE AUTOMATIC TRANSMISSION SHIFT LEVER BUTTON MECHANISM MAY WEAR TO THE POINT THAT THE BUTTON ON THE SHIFT LEVER NO LONGER NEEDS TO BE DEPRESSED TO SHIFT GEARS.
Consequence Summary:
A LEVER WITH THIS CONDITION COULD BE INADVERTENTLY BUMPEDOR MOVED FROM DRIVE TO REVERSE BY THE DRIVER OR A PASSENGER WHILE THE VEHICLEIS BEING DRIVEN. A SUDDEN UNEXPECTED SHIFTING COULD CAUSE LOSS OF VEHICLECONTROL AND A VEHICLE CRASH.
Corrective Summary:
A NEWLY DESIGNED TRANSMISSION SHIFT LEVER WILL BE INSTALLED ON ALL VEHICLES.
Notes:
SYSTEM: TRANSMISSION/SHIFT LEVER.VEHICLE DESCRIPTION: PASSENGER CARS.
-- --CHEVROLET: COBALT: EXTERIOR LIGHTING:HEADLIGHTS
| NHTSA Campaign Number: | 04V560000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 4100 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040801 - 20041130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1378 |
| Date Owner Notified By Manufacturer: | 20041117 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20041122 |
| Record Creation Date: | 20041123 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence Summary:
THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04100.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
--CHEVROLET: COBALT: STRUCTURE
| NHTSA Campaign Number: | 07V014000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 6217 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040901 - 20050630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 98707 |
| Date Owner Notified By Manufacturer: | 20070321 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20070118 |
| Record Creation Date: | 20070119 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence Summary:
IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Corrective Summary:
DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 06217. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: COBALT: STEERING:ELECTRIC POWER ASSIST SYSTEM
| NHTSA Campaign Number: | 10V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | N100023 |
| Manufacturer Component Description: | STEERING:ELECTRIC POWER ASSIST SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1050889 |
| Date Owner Notified By Manufacturer: | 20100329 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100303 |
| Record Creation Date: | 20100303 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence Summary:
IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM'S RECALL NO. N100023.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COBALT: STRUCTURE
| NHTSA Campaign Number: | 07V014000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 6217 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050401 - 20060331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 98707 |
| Date Owner Notified By Manufacturer: | 20070321 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20070118 |
| Record Creation Date: | 20070119 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence Summary:
IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Corrective Summary:
DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 06217. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: COBALT: STEERING:ELECTRIC POWER ASSIST SYSTEM
| NHTSA Campaign Number: | 10V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | N100023 |
| Manufacturer Component Description: | STEERING:ELECTRIC POWER ASSIST SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1050889 |
| Date Owner Notified By Manufacturer: | 20100329 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100303 |
| Record Creation Date: | 20100303 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence Summary:
IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM'S RECALL NO. N100023.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COBALT: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
| NHTSA Campaign Number: | 09V419000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 90226 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050401 - 20060630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 69139 |
| Date Owner Notified By Manufacturer: | 20100204 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20091029 |
| Record Creation Date: | 20091029 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence Summary:
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 090226.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COBALT: STEERING:ELECTRIC POWER ASSIST SYSTEM
| NHTSA Campaign Number: | 10V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | N100023 |
| Manufacturer Component Description: | STEERING:ELECTRIC POWER ASSIST SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1050889 |
| Date Owner Notified By Manufacturer: | 20100329 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100303 |
| Record Creation Date: | 20100303 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence Summary:
IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM'S RECALL NO. N100023.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COBALT: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
| NHTSA Campaign Number: | 09V419000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 90226 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20060401 - 20070330 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 69139 |
| Date Owner Notified By Manufacturer: | 20100204 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20091029 |
| Record Creation Date: | 20091029 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence Summary:
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 090226.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COBALT: STEERING:ELECTRIC POWER ASSIST SYSTEM
| NHTSA Campaign Number: | 10V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | N100023 |
| Manufacturer Component Description: | STEERING:ELECTRIC POWER ASSIST SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1050889 |
| Date Owner Notified By Manufacturer: | 20100329 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100303 |
| Record Creation Date: | 20100303 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence Summary:
IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM'S RECALL NO. N100023.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COBALT: STEERING:ELECTRIC POWER ASSIST SYSTEM
| NHTSA Campaign Number: | 10V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | N100023 |
| Manufacturer Component Description: | STEERING:ELECTRIC POWER ASSIST SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1050889 |
| Date Owner Notified By Manufacturer: | 20100329 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100303 |
| Record Creation Date: | 20100303 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence Summary:
IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM'S RECALL NO. N100023.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COBALT: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
| NHTSA Campaign Number: | 09V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 9041 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 276729 |
| Date Owner Notified By Manufacturer: | 20090315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090306 |
| Record Creation Date: | 20090306 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 102 & 114 |
Defect Summary:
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GENERAL MOTORS RECALL NO. 09041.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COBALT: STEERING:ELECTRIC POWER ASSIST SYSTEM
| NHTSA Campaign Number: | 10V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COBALT |
| Model Year: | 2010 |
| Manufacturer Campaign Number: | N100023 |
| Manufacturer Component Description: | STEERING:ELECTRIC POWER ASSIST SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1050889 |
| Date Owner Notified By Manufacturer: | 20100329 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100303 |
| Record Creation Date: | 20100303 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence Summary:
IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM'S RECALL NO. N100023.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
-- --CHEVROLET: COLORADO: VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
| NHTSA Campaign Number: | 11V276000 |
| Vehicle/Equipment Make: | GENERAL MOTORS LLC |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 11095 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20100922 - 20101105 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4674 |
| Date Owner Notified By Manufacturer: | 20110513 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS LLC |
| Report Received Date: | 20110506 |
| Record Creation Date: | 20110506 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET COLORADO AND GMC CANYON VEHICLES MANUFACTURED FROM SEPTEMBER 22, 2010, THROUGH NOVEMBER 5, 2010. SOME OF THESE VEHICLES HAVE THE CONDITION IN WHICH THE WINDSHIELD WIPER MOTOR CRANK ARM NUT MAY NOT BE TIGHTENED TO SPECIFICATION. WHEN THE WIPERS ARE OPERATED WITH A BUILD-UP OF SNOW OR ICE, OR IF THE WIPERS ARE OPERATED ON A DRY WINDSHIELD, THE NUT COULD LOOSEN. IF THERE IS SUFFICIENT LOOSENING OF THE NUT, THE WIPERS COULD BECOME INOPERATIVE.
Consequence Summary:
DRIVER VISIBILITY COULD BE REDUCED INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL SECURE THE WIPER MOTOR CRANK ARM NUT FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE MAY 11, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 OR WWW.GMOWNERCENTER.COM.
Notes:
GM'S SAFETY RECALL NO. 11095.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: CHILD SEAT
| NHTSA Campaign Number: | 10V575000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 10367 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 192676 |
| Date Owner Notified By Manufacturer: | 20101214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101118 |
| Record Creation Date: | 20101119 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence Summary:
BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Corrective Summary:
DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 10367 AND/OR 10407.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
| NHTSA Campaign Number: | 11V337000 |
| Vehicle/Equipment Make: | GENERAL MOTORS LLC |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 11181 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20110221 - 20110511 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6768 |
| Date Owner Notified By Manufacturer: | 20110719 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS LLC |
| Report Received Date: | 20110628 |
| Record Creation Date: | 20110628 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 102 & 114 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET COLORADO AND GMC CANYON PASSENGER VEHICLES EQUIPPED WITH A 2.9 OR 3.7 LITER ENGINE AND A FOUR-SPEED AUTOMATIC TRANSMISSION FOR FAILING TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT," AND FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES MAY HAVE BEEN BUILT WITH AN AUTOMATIC TRANSMISSION ADJUSTMENT CLIP THAT MAY NOT RETAIN THE SHIFT CABLE IN THE CORRECT POSITION. IF THE SHIFT CABLE IS NOT IN THE CORRECT POSITION, THE PRNDL SHIFT LEVER MAY NOT ACCURATELY REFLECT THE POSITION OF THE TRANSMISSION GEAR. THE DRIVER COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK."
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE, AND THE VEHICLE COULD ROLL AWAY AS THE DRIVER OR OTHER OCCUPANTS EXIT THE VEHICLE OR HAVE EXITED, RESULTING IN THE POSSIBILITY OF THE VEHICLE STRIKING THEM OR SOMEONE AROUND THE VEHICLE, OR COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
GM DEALERS WILL INSTALL A NEW AUTOMATIC TRANSMISSION ADJUSTMENT CLIP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 19, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Notes:
GM'S SAFETY RECALL NO. 11181.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: SUSPENSION:REAR:AXLE:SPINDLE
| NHTSA Campaign Number: | 11V007000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 10426A |
| Manufacturer Component Description: | SUSPENSION:REAR:AXLE:SPINDLE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20101201 - 20110103 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 30566 |
| Date Owner Notified By Manufacturer: | 20110111 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20110106 |
| Record Creation Date: | 20110111 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
THIS RECALL CAMPAIGN IS AN EXPANSION TO 10V-643.GM'S SAFETY RECALL NO. 10426A.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 09V310000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 9049 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20031030 - 20040630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185903 |
| Date Owner Notified By Manufacturer: | 20100802 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090729 |
| Record Creation Date: | 20090729 |
Defect Summary:
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence Summary:
THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09049.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 06V139000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 6030 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030601 - 20040630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 404733 |
| Date Owner Notified By Manufacturer: | 20061205 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060427 |
| Record Creation Date: | 20060427 |
Defect Summary:
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
Consequence Summary:
A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY. THE RECALL BEGAN ON DECEMBER 5, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463 OR ISUZU AT 1-800-255-6727.
Notes:
GM RECALL NO. 06030.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: COLORADO: CHILD SEAT
| NHTSA Campaign Number: | 10V575000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 10367 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 192676 |
| Date Owner Notified By Manufacturer: | 20101214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101118 |
| Record Creation Date: | 20101119 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence Summary:
BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Corrective Summary:
DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 10367 AND/OR 10407.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 09V310000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 9049 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040601 - 20050630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185903 |
| Date Owner Notified By Manufacturer: | 20100802 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090729 |
| Record Creation Date: | 20090729 |
Defect Summary:
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence Summary:
THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09049.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 06V139000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 6030 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040401 - 20050630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 404733 |
| Date Owner Notified By Manufacturer: | 20061205 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060427 |
| Record Creation Date: | 20060427 |
Defect Summary:
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
Consequence Summary:
A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY. THE RECALL BEGAN ON DECEMBER 5, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463 OR ISUZU AT 1-800-255-6727.
Notes:
GM RECALL NO. 06030.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: COLORADO: CHILD SEAT
| NHTSA Campaign Number: | 10V575000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 10367 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 192676 |
| Date Owner Notified By Manufacturer: | 20101214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101118 |
| Record Creation Date: | 20101119 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence Summary:
BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Corrective Summary:
DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 10367 AND/OR 10407.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: EQUIPMENT:OTHER:LABELS
| NHTSA Campaign Number: | 05V552000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5109 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050901 - 20050907 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 32068 |
| Date Owner Notified By Manufacturer: | 20060331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051207 |
| Record Creation Date: | 20051207 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence Summary:
A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Notes:
GM RECALL NO. 05109.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: COLORADO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 09V310000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 9049 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050601 - 20060630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185903 |
| Date Owner Notified By Manufacturer: | 20100802 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090729 |
| Record Creation Date: | 20090729 |
Defect Summary:
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence Summary:
THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09049.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 06V139000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 6030 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050401 - 20060411 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 404733 |
| Date Owner Notified By Manufacturer: | 20061205 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060427 |
| Record Creation Date: | 20060427 |
Defect Summary:
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
Consequence Summary:
A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY. THE RECALL BEGAN ON DECEMBER 5, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463 OR ISUZU AT 1-800-255-6727.
Notes:
GM RECALL NO. 06030.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: COLORADO: CHILD SEAT
| NHTSA Campaign Number: | 10V575000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 10367 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 192676 |
| Date Owner Notified By Manufacturer: | 20101214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101118 |
| Record Creation Date: | 20101119 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence Summary:
BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Corrective Summary:
DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 10367 AND/OR 10407.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 09V310000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 9049 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20060601 - 20070630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185903 |
| Date Owner Notified By Manufacturer: | 20100802 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090729 |
| Record Creation Date: | 20090729 |
Defect Summary:
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence Summary:
THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09049.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: WHEELS:RIM
| NHTSA Campaign Number: | 06V307000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 6079 |
| Manufacturer Component Description: | WHEELS:RIM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20060401 - 20060531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3227 |
| Date Owner Notified By Manufacturer: | 20061107 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060811 |
| Record Creation Date: | 20060811 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES AND TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES HAVE AN INCOMPLETE TIRE RIM DESIGNATION ON THE CERTIFICATION/TIRE LABEL LOCATED ON THE DRIVER'S DOOR EDGE. IN ADDITION, THE LABEL MAY ALSO BE MISSING THE TIRE LOAD RATING ON THE LABEL. ALTHOUGH THIS INFORMATION IS NOT REQUIRED BY THE STANDARD, IF A TIRE OF A LESSER LOAD RATING IS INSTALLED, THE TIRE MAY NOT BE ABLE TO SUSTAIN THE LOADS ENCOUNTERED DURING USE.
Consequence Summary:
IF A CUSTOMER REPLACES A WHEEL AND ONLY RELIES ON THE RIM SIZE DESIGNATION THAT IS INDICATED ON THE LABEL, A WHEEL THAT IS OF A DIFFERENT RIM CONTOUR DESIGNATION MAY BE INSTALLED. IT MAY BE DIFFICULT OR IMPOSSIBLE TO MOUNT THE TIRE ON A WHEEL WITH THE WRONG CONTOUR. IF THE TIRE IS MOUNTED ON THE WHEEL WITH THE WRONG CONTOUR, THE WHEEL AND TIRE MAY NOT PERFORM AS INTENDED, WHICH COULD INCREASE THE RISK OF A CRASH.
Corrective Summary:
A LABEL THAT WILL CORRECT THE LABEL ORIGINALLY INSTALLED WILL BE MAILED TO CONSUMERS ALONG WITH INSTALLATION INSTRUCTIONS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL. THE RECALL BEGAON ON NOVEMBER 7, 2006. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2239, CHEVROLET AT 1-800-630-2438, AND GMC TRUCKS AT 1-866-996-9463.
Notes:
GM RECALL NO. 06079.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: COLORADO: CHILD SEAT
| NHTSA Campaign Number: | 10V575000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 10367 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 192676 |
| Date Owner Notified By Manufacturer: | 20101214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101118 |
| Record Creation Date: | 20101119 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence Summary:
BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Corrective Summary:
DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 10367 AND/OR 10407.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 09V310000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 9049 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20070601 - 20080630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185903 |
| Date Owner Notified By Manufacturer: | 20100802 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090729 |
| Record Creation Date: | 20090729 |
Defect Summary:
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence Summary:
THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09049.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: CHILD SEAT
| NHTSA Campaign Number: | 10V575000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 10367 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 192676 |
| Date Owner Notified By Manufacturer: | 20101214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101118 |
| Record Creation Date: | 20101119 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence Summary:
BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Corrective Summary:
DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 10367 AND/OR 10407.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 09V154000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 8411 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20080601 - 20080930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27188 |
| Date Owner Notified By Manufacturer: | 20090518 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090506 |
| Record Creation Date: | 20090506 |
Defect Summary:
GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.
Consequence Summary:
WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 08411.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 09V310000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 9049 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20080601 - 20090630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185903 |
| Date Owner Notified By Manufacturer: | 20100802 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090729 |
| Record Creation Date: | 20090729 |
Defect Summary:
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence Summary:
THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09049.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: CHILD SEAT
| NHTSA Campaign Number: | 10V575000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 10367 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 192676 |
| Date Owner Notified By Manufacturer: | 20101214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101118 |
| Record Creation Date: | 20101119 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence Summary:
BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Corrective Summary:
DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 10367 AND/OR 10407.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: COLORADO: CHILD SEAT
| NHTSA Campaign Number: | 10V575000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | COLORADO |
| Model Year: | 2010 |
| Manufacturer Campaign Number: | 10367 |
| Manufacturer Component Description: | CHILD SEAT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 192676 |
| Date Owner Notified By Manufacturer: | 20101214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101118 |
| Record Creation Date: | 20101119 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence Summary:
BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Corrective Summary:
DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 10367 AND/OR 10407.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
-- --CHEVROLET: CORSICA: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
| NHTSA Campaign Number: | 86V164000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1987 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860801 - 19861101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1958 |
| Date Owner Notified By Manufacturer: | 19861213 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19861215 |
| Record Creation Date: | 19861222 |
Defect Summary:
PART OF PUSHBUTTON ATTACHMENT OF HEADLIGHT SWITCH MAY FRACTURE. CONSEQUENCE OF DEFECT: PUSH BUTTON WOULD NOT LATCH IN ON POSITION RESULTING IN INABILITY TO TURN ON HEADLIGHTS, REDUCED DRIVER VISIBILITY, AND THE POTENTIAL FOR A CRASH.
Corrective Summary:
INSTALL NEW HEADLIGHT SWITCH.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORSICA: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
| NHTSA Campaign Number: | 88V039000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1987 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861101 - 19871101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 282052 |
| Date Owner Notified By Manufacturer: | 19880426 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880323 |
| Record Creation Date: | 19880328 |
Defect Summary:
SECONDARY HOOD LATCH ASSEMBLY MAY NOT HAVE BEEN PROPERLY ADJUSTED RESULTING IN LATCH BECOMING BENT.
Consequence Summary:
A BENT SECONDARY HOOD LATCH COULD CAUSE THE PRIMARYLATCH TO MALFUNCTION. IF THIS OCCURED THE HOOD COULD UNEXPECTEDLY OPEN. IFTHIS HAPPENED WHILE VEHICLE IS IN MOTION REDUCTION OF FORWARD VISIBILITY COULDCAUSE A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
INSPECT AND REPLACE SECONDARY HOOD LATCH ASSEMBLIES AS REQUIRED.
Notes:
SYSTEM: HOOD LATCH/SECONDARY.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: STRUCTURE:BODY:HOOD
| NHTSA Campaign Number: | 91V135000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1987 |
| Manufacturer Component Description: | STRUCTURE:BODY:HOOD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860601 - 19871101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 290408 |
| Date Owner Notified By Manufacturer: | 19911021 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910819 |
| Record Creation Date: | 19910826 |
Defect Summary:
SECONDARY HOOD LATCH ASSEMBLY ON THESE VEHICLES MAY NOT BE PROPERLY ADJUSTED AND COULD BECOME BENT. THIS WILL LEAD TO A CONDITION WHERE FULL PRIMARY LATCH ENGAGEMENT IS NOT ATTAINED.
Consequence Summary:
A BENT SECONDARY HOOD LATCH COULD LEAD TO THE PRIMARYLATCH NOT BEING FULLY ENGAGED, ALLOWING THE HOOD TO UNEXPECTEDLY OPEN. IF THISWERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, THE HOOD MAY CONTACT THEWINDSHIELD, REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASHCOULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE THE PRIMARY HOOD LATCH ASSEMBLY, THE SECONDARY HOOD LATCH ASSEMBLY, AND THE SUPPORT BRACKET.
Notes:
SYSTEM: HOOD.VEHICLE DESCRIPTION: PASSENGER VEHICLES.
CHEVROLET: CORSICA: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
| NHTSA Campaign Number: | 86V165000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1987 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860801 - 19861101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4844 |
| Date Owner Notified By Manufacturer: | 19861213 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19861215 |
| Record Creation Date: | 19861222 |
Defect Summary:
SECONDARY HOOD LATCH MAY NOT PROPERLY ENGAGE DUE TO CONTACT WITH SUPPORT BRACKET AND/OR THE PRIMARY LATCH RETURN SPRING. CONSEQUENCE OF DEFECT: IF THIS OCCURS WHILE VEHICLE IS IN MOTION, HOOD COULD OPEN AND CONTACT THE WINDSHIELD, AFFECTING THE DRIVERS VISION AREA; THIS COULD RESULT IN A CRASH WITHOUT WARNING.
Corrective Summary:
INSTALL SECONDARY LATCH SKID PLATE ON CORSICA AND BERETTA MODELS. ALSO, INSTALL A REVISED SECONDARY LATCH ASSEMBLY ON BERETTA MODELS.
Notes:
SYSTEM: SECONDARY HOOD LATCH. VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
| NHTSA Campaign Number: | 87V062000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1987 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861101 - 19861201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2020 |
| Date Owner Notified By Manufacturer: | 19861213 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19870507 |
| Record Creation Date: | 19870511 |
Defect Summary:
LOSS OF SKID PLATE COULD LEAD TO DISENGAGEMENT OF BOTH SECONDARY AND PRIMARY HOOD LATCHES.
Consequence Summary:
HOOD COULD OPEN UNEXPECTANTLY; IF VEHICLE WERE INMOTION, THE HOOD COULD CONTACT THE WINDSHIELD, REDUCE THE DRIVERS VISION AREA,AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
INSTALL A SECONDARY LATCH SKID PLATE AND/OR SECONDARY LATCH SKID PLATE RETAINING SCREWS.
Notes:
SYSTEM: SECONDARY HOOD LATCH.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
| NHTSA Campaign Number: | 89V225000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1987 |
| Manufacturer Component Description: | STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861001 - 19870801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 170769 |
| Date Owner Notified By Manufacturer: | 19891208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19891218 |
| Record Creation Date: | 19900102 |
Defect Summary:
A DOOR HINGE (UPPER OR LOWER) MAY BREAK WHILE OPENING OR CLOSING THE DOOR MAKING IT DIFFICULT TO REPOSITION AND CLOSE PROPERLY.
Consequence Summary:
HINGE SEPARATION MAY REDUCE THE STRUCTURAL INTEGRITY OFTHE SIDE OF THE CAR AND INCREASE RISK OF INJURY IN CERTAIN TYPES OF ACCIDENTS.
Corrective Summary:
REPLACE DOOR HINGES ON BOTH DOORS.
Notes:
SYSTEM: DOOR HINGES.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORSICA: SEAT BELTS
| NHTSA Campaign Number: | 91V206000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1988 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880101 - 19900701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 722884 |
| Date Owner Notified By Manufacturer: | 19911218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911126 |
| Record Creation Date: | 19911126 |
Defect Summary:
THE FRONT SHOULDER BELT RETRACTORS MAY HAVE REDUCED SENSITIVITY OF THE LOCK-UP FEATURE AND WOULD NOT FUNCTION IN A SUDDEN DECELERATION OR CRASH.
Consequence Summary:
FAILURE OF THE SHOULDER BELT RETRACTOR WOULD RESULT INTHE SEAT OCCUPANT ONLY BEING RESTRAINED BY THE LAP BELT IN A CRASH OR SUDDENSTOP, AND AN INCREASED POSSIBILITY OF INJURY.
Notes:
SYSTEM: SAFETY BELTS (PASSIVE RESTRAINT).VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH DOOR MOUNTED SHOULDER AND LAPSAFETY BELT SYSTEMS.CORECTIVE ACTION: REPLACE THE FRONT SHOULDER BELT RETRACTORS AND ASSEMBLIES.
CHEVROLET: CORSICA: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
| NHTSA Campaign Number: | 88V039000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1988 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861101 - 19871101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 282052 |
| Date Owner Notified By Manufacturer: | 19880426 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880323 |
| Record Creation Date: | 19880328 |
Defect Summary:
SECONDARY HOOD LATCH ASSEMBLY MAY NOT HAVE BEEN PROPERLY ADJUSTED RESULTING IN LATCH BECOMING BENT.
Consequence Summary:
A BENT SECONDARY HOOD LATCH COULD CAUSE THE PRIMARYLATCH TO MALFUNCTION. IF THIS OCCURED THE HOOD COULD UNEXPECTEDLY OPEN. IFTHIS HAPPENED WHILE VEHICLE IS IN MOTION REDUCTION OF FORWARD VISIBILITY COULDCAUSE A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
INSPECT AND REPLACE SECONDARY HOOD LATCH ASSEMBLIES AS REQUIRED.
Notes:
SYSTEM: HOOD LATCH/SECONDARY.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: STRUCTURE:BODY:HOOD
| NHTSA Campaign Number: | 91V135000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1988 |
| Manufacturer Component Description: | STRUCTURE:BODY:HOOD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860601 - 19871101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 290408 |
| Date Owner Notified By Manufacturer: | 19911021 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910819 |
| Record Creation Date: | 19910826 |
Defect Summary:
SECONDARY HOOD LATCH ASSEMBLY ON THESE VEHICLES MAY NOT BE PROPERLY ADJUSTED AND COULD BECOME BENT. THIS WILL LEAD TO A CONDITION WHERE FULL PRIMARY LATCH ENGAGEMENT IS NOT ATTAINED.
Consequence Summary:
A BENT SECONDARY HOOD LATCH COULD LEAD TO THE PRIMARYLATCH NOT BEING FULLY ENGAGED, ALLOWING THE HOOD TO UNEXPECTEDLY OPEN. IF THISWERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, THE HOOD MAY CONTACT THEWINDSHIELD, REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASHCOULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE THE PRIMARY HOOD LATCH ASSEMBLY, THE SECONDARY HOOD LATCH ASSEMBLY, AND THE SUPPORT BRACKET.
Notes:
SYSTEM: HOOD.VEHICLE DESCRIPTION: PASSENGER VEHICLES.
CHEVROLET: CORSICA: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
| NHTSA Campaign Number: | 89V225000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1988 |
| Manufacturer Component Description: | STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861001 - 19870801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 170769 |
| Date Owner Notified By Manufacturer: | 19891208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19891218 |
| Record Creation Date: | 19900102 |
Defect Summary:
A DOOR HINGE (UPPER OR LOWER) MAY BREAK WHILE OPENING OR CLOSING THE DOOR MAKING IT DIFFICULT TO REPOSITION AND CLOSE PROPERLY.
Consequence Summary:
HINGE SEPARATION MAY REDUCE THE STRUCTURAL INTEGRITY OFTHE SIDE OF THE CAR AND INCREASE RISK OF INJURY IN CERTAIN TYPES OF ACCIDENTS.
Corrective Summary:
REPLACE DOOR HINGES ON BOTH DOORS.
Notes:
SYSTEM: DOOR HINGES.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: WHEELS
| NHTSA Campaign Number: | 91V213000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1989 |
| Manufacturer Component Description: | WHEELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890101 - 19890801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19603 |
| Date Owner Notified By Manufacturer: | 19911212 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911206 |
| Record Creation Date: | 19911216 |
Defect Summary:
THE STYLED STEEL WHEELS CAN HAVE CRACKS DEVELOPING AT THE OUTER EDGES OF THE WHEEL WHERE THE SPOKES MEET THE RIM. THE CRACKS PROPAGATE FROM EACH SIDE OF A SPOKE TOWARD EACH OTHER, AND EVENTUALLY MEET. THE MEETING OF THE CRACKS RESULTS IN COMPLETE SEAPARATION OF A SPOKE FROM THE WHEEL.
Consequence Summary:
THE CRACKING CONDITION CAN OCCUR ON EVERY SPOKE ON THEWHEEL, CAUSING COMPLETE SEPARATION OF THE WHEEL FROM THE VEHICLE, AND RESULTINGIN LOSS OF STEERING AND BRAKING CONTROL.
Corrective Summary:
REPLACE THE INVOLVED WHEEL ASSEMBLIES.
Notes:
SYSTEM: WHEELS.VEHICLE DESCRIPTION: PASSENGER CARS WITH STYLED STEEL WHEELS.
CHEVROLET: CORSICA: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
| NHTSA Campaign Number: | 88V189000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19881001 - 19881101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 13095 |
| Date Owner Notified By Manufacturer: | 19890119 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19881206 |
| Record Creation Date: | 19881215 |
Defect Summary:
A FUEL TANK LEAK COULD OCCUR DUE TO SMALL CREASES ON THE TANK UNDERSIDE CRACKING DURING PRESSURE CYCLING WHICH OCCURS DURING NORMAL OPERATION.
Consequence Summary:
IN PRESENCE OF AN IGNITION SOURCE, THIS CONDITION COULDRESULT IN A FIRE.
Corrective Summary:
REPLACE FUEL TANK.
Notes:
SYSTEM: FUEL TANK.VEHICLE DESCRIPTION: PASSENGER CARS WITH 2.0L OR 2.8L ENGINES.
CHEVROLET: CORSICA: FUEL SYSTEM, GASOLINE
| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORSICA: SEAT BELTS
| NHTSA Campaign Number: | 91V206000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880101 - 19900701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 722884 |
| Date Owner Notified By Manufacturer: | 19911218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911126 |
| Record Creation Date: | 19911126 |
Defect Summary:
THE FRONT SHOULDER BELT RETRACTORS MAY HAVE REDUCED SENSITIVITY OF THE LOCK-UP FEATURE AND WOULD NOT FUNCTION IN A SUDDEN DECELERATION OR CRASH.
Consequence Summary:
FAILURE OF THE SHOULDER BELT RETRACTOR WOULD RESULT INTHE SEAT OCCUPANT ONLY BEING RESTRAINED BY THE LAP BELT IN A CRASH OR SUDDENSTOP, AND AN INCREASED POSSIBILITY OF INJURY.
Notes:
SYSTEM: SAFETY BELTS (PASSIVE RESTRAINT).VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH DOOR MOUNTED SHOULDER AND LAPSAFETY BELT SYSTEMS.CORECTIVE ACTION: REPLACE THE FRONT SHOULDER BELT RETRACTORS AND ASSEMBLIES.
CHEVROLET: CORSICA: SEATS
| NHTSA Campaign Number: | 89V087000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890501 - 19890501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 642 |
| Date Owner Notified By Manufacturer: | 19890608 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890522 |
| Record Creation Date: | 19890605 |
Defect Summary:
THE FRONT SEAT FRAME ASSEMBLY MAY CONTAIN AN IMPROPER, MISSING AND/OR MISLOCATED WELD THAT COULD FRACTURE.
Consequence Summary:
THIS COULD CAUSE UNEXPECTED SEAT MOVEMENT AND RESULT INPERSONAL INJURY AND/OR LOSS OF CONTROL OF THE CAR.
Corrective Summary:
REPLACE BOTH FRONT SEAT ASSEMBLIES.
Notes:
SYSTEM: FRONT SEAT FRAME.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: SEAT BELTS
| NHTSA Campaign Number: | 89V034000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19881101 - 19881201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 29951 |
| Date Owner Notified By Manufacturer: | 19890330 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890310 |
| Record Creation Date: | 19890322 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
FRONT SEAT BELT LATCH PLATES MAY NOT ENGAGE THE BUCKLE ASSEMBLIES.
Consequence Summary:
IN EVENT OF AN ACCIDENT, UNBELTED OR IMPROPERLY BELTEDOCCUPANTS ARE MORE AT RISK TO INJURY THAN IF BELTS ARE PROPERLY BUCKLED.
Corrective Summary:
REPLACE IMPROPERLY FUNCTIONING BUCKLE ASSEMBLIES.
Notes:
SYSTEM: FRONT SEAT BELT LATCH/FMVSS 209.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: SEAT BELTS:REAR
| NHTSA Campaign Number: | 90V065000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890301 - 19890901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 26464 |
| Date Owner Notified By Manufacturer: | 19900419 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900405 |
| Record Creation Date: | 19900411 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
OWNER'S MANUALS WERE PRINTED WITH REAR CENTER SEAT BELT INFORMATION OMITTED.
Consequence Summary:
THIS WOULD NOT COMPLY WITH FMVSS 209.
Corrective Summary:
INSERT MISSING INFORMATION INTO OWNERS MANUAL.
Notes:
SYSTEM: SEAT BELT ASSEMBLIES; FMVSS 209.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: SEAT BELTS
| NHTSA Campaign Number: | 91V206000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880101 - 19900701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 722884 |
| Date Owner Notified By Manufacturer: | 19911218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911126 |
| Record Creation Date: | 19911126 |
Defect Summary:
THE FRONT SHOULDER BELT RETRACTORS MAY HAVE REDUCED SENSITIVITY OF THE LOCK-UP FEATURE AND WOULD NOT FUNCTION IN A SUDDEN DECELERATION OR CRASH.
Consequence Summary:
FAILURE OF THE SHOULDER BELT RETRACTOR WOULD RESULT INTHE SEAT OCCUPANT ONLY BEING RESTRAINED BY THE LAP BELT IN A CRASH OR SUDDENSTOP, AND AN INCREASED POSSIBILITY OF INJURY.
Notes:
SYSTEM: SAFETY BELTS (PASSIVE RESTRAINT).VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH DOOR MOUNTED SHOULDER AND LAPSAFETY BELT SYSTEMS.CORECTIVE ACTION: REPLACE THE FRONT SHOULDER BELT RETRACTORS AND ASSEMBLIES.
CHEVROLET: CORSICA: STEERING:WHEEL AND HANDLE BAR
| NHTSA Campaign Number: | 91V083000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1991 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900301 - 19901001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 36364 |
| Date Owner Notified By Manufacturer: | 19910615 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910610 |
| Record Creation Date: | 19910620 |
Defect Summary:
NUT ATTACHING STEERING WHEEL MAY NOT HAVE BEEN PROPERLY TIGHTENED DURING INSTALLATION.
Consequence Summary:
THIS COULD ALLOW STEERING WHEEL TO SEPARATE FROM STEERINGCOLUMN; LOSS OF VEHICLE CONTROL AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
TIGHTEN THE NUT TO THE PROPER TORQUE AS NECESSARY.
Notes:
SYSTEM: STEERING WHEEL NUT.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORSICA: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
| NHTSA Campaign Number: | 92V185000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910301 - 19920601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 140661 |
| Date Owner Notified By Manufacturer: | 19930119 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19921224 |
| Record Creation Date: | 19921230 |
Defect Summary:
THE SERVICE BRAKE STOP LAMP SWITCH BECOMES INOPERATIVE.
Consequence Summary:
THE INOPERATIVE STOP LAMP SWITCH WILL NOT ILLUMINATE THESTOP LAMPS WHEN THE BRAKE PEDAL IS DEPRESSED. THIS WOULD NOT ADEQUATELY INFORMOTHER DRIVERS OF THE VEHICLE OPERATOR'S INTENT TO STOP OR SLOW DOWN.
Corrective Summary:
REPLACE THE STOP LAMP SWITCH AND CORRECT THE WIRING IN THE CONNECTOR OF THE STOP LAMP SWITCH WIRING HARNESS.
Notes:
SYSTEM: LIGHTING; STOPLAMPS.VEHICLE DESCRIPTION: PASSENGER CARS.NOTE: IF THE FAILURE OCCURS DURING THREE CONSECUTIVE SERVICE BRAKE APPLICATIONSTHE AMBER ANTI-LOCK BRAKE SYSTEM (ABS) TELLTALE LAMP MAY ILLUMINATE INDICATINGA PROBLEM WITH THE SYSTEM.
CHEVROLET: CORSICA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | CORSICA |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
-CHEVROLET: CORVAIR: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
| NHTSA Campaign Number: | 71V224000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1961 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 679900 |
| Date Owner Notified By Manufacturer: | 19711208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711203 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 69-C-13.POSSIBILITY THAT FUMES INDIRECT AIRHEATING SYSTEM MAY BE TRANSFERRED FROM ENGINE COMPA RTMENT INTO PASSENGERCOMPARTMENT.SUCH FUMES, IN SOME CASES,CONTAIN CARBON MOXOXIDE IN SUFFICIENTCONCENTRATION TO HARM O R ENDANGER OCCUPANTS OF VEHICLE.(CORRECT BYINSPECTING AND R EPAIRING WHERE NECESSARY.)
--CHEVROLET: CORVAIR: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
| NHTSA Campaign Number: | 71V224000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1962 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 679900 |
| Date Owner Notified By Manufacturer: | 19711208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711203 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 69-C-13.POSSIBILITY THAT FUMES INDIRECT AIRHEATING SYSTEM MAY BE TRANSFERRED FROM ENGINE COMPA RTMENT INTO PASSENGERCOMPARTMENT.SUCH FUMES, IN SOME CASES,CONTAIN CARBON MOXOXIDE IN SUFFICIENTCONCENTRATION TO HARM O R ENDANGER OCCUPANTS OF VEHICLE.(CORRECT BYINSPECTING AND R EPAIRING WHERE NECESSARY.)
--CHEVROLET: CORVAIR: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
| NHTSA Campaign Number: | 71V224000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1963 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 679900 |
| Date Owner Notified By Manufacturer: | 19711208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711203 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 69-C-13.POSSIBILITY THAT FUMES INDIRECT AIRHEATING SYSTEM MAY BE TRANSFERRED FROM ENGINE COMPA RTMENT INTO PASSENGERCOMPARTMENT.SUCH FUMES, IN SOME CASES,CONTAIN CARBON MOXOXIDE IN SUFFICIENTCONCENTRATION TO HARM O R ENDANGER OCCUPANTS OF VEHICLE.(CORRECT BYINSPECTING AND R EPAIRING WHERE NECESSARY.)
--CHEVROLET: CORVAIR: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
| NHTSA Campaign Number: | 71V224000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1964 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 679900 |
| Date Owner Notified By Manufacturer: | 19711208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711203 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 69-C-13.POSSIBILITY THAT FUMES INDIRECT AIRHEATING SYSTEM MAY BE TRANSFERRED FROM ENGINE COMPA RTMENT INTO PASSENGERCOMPARTMENT.SUCH FUMES, IN SOME CASES,CONTAIN CARBON MOXOXIDE IN SUFFICIENTCONCENTRATION TO HARM O R ENDANGER OCCUPANTS OF VEHICLE.(CORRECT BYINSPECTING AND R EPAIRING WHERE NECESSARY.)
--CHEVROLET: CORVAIR: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
| NHTSA Campaign Number: | 71V224000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1965 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 679900 |
| Date Owner Notified By Manufacturer: | 19711208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711203 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 69-C-13.POSSIBILITY THAT FUMES INDIRECT AIRHEATING SYSTEM MAY BE TRANSFERRED FROM ENGINE COMPA RTMENT INTO PASSENGERCOMPARTMENT.SUCH FUMES, IN SOME CASES,CONTAIN CARBON MOXOXIDE IN SUFFICIENTCONCENTRATION TO HARM O R ENDANGER OCCUPANTS OF VEHICLE.(CORRECT BYINSPECTING AND R EPAIRING WHERE NECESSARY.)
--CHEVROLET: CORVAIR: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
| NHTSA Campaign Number: | 71V224000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1966 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 679900 |
| Date Owner Notified By Manufacturer: | 19711208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711203 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 69-C-13.POSSIBILITY THAT FUMES INDIRECT AIRHEATING SYSTEM MAY BE TRANSFERRED FROM ENGINE COMPA RTMENT INTO PASSENGERCOMPARTMENT.SUCH FUMES, IN SOME CASES,CONTAIN CARBON MOXOXIDE IN SUFFICIENTCONCENTRATION TO HARM O R ENDANGER OCCUPANTS OF VEHICLE.(CORRECT BYINSPECTING AND R EPAIRING WHERE NECESSARY.)
-- --CHEVROLET: CORVAIR: STEERING:WHEEL AND HANDLE BAR
| NHTSA Campaign Number: | 67V033000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1967 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19510 |
| Date Owner Notified By Manufacturer: | 19670328 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19670329 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT STEERING SHAFT MAY NOT HAVE BEEN PROPERLY INSTALLED.THIS COULD CAUSE A BINDING CONDI- TION WHICH, WHILE NOT NOTICEABLE TO THE DRIVER, MAY SUBJECT THE STEERING SHAFT TO ABNORMAL STRESSES.UNDER CERTAIN CONDITIONS, THESE STRESSES MAY CAUSE THE SHAFT TO BREAK WITH RESULTANT LOSS OF STEERING.(REPLACE THE SUBJECT SHAFTS WITH IMPROVED DESIGN WHICH WILL ELIMINATE THIS POSSIBILITY.)
--CHEVROLET: CORVAIR: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
| NHTSA Campaign Number: | 71V224000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1967 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 679900 |
| Date Owner Notified By Manufacturer: | 19711208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711203 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 69-C-13.POSSIBILITY THAT FUMES INDIRECT AIRHEATING SYSTEM MAY BE TRANSFERRED FROM ENGINE COMPA RTMENT INTO PASSENGERCOMPARTMENT.SUCH FUMES, IN SOME CASES,CONTAIN CARBON MOXOXIDE IN SUFFICIENTCONCENTRATION TO HARM O R ENDANGER OCCUPANTS OF VEHICLE.(CORRECT BYINSPECTING AND R EPAIRING WHERE NECESSARY.)
--CHEVROLET: CORVAIR: STRUCTURE:BODY:HOOD
| NHTSA Campaign Number: | 67V118000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1968 |
| Manufacturer Component Description: | STRUCTURE:BODY:HOOD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1046 |
| Date Owner Notified By Manufacturer: | 19671130 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19671207 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT THE LOCK STRIKER ON THE FRONT COMPARTMENT MAY NOT BESUFFICIENTLY RETAINED TO THE STRIKER SUPPORT TO MAINTAIN POSITIVE COMPARTMENT LID CLOSURE.IT IS POSSIBLE THAT THE TORQUE STRESS ON THE STRIKER SUPPORT CLINCH NUTS IS EXCESSIVE AND MAY CAUSE ONE OR BOTH OF THE NUTS TO DISLODGE FROM THE SUPPORT.THIS COULD RESULT IN A LOSS OF POSITIVE STRIKER RETENTION AND THELID COULD OPEN WHILE THE CAR IS IN OPERATION.(INSTALL NEW RETAINER BOLTS AND NUTS IN THE STRIKER ASSEMBLY).
--CHEVROLET: CORVAIR: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
| NHTSA Campaign Number: | 71V224000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1968 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 679900 |
| Date Owner Notified By Manufacturer: | 19711208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711203 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 69-C-13.POSSIBILITY THAT FUMES INDIRECT AIRHEATING SYSTEM MAY BE TRANSFERRED FROM ENGINE COMPA RTMENT INTO PASSENGERCOMPARTMENT.SUCH FUMES, IN SOME CASES,CONTAIN CARBON MOXOXIDE IN SUFFICIENTCONCENTRATION TO HARM O R ENDANGER OCCUPANTS OF VEHICLE.(CORRECT BYINSPECTING AND R EPAIRING WHERE NECESSARY.)
--CHEVROLET: CORVAIR: WHEELS:LUGS/NUTS/BOLTS
| NHTSA Campaign Number: | 67V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1968 |
| Manufacturer Component Description: | WHEELS:LUGS/NUTS/BOLTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 597 |
| Date Owner Notified By Manufacturer: | 19671130 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19671207 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT EXCESSIVE PRESSURE MAY HAVE BEEN USED TO PRESS THE REAR WHEEL STUDS IN PLACE.THIS COULD RESULT IN A STRESS FAILURE OF THE WHEEL STUD HEADS, ALLOWING ONE OR MORE OF THE STUDS TO WORK LOOSE.IF THIS SHOULD OCCUR, THE REAR WHEELS COULD LOOSEN OR POSSIBLY COME OFF DURING VEHICLE OPERATION.(INSPECT AND REPLACE REAR WHEEL STUDS AS REQUIRED.)
--CHEVROLET: CORVAIR: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
| NHTSA Campaign Number: | 71V224000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVAIR |
| Model Year: | 1969 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 679900 |
| Date Owner Notified By Manufacturer: | 19711208 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711203 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 69-C-13.POSSIBILITY THAT FUMES INDIRECT AIRHEATING SYSTEM MAY BE TRANSFERRED FROM ENGINE COMPA RTMENT INTO PASSENGERCOMPARTMENT.SUCH FUMES, IN SOME CASES,CONTAIN CARBON MOXOXIDE IN SUFFICIENTCONCENTRATION TO HARM O R ENDANGER OCCUPANTS OF VEHICLE.(CORRECT BYINSPECTING AND R EPAIRING WHERE NECESSARY.)
-- --CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1965 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
--CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1966 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
-- --CHEVROLET: CORVETTE: STRUCTURE:BODY:ROOF AND PILLARS
-->| NHTSA Campaign Number: | 09V491000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 90230 |
| Manufacturer Component Description: | STRUCTURE:BODY:ROOF AND PILLARS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20060831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 22090 |
| Date Owner Notified By Manufacturer: | 20100421 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20091223 |
| Record Creation Date: | 20091223 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Consequence Summary:
IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Corrective Summary:
DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 090230.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STRUCTURE:BODY:ROOF AND PILLARS
-->| NHTSA Campaign Number: | 06V181000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 6041 |
| Manufacturer Component Description: | STRUCTURE:BODY:ROOF AND PILLARS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050301 - 20060531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 30793 |
| Date Owner Notified By Manufacturer: | 20061019 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060524 |
Defect Summary:
ON CERTAIN 2005-2006 CHEVROLET CORVETTES EQUIPPED WITH PAINTED ROOFS, THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE.
Consequence Summary:
IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE AND IT COULD STRIKE ANOTHER VEHICLE AND CAUSE INJURY AND PROPERTY DAMAGE.
Corrective Summary:
DEALERS WILL INSPECT VEHICLES FREE OF CHARGE FOR POTENTIAL ROOF PANEL-TO- FRAME SEPARATION AND ADD THE SPECIFIED ADHESIVE FOAM OR REPLACE THE ROOF WITH ONE HAVING ADHESIVE FOAM. THE RECALL BEGAN ON OCTOBER 19, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: STEERING:COLUMN
-->| NHTSA Campaign Number: | 10V172000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2006 |
| Manufacturer Component Description: | STEERING:COLUMN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20060131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 40028 |
| Date Owner Notified By Manufacturer: | 20100430 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100426 |
| Record Creation Date: | 20100427 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 CHEVROLET CORVETTE PASSENGER CARS MANUFACTURED BETWEEN MARCH 2004 AND JANUARY 2006 EQUIPPED WITH A TILT AND TELESCOPING STEERING COLUMN (RPO N37). IN RARE CASES, REPEATED MOVEMENT OF THE STEERING COLUMN MAY CAUSE A SIGNAL INTERRUPTION WITHIN THE COLUMN. IF THIS OCCURS, THE MESSAGE, "SERVICE ACTIVE HANDLING SYSTEM" WILL APPEAR IN THE DRIVER INFORMATION CENTER, AND ONE OR MORE OF THE BRAKES MAY APPLY, POSSIBLY CAUSING THE VEHICLE TO PULL TO THE RIGHT OR LEFT.
Consequence Summary:
IF THE DRIVER DOES NOT RESPOND TO THE CHANGE IN VEHICLE MOVEMENT, A CRASH COULD OCCUR.
Corrective Summary:
GM WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM'S RECALL CAMPAIGN NUMBER IS N100118.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
-->| NHTSA Campaign Number: | 05V455000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5086 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050701 - 20050831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 123592 |
| Date Owner Notified By Manufacturer: | 20051014 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051005 |
| Record Creation Date: | 20051006 |
Defect Summary:
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence Summary:
IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05086.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: STRUCTURE:BODY:ROOF AND PILLARS
-->| NHTSA Campaign Number: | 09V491000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 90230 |
| Manufacturer Component Description: | STRUCTURE:BODY:ROOF AND PILLARS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20060831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 22090 |
| Date Owner Notified By Manufacturer: | 20100421 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20091223 |
| Record Creation Date: | 20091223 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Consequence Summary:
IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Corrective Summary:
DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 090230.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STRUCTURE:BODY:ROOF AND PILLARS
-->| NHTSA Campaign Number: | 06V181000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 6041 |
| Manufacturer Component Description: | STRUCTURE:BODY:ROOF AND PILLARS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20050831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 30793 |
| Date Owner Notified By Manufacturer: | 20061019 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060524 |
Defect Summary:
ON CERTAIN 2005-2006 CHEVROLET CORVETTES EQUIPPED WITH PAINTED ROOFS, THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE.
Consequence Summary:
IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE AND IT COULD STRIKE ANOTHER VEHICLE AND CAUSE INJURY AND PROPERTY DAMAGE.
Corrective Summary:
DEALERS WILL INSPECT VEHICLES FREE OF CHARGE FOR POTENTIAL ROOF PANEL-TO- FRAME SEPARATION AND ADD THE SPECIFIED ADHESIVE FOAM OR REPLACE THE ROOF WITH ONE HAVING ADHESIVE FOAM. THE RECALL BEGAN ON OCTOBER 19, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 04V525000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 4086 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040401 - 20040801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5225 |
| Date Owner Notified By Manufacturer: | 20050118 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20041103 |
| Record Creation Date: | 20041103 |
Defect Summary:
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH ONE OR BOTH REAR BRAKE HYDRAULIC LINES THAT CAN COME IN CONTACT WITH OR BE AFFECTED BY HEAT FROM THE LEFT ENGINE EXHAUST MANIFOLD AND THE LEFT EXHAUST PIPE. THE BRAKE FLUID COULD REACH ELEVATED TEMPERATURES AND BOIL.
Consequence Summary:
IF THE BRAKE FLUID BOILS IN A REAR BRAKE LINE, THE EFFECTIVENESS OF THE REAR BRAKE SYSTEM WOULD BE REDUCED WHICH COULD RESULT IN A BRAKE LINE LEAK AND LOSS OF BRAKE FLUID. IF ENOUGH FLUID LEAKS FROM THE REAR BRAKE SYSTEM SO THAT BRAKE PEDAL APPLICATION CAN NO LONGER BUILD PRESSURE TO THE REAR BRAKES. THE OPERATOR OF THE VEHICLE WILL EXPERIENCE LIMITED BRAKING WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL (1) INSPECT THE LEFT ENGINE EXHAUST MANIFOLD CLIP FOR PROPER ALIGNMENT AND PLACEMENT ON THE BODY-MOUNTED STUD. IF INCORRECT, THEY WILL REPOSITION THE CLIP ON THE BRAKE LINES AND REINSTALL THE CLIP ON THE STUD; (2) THE DEALER WILL VERIFY THAT BOTH REAR BRAKE LINES HAVE THE PROPER CLEARANCE TO THE LEFT EXHAUST PIPE. THEY WILL REPOSITION THE LINES BY BENDING AS NECESSARY; (3) DEALERS WILL REMOVE THE MACHINING TAB FROM THE REAR DIFFERENTIAL HOUSING. ALSO, DEALERS ARE TO INSPECT THE BRAKE LINES FOR WEAR IN THESE RELATED AREAS AND REPAIR OR REPLACE IF THERE IS ANY SIGN OF WEAR-THROUGH ON THE NYLON OVERCOATING. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2239 OR CHEVROLET AT 1-800-630-2438.
Notes:
GENERAL MOTORS RECALL NO. 04086.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: STEERING:COLUMN
-->| NHTSA Campaign Number: | 10V172000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2005 |
| Manufacturer Component Description: | STEERING:COLUMN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20060131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 40028 |
| Date Owner Notified By Manufacturer: | 20100430 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100426 |
| Record Creation Date: | 20100427 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 CHEVROLET CORVETTE PASSENGER CARS MANUFACTURED BETWEEN MARCH 2004 AND JANUARY 2006 EQUIPPED WITH A TILT AND TELESCOPING STEERING COLUMN (RPO N37). IN RARE CASES, REPEATED MOVEMENT OF THE STEERING COLUMN MAY CAUSE A SIGNAL INTERRUPTION WITHIN THE COLUMN. IF THIS OCCURS, THE MESSAGE, "SERVICE ACTIVE HANDLING SYSTEM" WILL APPEAR IN THE DRIVER INFORMATION CENTER, AND ONE OR MORE OF THE BRAKES MAY APPLY, POSSIBLY CAUSING THE VEHICLE TO PULL TO THE RIGHT OR LEFT.
Consequence Summary:
IF THE DRIVER DOES NOT RESPOND TO THE CHANGE IN VEHICLE MOVEMENT, A CRASH COULD OCCUR.
Corrective Summary:
GM WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM'S RECALL CAMPAIGN NUMBER IS N100118.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
-->| NHTSA Campaign Number: | 05V455000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5086 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050701 - 20050831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 123592 |
| Date Owner Notified By Manufacturer: | 20051014 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051005 |
| Record Creation Date: | 20051006 |
Defect Summary:
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence Summary:
IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05086.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: STRUCTURE:BODY:ROOF AND PILLARS
-->| NHTSA Campaign Number: | 09V491000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 90230 |
| Manufacturer Component Description: | STRUCTURE:BODY:ROOF AND PILLARS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20060831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 22090 |
| Date Owner Notified By Manufacturer: | 20100421 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20091223 |
| Record Creation Date: | 20091223 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Consequence Summary:
IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Corrective Summary:
DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 090230.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
-->| NHTSA Campaign Number: | 04V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4006 |
| Manufacturer Component Description: | STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030201 - 20040130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 126624 |
| Date Owner Notified By Manufacturer: | 20040426 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040209 |
| Record Creation Date: | 20040209 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence Summary:
IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04006.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STEERING:LINKAGES
-->| NHTSA Campaign Number: | 04V273000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4043 |
| Manufacturer Component Description: | STEERING:LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040101 - 20040430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 41928 |
| Date Owner Notified By Manufacturer: | 20040825 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040609 |
| Record Creation Date: | 20040616 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES INVOLVED IN THIS CAMPAIGN, THE LOWER CONTROL ARM BALL STUD NUT/WASHER ASSEMBLIES WITH WASHERS WERE MADE OF THE WRONG MATERIAL. THE WASHERS MAY FRACTURE AND BECOME LOOSE OR FALL AWAY FROM THE VEHICLE, REDUCING CLAMP LOAD. SEPARATION OF THE CONTROL ARM BALL STUD AND STEERING KNUCKLE, DUE TO DISENGAGEMENT OF THE TAPERED ATTACHMENT AND RETAINING NUT, IS POSSIBLE.
Consequence Summary:
IF THE CONTROL ARM SEPARATES FROM THE KNUCKLE, THE AFFECTED CORNER OF THE VEHICLE WILL DROP AND THE CONTROL ARM WOULD BE FORCED DOWNWARD, CONTACTING THE WHEEL. THE AFFECTED WHEEL COULD TILT OUTWARD AND CREATE A DRAGGING ACTION THAT WOULD TEND TO SLOW THE VEHICLE AND CREATE A TENDENCY FOR THE VEHICLE TO TURN IN THE DIRECTION OF THE AFFECTED WHEEL. IN EXTREME SITUATIONS, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL;S HYDRAULIC BRAKE HOSE AND RESULT IN DIMINISHED BRAKING PERFORMANCE OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE BALL STUD JOINTS AND MEASURE THE TORQUE OF THE NUT FOR ALL FRONT LOWER CONTROL ARMS IN ALL MODELS AFFECTED AS WELL AS THE REAR LOWER CONTROL ARMS ON THE XLR AND CORVETTE. IF THE TORQUE IS NOT AT SPECIFICATION, THE DEALERS WILL REPLACE THE BALL STUD, THE KNUCKLE, AND THE NUT. IF THE TORQUE IS AT SPECIFICATION, THE DEALERS WILL REPLACE THE NUT/WASHER ASSEMBLY ONLY. THE RECALL WILL BEGIN ON AUGUST 25, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339 OR CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04043. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
-->| NHTSA Campaign Number: | 04V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4006 |
| Manufacturer Component Description: | STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020201 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 126624 |
| Date Owner Notified By Manufacturer: | 20040426 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040209 |
| Record Creation Date: | 20040209 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence Summary:
IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04006.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
-->| NHTSA Campaign Number: | 04V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 4006 |
| Manufacturer Component Description: | STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010301 - 20020630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 126624 |
| Date Owner Notified By Manufacturer: | 20040426 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040209 |
| Record Creation Date: | 20040209 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence Summary:
IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04006.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
-->| NHTSA Campaign Number: | 04V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 4006 |
| Manufacturer Component Description: | STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 126624 |
| Date Owner Notified By Manufacturer: | 20040426 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040209 |
| Record Creation Date: | 20040209 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence Summary:
IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04006.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
-->| NHTSA Campaign Number: | 04V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 4006 |
| Manufacturer Component Description: | STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980301 - 19990630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 126624 |
| Date Owner Notified By Manufacturer: | 20040426 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040209 |
| Record Creation Date: | 20040209 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence Summary:
IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04006.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: SEAT BELTS:FRONT
-->| NHTSA Campaign Number: | 00V111000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 34 |
| Manufacturer Component Description: | SEAT BELTS:FRONT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19961001 - 19990831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 71569 |
| Date Owner Notified By Manufacturer: | 20001113 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000417 |
| Record Creation Date: | 20000428 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LAP BELT WEBBING CAN TWIST ALLOWING THE WEBBING TO BECOME JAMMED IN THE RETRACTOR.
Consequence Summary:
WHEN THE BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT MAY BE UNUSABLE.
Corrective Summary:
DEALERS WILL INSTALL INSERTS TO THE BELT WEB GUIDE OF EACH LAP BELT RETRACTOR.
Notes:
OWNER NOTIFICATION BEGAN NOVEMBER 13, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
-->| NHTSA Campaign Number: | 04V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 4006 |
| Manufacturer Component Description: | STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970301 - 19980630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 126624 |
| Date Owner Notified By Manufacturer: | 20040426 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040209 |
| Record Creation Date: | 20040209 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence Summary:
IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04006.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: SEAT BELTS:FRONT
-->| NHTSA Campaign Number: | 00V111000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 34 |
| Manufacturer Component Description: | SEAT BELTS:FRONT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19961001 - 19990831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 71569 |
| Date Owner Notified By Manufacturer: | 20001113 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000417 |
| Record Creation Date: | 20000428 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LAP BELT WEBBING CAN TWIST ALLOWING THE WEBBING TO BECOME JAMMED IN THE RETRACTOR.
Consequence Summary:
WHEN THE BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT MAY BE UNUSABLE.
Corrective Summary:
DEALERS WILL INSTALL INSERTS TO THE BELT WEB GUIDE OF EACH LAP BELT RETRACTOR.
Notes:
OWNER NOTIFICATION BEGAN NOVEMBER 13, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-->| NHTSA Campaign Number: | 97V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1997 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960901 - 19970430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3792 |
| Date Owner Notified By Manufacturer: | 19970715 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970623 |
| Record Creation Date: | 19970630 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES HAVE A TORN FUEL TANK SENDING UNIT/PUMP SEAL. THIS CAN CAUSE FUEL ODOR AND/OR LEAKAGE AT THE ATTACHMENT LOCATION.
Consequence Summary:
FUEL LEAKAGE FROM A TORN SEAL CAN RESULT IN A FIRE IF AN IGNITION SOURCE IS PRESENT.
Corrective Summary:
DEALERS WILL REPLACE THE LEFT AND RIGHT HAND FUEL TANK ASSEMBLIES (INCLUDING FUEL SENDING UNIT AND PUMP).
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING JULY 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CORVETTE: STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
-->| NHTSA Campaign Number: | 04V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 4006 |
| Manufacturer Component Description: | STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960901 - 19970731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 126624 |
| Date Owner Notified By Manufacturer: | 20040426 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040209 |
| Record Creation Date: | 20040209 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence Summary:
IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04006.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 97V044000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1997 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19961101 - 19970320 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1414 |
| Date Owner Notified By Manufacturer: | 19970331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970320 |
| Record Creation Date: | 19970325 |
Defect Summary:
THE REAR SUSPENSION TIE ROD ASSEMBLY CAN FRACTURE.
Consequence Summary:
IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, LOSS OF DIRECTIONAL CONTROL CAN RESULT INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE LEFT AND RIGHT-HAND REAR SUSPENSION TIE ROD LINKS.
Notes:
OWNER NOTIFICATION BEGAN MARCH 31, 1997. GM ISSUED A STOP SALE TO THEIR DEALERS ON MARCH 20, 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CORVETTE: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: CORVETTE: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 97V104000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1997 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960901 - 19970530 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4369 |
| Date Owner Notified By Manufacturer: | 19970715 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970628 |
| Record Creation Date: | 19970630 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELTS IN THESE VEHICLES INCORPORATE AN ENERGY MANAGEMENT LOOP. THIS LOOP IS INADEQUATE TO ABSORB THE NECESSARY FORCES THAT CAN BE EXERTED ON IT. THEREFORE, THE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE ENERGY MANAGEMENT LOOP WILL NOT ABSORB ENOUGH ENERGY, AND INJURY TO THE SEAT OCCUPANT CAN OCCUR.
Corrective Summary:
DEALERS WILL REPLACE THE DRIVER AND PASSENGER SIDE SEAT BELT RETRACTOR ASSEMBLIES.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING JULY 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: CORVETTE: SEAT BELTS:FRONT
-->| NHTSA Campaign Number: | 00V111000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 34 |
| Manufacturer Component Description: | SEAT BELTS:FRONT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19961001 - 19990831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 71569 |
| Date Owner Notified By Manufacturer: | 20001113 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000417 |
| Record Creation Date: | 20000428 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LAP BELT WEBBING CAN TWIST ALLOWING THE WEBBING TO BECOME JAMMED IN THE RETRACTOR.
Consequence Summary:
WHEN THE BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT MAY BE UNUSABLE.
Corrective Summary:
DEALERS WILL INSTALL INSERTS TO THE BELT WEB GUIDE OF EACH LAP BELT RETRACTOR.
Notes:
OWNER NOTIFICATION BEGAN NOVEMBER 13, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1993 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
-->| NHTSA Campaign Number: | 92V160000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1993 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19920601 - 19920901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5152 |
| Date Owner Notified By Manufacturer: | 19921030 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19921108 |
| Record Creation Date: | 19921116 |
Defect Summary:
THE POWER STEERING GEAR INLET HOSE ON THESE VEHICLES CAN FRACTURE, CAUSING POWER STEERING FLUID TO SPRAY FROM HOSE INTO THE ENGINE COMPARTMENT.
Consequence Summary:
THE POWER STEERING FLUID IS FLAMMABLE AND COULD CAUSEAN UNDERHOOD FIRE IF EXPOSED TO A SOURCE OF IGNITION.
Corrective Summary:
REPLACE THE POWER STEERING GEAR INLET HOSE WITH AN IMPROVED DESIGN.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS WITH LT1 ENGINES.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1992 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
-->| NHTSA Campaign Number: | 92V160000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1992 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19920601 - 19920901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5152 |
| Date Owner Notified By Manufacturer: | 19921030 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19921108 |
| Record Creation Date: | 19921116 |
Defect Summary:
THE POWER STEERING GEAR INLET HOSE ON THESE VEHICLES CAN FRACTURE, CAUSING POWER STEERING FLUID TO SPRAY FROM HOSE INTO THE ENGINE COMPARTMENT.
Consequence Summary:
THE POWER STEERING FLUID IS FLAMMABLE AND COULD CAUSEAN UNDERHOOD FIRE IF EXPOSED TO A SOURCE OF IGNITION.
Corrective Summary:
REPLACE THE POWER STEERING GEAR INLET HOSE WITH AN IMPROVED DESIGN.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS WITH LT1 ENGINES.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1991 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1991 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19910501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 231833 |
| Date Owner Notified By Manufacturer: | 19911025 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910904 |
| Record Creation Date: | 19910930 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATIONS AND OCCUPANT USAGE CONDITIONS, THE SAFETY BELTS CAN LOCKUP OR JAM IN THE SAFETY BELT RETRACTOR.
Consequence Summary:
IF LOCKUP OCCURS, IT IS IMPOSSIBLE TO PULL BELT OUT OFTHE RETRACTOR. THE OCCUPANT OF A SEAT WITH AN UNUSABLE SAFETY BELT ISSUBJECT TO INCREASED RISK OF INJURY OR DEATH IN THE EVENT OF A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE THE SAFETY BELTS IF THE LOCKUP OCCURS.
Notes:
SYSTEM: SAFETY BELTS.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1990 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19910501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 231833 |
| Date Owner Notified By Manufacturer: | 19911025 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910904 |
| Record Creation Date: | 19910930 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATIONS AND OCCUPANT USAGE CONDITIONS, THE SAFETY BELTS CAN LOCKUP OR JAM IN THE SAFETY BELT RETRACTOR.
Consequence Summary:
IF LOCKUP OCCURS, IT IS IMPOSSIBLE TO PULL BELT OUT OFTHE RETRACTOR. THE OCCUPANT OF A SEAT WITH AN UNUSABLE SAFETY BELT ISSUBJECT TO INCREASED RISK OF INJURY OR DEATH IN THE EVENT OF A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE THE SAFETY BELTS IF THE LOCKUP OCCURS.
Notes:
SYSTEM: SAFETY BELTS.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 90V008000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890401 - 19891001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 213 |
| Date Owner Notified By Manufacturer: | 19900131 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900122 |
| Record Creation Date: | 19900131 |
Defect Summary:
FUEL FEED AND RETURN LINE CONNECTORS HAVE INCORRECT LINE END FLARE CONFIGURATIONS.
Consequence Summary:
LINE ENDS COULD CRACK CAUSING A FUEL LEAK THAT COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
INSTALL NEW FUEL LINES WITH CORRECT END FLARE CONFIGURATION.
Notes:
SYSTEM: FUEL LINES.VEHICLE DESCRIPTION: PASSENGER CARS WITH LT5 ENGINES.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1989 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19910501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 231833 |
| Date Owner Notified By Manufacturer: | 19911025 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910904 |
| Record Creation Date: | 19910930 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATIONS AND OCCUPANT USAGE CONDITIONS, THE SAFETY BELTS CAN LOCKUP OR JAM IN THE SAFETY BELT RETRACTOR.
Consequence Summary:
IF LOCKUP OCCURS, IT IS IMPOSSIBLE TO PULL BELT OUT OFTHE RETRACTOR. THE OCCUPANT OF A SEAT WITH AN UNUSABLE SAFETY BELT ISSUBJECT TO INCREASED RISK OF INJURY OR DEATH IN THE EVENT OF A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE THE SAFETY BELTS IF THE LOCKUP OCCURS.
Notes:
SYSTEM: SAFETY BELTS.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY
-->| NHTSA Campaign Number: | 90V032000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1989 |
| Manufacturer Component Description: | SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870301 - 19890801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 45969 |
| Date Owner Notified By Manufacturer: | 19900314 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900212 |
| Record Creation Date: | 19900228 |
Defect Summary:
REAR WHEEL TIE ROD ASSEMBLY MAY FATIGUE AND COULD FRACTURE AT THE INBOARD BEARING DUE TO HIGH INNER JOINT ROCKING TORQUE.
Consequence Summary:
FRACTURE IN THIS ASSEMBLY COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE FAULTY TIE ROD ASSEMBLIES.
Notes:
SYSTEM: REAR WHEEL TIE RODS.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: WHEELS:CENTER SECTION
-->| NHTSA Campaign Number: | 88V017000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1988 |
| Manufacturer Component Description: | WHEELS:CENTER SECTION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870301 - 19871201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4901 |
| Date Owner Notified By Manufacturer: | 19880222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19880209 |
| Record Creation Date: | 19880216 |
Defect Summary:
MISSING WELD THAT ATTACHES WHEEL CENTER TO THE RIM COULD ALLOW WHEEL CENTER TO SEPARATE FROM THE RIM.
Consequence Summary:
THIS COULD RESULT IN PARTIAL LOSS OF STEERING CONTROLAND BRAKES, LOSS OF TIRE AIR PRESSURE, AND SUDDEN CHANGE IN VEHICLE DIRECTION,WHICH COULD RESULT IN CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE WHEELS WITH MISSING WELDS.
Notes:
SYSTEM: WHEEL WELDS.VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH 17 INCH WHEELS.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1988 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1988 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19910501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 231833 |
| Date Owner Notified By Manufacturer: | 19911025 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910904 |
| Record Creation Date: | 19910930 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATIONS AND OCCUPANT USAGE CONDITIONS, THE SAFETY BELTS CAN LOCKUP OR JAM IN THE SAFETY BELT RETRACTOR.
Consequence Summary:
IF LOCKUP OCCURS, IT IS IMPOSSIBLE TO PULL BELT OUT OFTHE RETRACTOR. THE OCCUPANT OF A SEAT WITH AN UNUSABLE SAFETY BELT ISSUBJECT TO INCREASED RISK OF INJURY OR DEATH IN THE EVENT OF A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE THE SAFETY BELTS IF THE LOCKUP OCCURS.
Notes:
SYSTEM: SAFETY BELTS.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY
-->| NHTSA Campaign Number: | 90V032000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1988 |
| Manufacturer Component Description: | SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870301 - 19890801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 45969 |
| Date Owner Notified By Manufacturer: | 19900314 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900212 |
| Record Creation Date: | 19900228 |
Defect Summary:
REAR WHEEL TIE ROD ASSEMBLY MAY FATIGUE AND COULD FRACTURE AT THE INBOARD BEARING DUE TO HIGH INNER JOINT ROCKING TORQUE.
Consequence Summary:
FRACTURE IN THIS ASSEMBLY COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE FAULTY TIE ROD ASSEMBLIES.
Notes:
SYSTEM: REAR WHEEL TIE RODS.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1987 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1987 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19910501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 231833 |
| Date Owner Notified By Manufacturer: | 19911025 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910904 |
| Record Creation Date: | 19910930 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATIONS AND OCCUPANT USAGE CONDITIONS, THE SAFETY BELTS CAN LOCKUP OR JAM IN THE SAFETY BELT RETRACTOR.
Consequence Summary:
IF LOCKUP OCCURS, IT IS IMPOSSIBLE TO PULL BELT OUT OFTHE RETRACTOR. THE OCCUPANT OF A SEAT WITH AN UNUSABLE SAFETY BELT ISSUBJECT TO INCREASED RISK OF INJURY OR DEATH IN THE EVENT OF A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE THE SAFETY BELTS IF THE LOCKUP OCCURS.
Notes:
SYSTEM: SAFETY BELTS.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1986 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
-->| NHTSA Campaign Number: | 86V056000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19850901 - 19851101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 93317 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860428 |
| Record Creation Date: | 19860501 |
Defect Summary:
THE PUSH-PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. NOTE: ALSO, SEE NHTSA CAMPAIGN NUMBER 86V131000.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS, TRUCKS AND VANS.
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1986 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1986 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19910501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 231833 |
| Date Owner Notified By Manufacturer: | 19911025 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910904 |
| Record Creation Date: | 19910930 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATIONS AND OCCUPANT USAGE CONDITIONS, THE SAFETY BELTS CAN LOCKUP OR JAM IN THE SAFETY BELT RETRACTOR.
Consequence Summary:
IF LOCKUP OCCURS, IT IS IMPOSSIBLE TO PULL BELT OUT OFTHE RETRACTOR. THE OCCUPANT OF A SEAT WITH AN UNUSABLE SAFETY BELT ISSUBJECT TO INCREASED RISK OF INJURY OR DEATH IN THE EVENT OF A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE THE SAFETY BELTS IF THE LOCKUP OCCURS.
Notes:
SYSTEM: SAFETY BELTS.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
-->| NHTSA Campaign Number: | 86V120000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1986 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19850401 - 19860201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 18223 |
| Date Owner Notified By Manufacturer: | 19860920 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860826 |
| Record Creation Date: | 19860827 |
Defect Summary:
SEVERE AND UNUSUAL BRAKING CONDITIONS MAY CAUSE DAMAGE TO THE BRAKE MASTER CYLINDER CENTER VALVE. CONSEQUENCE OF DEFECT: IF SUFFICIENT DAMAGE OCCURS, LOSS OF FRONT BRAKES MAY OCCUR WITH INCREASED PEDAL TRAVEL AND REDUCED BRAKING ABILITY. THE REDUCTION OF BRAKING ABILITY AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
NEW MASTER CYLINDER CENTER VALVE AND RELATED PARTS WILL BE INSTALLED.
Notes:
SYSTEM: BRAKES/MASTER CYLINDER. VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1985 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1985 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1985 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19910501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 231833 |
| Date Owner Notified By Manufacturer: | 19911025 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910904 |
| Record Creation Date: | 19910930 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATIONS AND OCCUPANT USAGE CONDITIONS, THE SAFETY BELTS CAN LOCKUP OR JAM IN THE SAFETY BELT RETRACTOR.
Consequence Summary:
IF LOCKUP OCCURS, IT IS IMPOSSIBLE TO PULL BELT OUT OFTHE RETRACTOR. THE OCCUPANT OF A SEAT WITH AN UNUSABLE SAFETY BELT ISSUBJECT TO INCREASED RISK OF INJURY OR DEATH IN THE EVENT OF A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE THE SAFETY BELTS IF THE LOCKUP OCCURS.
Notes:
SYSTEM: SAFETY BELTS.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: ELECTRICAL SYSTEM:BATTERY:CABLES
-->| NHTSA Campaign Number: | 83V081000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1984 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:BATTERY:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19830701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 11909 |
| Date Owner Notified By Manufacturer: | 19830902 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830825 |
| Record Creation Date: | 19830906 |
Defect Summary:
THE INSULATION OF THE BATTERY CABLE, BECAUSE OF ITS POSITION, RUBS AGAINST SOME OF THE ENGINE WIRING COMPONENTS. ONCE THE INSULATION IS WORN THROUGH, THE BATTERY COULD RAPIDLY DISCHARGE.
Corrective Summary:
DEALER WILL INSTALL A NEW ENGINE HARNESS RETAINER BRACKET, PROTECTIVE CONDUIT, CABLE CLIPS, A CABLE TIE STRAP AND WILL REPOSITION THE TERMINALS ON THE GROUND STUD ON ALL INVOLVED VEHICLES.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: ELECTRICAL; BATTERY CABLE INSULATION.CONSEQUENCES OF DEFECT: THE HEADLIGHTS WOULD CEASE TO FUNCTION, DUE TO LOSS OFBATTERY POWER; DRIVING AT NIGHT, IN FOG OR OTHER SEVERE WEATHER CONDITIONSCOULD RESULT IN AN ACCIDENT.
CHEVROLET: CORVETTE: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 85V029000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1984 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19840801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 47081 |
| Date Owner Notified By Manufacturer: | 19850320 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850319 |
| Record Creation Date: | 19850321 |
Defect Summary:
THE CRUISE CONTROL VACUUM SOLENOID VALVES MAY MALFUNCTION AT ANY TIME THE ENGINE IS RUNNING AND THE CRUISE CONTROL IS ENGAGED AND CAUSE UNEXPECTED ENGINE ACCELERATION. CONSEQUENCE OF DEFECT: LOSS OF ACCELERATOR CONTROL COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
INSTALL AND RELOCATE A NEW CRUISE CONTROL SERVO ASSEMBLY.
Notes:
VEHICLE DESCRIPTION: PASSENGER CARS EQUIPPED WITH RPO K34 CRUISE CONTROL. SYSTEM: CRUISE CONTROL.
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1984 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 91V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19910501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 231833 |
| Date Owner Notified By Manufacturer: | 19911025 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910904 |
| Record Creation Date: | 19910930 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATIONS AND OCCUPANT USAGE CONDITIONS, THE SAFETY BELTS CAN LOCKUP OR JAM IN THE SAFETY BELT RETRACTOR.
Consequence Summary:
IF LOCKUP OCCURS, IT IS IMPOSSIBLE TO PULL BELT OUT OFTHE RETRACTOR. THE OCCUPANT OF A SEAT WITH AN UNUSABLE SAFETY BELT ISSUBJECT TO INCREASED RISK OF INJURY OR DEATH IN THE EVENT OF A SUDDEN STOP ORACCIDENT.
Corrective Summary:
REPLACE THE SAFETY BELTS IF THE LOCKUP OCCURS.
Notes:
SYSTEM: SAFETY BELTS.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: CORVETTE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
-->| NHTSA Campaign Number: | 83V064000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1984 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19830601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 9197 |
| Date Owner Notified By Manufacturer: | 19830627 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830707 |
| Record Creation Date: | 19830803 |
Defect Summary:
ATTACHING BOLTS WERE MISTAKENLY COATED WITH A SLIPPERY MATERIAL DURING PRODUCTION. THIS MATERIAL WILL ACT AS A LUBRICANT AND BOLTS MAY LOOSEN AND EVENTUALLY FALL OFF.
Corrective Summary:
DEALER WILL INSTALL NEW CALIPER BRACKET BOLTS FREE OF CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; FRONT BRAKE CALIPER BRACKET TO STEERING KNUCKLEATTACHING BOLT.CONSEQUENCES OF DEFECT: THE FRONT BRAKE ASSEMBLY COULD BECOME PARTIALLYSEPARATED FROM THE KNUCKLE ASSEMBLY, CAUSING THE WHEEL TO LOCK. LOSS OF VEHICLECONTROL WITHOUT PRIOR WARNING AND AN ACCIDENT COULD RESULT.
CHEVROLET: CORVETTE: POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
-->| NHTSA Campaign Number: | 85V118000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1984 |
| Manufacturer Component Description: | POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830201 - 19840801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 44342 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19851001 |
| Record Creation Date: | 19851021 |
Defect Summary:
CARS MAY LOSE THE WIRE SNAP RINGS THAT HOLD THE DIFFERENTIAL CROSS SHAFT IN POSITION IN THE REAR AXLE DIFFERENTIAL CASE ASSEMBLY, ALLOWING THE SHAFT TO MOVE. CONSEQUENCE OF DEFECT: THE CROSS SHAFT MOVEMENT COULD CAUSE THE SHAFT TO CONTACT THE CARRIER OR PINION TEETH, POSSIBLY LOCKING UP THE REAR WHEELS AND RESULT IN A CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
INSTALL A REAR AXLE DIFFERENTIAL CROSS SHAFT RETAINING KIT.
Notes:
SYSTEM: REAR AXLE.VEHICLE DESCRIPTION: PASSENGER CARS WITH 3.07 AXLE AND F41 SUSPENSION.
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1982 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1982 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1981 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1981 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1980 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1980 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1979 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1979 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1978 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1978 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: COMMUNICATIONS:HORN ASSEMBLY
-->| NHTSA Campaign Number: | 77V115000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1977 |
| Manufacturer Component Description: | COMMUNICATIONS:HORN ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15484 |
| Date Owner Notified By Manufacturer: | 19770725 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19770728 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 107 |
Defect Summary:
THE INVOLVED VEHICLES HAVE STEERING WHEEL CENTER HUBS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 107, "REFLECTING SURFACES". THE HORN BUTTON CAP AND THE LOCK LEVER HAVE A BRUSHED CHROME FINISH. THE SURFACE REFLECTIVITY OF THIS FINISH ON SOME OF THESE HORN BUTTON CAPS AND LOCK LEVERS IS APPROXIMATELY TWICE THE MAXIMUM REFLECTIVITY ALLOWED BY THE STANDARD.
Corrective Summary:
DEALER WILL REPLACE THE CAP AND LEVER WITH PARTS PAINTED TO MATCH THE INTERIOR TRIM COLOR AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH TILT TELESCOPING STEERINGASSEMBLY.SYSTEM: STEERING; STEERING WHEEL CENTER HUB.CONSEQUENCES OF DEFECT: IF THE DRIVER DOES NOT TAKE STEPS TO ALLEVIATE THEDISTRACTION OF LIGHT REFLECTING OFF THE STEERING WHEEL HUB, THIS COULD LEAD TOAN ACCIDENT.
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1977 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1977 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1976 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1975 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1974 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1974 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: CORVETTE: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
-->| NHTSA Campaign Number: | 74V050000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1974 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2937 |
| Date Owner Notified By Manufacturer: | 19740325 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740325 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 74-C-13.POSSIBILITY THAT THE FUEL TANK RETURN LINEFITTING MAY HAVE A THIN WALL SECTION THAT COULD BREAK.IF THIS OCCURS FUELBEING RETURNED TO THE GASOLINE TANK WILL BE SPILLED AROUND THE TAIL PIPE OUTLETAS LONG AS THE ENGINE CONTINUES TO RUN.IF, UNDER THESE CONDITIONS THE VEHICLEBACKFIRES OR SPARKS ARE EMITTED FROM THE EXHAUST SYSTEM, THE FUEL VAPOR CAN BEIGNITED.(CORRECT BY INSPECTING AND REPLACING FUEL LINES WHERE NECESSARY).
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1972 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1971 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1970 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1969 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 69V001000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1969 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4420 |
| Date Owner Notified By Manufacturer: | 19681227 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690807 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT SEAT BELTS WILL NOT LATCH PROPERLY IF BELT TONGUE IS INSERTEDUPSIDE DOWN INTO BELT BUCKLE, EVEN THOUGH IT WILL GIVE IMPRESSION OF BEINGPROPERLY LATCHED.ALSO A POSSIBILITY THAT PROPERLY LATCHED BUCKLE COULD DIS-ENGAGE IF SEVERE SIDE IMPACT IS RECEIVED IN BUCKLE AREA.(CORRECT BYINSTALLING NEW BELT ASSEMBLIES.) POSSIBILITY THAT SEAT BACK LOCK FORKS MAY HAVEBEEN IMPROPERLY HEAT TREATED, MAKING IT POSSIBLE FOR ONE OR BOTH OF THEM TOBREAK DURING LATCHING OF SEAT BACK.THIS COULD PERMIT FORWARD MOVEMENT OF SEATBACK IF FORWARD FORCE IS APPLIED TO SEAT BACK ASSEMBLY.(CORRECT BY INSTALLINGNEW LOCK FORKS WHERE NECESSARY.)
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1968 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: CORVETTE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 67V117000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1968 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2781 |
| Date Owner Notified By Manufacturer: | 19671130 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19671207 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBLE INSUFFICIENT CLEARANCE BETWEEN THE LOWER EDGE OF THE LEFT FRONT FENDER SKIRT AND THE FRONT BRAKE PIPE, JUST IN FRONT OF THE STEERING GEAR.THIS COULD ALLOW THE SKIRT TO CHAFE AGAINST THE BRAKE PIPE WHICH COULD EVENTUALLY RESULT IN WEAR THROUGH OF THE BRAKE PIPE AND LOSS OF FRONT WHEEL BRAKE SYSTEM.BECAUSE OF DUAL SYSTEM, REAR BRAKES WOULD STILL BE OPERATIVE.(REWORK THE FENDER SKIRT.)
CHEVROLET: CORVETTE: SERVICE BRAKES, AIR:DISC:CALIPER
-->| NHTSA Campaign Number: | 03E032000 |
| Vehicle/Equipment Make: | CARDONE INDUSTRIES, INC. |
| Vehicle/Equipment Model: | CORVETTE |
| Model Year: | 1967 |
| Manufacturer Component Description: | SERVICE BRAKES, AIR:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15899 |
| Date Owner Notified By Manufacturer: | 20030501 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CARDONE INDUSTRIES, INC. |
| Report Received Date: | 20030512 |
| Record Creation Date: | 20030516 |
Defect Summary:
REMANUFACTURERD REAR BRAKE CALIPERS, PART NOS. 18-7019, 18-7020, 16-7019, AND 16-7020, MANUFACTURED FROM FEBRUARY 1, 2002, TO APRIL, 25, 2003., AND FOR USE ON 1965 THRU 1982 CHEVROLET CORVETTES. THE SUBJECT BRAKE CALIPERS WERE MANUFACTURED USING IMPROPERLY MANUFACTURED PISTON SEALS. THESE SEALS ARE INTENDED TO PREVENT FLUID LEAKAGE BETWEEN THE CALIPER HOUSING AND THE PISTONS. THESE BRAKE CALIPERS ARE FOR USE ONLY ON 1965 THRU 1982 CHEVROLET CORVETTE VEHICLES. THIS RECALL DOES NOT INVOLVE GENERAL MOTORS CORPORATION OR ANY OF ITS PRODUCTS.
Consequence Summary:
UNDER THESE CONDITIONS, THE VEHICLE OPERATOR MAY NOT BE ABLE TO STOP THE CAR, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
CARDONE WILL NOTIFY ITS CUSTOMERS AND ALL UNSOLD INVENTORY WILL BE REPURCHASED AND WILL PROVIDE A FULL REFUND TO CUSTOMERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CARDONE AT 215-912-3000.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
--CHEVROLET: CRUZE: POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
| NHTSA Campaign Number: | 11V273000 |
| Vehicle/Equipment Make: | GENERAL MOTORS LLC |
| Vehicle/Equipment Model: | CRUZE |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 11142 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20091006 - 20010427 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 100308 |
| Date Owner Notified By Manufacturer: | 20110517 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS LLC |
| Report Received Date: | 20110506 |
| Record Creation Date: | 20110506 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 102 & 114 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 6, 2009, THROUGH APRIL 27, 2011 AND EQUIPPED WITH AN AUTOMATIC TRANSMISSION FOR FAILING TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, 'TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT,' AND FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION.' THESE VEHICLES MAY HAVE BEEN BUILT WITH A TRANSMISSION SHIFT LINKAGE THAT IS NOT PROPERLY INSTALLED. IF THE LINKAGE IS NOT PROPERLY INSTALLED, THE PRNDL SHIFT LEVER MAY NOT ACCURATELY REFLECT THE POSITION OF THE TRANSMISSION GEAR. WITH THIS CONDITION, THE DRIVER COULD MOVE THE SHIFTER TO PARK AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN PARK.
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSPECT THE TRANSMISSION SHIFT LINKAGE FOR CORRECT INSTALLATION AND ADJUST THE SHIFT LINKAGE SYSTEM FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 23, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR WWW.GMOWNERCENTER.COM.
Notes:
GM'S SAFETY RECALL NO. 11142.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: CRUZE: STEERING
| NHTSA Campaign Number: | 11V221000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CRUZE |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 11094 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20101101 - 20110318 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2100 |
| Date Owner Notified By Manufacturer: | 20110407 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20110406 |
| Record Creation Date: | 20110406 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.
Consequence Summary:
SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSPECT TO ENSURE THAT THE STEERING WHEEL IS ASSEMBLED PROPERLY. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 7, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM'S SAFETY RECALL NO. 11094. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: CRUZE: STEERING:COLUMN
| NHTSA Campaign Number: | 11V221000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | CRUZE |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 11094 |
| Manufacturer Component Description: | STEERING:COLUMN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20101101 - 20110318 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2100 |
| Date Owner Notified By Manufacturer: | 20110407 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20110406 |
| Record Creation Date: | 20110406 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES. DURING MANUFACTURING THE STEERING WHEEL COULD HAVE BEEN IMPROPERLY FASTENED AND MAY DETACH FROM THE STEERING COLUMN.
Consequence Summary:
SHOULD THE STEERING WHEEL DETACH FROM THE STEERING COLUMN WHILE DRIVING, THE DRIVER COULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSPECT TO ENSURE THAT THE STEERING WHEEL IS ASSEMBLED PROPERLY. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 7, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM'S SAFETY RECALL NO. 11094. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: CRUZE: STEERING:GEAR BOX:SHAFT SECTOR
| NHTSA Campaign Number: | 11V270000 |
| Vehicle/Equipment Make: | GENERAL MOTORS LLC |
| Vehicle/Equipment Model: | CRUZE |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 11149 |
| Manufacturer Component Description: | STEERING:GEAR BOX:SHAFT SECTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20091002 - 20110421 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 128911 |
| Date Owner Notified By Manufacturer: | 20110523 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS LLC |
| Report Received Date: | 20110506 |
| Record Creation Date: | 20110506 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH APRIL 21, 2011. THE BOLT ATTACHING THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR INPUT SHAFT MAY NOT HAVE BEEN PROPERLY INSTALLED.
Consequence Summary:
THIS COULD ALLOW THE SHAFTS TO SEPARATE, RESULTING IN THE LOSS OF STEERING. LOSS OF STEERING CONTROL MAY INCREASE THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSPECT, AND IF REQUIRED, REPAIR THE INTERMEDIATE SHAFT/STEERING GEAR ASSEMBLY TO ASSURE THE BOLT IS FULLY SEATED AND THE SHAFT PROPERLY ASSEMBLED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 23, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR WWW.GMOWNERCENTER.COM.
Notes:
GM'S SAFETY RECALL NO. 11149.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: EL CAMINO: FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
| NHTSA Campaign Number: | 76V160000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1966 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19650801 - 19660301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 811180 |
| Date Owner Notified By Manufacturer: | 19761007 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19761012 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO.66C12.BUICK CAMPAIGN NO.66C1.POSSIBILITY THAT THEFUEL INLET PLUG ON ROCHESTER QUADRAJET CARBURETOR MAY FAIL WHICH COULD RESULTIN ENGINE COMPARTMENT FIRE.THIS CONDITION, IF IT EXISTS, COULD CAUSE INJURYFROM FIRE OR FROM LOSS OF VEHICLE CONTROL.(CORRECT BY INSPECTING ANDINSTALLING A SPECIAL BRACKET ON THE CARBURETOR TO PREVENT LOSS OF FUEL INLETPLUG).PASSENGER VEHICLE.
-- --CHEVROLET: EL CAMINO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1987 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-->| NHTSA Campaign Number: | 87V168000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1987 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870601 - 19870701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 11936 |
| Date Owner Notified By Manufacturer: | 19871125 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19871026 |
| Record Creation Date: | 19871104 |
Defect Summary:
MANUAL VALVE LINK IN THE TRANSMISSION MAY HAVE BEEN IMPROPERLY FORMED.
Consequence Summary:
THE VALVE LINK COULD SEPARATE RESULTING IN A GEARSELECTION DIFFERENT FROM WHAT THE DRIVER SELECTS. ALSO, CAR COULD BE STARTEDWITH TRANSMISSION IN GEAR ALLOWING VEHICLE TO MOVE IN AN UNANTICIPATEDDIRECTION.
Corrective Summary:
REPLACE THE MANUAL VALVE DETENT LEVER LINK.
Notes:
SYSTEM: TRANSMISSIONVEHICLE DESCRIPTION: PASSENGER CARS AND WAGONS WITH 200 4R TRANSMISSIONS.
CHEVROLET: EL CAMINO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1986 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1986 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1985 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1985 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1984 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: SEATS:FRONT ASSEMBLY:RECLINER
-->| NHTSA Campaign Number: | 84V011000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830701 - 19830901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 76586 |
| Date Owner Notified By Manufacturer: | 19840224 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840206 |
| Record Creation Date: | 19840222 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 207 |
Defect Summary:
SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Corrective Summary:
INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
CHEVROLET: EL CAMINO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 83V106000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1983 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820801 - 19830601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4667 |
| Date Owner Notified By Manufacturer: | 19831025 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19831013 |
| Record Creation Date: | 19831021 |
Defect Summary:
THE MASTER CYLINDER REAR BRAKE PIPE, WHICH CARRIES BRAKE FLUID TO THE REAR BRAKES, MAY DEVELOP A LEAK DUE TO EXTENDED CHAFING ON THE AIR CLEANER RESONATOR BRACKET.
Corrective Summary:
IF UPON INSPECTION THE DEALER FINDS THAT THERE IS INADEQUATE CLEARANCE, THE PIPE WILL BE REFORMED TO OBTAIN THE NECESSARY THREE QUARTER INCH SPACE. ONLY THOSE PIPES SHOWING SIGNS OF WEAR WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITH 5.7LITER DIESEL ENGINES.SYSTEM: SERVICE BRAKES; MASTER CYLINDER, REAR BRAKE PIPE.CONSEQUENCES OF DEFECT: BRAKE FLUID LEAKAGE WILL RESULT IN LOSS OF BRAKINGACTION AT THE REAR WHEELS. LOSS OF VEHICLE CONTROL AND AN ACCIDENT COULDRESULT, PARTICULARLY IN SITUATIONS WHERE MINIMUM STOPPING DISTANCE IS REQUIRED.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1983 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: WHEELS:CENTER SECTION
-->| NHTSA Campaign Number: | 81V036000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1981 |
| Manufacturer Component Description: | WHEELS:CENTER SECTION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19800901 - 19801001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6690 |
| Date Owner Notified By Manufacturer: | 19810330 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810323 |
| Record Creation Date: | 19810408 |
Defect Summary:
TX HEAVY DUTY WHEELS MAY HAVE BEEN MANUFACTURED WITH LAMINATED STEEL. THE WHEEL DISC MAY FRACTURE AND THE WHEEL AND TIRE COULD PARTIALLY OR COMPLETELY SEPARATE FROM THE VEHICLE.
Corrective Summary:
THE DEFECTIVE WHEELS WILL BE REPLACED WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITH "TX"HEAVY DUTY WHEELS.SYSTEM: SUSPENSION; WHEELS.CONSEQUENCES OF DEFECT: IF SEPARATION OF WHEEL AND TIRE FROM VEHICLE OCCURSWHILE VEHICLE IS IN MOTION, DRIVER COULD EXPERIENCE LOSS OF VEHICLE CONTROL ANDHAVE AN ACCIDENT.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1981 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1981 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: EL CAMINO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 85V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1980 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1810000 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850429 |
| Record Creation Date: | 19850501 |
Defect Summary:
EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT. FRONT BRAKES WOULD REMAIN OPERATIONAL.
Corrective Summary:
ADD A PART TO PREVENT WHEEL CYLINDER FROM ROTATING.
Notes:
NOTE: OWNER NOTIFICATION WILL BEGIN AFTER SEPTEMBER 1, 1985 AND SHOULD BE COMPLETED BY SEPTEMBER 30, 1985.VEHICLE DESCRIPTION: MIDSIZE PASSENGER CARS AND SMALL TRUCKS. SYSTEM: REAR BRAKES.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1980 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1980 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: EL CAMINO: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 84V149000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1980 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19800701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3100000 |
| Date Owner Notified By Manufacturer: | 19841228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19841124 |
| Record Creation Date: | 19841127 |
Defect Summary:
REAR AXLE ASSEMBLY MAY HAVE AXLES THAT WERE IMPROPERLY MANUFACTURED. THIS CONDITION MAY RESULT IN SEPARATION OF THE AXLE SHAFT AND WHEEL ASSEMBLY FROM THE VEHICLE.
Corrective Summary:
THE DEALER WILL INSPECT THE REAR AXLE TO DETERMINE WHETHER IT WAS MANUFACTURED AT THE BUFFALO PLANT. IF SO, THEY WILL MAKE AXLE MEASUREMENTS AND IF NECESSARY REPLACE OR MODIFY AFFECTED AXLE COMPONENTS WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.SYSTEM: POWER TRAIN; REAR AXLE.CONSEQUENCES OF DEFECT: LOSS OF THE WHEEL ASSEMBLY COULD LEAD TO LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: EL CAMINO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 85V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1979 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1810000 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850429 |
| Record Creation Date: | 19850501 |
Defect Summary:
EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT. FRONT BRAKES WOULD REMAIN OPERATIONAL.
Corrective Summary:
ADD A PART TO PREVENT WHEEL CYLINDER FROM ROTATING.
Notes:
NOTE: OWNER NOTIFICATION WILL BEGIN AFTER SEPTEMBER 1, 1985 AND SHOULD BE COMPLETED BY SEPTEMBER 30, 1985.VEHICLE DESCRIPTION: MIDSIZE PASSENGER CARS AND SMALL TRUCKS. SYSTEM: REAR BRAKES.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1979 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1979 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: EL CAMINO: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 84V149000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1979 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19800701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3100000 |
| Date Owner Notified By Manufacturer: | 19841228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19841124 |
| Record Creation Date: | 19841127 |
Defect Summary:
REAR AXLE ASSEMBLY MAY HAVE AXLES THAT WERE IMPROPERLY MANUFACTURED. THIS CONDITION MAY RESULT IN SEPARATION OF THE AXLE SHAFT AND WHEEL ASSEMBLY FROM THE VEHICLE.
Corrective Summary:
THE DEALER WILL INSPECT THE REAR AXLE TO DETERMINE WHETHER IT WAS MANUFACTURED AT THE BUFFALO PLANT. IF SO, THEY WILL MAKE AXLE MEASUREMENTS AND IF NECESSARY REPLACE OR MODIFY AFFECTED AXLE COMPONENTS WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.SYSTEM: POWER TRAIN; REAR AXLE.CONSEQUENCES OF DEFECT: LOSS OF THE WHEEL ASSEMBLY COULD LEAD TO LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: EL CAMINO: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-->| NHTSA Campaign Number: | 78V139000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1978 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19780101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 333619 |
| Date Owner Notified By Manufacturer: | 19780619 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19780613 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE HUB PORTION OF THE FAN BLADE ASSEMBLY COULD CRACK DUE TO HIGH STRESS LEVELS GENERATED DURING ENGINE OPERATING CONDITIONS. EVENTUALLY, THE BLADE COULD BREAK APART AT THE HUB AND BLADE PIECES COULD BE PROPELLED INTO THE ENGINE. IF THE HOOD IS OPEN WHILE THE ENGINE IS RUNNING, THE FRAGMENTS WOULD BE FREE TO FLY FROM THE VEHICLE.
Corrective Summary:
DEALER WILL REPLACE THE FAN BLADE ASSEMBLY WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: ENGINE COOLING; FAN BLADE ASSEMBLY.CONSEQUENCES OF DEFECT: FAN FAILURE COULD RESULT IN DAMAGE TO COMPONENTS IN THEENGINE AREA, OR PERSONAL INJURY TO BYSTANDERS IF THE HOOD IS OPEN AT THE TIME.NOTE: THE VEHICLE SHOULD NOT BE SERVICED WITH THE HOOD OPEN AND THE ENGINERUNNING UNTIL THE DEFECT IS CORRECTED.
CHEVROLET: EL CAMINO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 85V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1978 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1810000 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850429 |
| Record Creation Date: | 19850501 |
Defect Summary:
EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT. FRONT BRAKES WOULD REMAIN OPERATIONAL.
Corrective Summary:
ADD A PART TO PREVENT WHEEL CYLINDER FROM ROTATING.
Notes:
NOTE: OWNER NOTIFICATION WILL BEGIN AFTER SEPTEMBER 1, 1985 AND SHOULD BE COMPLETED BY SEPTEMBER 30, 1985.VEHICLE DESCRIPTION: MIDSIZE PASSENGER CARS AND SMALL TRUCKS. SYSTEM: REAR BRAKES.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1978 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1978 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: EL CAMINO: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 84V149000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1978 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19800701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3100000 |
| Date Owner Notified By Manufacturer: | 19841228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19841124 |
| Record Creation Date: | 19841127 |
Defect Summary:
REAR AXLE ASSEMBLY MAY HAVE AXLES THAT WERE IMPROPERLY MANUFACTURED. THIS CONDITION MAY RESULT IN SEPARATION OF THE AXLE SHAFT AND WHEEL ASSEMBLY FROM THE VEHICLE.
Corrective Summary:
THE DEALER WILL INSPECT THE REAR AXLE TO DETERMINE WHETHER IT WAS MANUFACTURED AT THE BUFFALO PLANT. IF SO, THEY WILL MAKE AXLE MEASUREMENTS AND IF NECESSARY REPLACE OR MODIFY AFFECTED AXLE COMPONENTS WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.SYSTEM: POWER TRAIN; REAR AXLE.CONSEQUENCES OF DEFECT: LOSS OF THE WHEEL ASSEMBLY COULD LEAD TO LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: EL CAMINO: STEERING:WHEEL AND HANDLE BAR
-->| NHTSA Campaign Number: | 76V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1977 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55564 |
| Date Owner Notified By Manufacturer: | 19760830 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760907 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 77-C-1.POSSIBILITY THAT THE STEERING INTERMEDIATESHAFT MAY HAVE BEEN ASSEMBLED WITH COUPLING RETAINER LOCKING TABS NOT BENT OVERPROPERLY OR ONE OR MORE OF THE LOWER FLEXIBLE COUPLING RIVETS IMPROPERLYPEENED.IF EITHER OF THESE CONDITIONS EXISTS, THE INTERMEDIATE SHAFT ASSEMBLYCOULD SEPARATE CAUSING LOSS OF STEERING CONTROL, AND VEHICLE CRASH MAY OCCURWITHOUT PRIOR WARNING.(CORRECT BY INSPECTING, AND REPLACING SHAFT WHERENECESSARY).PASSENGER VEHICLE.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1977 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1976 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 75V032000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1975 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 220982 |
| Date Owner Notified By Manufacturer: | 19750220 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19750219 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE AND BUICK CAMPAIGN NO 75-C-7.CHEVROLET CAMPAIGN NO 75-C-08.PONTIAC CAMPAIGN NO 75-C-9.DATES OF MANUFACTURE FOR CHEVROLET, BUICK,OLDSMOBILE AND GMC ARE SEPT THRU NOV 1974.PONTIAC DATES ARE SEPT 1974 THRUJAN 1975.NO STATION WAGONS ARE INVOLVED.POSSIBILITY THAT THE REAR AXLE WASASSEMBLED WITH REAR AXLE SHAFT OUTER BEARING (REAR WHEEL BEARING) WITH THRUSTPLATES THAT WERE NOT HEAT TREATED.IF THE INNER OR OUTER THRUST PLATES OFTHESE BEARINGS ARE NOT HARDENED, THE ROLLERS CAN WEAR THROUGH AND ALLOW THEREAR AXLE SHAFT TO MOVE WITH RESPECT TO AXLE HOUSING.(CORRECT BY INSPECTINGAND REPLACING AXLE ASSEMBLIES WHERE NECESSARY.)
CHEVROLET: EL CAMINO: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
-->| NHTSA Campaign Number: | 73V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1974 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 782111 |
| Date Owner Notified By Manufacturer: | 19740109 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731227 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 74-C-09.PONTIAC 74-C-2.BUICK 74-C-2.OLDSMOBILE74-C-3.SPRINT 74-C-4.POSSIBILITY THAT THE FRONT UPPER CONTROL ARM INNERBUSHING RETAINER NUTS MAY LOOSEN AND COME OFF DURING NORMAL OPERATINGCONDITIONS.SHOULD THIS OCCUR, THE LOOSE CONTROL ARM MAY MOVE FORWARD ANDCONTACT THE UPPER CONTROL ARM MOUNTING BRACKET ON THE FRAME WHICH RESTRICTS ANYFURTHER FORWARD MOVEMENT.IF THIS VEHICLE IS OPERATED IN THIS CONDITION IT ISPOSSIBLE FOR THE CONTROL ARM CROSS SHAFT TO BREAK.(CORRECT BY INSPECTING ANDINSTALLING NEW BUSHING RETAINERS WHERE NECESSARY.)
CHEVROLET: EL CAMINO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1974 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EL CAMINO: SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
-->| NHTSA Campaign Number: | 72V303000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1973 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WARNING LIGHT/DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 693 |
| Date Owner Notified By Manufacturer: | 19721206 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19721211 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 73-C-05.POSSIBILITY THAT SEAT BELT WARNING SYSTEMMAY BE RENDERED INOPERATIVE DUE TO MISMATING OF RELAY JUMPER WIRE ASSEMBLY ATPARKING BRAKE ALARM SWITCH.(CORRECT BY INSPECTING AND INSTALLING JUMPER WIREWITH TERMINAL AND CONNECTORS THAT MATE PROPERLY.)
CHEVROLET: EL CAMINO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
-->| NHTSA Campaign Number: | 73V152000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720801 - 19730601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3094 |
| Date Owner Notified By Manufacturer: | 19730712 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730716 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO.73-C-15, PONTIAC CAMPAIGN NO 73-C-6, BUICK CAMPAIGN NO73-C-2, GMC CAMPAIGN NO 73-C-20.POSSIBILITY THAT THE GASKET BETWEEN THEMASTER CYLINDER AND THEFORWARD SIDE OF THE DASH, AND THE BOOT WHICH COVERS THEREAR OPENING OF THE MASTER CYLINDER IN THE DRIVER'S COMPARTMENT WEREOMITTED INASSEMBLY.IF THIS CONDITION EXISTS IT COULD CAUSE CORROSION OF THE CYLINDERBORE AND DAMAGE PISTON SEAL RESULTINGIN LOSS OF BRAKE FLUID AND IMPAIREDBRAKING.(CORRECT BY INSPECTING AND REPLACING GASKET AND BOOT.)
CHEVROLET: EL CAMINO: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: EL CAMINO: STEERING:LINKAGES
-->| NHTSA Campaign Number: | 72V275000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1973 |
| Manufacturer Component Description: | STEERING:LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720801 - 19720901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 155418 |
| Date Owner Notified By Manufacturer: | 19721110 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19721114 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO (CHEVROLET 73-C-03, PONTIAC 73-C-1, BUICK 73-C-1,OLDSMOBILE 73-C-2, AND GMC 73-C-1).POSSIBILITY THAT STEERING LINKAGE MAYOVER-TRAVEL AND CAUSE SEVERE FRONT WHEEL TOE-IN.CONDITION CAN OCCUR WHENSTEERING WHEEL IS TURNED TO EXTREME LEFT POSITION WHILE VEHICLE IS IN REVERSEAND RIGHT FRONT TIRE STRIKES OBJECT SUCH AS CURB OR PARKING BLOCK.OPERATIONOF VEHICLE IN THIS CONDITION CAN DAMAGE RIGHT HAND INNER TIE ROD END ASSEMBLYWHICH EVENTUALLY COULD RESULT IN LOSS OF STEERING CONTROL OF RIGHT FRONT WHEEL.(CORRECT BY INSPECTING AND INSTALLING IDLER ARM STOP BRACKET WHERE NECESSARY.)
CHEVROLET: EL CAMINO: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 70V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1970 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12600 |
| Date Owner Notified By Manufacturer: | 19701125 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19701203 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT THROTTLE ROD TO THROTTLE LEVER RETAINING CLIP ON CARBURETORMAY BE INCORRECTLY INSTALLED.IF THIS CONDITION EXISTS, THROTTLE LEVER COULDBE HELD IN PARTIALLY OPEN POSITION.IF THIS OCCURS WHILE VEHICLE IS IN MOTION,VEHICLE WILL NOT SLOW DOWN WHEN DRIVER'S FOOT IS REMOVED FROM ACCELERATOR.(CORRECT BY REPLACING CLIP WITH IMPROVED DESIGN WHERE NECESSARY.)
CHEVROLET: EL CAMINO: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 68V085000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1968 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 310290 |
| Date Owner Notified By Manufacturer: | 19680909 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19680917 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT CARBURETOR THROTTLE LEVER MAY INTERFERE WITH THROTTLE RETAINING CLIP.IF THIS OCCURS, CAN CAUSE THROTTLE LEVER TO BE HELD PARTIALLY OPEN,PREVENTING ITS RETURN TO IDLE POSITION. POSSIBLE THIS WILL MAKE VEHICLE DIFFICULT TO STOP.(CORRECT WHERE NECESSARY WITH IMPROVED TYPE THROTTLE RODCLIP.)
CHEVROLET: EL CAMINO: STEERING:WHEEL AND HANDLE BAR
-->| NHTSA Campaign Number: | 66V032001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EL CAMINO |
| Model Year: | 1967 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 138878 |
| Date Owner Notified By Manufacturer: | 19661110 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19660119 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT STEERING SHAFT MAY HAVE BEEN IMPROPERLY INSTALLED.THIS COULD CAUSE A BINDING CONDITION WHICH, EVEN THOUGH NOT NOTICABLE TO THE OWNER ,MIGHT SUBJECT THE SHAFT TO ABNORMAL STRESSES UNDER CERTAIN CONDITIONS.SHOULD THESE STRESSES BE SEVERE ENOUGH OR EXTEND OVER A SUFFICIENT PERIOD OF TIME, THE STEERING SHAFT COULD BREAK WITH RESULTANT LOSS OF STEERING.(REPLACE ALL SHAFTS WITH IMPROVED DESIGN.)
--CHEVROLET: EQUINOX: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
| NHTSA Campaign Number: | 10V623000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EQUINOX |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 100370 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20100329 - 20101129 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 97843 |
| Date Owner Notified By Manufacturer: | 20110118 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101215 |
| Record Creation Date: | 20101216 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC SRX, CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES. THE DRIVER AND /OR FRONT PASSENGER SAFETY BELT BUCKLE ANCHOR MAY FRACTURE AND SEPARATE NEAR THE SEAT ATTACHMENT IN A VEHICLE CRASH.
Consequence Summary:
THE SAFETY BELT SYSTEM MAY NOT RESTRAIN THE OCCUPANT(S) AS DESIGNED AND COULD INCREASE THE RISK OF INJURY.
Corrective Summary:
DEALERS WILL MODIFY THE PASSENGER AND/OR THE DRIVER SAFETY BELT BUCKLES AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 18, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 100370.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
-- --CHEVROLET: EQUINOX: POWER TRAIN:AUTOMATIC TRANSMISSION
| NHTSA Campaign Number: | 04V302000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EQUINOX |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 4044 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040401 - 20040430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 132 |
| Date Owner Notified By Manufacturer: | 20040817 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040630 |
| Record Creation Date: | 20040701 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, 'THEFT PROTECTION.' AN IGNITION KEY PARK LOCK CABLE END FITTING WAS NOT FULLY SEATED ON THE AUTOMATIC TRANSMISSION SHIFTER NAIL HEAD DURING INSTALLATION.
Consequence Summary:
THIS CAN PREVENT THE CABLE AUTO-SET FROM CORRECTLY ADJUSTING THE CABLE. AN INCORRECTLY ADJUSTED CABLE PREVENTS THE SHIFTER FROM LOCKING IN THE 'PARK' POSITION WHEN THE KEY IS REMOVED FROM THE KEY CYLINDER.
Corrective Summary:
DEALERS WILL INSPECT FOR A PROPERLY FUNCTIONING SHIFT LOCK WHEN THE IGNITION KEY IS REMOVED. DEALERS WILL REPAIR VEHICLES THAT EXHIBIT THE SUBJECT CONDITION. THE RECALL BEGAN AUGUST 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04044.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
--CHEVROLET: EQUINOX: AIR BAGS
| NHTSA Campaign Number: | 07V520000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EQUINOX |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 7281 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20060501 - 20070331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 57100 |
| Date Owner Notified By Manufacturer: | 20080508 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20071107 |
| Record Creation Date: | 20071107 |
| Regulation Part Number: | 573 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIRBAGS OR OPTIONAL SUNROOF FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201,"OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING NHTSA IMPACT TESTS, THE INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD REQUIREMENTS.
Consequence Summary:
THE RESULTS OF THIS TEST INDICATED A POSSIBILITY OF AN INCREASED RISK OF HEAD INJURY IN A CRASH.
Corrective Summary:
DEALERS WILL INSTALL AN ENERGY ABSORBING FOAM PIECE TO EACH OF THE A-PILLAR TRIM ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON MAY 8, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 07281.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: EQUINOX: VISIBILITY:WINDSHIELD
| NHTSA Campaign Number: | 07V242000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EQUINOX |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 7154 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20070401 - 20070531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6213 |
| Date Owner Notified By Manufacturer: | 20070614 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20070613 |
| Record Creation Date: | 20070614 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 212 |
Defect Summary:
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." AN INCORRECT PRIMER MAY HAVE BEEN USED WHEN INSTALLING THE WINDSHIELD. THE SAME PRIMER MAY HAVE ALSO BEEN APPLIED TO THE LIFTGATE GLASS AND THE SIDE STATIONARY GLASS.
Consequence Summary:
IN THE EVENT OF A CRASH, THE WINDSHIELD MAY NOT BE RETAINED TO THE EXTENT REQUIRED BY THE STANDARD, INCREASING THE RISK OF PERSONAL INJURIES TO THE VEHICLE OCCUPANTS.
Corrective Summary:
DEALERS WILL REPLACE THE WINDSHIELD, THE LIFTGATE GLASS, AND THE SIDE STATIONARY GLASS. THE RECALL BEGAN ON JUNE 14, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 07154.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: EQUINOX: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
| NHTSA Campaign Number: | 07V344000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EQUINOX |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 7174 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20061201 - 20070531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 437 |
| Date Owner Notified By Manufacturer: | 20070830 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20070807 |
| Record Creation Date: | 20070808 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." IN THESE VEHICLES, THE RIGHT FRONT PASSENGER SEAT IS BUILT WITH A PASSENGER SENSING SYSTEM. WHEN TESTED WITH A REPRESENTATIVE UNRESTRAINED SMALL ADULT, THE SYSTEM IS REQUIRED TO TURN THE RIGHT FRONT PASSENGER'S FRONTAL AIRBAG ON. AN ERROR IN THE SEAT SENSOR CALIBRATION CAN CAUSE IT TO FAIL THIS TEST. IN ADDITION, THIS CONDITION CAN PREVENT THE AIRBAG FROM TURNING OFF WHEN THE SEAT IS OCCUPIED BY A SMALL CHILD.
Consequence Summary:
WHENEVER THE FRONT PASSENGER SEAT IS OCCUPIED, THE DRIVER SHOULD ALWAYS CHECK THE AIRBAG INDICATOR TO SEE IF THE AIRBAG IS ON OR OFF. IF IT IS NOT CORRECT FOR THE SITUATION, THE PASSENGER SHOULD BE MOVED TO A DIFFERENT SEAT. THIS CAN INCREASE THE RISK OF INJURY TO A SEAT OCCUPANT DURING CERTAIN CRASH CONDITIONS.
Corrective Summary:
DEALERS WILL REPROGRAM THE SEAT'S ELECTRONIC CONTROL UNIT. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 07174.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: EQUINOX: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
| NHTSA Campaign Number: | 09V489000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EQUINOX |
| Model Year: | 2010 |
| Manufacturer Campaign Number: | 90298 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20090201 - 20091130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 59031 |
| Date Owner Notified By Manufacturer: | 20100112 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20091223 |
| Record Creation Date: | 20091223 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 103 & 101 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2010 CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEMS AND WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, CONTROLS AND DISPLAYS". THE SOFTWARE IN THE CENTER INSTRUMENT PANEL CAN CAUSE THE HEATING, AIR CONDITIONING, DEFROST, AND RADIO CONTROLS, AS WELL AS THE PANEL ILLUMINATION TO BECOME INOPERATIVE.
Consequence Summary:
DRIVING WITHOUT A FUNCTIONING DEFROST SYSTEM CAN DECREASE YOUR VISIBILITY UNDER CERTAIN DRIVING CONDITIONS AND COULD RESULT IN A CRASH WITHOUT WARNING.
Corrective Summary:
DEALERS WILL REPLACE THE COMPUTER MODULE IN THE CENTER INSTRUMENT PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JANUARY 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 090298.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
-- --CHEVROLET: EXPRESS: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
-->| NHTSA Campaign Number: | 10V096000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2010 |
| Manufacturer Campaign Number: | 10012 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20090727 - 20090831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 9137 |
| Date Owner Notified By Manufacturer: | 20100312 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100312 |
| Record Creation Date: | 20100312 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 103 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES FOR FAILING TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD WIPING AND WASHING SYSTEMS." THESE VEHICLES WERE BUILT WITH HEATING, VENTILATION, AND AIR CONDITIONING (HVAC) CONTROL KNOBS THAT MAY FRACTURE AND SPIN ON THE CONTROL SHAFT. THE DRIVER MAY NO LONGER BE ABLE TO CONTROL THE HEATING, COOLING, AND VENTILATION FOR THE VEHICLE.
Consequence Summary:
IF THIS CONDITION AFFECTS THE DEFROST SYSTEM WHEN IT IS REQUIRED, IT MAY DECREASE THE DRIVER'S VISIBILITY, AND COULD POSSIBLY RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE ALL HVAC CONTROL KNOBS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 11, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 10012.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
-->| NHTSA Campaign Number: | 10V138000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2010 |
| Manufacturer Campaign Number: | 10216 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20100201 - 20100320 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4485 |
| Date Owner Notified By Manufacturer: | 20100412 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100406 |
| Record Creation Date: | 20100406 |
Defect Summary:
GENERAL MOTORS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2010 CHEVROLET EXPRESS AND GMC SAVANA VANS 2500, 3500 AND 4500 SERIES. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE GENERATOR MAY DEVELOP A LOW RESISTANCE SHORT WITHIN THE VOLTAGE REGULATOR.
Consequence Summary:
THE LOW RESISTANCE SHORT COULD EVENTUALLY GENERATE ENOUGH HEAT TO RESULT IN AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE ANY SUSPECT GENERATORS IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 10216. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
-->| NHTSA Campaign Number: | 10V096000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 10012 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20090526 - 20090610 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 9137 |
| Date Owner Notified By Manufacturer: | 20100312 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100312 |
| Record Creation Date: | 20100312 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 103 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES FOR FAILING TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD WIPING AND WASHING SYSTEMS." THESE VEHICLES WERE BUILT WITH HEATING, VENTILATION, AND AIR CONDITIONING (HVAC) CONTROL KNOBS THAT MAY FRACTURE AND SPIN ON THE CONTROL SHAFT. THE DRIVER MAY NO LONGER BE ABLE TO CONTROL THE HEATING, COOLING, AND VENTILATION FOR THE VEHICLE.
Consequence Summary:
IF THIS CONDITION AFFECTS THE DEFROST SYSTEM WHEN IT IS REQUIRED, IT MAY DECREASE THE DRIVER'S VISIBILITY, AND COULD POSSIBLY RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE ALL HVAC CONTROL KNOBS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 11, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 10012.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V270000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2009 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20050401 - 20090625 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 20090625 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20090706 |
| Record Creation Date: | 20090714 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V272000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2009 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20050401 - 20090625 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 20090625 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20090706 |
| Record Creation Date: | 20090714 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 10V205000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2009 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20071001 - 20100507 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 133 |
| Date Owner Notified By Manufacturer: | 20100527 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20100513 |
| Record Creation Date: | 20100513 |
Defect Summary:
MAIN MOBILITY IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON CHEVROLET EXPRESS AND GMC SAVANA CHASSIS FROM OCTOBER 2007 THROUGH MAY 2010 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.
Consequence Summary:
WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.
Corrective Summary:
MAIN MOBILITY WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
THIS RECALL ONLY PERTAINS TO VEHICLES ALTERED BY MAIN MOBILITY AND HAS NO RELATION TO ANY VEHICLES MANUFACTURED BY GENERAL MOTORS.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 08V569000 |
| Vehicle/Equipment Make: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2008 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42 |
| Date Owner Notified By Manufacturer: | 20081121 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Report Received Date: | 20081024 |
| Record Creation Date: | 20081028 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Corrective Summary:
CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
-->| NHTSA Campaign Number: | 08V340000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 8244 |
| Manufacturer Component Description: | POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20080601 - 20080731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 151 |
| Date Owner Notified By Manufacturer: | 20080815 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080728 |
| Record Creation Date: | 20080724 |
Defect Summary:
GM IS RECALLING 151 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES EQUIPPED WITH ALL WHEEL DRIVE (AWD). SOME OF THESE VEHICLES HAVE TRANSFER CASES THAT WERE MANUFACTURED WITH AN INCORRECT PART THAT CAN CAUSE EARLY FAILURE OF A DRIVE CHAIN. IF THE CHAIN BREAKS, SHIFTING THE TRANSMISSION TO PARK MAY NOT KEEP THE VEHICLE STATIONARY.
Consequence Summary:
IF THE VEHICLE IS PARKED ON AN INCLINE OR BUMPED, IT MAY ROLL AND STRIKE A PERSON, OBJECT, OR ANOTHER VEHICLE WITHOUT WARNING, AND CAUSE PERSONAL INJURY.
Corrective Summary:
DEALERS WILL INSPECT THE TRANSFER CASE DATE CODE AND, IF NECESSARY, REPLACE THE TRANSFER CASE. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08244.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT:ELECTRICAL:AIR CONDITIONER
-->| NHTSA Campaign Number: | 09V456000 |
| Vehicle/Equipment Make: | CUES, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2008 |
| Manufacturer Component Description: | EQUIPMENT:ELECTRICAL:AIR CONDITIONER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 269 |
| Date Owner Notified By Manufacturer: | 20100105 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CUES, INC. |
| Report Received Date: | 20091119 |
| Record Creation Date: | 20091130 |
Defect Summary:
CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.
Consequence Summary:
THIS DEFECT COULD RESULT IN A FIRE.
Corrective Summary:
CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V270000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2008 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20050401 - 20090625 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 20090625 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20090706 |
| Record Creation Date: | 20090714 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: FUEL SYSTEM, GASOLINE:STORAGE
-->| NHTSA Campaign Number: | 08V315000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 8205 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 567 |
| Date Owner Notified By Manufacturer: | 20080730 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080714 |
| Record Creation Date: | 20080714 |
Defect Summary:
GM IS RECALLING 567 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA CUTAWAY VEHICLES WITH A 139" WHEEL BASE. THE FRAME RAIL ON THE DRIVER'S SIDE MAY BE WIDER THAN SPECIFICATION.
Consequence Summary:
IF THE FRAME RAIL IS WIDER THAN SPECIFICATION, OVER TIME IT MAY CONTACT THE FUEL TANK HOUSING, RESULTING IN A POSSIBLE FUEL LEAK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE FRAME RAIL AND FUEL TANK HOUSING AND WILL REWORK THE FRAME RAIL IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JULY 30, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-966-9463, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08205.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V272000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2008 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20050401 - 20090625 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 20090625 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20090706 |
| Record Creation Date: | 20090714 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 10V205000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2008 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20071001 - 20100507 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 133 |
| Date Owner Notified By Manufacturer: | 20100527 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20100513 |
| Record Creation Date: | 20100513 |
Defect Summary:
MAIN MOBILITY IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON CHEVROLET EXPRESS AND GMC SAVANA CHASSIS FROM OCTOBER 2007 THROUGH MAY 2010 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.
Consequence Summary:
WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.
Corrective Summary:
MAIN MOBILITY WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
THIS RECALL ONLY PERTAINS TO VEHICLES ALTERED BY MAIN MOBILITY AND HAS NO RELATION TO ANY VEHICLES MANUFACTURED BY GENERAL MOTORS.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 08V568000 |
| Vehicle/Equipment Make: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2008 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42 |
| Date Owner Notified By Manufacturer: | 20081121 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Report Received Date: | 20081024 |
| Record Creation Date: | 20081028 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 404 |
Defect Summary:
CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 08V313000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 8218 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20070801 - 20080731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6390 |
| Date Owner Notified By Manufacturer: | 20080730 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080711 |
| Record Creation Date: | 20080711 |
Defect Summary:
GM IS RECALLING 2,481 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA G-CUTAWAY FLEET VAN EQUIPPED WITH A 6.0L (RPO LY6) V8 ENGINE, 4L80E (RPO MT1) TRANSMISSION, 4.10 (RPO GT5) AXLE AND 75 MPH GOVERNOR (RPO 9D7). THESE VEHICLES HAVE A CONDITION IN WHICH THE TRANSMISSION MAY BE DAMAGED DUE TO FIRST GEAR ENGAGEMENT AT HIGHWAY SPEEDS AND THEN DOES NOT TRANSMIT POWER WITH D4 OR R SELECTED. THIS MAY BE PRECEDED BY ENGINE SHUTDOWN IF THE VEHICLE EXCEEDS 81 MILES PER HOUR IN CERTAIN CONDITIONS.
Consequence Summary:
THE VEHICLE MAY BE STRANDED ON OR NEAR A HIGHWAY, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPROGRAM THE TRANSMISSION AND ENGINE CONTROL MODULES FREE OF CHARGE. THE RECALL BEGAN ON OR ABOUT JULY 30, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08218.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 08V569000 |
| Vehicle/Equipment Make: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2007 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42 |
| Date Owner Notified By Manufacturer: | 20081121 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Report Received Date: | 20081024 |
| Record Creation Date: | 20081028 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Corrective Summary:
CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V270000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2007 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20050401 - 20090625 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 20090625 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20090706 |
| Record Creation Date: | 20090714 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V272000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2007 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20050401 - 20090625 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 20090625 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20090706 |
| Record Creation Date: | 20090714 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 08V568000 |
| Vehicle/Equipment Make: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2007 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42 |
| Date Owner Notified By Manufacturer: | 20081121 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Report Received Date: | 20081024 |
| Record Creation Date: | 20081028 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 404 |
Defect Summary:
CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 05V552000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5109 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050901 - 20050907 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 32068 |
| Date Owner Notified By Manufacturer: | 20060331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051207 |
| Record Creation Date: | 20051207 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence Summary:
A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Notes:
GM RECALL NO. 05109.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V038000 |
| Vehicle/Equipment Make: | OBS, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | OBS, INC. |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3 |
| Date Owner Notified By Manufacturer: | 20090514 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | OBS, INC. |
| Report Received Date: | 20090128 |
| Record Creation Date: | 20090130 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 404 |
Defect Summary:
OBS IS RECALLING 3 RICON WHEELCHAIR LIFTS WHICH IT INSTALLED ON MY 2006 BLUE BIRD AND CHEVROLET EXPRESS SCHOOL BUSES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
OBS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR OBS AT 1-330-453-3725.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 08V569000 |
| Vehicle/Equipment Make: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42 |
| Date Owner Notified By Manufacturer: | 20081121 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Report Received Date: | 20081024 |
| Record Creation Date: | 20081028 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Corrective Summary:
CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V050000 |
| Vehicle/Equipment Make: | MOBILITY SPECIALIST INC |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MOBILITY SPECIALIST INC |
| Manufacturered: | 20050101 - 20061231 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 43 |
| Date Owner Notified By Manufacturer: | 20090228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MOBILITY SPECIALIST INC |
| Report Received Date: | 20090206 |
| Record Creation Date: | 20090205 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MOBILITY IS RECALLING 43 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Corrective Summary:
MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V049000 |
| Vehicle/Equipment Make: | MOBILITY SPECIALIST INC |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MOBILITY SPECIALIST INC |
| Manufacturered: | 20050101 - 20061231 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 86 |
| Date Owner Notified By Manufacturer: | 20090228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MOBILITY SPECIALIST INC |
| Report Received Date: | 20090206 |
| Record Creation Date: | 20090205 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 404 |
Defect Summary:
MOBILITY IS RECALLING 86 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VAN EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V270000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20050401 - 20090625 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 20090625 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20090706 |
| Record Creation Date: | 20090714 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: SEAT BELTS
-->| NHTSA Campaign Number: | 05V558000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5113 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050401 - 20051031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 425593 |
| Date Owner Notified By Manufacturer: | 20060315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051219 |
| Record Creation Date: | 20051219 |
Defect Summary:
ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
Consequence Summary:
IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Corrective Summary:
DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL WILL BE CONDUCTED IN PHASES. THE FIRST PHASE MAILING BEGAN DURING MARCH 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05113. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
-->| NHTSA Campaign Number: | 05V455000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5086 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050701 - 20050831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 123592 |
| Date Owner Notified By Manufacturer: | 20051014 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051005 |
| Record Creation Date: | 20051006 |
Defect Summary:
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence Summary:
IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05086.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 08V488000 |
| Vehicle/Equipment Make: | QUALITY VAN SALES, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | QUALITY VAN SALES, INC. |
| Manufacturered: | 20060601 - 20060630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 18 |
| Date Owner Notified By Manufacturer: | 20080917 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | QUALITY VAN SALES, INC. |
| Report Received Date: | 20080922 |
| Record Creation Date: | 20080925 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 404 |
Defect Summary:
QUALITY VAN SALES IS RECALLING 18 MY 2005-2007 FORD E-250, MY 2006 FORD E-350, AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
QUALITY VAN SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR QUALITY VAN SALES AT 1-800-408-8550.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V272000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20050401 - 20090625 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 20090625 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20090706 |
| Record Creation Date: | 20090714 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 08V568000 |
| Vehicle/Equipment Make: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42 |
| Date Owner Notified By Manufacturer: | 20081121 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | CUMMINGS MOBILITY CONVERSION & SUPPLY, I |
| Report Received Date: | 20081024 |
| Record Creation Date: | 20081028 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 404 |
Defect Summary:
CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 08V489000 |
| Vehicle/Equipment Make: | QUALITY VAN SALES, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | QUALITY VAN SALES, INC. |
| Manufacturered: | 20060601 - 20060630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 18 |
| Date Owner Notified By Manufacturer: | 20080917 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | QUALITY VAN SALES, INC. |
| Report Received Date: | 20080922 |
| Record Creation Date: | 20080925 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
QUALITY VAN SALES IS RECALLING 18 MY 2005-2007 FORD E-250, MY 2006 FORD E-350 AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Corrective Summary:
QUALITY VAN SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR QUALITY VAN SALES AT 1-800-408-8550.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: SEAT BELTS
-->| NHTSA Campaign Number: | 08V238000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 05113A |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050401 - 20051031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4003 |
| Date Owner Notified By Manufacturer: | 20080430 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080415 |
| Record Creation Date: | 20080529 |
Defect Summary:
GM IS RECALLING 4,003 MY 2006 CHEVROLET EXPRESS AND GMC SAVANA FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS. THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
Consequence Summary:
IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Corrective Summary:
DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL BEGAN ON APRIL 30, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 05V558).
Notes:
GM RECALL NO. 05113A. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2005 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V050000 |
| Vehicle/Equipment Make: | MOBILITY SPECIALIST INC |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2005 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MOBILITY SPECIALIST INC |
| Manufacturered: | 20050101 - 20061231 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 43 |
| Date Owner Notified By Manufacturer: | 20090228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MOBILITY SPECIALIST INC |
| Report Received Date: | 20090206 |
| Record Creation Date: | 20090205 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MOBILITY IS RECALLING 43 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Corrective Summary:
MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V049000 |
| Vehicle/Equipment Make: | MOBILITY SPECIALIST INC |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2005 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MOBILITY SPECIALIST INC |
| Manufacturered: | 20050101 - 20061231 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 86 |
| Date Owner Notified By Manufacturer: | 20090228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MOBILITY SPECIALIST INC |
| Report Received Date: | 20090206 |
| Record Creation Date: | 20090205 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 404 |
Defect Summary:
MOBILITY IS RECALLING 86 MY 2005-2006 FORD E-SERIES AND CHEVROLET EXPRESS VAN EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY AT 714-674-0480.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V270000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2005 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20050401 - 20090625 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 20090625 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20090706 |
| Record Creation Date: | 20090714 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: SEAT BELTS
-->| NHTSA Campaign Number: | 05V558000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5113 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20050630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 425593 |
| Date Owner Notified By Manufacturer: | 20060315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051219 |
| Record Creation Date: | 20051219 |
Defect Summary:
ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
Consequence Summary:
IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Corrective Summary:
DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL WILL BE CONDUCTED IN PHASES. THE FIRST PHASE MAILING BEGAN DURING MARCH 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05113. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 05V043000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5006 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20040930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77411 |
| Date Owner Notified By Manufacturer: | 20050323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050208 |
| Record Creation Date: | 20050208 |
Defect Summary:
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence Summary:
IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05006.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 09V272000 |
| Vehicle/Equipment Make: | MAIN MOBILITY, INC. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2005 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | MAIN MOBILITY, INC. |
| Manufacturered: | 20050401 - 20090625 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 185 |
| Date Owner Notified By Manufacturer: | 20090625 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | MAIN MOBILITY, INC. |
| Report Received Date: | 20090706 |
| Record Creation Date: | 20090714 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 04V045000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4004 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030601 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 68875 |
| Date Owner Notified By Manufacturer: | 20040618 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 135 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence Summary:
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective Summary:
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 04V189000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4025 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20040430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 331 |
| Date Owner Notified By Manufacturer: | 20040507 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040419 |
| Record Creation Date: | 20040421 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
CERTAIN VANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THESE VEHICLES MAY HAVE BEEN PRODUCED WITH SEAT BELT BUCKLE ASSEMBLIES CONTAINING A LATCH WITH A BRITTLE CONDITION THAT MAY NOT WITHSTAND THE FORCE REQUIREMENTS OF THE STANDARD.
Consequence Summary:
THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, WHICH COULD RESULT IN INJURY TO THE OCCUPANT.
Corrective Summary:
DEALERS WILL REPLACE THE SAFETY BELT BUCKLE. THE RECALL BEAGN MAY 7, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04025.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: SEAT BELTS
-->| NHTSA Campaign Number: | 05V558000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5113 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030301 - 20040731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 425593 |
| Date Owner Notified By Manufacturer: | 20060315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051219 |
| Record Creation Date: | 20051219 |
Defect Summary:
ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
Consequence Summary:
IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Corrective Summary:
DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL WILL BE CONDUCTED IN PHASES. THE FIRST PHASE MAILING BEGAN DURING MARCH 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05113. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 05V043000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5006 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040201 - 20040731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77411 |
| Date Owner Notified By Manufacturer: | 20050323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050208 |
| Record Creation Date: | 20050208 |
Defect Summary:
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence Summary:
IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05006.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-->| NHTSA Campaign Number: | 04V320000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4061 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040518 - 20040525 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1792 |
| Date Owner Notified By Manufacturer: | 20040819 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040706 |
| Record Creation Date: | 20040707 |
Defect Summary:
CERTAIN VANS WERE BUILT WITH A TRANSMISSION SHIFT CABLE ASSEMBLY THAT MAY SEPARATE. IF THE CABLE ASSEMBLY SEPARATES, THE TRANSMISSION SHIFT LEVER POSITION AND THE TRANSMISSION INDICATOR MAY NO LONGER CORRELATE.
Consequence Summary:
IF THIS WERE TO OCCUR, THE VEHICLE COULD MOVE IN A DIRECTION NOT ANTICIPATED BY THE DRIVER, WHICH COULD RESULT IN A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE TRANSMISSION SHIFT CABLE ASSEMBLY, AND IF NECESSARY, REPLACE IT. THE RECALL BEGAN ON AUGUST 19, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04061.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 03V217000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3031 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20030131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 50225 |
| Date Owner Notified By Manufacturer: | 20030721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030610 |
| Record Creation Date: | 20030611 |
Defect Summary:
CERTAIN VANS HAVE A CONDITION IN WHICH WATER MAY ENTER AND CORRODE THE REAR LICENSE PLATE LAMP SOCKET. IF THE LAMP SOCKET WERE TO CORRODE, THE REAR LICENSE PLATE LAMP MAY OPERATE INTERMITTENTLY OR NOT AT ALL, AND THE LEFT REAR TAIL LAMP MAY BECOME INOPERATIVE. THE TEMPERATURE OF THE LICENSE PLATE LAMP SOCKET COULD INCREASE TO THE POINT THAT IT MAY BEGIN TO SOFTEN AND MELT.
Consequence Summary:
IF THE SOCKET ASSEMBLY WERE TO REACH THE POINT OF MELTING, THE OCCUPANTS OF THE VEHICLE MAY NOTICE AN ODOR AND SMOKE AT THE REAR DOORS OF THE VEHICLE. IF THIS ODOR AND SMOKE WERE IGNORED, THE PLASTIC COULD IGNITE AND A FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A NEW SEALED REAR LICENSE PLATE LAMP SOCKET ASSEMBLY. OWNER NOTIFICATION BEGAN JULY 21, 2003. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03031.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: STEERING:LINKAGES
-->| NHTSA Campaign Number: | 02V330000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 2063 |
| Manufacturer Component Description: | STEERING:LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20021014 - 20021025 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4158 |
| Date Owner Notified By Manufacturer: | 20021210 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20021212 |
| Record Creation Date: | 20021219 |
Defect Summary:
ON CERTAIN VANS WITH AN 8,500 LB. OR 8,600 LB. GROSS VEHICLE WEIGHT RATING, THE NUT ATTACHING THE PITMAN ARM TO THE STEERING LINKAGE MAY NOT BE TIGHTENED ADEQUATELY RESULTING IN A POSSIBLE SEPARATION.
Consequence Summary:
A SEPARATION COULD RESULT IN LOSS OF VEHICLE CONTROL, AND A CRASH COULD OCCUR WITH PRIOR WARNING.
Corrective Summary:
DEALERS WILL TIGHTEN THE PITMAN ARM NUT TO THE PROPER SPECIFICATION. IF THE NUT IS MISSING, THE DEALER WILL INSTALL A NEW NUT AND TIGHTEN IT CORRECTLY. OWNER NOTIFICATION BEGAN DECEMBER 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 02063.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-->| NHTSA Campaign Number: | 03V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3039 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1707825 |
| Date Owner Notified By Manufacturer: | 20030820 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030715 |
| Record Creation Date: | 20030724 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence Summary:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 03039.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: SEAT BELTS:FRONT:BUCKLE ASSEMBLY
-->| NHTSA Campaign Number: | 03V050000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3007 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:BUCKLE ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20030112 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 18327 |
| Date Owner Notified By Manufacturer: | 20030603 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030214 |
| Record Creation Date: | 20030224 |
Defect Summary:
ON CERTAIN VANS WITH A GROSS VEHICLE WEIGHT OF LESS THAN 8,500 POUNDS, DURING A VEHICLE CRASH SUFFICIENT ENOUGH TO DEPLOY THE SAFETY BELT PRETENSIONER, THE FRONT SAFETY BELT BUCKLES MAY NOT RELEASE AFTER THE VEHICLE CRASH, OR ALTERNATELY MAY EJECT THE SAFETY BELT LATCH DURING THE VEHICLE CRASH.
Consequence Summary:
THIS COULD RESULT IN INCREASED RISK OF PERSONAL INJURY.
Corrective Summary:
DEALERS WILL REPLACE THE FRONT DRIVER AND PASSENGER SIDE SAFETY BELT BUCKLE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03007. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 04V225000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4038 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020601 - 20030531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 736 |
| Date Owner Notified By Manufacturer: | 20040909 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040511 |
| Record Creation Date: | 20040512 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Consequence Summary:
THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Corrective Summary:
TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04038.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 04V045000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4004 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030501 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 68875 |
| Date Owner Notified By Manufacturer: | 20040618 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 135 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence Summary:
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective Summary:
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: SEAT BELTS
-->| NHTSA Campaign Number: | 05V558000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 5113 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020201 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 425593 |
| Date Owner Notified By Manufacturer: | 20060315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051219 |
| Record Creation Date: | 20051219 |
Defect Summary:
ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.
Consequence Summary:
IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Corrective Summary:
DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL WILL BE CONDUCTED IN PHASES. THE FIRST PHASE MAILING BEGAN DURING MARCH 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05113. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: WHEELS:LUGS/NUTS/BOLTS
-->| NHTSA Campaign Number: | 02V305000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 2053 |
| Manufacturer Component Description: | WHEELS:LUGS/NUTS/BOLTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20021031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 18409 |
| Date Owner Notified By Manufacturer: | 20021113 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20021114 |
| Record Creation Date: | 20021119 |
Defect Summary:
CERTAIN VANS WERE BUILT WITHOUT A WHEEL BEARING ASSEMBLY RETAINING NUT, WHICH COULD LEAD TO A POSSIBLE BEARING SEPARATION.
Consequence Summary:
IF THIS WERE TO OCCUR, THE AMBER-COLORED ABS TELL-TALE LAMP IN THE INSTRUMENT PANEL WOULD ILLUMINATE AND THE ABS SYSTEM WOULD BE DISABLED. THE DRIVER WOULD ALSO NOTICE A GRINDING NOISE, A DECREASE IN THE VEHICLE SPEED, AND THE STEERING WILL PULL IN THE DIRECTION OF THE AFFECTED BRAKE ASSEMBLY. THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE WHEEL BEARING ASSEMBLY. IF THE INSPECTION REVEALS A MISSING RETAINING NUT, THE WHEEL BEARING ASSEMBLY WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: STEERING:LINKAGES:TIE ROD ASSEMBLY
-->| NHTSA Campaign Number: | 02V326000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 2058 |
| Manufacturer Component Description: | STEERING:LINKAGES:TIE ROD ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20021031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 18648 |
| Date Owner Notified By Manufacturer: | 20021127 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20021202 |
| Record Creation Date: | 20021219 |
Defect Summary:
ON CERTAIN VANS, THE RIGHT-HAND TIE ROD END NUT MAY NOT BE TIGHTENED ADEQUATELY. THE NUT CAN LOOSEN RESULTING IN SEPARATION OF THE TIE ROD FROM THE STEERING KNUCKLE.
Consequence Summary:
SEPARATION OF A TIE ROD CAN CAUSE UNEXPECTED VEHICLE STEERING IN SOME MANEUVERS AND COULD CAUSE A CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL TIGHTEN THE TIE ROD END NUT AND, IF NECESSARY, REPLACE THE TIE ROD END. OWNER NOTIFICATION BEGAN NOVEMBER 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
CGM RECALL NO. 02058. USTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 08V650000 |
| Vehicle/Equipment Make: | RIFLED AIR CONDITIONING SYSTEMS |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2001 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | RIFLED AIR CONDITIONING SYSTEMS |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6 |
| Date Owner Notified By Manufacturer: | 20090105 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | RIFLED AIR CONDITIONING SYSTEMS |
| Report Received Date: | 20081210 |
| Record Creation Date: | 20081210 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 404 |
Defect Summary:
RIFLED AIR CONDITIONING (RAC) IS RECALLING 6 MY 2001 CHEVROLET EXPRESS PRIVATE TRANSPORT, MY 2005 THOMAS BUILT FS65, MY 2006-2007 MONITOUR BUS, AND MY 2007 C-2 SCHOOL BUS VEHICLES BUILT ON FREIGHTLINER, AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence Summary:
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Corrective Summary:
RAC IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR RAC AT 1-800-627-1707.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: EQUIPMENT ADAPTIVE
-->| NHTSA Campaign Number: | 08V649000 |
| Vehicle/Equipment Make: | RIFLED AIR CONDITIONING SYSTEMS |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 2001 |
| Manufacturer Component Description: | EQUIPMENT ADAPTIVE |
| Manufacturers Involved in Recall: | RIFLED AIR CONDITIONING SYSTEMS |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6 |
| Date Owner Notified By Manufacturer: | 20090105 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | RIFLED AIR CONDITIONING SYSTEMS |
| Report Received Date: | 20081209 |
| Record Creation Date: | 20081209 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 403 |
Defect Summary:
RIFLED AIR CONDITIONING (RAC) IS RECALLING 6 MY 2001 CHEVROLET EXPRESS PRIVATE TRANSPORT, MY 2005 THOMAS BUILT FS65, MY 2006-2007 MONITOUR BUS, AND MY 2007 C-2 SCHOOL BUS VEHICLES BUILT ON FREIGHTLINER, AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403,"PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence Summary:
A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Corrective Summary:
RAC IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR RAC AT 1-800-627-1707.
Notes:
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: EXPRESS: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
-->| NHTSA Campaign Number: | 00V085000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 28 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980301 - 19990630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 10468 |
| Date Owner Notified By Manufacturer: | 20000411 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000316 |
| Record Creation Date: | 20000322 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
Consequence Summary:
IF THIS OCCURS, POWER STEERING FLUID COULD FLOW ONTO HOT ENGINE PARTS AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT FOR THREE SCREW CLAMPS TO THE POWER STEERING HOSE JOINTS. IF THE CLAMPS ARE NOT THE SCREW TYPE, DEALERS WILL REPLACE THE CLAMPS.
Notes:
OWNER NOTIFICATION BEGAN APRIL 11, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 98V033000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 1998 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19971001 - 19971031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1137 |
| Date Owner Notified By Manufacturer: | 19980315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980217 |
| Record Creation Date: | 19980225 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. ONE OR BOTH FRONT BRAKE ROTOR/HUBS WERE BUILT WITH AN OUT-OF-SPECIFICATION GRAY IRON THAT CAN FAIL DURING THE LIFE OF THE VEHICLE.
Consequence Summary:
IF A DRIVER CONTINUES TO DRIVE WITH A CRACKED ROTOR, THE CRACKS COULD CONTINUE AROUND THE WHEEL MOUNTING BOLT CIRCLE AND ULTIMATELY RESULT IN A WHEEL SEPARATION.
Corrective Summary:
DEALERS WILL INSPECT THE ROTORS FOR A CORE DATE OF "287" AND, IF FOUND, REPLACE THE ROTOR.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 00V110000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 31 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950901 - 19970630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 109239 |
| Date Owner Notified By Manufacturer: | 20010326 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000417 |
| Record Creation Date: | 20000428 |
Defect Summary:
PASSENGER VANS. THESE VANS EXPERIENCE FUEL ODORS OR LEAKAGE.
Consequence Summary:
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A REVISED EVAPORATIVE EMISSION PIPE ASSEMBLY.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN MARCH 26, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: EXPRESS: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 00V110000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 31 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950901 - 19970630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 109239 |
| Date Owner Notified By Manufacturer: | 20010326 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000417 |
| Record Creation Date: | 20000428 |
Defect Summary:
PASSENGER VANS. THESE VANS EXPERIENCE FUEL ODORS OR LEAKAGE.
Consequence Summary:
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A REVISED EVAPORATIVE EMISSION PIPE ASSEMBLY.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN MARCH 26, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: EXPRESS: SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE
-->| NHTSA Campaign Number: | 96V092000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | EXPRESS |
| Model Year: | 1996 |
| Manufacturer Component Description: | SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19951001 - 19960301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 105 |
| Date Owner Notified By Manufacturer: | 19960620 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960603 |
| Record Creation Date: | 19960613 |
Defect Summary:
ONE OF THE FOUR REAR AXLE U-BOLTS CAN BREAK. THIS CAN POTENTIALLY LEAD TO THE SPRING LIFTING FROM THE AXLE UNDER CERTAIN REBOUND, BRAKING OR CORNERING MANEUVERS.
Consequence Summary:
THIS CONDITION COULD RESULT IN SUDDEN LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL REPLACE THE FOUR REAR AXLE U-BOLTS ON THE AFFECTED VEHICLES.
Notes:
SYSTEM: SUSPENSION; REAR; LEAF SPRING; U-BOLT. VEHICLE DESCRIPTION: CARGO VANS EQUIPPED WITH 7,700 LB. OR GREATER GROSS VEHICLE WEIGHT RATING. OWNER NOTIFICATION:OWNER LETTERS ARE EXPECTED TO BE MAILED DURING JUNE 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
--CHEVROLET: HHR: AIR BAGS:FRONTAL
| NHTSA Campaign Number: | 06V417000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | HHR |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 6102 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050701 - 20050731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 794 |
| Date Owner Notified By Manufacturer: | 20061106 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20061031 |
| Record Creation Date: | 20061101 |
Defect Summary:
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence Summary:
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Corrective Summary:
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Notes:
GM RECALL NO. 06102.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: HHR: AIR BAGS
| NHTSA Campaign Number: | 08V046000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | HHR |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 8016 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 181516 |
| Date Owner Notified By Manufacturer: | 20080402 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080130 |
| Record Creation Date: | 20080131 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence Summary:
THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Corrective Summary:
DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08016.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: HHR: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
| NHTSA Campaign Number: | 08V444000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | HHR |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 8157 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050430 - 20060630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 296422 |
| Date Owner Notified By Manufacturer: | 20081223 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080903 |
| Record Creation Date: | 20080903 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence Summary:
THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Corrective Summary:
A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08157.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: HHR: AIR BAGS
| NHTSA Campaign Number: | 08V046000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | HHR |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 8016 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 181516 |
| Date Owner Notified By Manufacturer: | 20080402 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080130 |
| Record Creation Date: | 20080131 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence Summary:
THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Corrective Summary:
DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08016.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: HHR: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
| NHTSA Campaign Number: | 08V444000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | HHR |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 8157 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20060530 - 20070630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 296422 |
| Date Owner Notified By Manufacturer: | 20081223 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080903 |
| Record Creation Date: | 20080903 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence Summary:
THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Corrective Summary:
A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08157.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: HHR: AIR BAGS
| NHTSA Campaign Number: | 08V046000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | HHR |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 8016 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 181516 |
| Date Owner Notified By Manufacturer: | 20080402 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080130 |
| Record Creation Date: | 20080131 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
GM IS RECALLING 181,516 MY 2006-2008 CHEVROLET HHR VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIR BAGS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.' IN TESTS, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENT.
Consequence Summary:
THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Corrective Summary:
DEALERS WILL INSTALL AN ENERGY-ABSORBING PLASTIC PIECE TO THE HEADLINER TRIM. THE RECALL BEGAN ON APRIL 2, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08016.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: HHR: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
| NHTSA Campaign Number: | 08V444000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | HHR |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 8157 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20070501 - 20080430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 296422 |
| Date Owner Notified By Manufacturer: | 20081223 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080903 |
| Record Creation Date: | 20080903 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
GM IS RECALLING 296,422 MY 2006-2008 CHEVROLET HHR VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT." THE DOOR ON THE STORAGE BIN IN THE TOP CENTER OF THE INSTRUMENT PANEL FAILED TO REMAIN CLOSED AS REQUIRED.
Consequence Summary:
THIS STANDARD SPECIFIES PERFORMANCE REQUIREMENTS TO PROVIDE HEAD IMPACT PROTECTION FOR OCCUPANTS.
Corrective Summary:
A REDESIGNED LATCH WILL BE MADE AVAILABLE. THE RECALL BEGAN ON DECEMBER 23, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08157.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: HHR: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
| NHTSA Campaign Number: | 09V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | HHR |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 9041 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 276729 |
| Date Owner Notified By Manufacturer: | 20090315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090306 |
| Record Creation Date: | 20090306 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 102 & 114 |
Defect Summary:
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GENERAL MOTORS RECALL NO. 09041.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
-- --CHEVROLET: IMPALA: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
| NHTSA Campaign Number: | 11V398000 |
| Vehicle/Equipment Make: | GENERAL MOTORS LLC |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2012 |
| Manufacturer Campaign Number: | 11224 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20110419 - 20110729 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 10344 |
| Date Owner Notified By Manufacturer: | 20110905 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS LLC |
| Report Received Date: | 20110805 |
| Record Creation Date: | 20110804 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET IMPALA VEHICLES MANUFACTURED FROM APRIL 19, 2011, THROUGH JULY 29, 2011. THE UPPER POWER STEERING HOSE MAY HAVE BEEN MISROUTED SO THAT IT CAN COME IN CLOSE PROXIMITY TO AND/OR CONTACT THE CATALYTIC CONVERTER. WITH THE ENGINE ON, HEAT FROM THE CATALYTIC CONVERTER MAY MELT THE POWER STEERING HOSE.
Consequence Summary:
POWER STEERING FLUID COULD FLOW ONTO THE CATALYTIC CONVERTER, AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
GM DEALERS WILL INSPECT TO ENSURE THAT THE UPPER POWER STEERING HOSE IS ROUTED CORRECTLY AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 5, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM'S SAFETY RECALL CAMPAIGN NUMBER IS 11224. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: IMPALA: STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT
| NHTSA Campaign Number: | 67V098000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1965 |
| Manufacturer Component Description: | STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1143000 |
| Date Owner Notified By Manufacturer: | 19671023 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19671023 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT, AFTER EXTENDED MILEAGE, THE IDLER ARM ASSEMBLY COULD SEPARATE DURING VEHICLE OPERATION AND RESULT IN A SEVERE PULL TO THE RIGHT AS BRAKES ARE APPLIED AT LOW TO MODERATE SPEED.(INSPECT AND RE- PLACE IDLER ARM ASSEMBLY AS REQUIRED.)
--CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
-- --CHEVROLET: IMPALA: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 10V480000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2010 |
| Manufacturer Campaign Number: | 10312 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20090401 - 20100330 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 303100 |
| Date Owner Notified By Manufacturer: | 20101105 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101013 |
| Record Creation Date: | 20101013 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET IMPALAS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE FRONT SAFETY BELT WEBBING MAY NOT HAVE BEEN PROPERLY SECURED TO THE LAP BELT ANCHOR PRETENSIONER MOUNTED TO THE SIDE OF THE SEAT NEAREST THE DOOR.
Consequence Summary:
THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, WHICH COULD RESULT IN INJURY TO THE OCCUPANT.
Corrective Summary:
DEALERS WILL INSPECT BOTH FRONT SAFETY BELTS FOR PROPER INSTALLATION OF THE ANCHORS TO THE PRETENSIONERS AND, IF NECESSARY, REINSTALL THE ANCHORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 5, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 10312.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 10V480000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 10312 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20080401 - 20090630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 303100 |
| Date Owner Notified By Manufacturer: | 20101105 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101013 |
| Record Creation Date: | 20101013 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET IMPALAS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE FRONT SAFETY BELT WEBBING MAY NOT HAVE BEEN PROPERLY SECURED TO THE LAP BELT ANCHOR PRETENSIONER MOUNTED TO THE SIDE OF THE SEAT NEAREST THE DOOR.
Consequence Summary:
THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, WHICH COULD RESULT IN INJURY TO THE OCCUPANT.
Corrective Summary:
DEALERS WILL INSPECT BOTH FRONT SAFETY BELTS FOR PROPER INSTALLATION OF THE ANCHORS TO THE PRETENSIONERS AND, IF NECESSARY, REINSTALL THE ANCHORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 5, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 10312.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 08V517000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 8342 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20080701 - 20080930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 79 |
| Date Owner Notified By Manufacturer: | 20081010 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20081006 |
| Record Creation Date: | 20081006 |
Defect Summary:
GM IS RECALLING 79 MY 2009 CHEVROLET IMPALA VEHICLES. SOME OF THESE VEHICLES HAVE A PASSENGER-SIDE FRONT AIR BAG INFLATOR THAT COULD FRACTURE AT AN INFLATOR TUBE DURING A DEPLOYMENT.
Consequence Summary:
DURING A PASSENGER-SIDE AIR BAG DEPLOYMENT, PIECES OF THE INFLATOR TUBE COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE PASSENGER.
Corrective Summary:
DEALERS WILL INSTALL A NEW PASSENGER-SIDE FRONT AIR BAG. THE RECALL BEGAN ON OCTOBER 10, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08342.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: FUEL SYSTEM, GASOLINE:STORAGE
-->| NHTSA Campaign Number: | 06V419000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 6160 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20060801 - 20060831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1602 |
| Date Owner Notified By Manufacturer: | 20061113 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20061031 |
| Record Creation Date: | 20061101 |
Defect Summary:
ON CERTAIN VEHICLES, THE FUEL TANK IS MISSING THE ADHESIVE LAYER THAT BONDS THE BARRIER LAYER TO THE OUTER SHELL OF THE FUEL TANK.
Consequence Summary:
WITH THIS CONDITION, FUEL AND/OR FUEL VAPORS COULD SEEP OUT BETWEEN THE LAYERS, INCREASING THE RISK OF A FIRE.
Corrective Summary:
DEALERS WILL INSPECT THE SERIAL NUMBER ON THE FUEL TANK AND REPLACE THE FUEL TANK IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 13, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 06160.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2007 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2006 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA (GMX 211): SEATS
-->| NHTSA Campaign Number: | 06V215000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA (GMX 211) |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 6016 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20051001 - 20051027 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2023 |
| Date Owner Notified By Manufacturer: | 20060705 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060615 |
| Record Creation Date: | 20060615 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
CERTAIN VEHICLES EQUIPPED WITH A MANUAL PASSENGER SEAT ADJUSTER FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE LEFT FLOOR MOUNTING BRACKET MAY BE MISLOCATED.
Consequence Summary:
IN A SEVERE VEHICLE CRASH, THE SEAT ADJUSTER MAY SEPARATE FROM THE MOUNTING BRACKET, INCREASING THE RISK OF OCCUPANT INJURY.
Corrective Summary:
DEALERS WILL INSPECT THE SEAT ADJUSTER AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE RECALL ON JULY 2, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 06016.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2005 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2005 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2005 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 04V287000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4049 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20040430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 47991 |
| Date Owner Notified By Manufacturer: | 20040628 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040623 |
| Record Creation Date: | 20040623 |
Defect Summary:
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Consequence Summary:
DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
Corrective Summary:
DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
Notes:
RECALL NO. 04049.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: IMPALA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2004 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2004 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2004 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE
-->| NHTSA Campaign Number: | 03V051000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3008 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020701 - 20021031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130 |
| Date Owner Notified By Manufacturer: | 20030311 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030214 |
| Record Creation Date: | 20030224 |
Defect Summary:
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence Summary:
THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Corrective Summary:
DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
Notes:
GM RECALL NO. 03008. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: IMPALA: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 02V222000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 2032 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020501 - 20020731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 133221 |
| Date Owner Notified By Manufacturer: | 20020815 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020809 |
| Record Creation Date: | 20020814 |
Defect Summary:
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence Summary:
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Corrective Summary:
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Notes:
GM RECALL NO. 02032. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: IMPALA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2003 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2003 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 09V116000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 9047 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1497516 |
| Date Owner Notified By Manufacturer: | 20090409 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090408 |
| Record Creation Date: | 20090408 |
Defect Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2003 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 02V222000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 2032 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020501 - 20020731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 133221 |
| Date Owner Notified By Manufacturer: | 20020815 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020809 |
| Record Creation Date: | 20020814 |
Defect Summary:
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence Summary:
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Corrective Summary:
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Notes:
GM RECALL NO. 02032. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: IMPALA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2002 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2002 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 09V116000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 9047 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1497516 |
| Date Owner Notified By Manufacturer: | 20090409 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090408 |
| Record Creation Date: | 20090408 |
Defect Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2002 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: AIR BAGS:SIDE/WINDOW
-->| NHTSA Campaign Number: | 00V371000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 90 |
| Manufacturer Component Description: | AIR BAGS:SIDE/WINDOW |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000201 - 20000731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12 |
| Date Owner Notified By Manufacturer: | 20001116 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20001113 |
| Record Creation Date: | 20001116 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence Summary:
IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Corrective Summary:
DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING DECEMBER 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR BUICK AT 1-800-521-7300.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: IMPALA: AIR BAGS
-->| NHTSA Campaign Number: | 00V244000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 73 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000701 - 20000731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 580 |
| Date Owner Notified By Manufacturer: | 20001026 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000829 |
| Record Creation Date: | 20000825 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence Summary:
IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Corrective Summary:
DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Notes:
OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: IMPALA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2001 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2001 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 09V116000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 9047 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1497516 |
| Date Owner Notified By Manufacturer: | 20090409 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090408 |
| Record Creation Date: | 20090408 |
Defect Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 01V136000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 1035 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19990101 - 20010331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 126745 |
| Date Owner Notified By Manufacturer: | 20010629 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010424 |
| Record Creation Date: | 20010426 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 301 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence Summary:
IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: IMPALA: SEAT BELTS
-->| NHTSA Campaign Number: | 00V228003 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 67 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000501 - 20000531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 156305 |
| Date Owner Notified By Manufacturer: | 20000824 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000807 |
| Record Creation Date: | 20000822 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Notes:
OWNER NOTIFICATION BEGAN AUGUST 24, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; CHEVROLET AT 1-800-222-1020; GMC AT 1-800-462-8782; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR SATURN AT 1-800-553-6000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: IMPALA: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 2001 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: IMPALA: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1985 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1983 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: VEHICLE SPEED CONTROL:CABLES
-->| NHTSA Campaign Number: | 83V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1983 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19801001 - 19830401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19108 |
| Date Owner Notified By Manufacturer: | 19830810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830819 |
| Record Creation Date: | 19830906 |
Defect Summary:
ACCELERATOR PUMP LEVER RETAINING PIN MAY LOOSEN AFTER REPEATED HEAVY ACCELERATOR PEDAL APPLICATIONS. THIS COULD CAUSE THE THROTTLE TO BECOME STUCK IN THE OPEN POSITION.
Corrective Summary:
DEALER WILL INSTALL A SPECIAL COTTER PIN, TO RETAIN THE ACCELERATOR PUMP PIN, AND A SPRING CLIP THRUST WASHER ON THE ACCELERATOR PUMP LINK.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CLOSED LOOP QUADRAJETCARBURETORS AND POLICE CAR PACKAGES.SYSTEM: POWER TRAIN; ACCELERATOR PUMP LEVER RETAINING PIN.CONSEQUENCES OF DEFECT: VEHICLE SPEED WOULD NOT DECREASE EVEN AFTER THEACCELERATOR PEDAL IS NO LONGER DEPRESSED. LOSS OF ACCELERATOR CONTROL WITHOUTPRIOR WARNING COULD RESULT IN AN ACCIDENT.NOTE: IF THE FAILURE OCCURS BEFORE CORRECTIVE SERVICE CAN BE PERFORMED, DRIVERSHOULD SHIFT TO NEUTRAL GEAR AND APPLY BRAKES AS NECESSARY. VEHICLE SHOULD BEPULLED OUT OF TRAFFIC AND THE IGNITION SHOULD BE TURNED OFF AFTER A COMPLETESTOP.
CHEVROLET: IMPALA: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1982 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: IMPALA: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
-->| NHTSA Campaign Number: | 82V012000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1982 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810801 - 19811101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 79686 |
| Date Owner Notified By Manufacturer: | 19820218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19820103 |
| Record Creation Date: | 19820208 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATING CONDITIONS, THE GOVERNOR WEIGHT RETAINER IN THE INJECTION PUMP MAY FAIL. THE THROTTLE VALVE COULD STICK, PREVENTING RETURN TO IDLE AND SHUT DOWN OF THE ENGINE BY THE DRIVER.
Corrective Summary:
DEALER WILL REPLACE THE GOVERNOR WEIGHT ASSEMBLY IN THE INJECTION PUMP AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 5.7 V8 ENGINES.SYSTEM: FUEL; THROTTLE VALVE.CONSEQUENCES OF DEFECT: THIS COULD RESULT IN LOSS OF VEHICLE CONTROL AND AVEHICLE ACCIDENT.NOTE: IF THROTTLE STICKING OCCURS BEFORE THE VEHICLE HAS RECEIVED THE NECESSARYMODIFICATIONS, THE DRIVER SHOULD SHIFT THE TRANSMISSION TO NEUTRAL, APPLY THESERVICE BRAKES TO BRING THE VEHICLE TO A SAFE STOP, THE IGNITION SHOULD BETURNED OFF AND THE NEAREST DEALERSHIP SHOULD BE CALLED FOR ASSISTANCE.
CHEVROLET: IMPALA: VEHICLE SPEED CONTROL:CABLES
-->| NHTSA Campaign Number: | 83V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1982 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19801001 - 19830401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19108 |
| Date Owner Notified By Manufacturer: | 19830810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830819 |
| Record Creation Date: | 19830906 |
Defect Summary:
ACCELERATOR PUMP LEVER RETAINING PIN MAY LOOSEN AFTER REPEATED HEAVY ACCELERATOR PEDAL APPLICATIONS. THIS COULD CAUSE THE THROTTLE TO BECOME STUCK IN THE OPEN POSITION.
Corrective Summary:
DEALER WILL INSTALL A SPECIAL COTTER PIN, TO RETAIN THE ACCELERATOR PUMP PIN, AND A SPRING CLIP THRUST WASHER ON THE ACCELERATOR PUMP LINK.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CLOSED LOOP QUADRAJETCARBURETORS AND POLICE CAR PACKAGES.SYSTEM: POWER TRAIN; ACCELERATOR PUMP LEVER RETAINING PIN.CONSEQUENCES OF DEFECT: VEHICLE SPEED WOULD NOT DECREASE EVEN AFTER THEACCELERATOR PEDAL IS NO LONGER DEPRESSED. LOSS OF ACCELERATOR CONTROL WITHOUTPRIOR WARNING COULD RESULT IN AN ACCIDENT.NOTE: IF THE FAILURE OCCURS BEFORE CORRECTIVE SERVICE CAN BE PERFORMED, DRIVERSHOULD SHIFT TO NEUTRAL GEAR AND APPLY BRAKES AS NECESSARY. VEHICLE SHOULD BEPULLED OUT OF TRAFFIC AND THE IGNITION SHOULD BE TURNED OFF AFTER A COMPLETESTOP.
CHEVROLET: IMPALA: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 80V125000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1981 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19800801 - 19800801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4615 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19800925 |
| Record Creation Date: | 19801210 |
Defect Summary:
THE INVOLVED VEHICLES MAY HAVE BEEN ASSEMBLED WITH A BRAKE PEDAL SUPPORT BRACKET WHICH WAS DESIGNED FOR USE IN DIESEL ENGINE VEHICLES. THE INCORRECT BRACKET MAY CAUSE THE SERVICE BRAKES TO REMAIN PARTIALLY APPLIED, RESULTING IN BRAKE OVERHEATING AND REDUCED BRAKING EFFECTIVENESS.
Corrective Summary:
DEALER WILL INSPECT VEHICLES AND, IF NECESSARY, REPLACE THE PEDAL SUPPORT BRACKET AT NO CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH GASOLINE ENGINES.SYSTEM: SERVICE BRAKES; BRAKE PEDAL, SUPPORT BRACKET.CONSEQUENCES OF DEFECT: THIS DEFECT COULD CAUSE AN ACCIDENT, ESPECIALLY INSITUATIONS WHICH REQUIRE A MINIMUM VEHICLE STOPPING DISTANCE.
CHEVROLET: IMPALA: VEHICLE SPEED CONTROL:CABLES
-->| NHTSA Campaign Number: | 83V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1981 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19801001 - 19830401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19108 |
| Date Owner Notified By Manufacturer: | 19830810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830819 |
| Record Creation Date: | 19830906 |
Defect Summary:
ACCELERATOR PUMP LEVER RETAINING PIN MAY LOOSEN AFTER REPEATED HEAVY ACCELERATOR PEDAL APPLICATIONS. THIS COULD CAUSE THE THROTTLE TO BECOME STUCK IN THE OPEN POSITION.
Corrective Summary:
DEALER WILL INSTALL A SPECIAL COTTER PIN, TO RETAIN THE ACCELERATOR PUMP PIN, AND A SPRING CLIP THRUST WASHER ON THE ACCELERATOR PUMP LINK.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CLOSED LOOP QUADRAJETCARBURETORS AND POLICE CAR PACKAGES.SYSTEM: POWER TRAIN; ACCELERATOR PUMP LEVER RETAINING PIN.CONSEQUENCES OF DEFECT: VEHICLE SPEED WOULD NOT DECREASE EVEN AFTER THEACCELERATOR PEDAL IS NO LONGER DEPRESSED. LOSS OF ACCELERATOR CONTROL WITHOUTPRIOR WARNING COULD RESULT IN AN ACCIDENT.NOTE: IF THE FAILURE OCCURS BEFORE CORRECTIVE SERVICE CAN BE PERFORMED, DRIVERSHOULD SHIFT TO NEUTRAL GEAR AND APPLY BRAKES AS NECESSARY. VEHICLE SHOULD BEPULLED OUT OF TRAFFIC AND THE IGNITION SHOULD BE TURNED OFF AFTER A COMPLETESTOP.
CHEVROLET: IMPALA: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 80V135000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1980 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790801 - 19800301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 24719 |
| Date Owner Notified By Manufacturer: | 19801015 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19801015 |
| Record Creation Date: | 19801209 |
Defect Summary:
THE INVOLVED VEHICLES MAY HAVE INSUFFICIENT CLEARANCE BETWEEN THE FRONT BRAKE PIPE AND THE ENGINE OIL PAN. THIS CONDITION COULD CAUSE THE BRAKE PIPE TO CONTACT THE LEFT HAND FRONT EDGE OF THE OIL PAN, RESULTING IN WEAR AND, EVENTUALLY, DAMAGE TO THE BRAKE PIPE. THIS COULD LEAD TO A LOSS OF BRAKE FLUID AND SUBSEQUENT LOSS OF BRAKES.
Corrective Summary:
DEALER WILL REPLACE THE BRAKE PIPE, IF NECESSARY, FREE OF CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 3.8 LITER CID V-6ENGINES.SYSTEM: SERVICE BRAKES; HYDRAULIC LINES, METALLIC.CONSEQUENCES OF DEFECT: LOSS OF FRONT BRAKING AT A TIME WHEN MINIMUM VEHICLESTOPPING DISTANCE IS REQUIRED COULD RESULT IN AN ACCIDENT.NOTE: THE DRIVER MAY BE ALERTED TO BRAKE FLUID LOSS BY ILLUMINATION OF THEBRAKE WARNING LIGHT.
CHEVROLET: IMPALA: VEHICLE SPEED CONTROL:CABLES
-->| NHTSA Campaign Number: | 83V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1980 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19801001 - 19830401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19108 |
| Date Owner Notified By Manufacturer: | 19830810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830819 |
| Record Creation Date: | 19830906 |
Defect Summary:
ACCELERATOR PUMP LEVER RETAINING PIN MAY LOOSEN AFTER REPEATED HEAVY ACCELERATOR PEDAL APPLICATIONS. THIS COULD CAUSE THE THROTTLE TO BECOME STUCK IN THE OPEN POSITION.
Corrective Summary:
DEALER WILL INSTALL A SPECIAL COTTER PIN, TO RETAIN THE ACCELERATOR PUMP PIN, AND A SPRING CLIP THRUST WASHER ON THE ACCELERATOR PUMP LINK.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CLOSED LOOP QUADRAJETCARBURETORS AND POLICE CAR PACKAGES.SYSTEM: POWER TRAIN; ACCELERATOR PUMP LEVER RETAINING PIN.CONSEQUENCES OF DEFECT: VEHICLE SPEED WOULD NOT DECREASE EVEN AFTER THEACCELERATOR PEDAL IS NO LONGER DEPRESSED. LOSS OF ACCELERATOR CONTROL WITHOUTPRIOR WARNING COULD RESULT IN AN ACCIDENT.NOTE: IF THE FAILURE OCCURS BEFORE CORRECTIVE SERVICE CAN BE PERFORMED, DRIVERSHOULD SHIFT TO NEUTRAL GEAR AND APPLY BRAKES AS NECESSARY. VEHICLE SHOULD BEPULLED OUT OF TRAFFIC AND THE IGNITION SHOULD BE TURNED OFF AFTER A COMPLETESTOP.
CHEVROLET: IMPALA: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 80V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1980 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790801 - 19791001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 85158 |
| Date Owner Notified By Manufacturer: | 19801008 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19801014 |
| Record Creation Date: | 19801112 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
VEHICLES MAY NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS". THE TIRE RIM SIZE WAS OMITTED ON THE EXISTING LABEL.
Corrective Summary:
THE OWNER HAS THE OPTION OF AFFIXING THE CORRECT INFORMATION LABEL HIM/HERSELF OR HAVING THE DEALER DO IT AT NO CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: EQUIPMENT; TIRE INFORMATION LABELS.CONSEQUENCES OF DEFECT: LACK OF INFORMATION COULD LEAD TO THE SELECTION OFINCORRECT RIMS AS REPLACEMENT PARTS. THIS WOULD CREATE AN UNSAFE SITUATION THATCOULD RESULT IN AN ACCIDENT.
CHEVROLET: IMPALA: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-->| NHTSA Campaign Number: | 79V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1979 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19790201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 476245 |
| Date Owner Notified By Manufacturer: | 19790703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790702 |
| Record Creation Date: | 19791012 |
Defect Summary:
A CHILD COULD OPEN THE REAR SIDE COMPARTMENT DOOR AND ENTER THIS COMPARTMENT. THE CHILD COULD BECOME ENTRAPPED IF THE DOOR WERE TO CLOSE, AS IT CANNOT BE UNLATCHED FROM THE INSIDE.
Corrective Summary:
DEALER WILL REPLACE THE ORIGINAL COMPARTMENT DOOR LATCH, WHICH CAN BE LATCHED WITHOUT A KEY, WITH A NEW ASSEMBLY THAT REQUIRES A KEY TO LATCH AS WELL AS LOCK THE DOOR.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STRUCTURE; STORAGE COMPARTMENT.CONSEQUENCES OF DEFECT: IN THE ABSENCE OF OUTSIDE HELP, THE CHILD WOULDSUFFOCATE.NOTE: THE OWNER IS ADVISED TO KEEP THIS COMPARTMENT LOCKED EXCEPT WHILE EITHERLOADING OR UNLOADING IT.
CHEVROLET: IMPALA: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 79V247000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1979 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19780901 - 19791001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1326404 |
| Date Owner Notified By Manufacturer: | 19791112 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19791113 |
| Record Creation Date: | 19800205 |
Defect Summary:
THE HEADS MAY BREAK OFF THE FRONT OUTBOARD SEAT BELT ANCHOR BOLTS DURING NORMAL VEHICLE OPERATION EVEN UNDER NO LOAD CONDITIONS. THIS IS DUE TO THE COMBINATION OF BOLTS USED, HIGH INSTALLATION TORQUE AND ARRANGEMENT OF THE BODY ANCHORAGE.
Corrective Summary:
DEALER WILL REPLACE ALL ORIGINAL EQUIPMENT FRONT OUTBOARD SEAT BELT ANCHOR BOLTS ON THE AFFECTED VEHICLES AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: INTERIOR; SEAT BELT ANCHORS.CONSEQUENCES OF DEFECT: IN THE EVENT OF AN ACCIDENT, FAILURE OF A SEAT BELTANCHORAGE WILL INCREASE THE RISK OF INJURY TO THE WEARER.
CHEVROLET: IMPALA: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 79V142000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1979 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19781201 - 19790101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15328 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790606 |
| Record Creation Date: | 19791012 |
Defect Summary:
ON THE INVOLVED VEHICLES THE BRAKE STOPLIGHT AND CRUISE CONTROL SWITCH WHICH IS OPERATED BY THE BRAKE PEDAL MAY HAVE BEEN ASSEMBLED WITH AN INCORRECT LUBRICANT ON THE ACTUATING PLUNGER. THIS CAN CAUSE THE REAR BRAKE STOPLIGHTS TO BECOME INOPERATIVE AND THE CRUISE CONTROL, IF ACTIVATED, TO STAY ELECTRICALLY ENGAGED.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE BRAKE STOPLIGHT AND CRUISE CONTROL SWITCH AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: LIGHTING AND COMMUNICATIONS; SWITCH BUTTON RING, BRAKE LIGHTS.CONSEQUENCES OF DEFECT: WITH INOPERATIVE BRAKE LIGHTS, A VEHICLE APPROACHINGFROM THE REAR WOULD NOT BE AWARE THAT BRAKES WERE BEING APPLIED. ALSO, IF THECRUISE CONTROL FAILS TO AUTOMATICALLY DISENGAGE THROUGH BRAKE PEDAL OPERATION,VEHICLE MAY ACCELERATE WHEN THE BRAKE PEDAL IS RELEASED. EITHER CONDITION COULDRESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.NOTE: OWNER IS ADVISED NOT TO ENGAGE THE CRUISE CONTROL UNTIL IT HAS BEENINSPECTED BY DEALER.
CHEVROLET: IMPALA: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-->| NHTSA Campaign Number: | 79V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1978 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19790201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 476245 |
| Date Owner Notified By Manufacturer: | 19790703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790702 |
| Record Creation Date: | 19791012 |
Defect Summary:
A CHILD COULD OPEN THE REAR SIDE COMPARTMENT DOOR AND ENTER THIS COMPARTMENT. THE CHILD COULD BECOME ENTRAPPED IF THE DOOR WERE TO CLOSE, AS IT CANNOT BE UNLATCHED FROM THE INSIDE.
Corrective Summary:
DEALER WILL REPLACE THE ORIGINAL COMPARTMENT DOOR LATCH, WHICH CAN BE LATCHED WITHOUT A KEY, WITH A NEW ASSEMBLY THAT REQUIRES A KEY TO LATCH AS WELL AS LOCK THE DOOR.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STRUCTURE; STORAGE COMPARTMENT.CONSEQUENCES OF DEFECT: IN THE ABSENCE OF OUTSIDE HELP, THE CHILD WOULDSUFFOCATE.NOTE: THE OWNER IS ADVISED TO KEEP THIS COMPARTMENT LOCKED EXCEPT WHILE EITHERLOADING OR UNLOADING IT.
CHEVROLET: IMPALA: SEATS:FRONT ASSEMBLY:RECLINER
-->| NHTSA Campaign Number: | 78V180000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1978 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1400 |
| Date Owner Notified By Manufacturer: | 19780815 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19780816 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 207 |
Defect Summary:
THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "ANCHORAGE OF SEATS", IN THAT THE FRONT SEAT ADJUSTER ASSEMBLIES HAVE LOCK BARS WHICH MAY NOT REMAIN ENGAGED WHEN TEST PROCEDURE FORCES ARE APPLIED TO THE SEAT.
Corrective Summary:
DEALER WILL INSTALL AN ADDITIONAL LOCK BAR RETURN SPRING WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT BENCH SEATSSYSTEM: INTERIOR; ADJUSTER LOCK BAR.CONSEQUENCES OF DEFECT: IN THE EVENT OF AN ACCIDENT, IMPROPERLY ANCHORED SEATSINCREASE THE RISK OF INJURY TO THE OCCUPANTS.
CHEVROLET: IMPALA: WHEELS:LUGS/NUTS/BOLTS
-->| NHTSA Campaign Number: | 77V200000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1978 |
| Manufacturer Component Description: | WHEELS:LUGS/NUTS/BOLTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4504 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19771116 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE REAR WHEEL MOUNTING BOLTS ON THE AFFECTED VEHICLES, ARE BRITTLE AND THEREFORE MAY FRACTURE. THIS BRITTLENESS IS DUE TO IMPROPER HEAT TREATMENT DURING MANUFACTURE. IF THE BOLTS BREAK, THE TIRE AND WHEEL ASSEMBLY MAY SEPARATE FROM THE VEHICLE.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, WILL REPLACE DEFECTIVE BOLTS ON ALL AXLES AND THE TEN REAR AXLE WHEEL MOUNTING BOLTS, FREE OF CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; REAR WHEEL MOUNTING BOLTS.CONSEQUENCES OF DEFECT: IF SEPARATION OCCURS UNDER VEHICLE OPERATION, LOSS OFVEHICLE CONTROL WITHOUT PRIOR WARNING AND AN ACCIDENT COULD RESULT.
CHEVROLET: IMPALA: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-->| NHTSA Campaign Number: | 79V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1977 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19790201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 476245 |
| Date Owner Notified By Manufacturer: | 19790703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790702 |
| Record Creation Date: | 19791012 |
Defect Summary:
A CHILD COULD OPEN THE REAR SIDE COMPARTMENT DOOR AND ENTER THIS COMPARTMENT. THE CHILD COULD BECOME ENTRAPPED IF THE DOOR WERE TO CLOSE, AS IT CANNOT BE UNLATCHED FROM THE INSIDE.
Corrective Summary:
DEALER WILL REPLACE THE ORIGINAL COMPARTMENT DOOR LATCH, WHICH CAN BE LATCHED WITHOUT A KEY, WITH A NEW ASSEMBLY THAT REQUIRES A KEY TO LATCH AS WELL AS LOCK THE DOOR.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: STRUCTURE; STORAGE COMPARTMENT.CONSEQUENCES OF DEFECT: IN THE ABSENCE OF OUTSIDE HELP, THE CHILD WOULDSUFFOCATE.NOTE: THE OWNER IS ADVISED TO KEEP THIS COMPARTMENT LOCKED EXCEPT WHILE EITHERLOADING OR UNLOADING IT.
CHEVROLET: IMPALA: STEERING:WHEEL AND HANDLE BAR
-->| NHTSA Campaign Number: | 76V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1977 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55564 |
| Date Owner Notified By Manufacturer: | 19760830 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760907 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 77-C-1.POSSIBILITY THAT THE STEERING INTERMEDIATESHAFT MAY HAVE BEEN ASSEMBLED WITH COUPLING RETAINER LOCKING TABS NOT BENT OVERPROPERLY OR ONE OR MORE OF THE LOWER FLEXIBLE COUPLING RIVETS IMPROPERLYPEENED.IF EITHER OF THESE CONDITIONS EXISTS, THE INTERMEDIATE SHAFT ASSEMBLYCOULD SEPARATE CAUSING LOSS OF STEERING CONTROL, AND VEHICLE CRASH MAY OCCURWITHOUT PRIOR WARNING.(CORRECT BY INSPECTING, AND REPLACING SHAFT WHERENECESSARY).PASSENGER VEHICLE.
CHEVROLET: IMPALA: EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
-->| NHTSA Campaign Number: | 76V175000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1977 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:TURN SIGNAL:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 66632 |
| Date Owner Notified By Manufacturer: | 19761022 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19761103 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Notes:
GENERAL MOTOR CAMPAIGN NO (CHEVROLET) 77C02 (PONTIAC) 77-C-4 (BUICK) 77-C-5.POSSIBILITY THAT THE TURN SIGNAL OPERATING UNIT OR VEHICLES WITH TILT STEERINGCOLUMNS MAY NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.108.THE TURN SIGNAL LEVER ACTUATOR PIVOT PIN WHICH MAY WORK OUT OF THE PIVOT,RESULTING IN NOT BEING ABLE TO USE TURN SIGNAL TO ALERT OTHER DRIVERS OF YOURINTENTIONS TO CHANGE LANES OR TURN, CAUSING POSSIBLE VEHICLE CRASH.(CORRECTBY INSPECTING AND INSTALLING A RETAINER TO PRECLUDE PIVOT PIN DISENGAGEMENT).PASSENGER VEHICLE.
CHEVROLET: IMPALA: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
-->| NHTSA Campaign Number: | 75V214000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 39278 |
| Date Owner Notified By Manufacturer: | 19751223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19751219 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C04, PONTIAC CAMPAIGN NO. 76C7, OLDSMOBILE CAMPAIGN NO.76C1, BUICK CAMPAIGN NO. 76C1.POSSIBILITY THAT THE COMBINATION VALVE, WHICHIS A PART OF THE HYDRAULIC SERVICE BRAKE SYSTEM MAY HAVE BEEN IMPROPERLYMANUFACTURED AND COULD MALFUNCTION.SHOULD THIS CONDITION OCCUR WHILE VEHICLEIS IN MOTION AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED.A VEHICLECRASH COULD OCCUR WITHOUT PRIOR WARNING.(CORRECT BY INSPECTING AND REPLACINGVALVE WHERE NECESSARY.) PASSENGER CARS AND LIGHT TRUCKS.
CHEVROLET: IMPALA: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 73V244000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1974 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 9215 |
| Date Owner Notified By Manufacturer: | 19740102 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731219 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTORS CAMPAIGN NO CHEVROLET 74-C-07.STATION WAGON.POSSIBILITY THATTHE REAR BRAKE PIPE WAS IMPROPERLY POSITIONED WHEN ATTACHED TO THE REAR AXLEASSEMBLY.THIS MAY RESULT IN REPEATED CONTACT OF THE PIPE WITH THE UNDERBODY,CAUSING IT TO FLEX UP AND DOWN UNTIL IT BREAKS, RESULTING IN LOSS OF BRAKEFLUID AND LOSS OF REAR BRAKING ACTION.(CORRECT BY INSPECTING AND INSTALLINGBRAKE PIPE PROPERLY)).
CHEVROLET: IMPALA: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
-->| NHTSA Campaign Number: | 73V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1974 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 782111 |
| Date Owner Notified By Manufacturer: | 19740109 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731227 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 74-C-09.PONTIAC 74-C-2.BUICK 74-C-2.OLDSMOBILE74-C-3.SPRINT 74-C-4.POSSIBILITY THAT THE FRONT UPPER CONTROL ARM INNERBUSHING RETAINER NUTS MAY LOOSEN AND COME OFF DURING NORMAL OPERATINGCONDITIONS.SHOULD THIS OCCUR, THE LOOSE CONTROL ARM MAY MOVE FORWARD ANDCONTACT THE UPPER CONTROL ARM MOUNTING BRACKET ON THE FRAME WHICH RESTRICTS ANYFURTHER FORWARD MOVEMENT.IF THIS VEHICLE IS OPERATED IN THIS CONDITION IT ISPOSSIBLE FOR THE CONTROL ARM CROSS SHAFT TO BREAK.(CORRECT BY INSPECTING ANDINSTALLING NEW BUSHING RETAINERS WHERE NECESSARY.)
CHEVROLET: IMPALA: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1974 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: IMPALA: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: IMPALA: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
-->| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1972 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: IMPALA: SEATS
-->| NHTSA Campaign Number: | 72V185000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1972 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720501 - 19720501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1699 |
| Date Owner Notified By Manufacturer: | 19720719 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19720719 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 72-C-2.CHEVROLET CAMPAIGN NO 72-C-10.PONTIACCAMPAIGN NO 72-C-4.POSSIBILITY THAT MANUAL FRONT SEAT ADJUSTER MAY NOT HAVEBEEN INSTALLED PROPERLY AND MAY NOT STAY ENGAGED IN ADJUSTER TRACK DURING ANIMPACT, AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO.207.(CORRECT BY INSTALLING NEW SEAT ADJUSTER ON PASSENGER SIDE OF FRONT SEAT.)
CHEVROLET: IMPALA: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
-->| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1971 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: IMPALA: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 70V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1971 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12600 |
| Date Owner Notified By Manufacturer: | 19701125 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19701203 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT THROTTLE ROD TO THROTTLE LEVER RETAINING CLIP ON CARBURETORMAY BE INCORRECTLY INSTALLED.IF THIS CONDITION EXISTS, THROTTLE LEVER COULDBE HELD IN PARTIALLY OPEN POSITION.IF THIS OCCURS WHILE VEHICLE IS IN MOTION,VEHICLE WILL NOT SLOW DOWN WHEN DRIVER'S FOOT IS REMOVED FROM ACCELERATOR.(CORRECT BY REPLACING CLIP WITH IMPROVED DESIGN WHERE NECESSARY.)
CHEVROLET: IMPALA: EQUIPMENT:MECHANICAL:JACKS
-->| NHTSA Campaign Number: | 71V121000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1971 |
| Manufacturer Component Description: | EQUIPMENT:MECHANICAL:JACKS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6000 |
| Date Owner Notified By Manufacturer: | 19710708 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19710720 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 71-C-11.STATION WAGONS ONLY.POSSIBIL ITY THAT BUMPERJACK LOAD REST LIP MAY NOT BE PROPERLY FORMEDALLOWING IT TO BEND AND VEHICLESLIP FROM JACK LOAD REST.(CO RRECT BY INSTALLING CORRECT JACK CORRECT JACKWHERENECESSARY. )
CHEVROLET: IMPALA: TIRES:TREAD/BELT
-->| NHTSA Campaign Number: | 71V125000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1971 |
| Manufacturer Component Description: | TIRES:TREAD/BELT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1672 |
| Date Owner Notified By Manufacturer: | 19710726 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19710726 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 109 |
Notes:
CHEVROLET CAMPAIGN NO 71-C-17.PONTIAC CAMPAIGN NO 71-C-4.S TATION WAGONS.EQUIPPED WITH L-78-15 FASTRAK W.S.POSSIBIL ITY THAT TIRE MAY BE SUSCEPTIBLETO EARLY TREAD SEPARATION, AN D MAY NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETYSTANDARD NO. 109.THIS TYPE TREAD SEPARATION WILL NOT CAUSE DEFLATION OFBUT MAY CAUSE NOTICEABLE ROUGHNESS IN RIDE AND HANDLING OF CA R OF CAR ANDPOSSIBLE LOSS OF PORTIONS OF TREAD STOCK.REPLAC ING TIRE WHERE NECESSARY).
CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: IMPALA: TIRES
-->| NHTSA Campaign Number: | 69V020000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1969 |
| Manufacturer Component Description: | TIRES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1396 |
| Date Owner Notified By Manufacturer: | 19690214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690220 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT FIRESTONE TIRES (8.25 X 14 WHITE SIDEWALL 4-PLY RATED), MAYNOT MEET MINIMUM STRENGTH REQUIREMENTS.FAILURE IN BODY OF TIRE COULD RESULTIN LOSS OF TIRE PRESSURE.(CORRECT BY RE- PLACING ALL TIRES WITH NEW IMPROVEDTYPE.)
CHEVROLET: IMPALA: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
-->| NHTSA Campaign Number: | 69V091000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1969 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 24017 |
| Date Owner Notified By Manufacturer: | 19690703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690709 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT FILLER PLATE WAS OMITTED FROM LEFT REAR FLOOR PAN AREA BETWEENBUMPER AND FUEL TANK.IF THIS PLATE IS MISSING IT COULD ALLOW DUST AND, UNDERCERTAIN CONDITIONS, EXHAUST FUMES TO ENTER PASSENGER COMPARTMENT.(CORRECT BYINSPECTING AND INSTALLING FILLER PLATE WHEN NECESSARY.)
CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-->| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-->| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING:ENGINE
-->| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: IMPALA: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
-->| NHTSA Campaign Number: | 69V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | IMPALA |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2570914 |
| Date Owner Notified By Manufacturer: | 19690226 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690228 |
| Record Creation Date: | 19791012 |
Defect Summary:
EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.
Consequence Summary:
UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.
Corrective Summary:
RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.
Notes:
SYSTEM: EXHAUST.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: KINGSWOOD: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | KINGSWOOD |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: KINGSWOOD: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | KINGSWOOD |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
-- --CHEVROLET: KINGSWOOD: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | KINGSWOOD |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: KINGSWOOD: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | KINGSWOOD |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: KINGSWOOD: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | KINGSWOOD |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: KINGSWOOD: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | KINGSWOOD |
| Model Year: | 1971 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: KINGSWOOD: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | KINGSWOOD |
| Model Year: | 1972 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: KINGSWOOD: SEAT BELTS:FRONT:ANCHORAGE
| NHTSA Campaign Number: | 71V182000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | KINGSWOOD |
| Model Year: | 1972 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 475 |
| Date Owner Notified By Manufacturer: | 19711011 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711013 |
| Record Creation Date: | 19791012 |
Notes:
ALL STATION WAGONS.POSSIBILITY THAT THIRD SEAT LAP BELTS MAYNOT BE LONGENOUGH TO MEET REQUIREMENT OF SAFETY STANDARD NO. 208.(CORRECT BYINSPECTING AND REPLACING WITH BELT OF PROP ER LENGTH WHERE NECESSARY.)
--CHEVROLET: KINGSWOOD: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
| NHTSA Campaign Number: | 75V214000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | KINGSWOOD |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 39278 |
| Date Owner Notified By Manufacturer: | 19751223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19751219 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C04, PONTIAC CAMPAIGN NO. 76C7, OLDSMOBILE CAMPAIGN NO.76C1, BUICK CAMPAIGN NO. 76C1.POSSIBILITY THAT THE COMBINATION VALVE, WHICHIS A PART OF THE HYDRAULIC SERVICE BRAKE SYSTEM MAY HAVE BEEN IMPROPERLYMANUFACTURED AND COULD MALFUNCTION.SHOULD THIS CONDITION OCCUR WHILE VEHICLEIS IN MOTION AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED.A VEHICLECRASH COULD OCCUR WITHOUT PRIOR WARNING.(CORRECT BY INSPECTING AND REPLACINGVALVE WHERE NECESSARY.) PASSENGER CARS AND LIGHT TRUCKS.
-- --CHEVROLET: LAGUNA: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
| NHTSA Campaign Number: | 73V152000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LAGUNA |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720801 - 19730601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3094 |
| Date Owner Notified By Manufacturer: | 19730712 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730716 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO.73-C-15, PONTIAC CAMPAIGN NO 73-C-6, BUICK CAMPAIGN NO73-C-2, GMC CAMPAIGN NO 73-C-20.POSSIBILITY THAT THE GASKET BETWEEN THEMASTER CYLINDER AND THEFORWARD SIDE OF THE DASH, AND THE BOOT WHICH COVERS THEREAR OPENING OF THE MASTER CYLINDER IN THE DRIVER'S COMPARTMENT WEREOMITTED INASSEMBLY.IF THIS CONDITION EXISTS IT COULD CAUSE CORROSION OF THE CYLINDERBORE AND DAMAGE PISTON SEAL RESULTINGIN LOSS OF BRAKE FLUID AND IMPAIREDBRAKING.(CORRECT BY INSPECTING AND REPLACING GASKET AND BOOT.)
--CHEVROLET: LAGUNA: SEAT BELTS:FRONT:RETRACTOR
| NHTSA Campaign Number: | 74V016000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LAGUNA |
| Model Year: | 1974 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:RETRACTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 26421 |
| Date Owner Notified By Manufacturer: | 19740128 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740125 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTORS CAMPAIGN NO 74-C-10.OLDSMOBILE CAMPAIGN NO 74-C-4.BUICKCAMPAIGN NO 74-C-3.PONTIAC CAMPAIGN NO 74-C-4.POSSIBILITY THAT THE FRONTSEAT LAP-BELT RETRACTOR MAY INTERMITTENTLY FAIL TO LOCK THE SEAT LAP-BELTWEBBING DUE TO WEAK LOCKING BAR SPRING.AS A RESULT, THE RETRACTOR MAY FAIL TOHOLD THE BELT IN POSITION DURING EXTREMELY HARD BRAKING ACTION OR UNDERACCIDENT CONDITIONS.THIS MAY CAUSE THE OCCUPANT TO SLIDE FORWARD ON THE SEATAND INCREASE THE POSSIBILITY OF INJURY.(CORRECT BY INSPECTING AND INSTALLINGNEW ASSIST SPRING WHERE NECESSARY.)
--CHEVROLET: LAGUNA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | LAGUNA |
| Model Year: | 1974 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: LAGUNA: LATCHES/LOCKS/LINKAGES:HOOD:LATCH
| NHTSA Campaign Number: | 74V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LAGUNA |
| Model Year: | 1974 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3458 |
| Date Owner Notified By Manufacturer: | 19740515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740517 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 74-C-16.POSSIBILITY THAT THE PRIMARY HOOD SECONDARYCATCH MAY NOT PROPERLY ENGAGE.IF THIS CONDITION EXISTS AND VEHICLE IS DRIVENWITH THE PRIMARY HOOD CATCH NOT ENGAGED OR INADVERTENTLY RELEASED, THE HOODCOULD OPEN TO A POSITION THAT OBSTRUCTS THE DRIVER'S VISION.(CORRECT BYINSPECTING AND MODIFYING THE HOOD SECONDARY CATCH).
--CHEVROLET: LAGUNA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | LAGUNA |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: LAGUNA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | LAGUNA |
| Model Year: | 1976 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
-- --CHEVROLET: LUMINA: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 02V329000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 2061 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19991101 - 19991130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 272 |
| Date Owner Notified By Manufacturer: | 20021216 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20021209 |
| Record Creation Date: | 20021219 |
Defect Summary:
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence Summary:
THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Corrective Summary:
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
Notes:
GM RECALL NO. 02061. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: LUMINA: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 02V329000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 2061 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001101 - 20010430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 272 |
| Date Owner Notified By Manufacturer: | 20021216 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20021209 |
| Record Creation Date: | 20021219 |
Defect Summary:
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence Summary:
THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Corrective Summary:
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
Notes:
GM RECALL NO. 02061. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: LUMINA: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 01V026000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 1004 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001110 - 20001130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 38 |
| Date Owner Notified By Manufacturer: | 20010129 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010201 |
| Record Creation Date: | 20010207 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence Summary:
IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Corrective Summary:
DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: LUMINA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 2001 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: SEAT BELTS
-->| NHTSA Campaign Number: | 00V228003 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 67 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000501 - 20000531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 156305 |
| Date Owner Notified By Manufacturer: | 20000824 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000807 |
| Record Creation Date: | 20000822 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Notes:
OWNER NOTIFICATION BEGAN AUGUST 24, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; CHEVROLET AT 1-800-222-1020; GMC AT 1-800-462-8782; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR SATURN AT 1-800-553-6000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: LUMINA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1999 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 09V116000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 9047 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1497516 |
| Date Owner Notified By Manufacturer: | 20090409 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090408 |
| Record Creation Date: | 20090408 |
Defect Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: LUMINA: STEERING:RACK AND PINION
-->| NHTSA Campaign Number: | 03V527000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 3062 |
| Manufacturer Component Description: | STEERING:RACK AND PINION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19971031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 750283 |
| Date Owner Notified By Manufacturer: | 20040205 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20031211 |
| Record Creation Date: | 20031218 |
Defect Summary:
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence Summary:
IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 03062.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: LUMINA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1998 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 09V116000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 9047 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1497516 |
| Date Owner Notified By Manufacturer: | 20090409 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090408 |
| Record Creation Date: | 20090408 |
Defect Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: LUMINA: STEERING:RACK AND PINION
-->| NHTSA Campaign Number: | 03V527000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 3062 |
| Manufacturer Component Description: | STEERING:RACK AND PINION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960401 - 19970731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 750283 |
| Date Owner Notified By Manufacturer: | 20040205 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20031211 |
| Record Creation Date: | 20031218 |
Defect Summary:
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence Summary:
IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 03062.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: LUMINA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1997 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 96V122000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1996 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960601 - 19960601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3591 |
| Date Owner Notified By Manufacturer: | 19960705 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960701 |
| Record Creation Date: | 19960708 |
Defect Summary:
THESE VEHICLES WERE ASSEMBLED WITH ONE OF THE FOUR BRAKE BOOSTER TABS NOT PROPERLY LOCATED IN THE FRONT OF DASH REINFORCEMENT ASSEMBLY.
Consequence Summary:
IF THIS CONDITION WERE PRESENT IN A SITUATION WHERE STOPPING DISTANCES WERE SMALL, A VEHICLE CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT FOR PROPER BOOSTER INSTALLATION. BOOSTERS FOUND TO BE IMPROPERLY LOCATED WILL BE REMOVED AND REINSTALLED PROPERLY.
Notes:
SYSTEM: BRAKES; HYDRAULIC; POWER ASSIST; BOOSTER. VEHICLE DESCRIPTION: PASSENGER VEHICLES. OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN IN JULY 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 96V069000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1996 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950401 - 19951001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 43213 |
| Date Owner Notified By Manufacturer: | 19960422 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960419 |
| Record Creation Date: | 19960422 |
Defect Summary:
THE LEFT FRONT BRAKE LINE CAN CONTACT THE TRANSAXLE MOUNTING BRACKET OR ATTACHMENT BOLT.
Consequence Summary:
THIS CONDITION CAN CAUSE THE BRAKE LINE TO WEAR THROUGH, RESULTING IN LOSS OF BRAKE FLUID AND EVENTUAL LOSS OF ONE-HALF OF THE VEHICLE'S BRAKE SYSTEM, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLE FOR PROPER BRAKE LINE CLEARANCE AND REPOSITION THOSE BRAKE LINES FOUND TO HAVE LESS THAN MINIMAL CLEARANCE. ADDITIONALLY, THOSE BRAKE LINES FOUND TO HAVE AN INDENTATION CAUSED BY THE CONTACT WILL BE REPLACED AND PROPERLY ROUTED.
Notes:
SYSTEM: BRAKES; HYDRAULIC; LINES.VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 95V214000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1995 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950501 - 19950901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6772 |
| Date Owner Notified By Manufacturer: | 19960129 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19951103 |
| Record Creation Date: | 19951109 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 124 |
Defect Summary:
THESE VEHICLES WERE ASSEMBLED WITH THROTTLE CABLE SUPPORT BRACKETS THAT COULD CONTACT THE THROTTLE LEVER SYSTEM AND INHIBIT THE THROTTLE RETURN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: THE THROTTLE MAY FAITL TO RETURN QUICKLY CAUSING THE ENGINE SPEED TO NOT DECREASE TO A LEVEL ANTICIPATED BY THE DRIVER.
Corrective Summary:
DEALERS WILL REPLACE THE THROTTLE CABLE SUPPORT BRACKET.
Notes:
SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL; FMVSS NO. 124.VEHICLE DESCRIPTION: PASSENGER MINI-VANS EQUIPPED WITH A 3.1L ENGINE (LG6). NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR PONTIAC AT 1-800-762-2737. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 98V306000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1995 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19941101 - 19950131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 111470 |
| Date Owner Notified By Manufacturer: | 19981218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19981201 |
| Record Creation Date: | 19981203 |
Defect Summary:
THE CENTER REAR SEAT BELT ANCHOR PLATE EXHIBITS STRESS CRACKS.
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE SEAT BELT SYSTEM CAN FRACTURE, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Corrective Summary:
DEALERS WILL REPLACE THE CENTER REAR SEAT BELT SYSTEM.
Notes:
OWNER NOTIFICATION BEGAN DURING DECEMBER 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: LUMINA: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 97V065000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1995 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950201 - 19950228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 50709 |
| Date Owner Notified By Manufacturer: | 19970513 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970418 |
| Record Creation Date: | 19970501 |
Defect Summary:
THE CENTER REAR SEAT BELT ANCHOR PLATE EXHIBITS STRESS CRACKS.
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE SEAT BELT SYSTEM CAN FRACTURE AND INJURY TO THE SEAT OCCUPANT CAN OCCUR.
Corrective Summary:
DEALERS WILL REPLACE THE CENTER REAR SEAT BELT SYSTEM.
Notes:
OWNER NOTIFICATION BEGAN MAY 13, 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: STEERING:WHEEL AND HANDLE BAR
-->| NHTSA Campaign Number: | 95V030000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1995 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19941001 - 19941001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 420 |
| Date Owner Notified By Manufacturer: | 19950216 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950227 |
| Record Creation Date: | 19950227 |
Defect Summary:
THE FOUR (4) STEERING COLUMN SUPPORT BRACKET ATTACHING BOLTS WERE UNDER TORQUED DURING ASSEMBLY.
Consequence Summary:
INADEQUATE TORQUE CAN CAUSE THESE BOLTS TO VIBRATE, LOOSEN, OR FALL OUT RESULTING IN LOSS OF STEERING CONTROL AND INCREASE THE POTENTIAL FOR A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL RETORQUE THE STEERING COLUMN SUPPORT BRACKET ATTACHING BOLTS TO THE CORRECT SPECIFICATIONS.
Notes:
SYSTEM: STEERING; COLUMN.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, CONTACT CHEVROLET AT 1-800-222-1020 OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
-->| NHTSA Campaign Number: | 94V230000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1995 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19940801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 221 |
| Date Owner Notified By Manufacturer: | 19941208 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19941121 |
| Record Creation Date: | 19941130 |
Defect Summary:
A RIGHT-HAND LOWER CONTROL ARM TAPERED BALL JOINT MOUNTING HOLE WAS INCORRECTLY MACHINED. MOVEMENT WITHIN THIS ATTACHMENT CAN ALLOW THE BALL JOINT STUD TO FATIGUE AND FRACTURE.
Consequence Summary:
IF THE BALL JOINT FRACTURED WHILE THE VEHICLE WAS IN MOTION, LOSS OF STEERING CONTROL TO THE VEHICLE CAN OCCUR.
Corrective Summary:
DEALERS WILL REPLACE THE RIGHT-HAND LOWER CONTROL ARM AND BALL JOINT STUD ON ALL INVOLVED VEHICLES.
Notes:
SYSTEM: SUSPENSION; INDEPENDENT FRONT CONTROL ARM; LOWER; BALL JOINT.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT CHEVROLET AT 1-800-222-1020. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING
-->| NHTSA Campaign Number: | 97V017000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1995 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19931001 - 19940930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 349331 |
| Date Owner Notified By Manufacturer: | 19970306 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970211 |
| Record Creation Date: | 19970226 |
Defect Summary:
SOME OF THESE VEHICLES HAVE A STRAINED OR SEPARATED WASHER/WIPER SWITCH POWER FEED WIRE.
Consequence Summary:
THIS CAN CAUSE THE WINDSHIELD WASHER/WIPER TO WORK INTERMITTENTLY AND COULD ULTIMATELY RESULT IN INOPERATIVE WIPERS. IF THIS WERE TO OCCUR IN A SEVERE WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE OLD DESIGNED WASHER/WIPER SWITCHES WITH A NEWLY DESIGNED SWITCH.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 1997. NOTES:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: LUMINA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1993 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: SEATS
-->| NHTSA Campaign Number: | 93V035000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1993 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19930201 - 19930201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5574 |
| Date Owner Notified By Manufacturer: | 19930303 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930309 |
| Record Creation Date: | 19930325 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 207 |
Defect Summary:
THE DRIVER AND PASSENGER FRONT SEAT MANUAL RECLINING MECHANISMS DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS 207, "SEATING SYSTEMS." THE SEAT BACK MECHANISMS WILL NOT LATCH UNDER CERTAIN CONDITIONS.
Consequence Summary:
THE SEATS MAY RECLINE WITHOUT PRIOR WARNING, RESULTINGIN A HAZARD TO SEAT OCCUPANTS AND POSSIBLE LOSS OF VEHICLE CONTROL.
Corrective Summary:
REPLACE THE MANUAL SEAT RECLINER MECHANISM WITH A MECHANISM THAT COMPLIES WITH FMVSS 207.
Notes:
SYSTEM: FRONT SEAT MANUAL RECLINER MECHANISMS; FMVSS 207.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: LUMINA: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 91V214000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1992 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19911001 - 19911101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 10141 |
| Date Owner Notified By Manufacturer: | 19911129 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911206 |
| Record Creation Date: | 19911216 |
Defect Summary:
THE REVERSE SERVO APPLY PIN MAY BIND IN THE CASE WHICH COULD CAUSE REVERSE BAND DISTRESS (LOSS OR SLIPPING OF REVERSE), REVERSE BAND DRAG IN DRIVE RANGE (POOR PERFORMANCE -- POOR POWER), OR THE TRANSMISSION TO REMAIN IN REVERSE WHILE THE SHIFT INDICATOR SHOWS NEUTRAL GEAR POSITION.
Consequence Summary:
IF THE TRANSMISSION REMAINS IN REVERSE WHILE THE SHIFTINDICATOR SHOWS NEUTRAL, THE VEHICLE MAY UNEXPECTEDLY MOVE REARWARD AND RESULTIN A VEHICLE ACCIDENT.
Corrective Summary:
REPLACE THE TRANSAXLE WHERE REQUIRED.
Notes:
SYSTEM: TRANSMISSION AND TRANSMISSION SHIFT INDICATOR.VEHICLE DESCRIPTION: 1992 "A" AND "W" BODY PASSENGER CARS WITH 4-SPEEDAUTOMATIC TRANSMISSIONS.
CHEVROLET: LUMINA: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: LUMINA: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 92V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1992 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19920401 - 19920401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1058 |
| Date Owner Notified By Manufacturer: | 19921110 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19921103 |
| Record Creation Date: | 19921116 |
Defect Summary:
THERE IS FUEL LEAKAGE AT THE FUEL TANK FILL AND/OR VENT PIPE EXTENSION SOLDER JOINTS.
Consequence Summary:
FUEL LEAKS CAN LEAD TO A VEHICLE FIRE IF EXPOSED TO ASOURCE OF IGNITION.
Corrective Summary:
REPLACE THE FUEL TANK.
Notes:
SYSTEM: FUEL SYSTEM.VEHICLE DESCRIPTION: PASSENGER CARS WITH METHANOL/ETHANOL FUEL SYSTEMS.
CHEVROLET: LUMINA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1992 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: LUMINA: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1991 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: STRUCTURE
-->| NHTSA Campaign Number: | 00V189000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1991 |
| Manufacturer Campaign Number: | 00061/00065 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 713435 |
| Date Owner Notified By Manufacturer: | 20000928 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000711 |
| Record Creation Date: | 20000712 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, WHERE ROAD SALT USE IS HEAVY. A CONDITION WHERE ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS.
Consequence Summary:
IF BOTH BOLTS PULL THROUGH, THE FRONT OF THE CRADLE WOULD NO LONGER BE SUPPORTED AT THE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT COULD SEPARATE FROM THE STEERING GEAR.
Corrective Summary:
DEALERS WILL REPLACE THE FRONT AND REAR FRAME/CRADLE BOLTS AND RETAINERS.
Notes:
OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: LUMINA: STRUCTURE
-->| NHTSA Campaign Number: | 97V058000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1991 |
| Manufacturer Campaign Number: | 97016 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900801 - 19901130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 676535 |
| Date Owner Notified By Manufacturer: | 19970611 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970408 |
| Record Creation Date: | 19970417 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence Summary:
IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Corrective Summary:
DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 1997.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: SEAT BELTS
-->| NHTSA Campaign Number: | 92V003000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900201 - 19910201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 347866 |
| Date Owner Notified By Manufacturer: | 19920131 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19920110 |
| Record Creation Date: | 19920123 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
THE FRONT DOOR SHOULDER BELT GUIDE LOOPS MAY BE CRACKED AND ARE NOT IN COMPLIANCE WITH FMVSS 208.
Consequence Summary:
THE SEAT OCCUPANT FACES INCREASED RISK OF INJURY IN THEEVENT OF A SUDDEN STOP OR ACCIDENT.
Corrective Summary:
INSTALL REINFORCING PLATES ON THE CRACKED SHOULDER BELT GUIDES.
Notes:
SYSTEM: SAFETY BELTS; FMVSS 208.DESCRIPTION OF VEHICLES: PASSENGER VEHICLES; 1991 GM "J" AND "W" MODEL CARS.
CHEVROLET: LUMINA: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1991 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 90V185000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1990 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890101 - 19900101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 476422 |
| Date Owner Notified By Manufacturer: | 19901108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19901016 |
| Record Creation Date: | 19901026 |
Defect Summary:
BRAKE STOPLAMPS MAY NOT ILLUMINATE OR, IN SOME CASES, STOPLAMPS WILL NOT STAY ILLUMINATED ALL THE TIME WHEN BRAKES ARE APPLIED DUE TO A FAULTY STOPLAMP SWITCH. ALSO IN VEHICLES EQUIPPED WITH CRUISE CONTROL, A FAULTY STOPLAMP SWITCH CAN RESULT IN RESUMPTION OF THE CRUISE CONTROL FUNCTION UPON RELEASE OF THE BRAKE PEDAL.
Consequence Summary:
A TRAILING VEHICLE MAY NOT RECOGNIZE A BRAKING ACTIONIN TIME TO RESPOND APPROPRIATELY. ALSO, CRUISE CONTROL WILL REENGAGE UPONRELEASE OF THE BRAKE PEDAL AND RESUME THE SET SPEED. IN EITHER CASE, IT COULDRESULT IN A CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
INSTALL AN IMPROVED DESIGN STOPLAMP SWITCH.
Notes:
SYSTEM: BRAKE STOPLAMP SWITCH.VEHICLE DESCRIPTION: PASSENGER CARS.NOTE: ALSO SEE NHTSA RECALL 92V086000.
CHEVROLET: LUMINA: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1990 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: LUMINA: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: LUMINA: STRUCTURE
-->| NHTSA Campaign Number: | 00V189000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1990 |
| Manufacturer Campaign Number: | 00061/00065 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 713435 |
| Date Owner Notified By Manufacturer: | 20000928 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000711 |
| Record Creation Date: | 20000712 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, WHERE ROAD SALT USE IS HEAVY. A CONDITION WHERE ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS.
Consequence Summary:
IF BOTH BOLTS PULL THROUGH, THE FRONT OF THE CRADLE WOULD NO LONGER BE SUPPORTED AT THE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT COULD SEPARATE FROM THE STEERING GEAR.
Corrective Summary:
DEALERS WILL REPLACE THE FRONT AND REAR FRAME/CRADLE BOLTS AND RETAINERS.
Notes:
OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: LUMINA: STRUCTURE
-->| NHTSA Campaign Number: | 97V058000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1990 |
| Manufacturer Campaign Number: | 97016 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890101 - 19900730 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 676535 |
| Date Owner Notified By Manufacturer: | 19970611 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970408 |
| Record Creation Date: | 19970417 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence Summary:
IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Corrective Summary:
DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 1997.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: SEAT BELTS
-->| NHTSA Campaign Number: | 91V005000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890201 - 19900801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 412792 |
| Date Owner Notified By Manufacturer: | 19910222 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19911002 |
| Record Creation Date: | 19910219 |
Defect Summary:
FRONT SHOULDER SAFETY BELT WEBBING MAY SEPARATE AT FRONT BELT UPPER GUIDE LOOPS ON EITHER SIDE OF THE FRONT SEAT.
Consequence Summary:
WEBBING SEPARATION COULD OCCUR WITHOUT PRIOR WARNING ANDINCREASE THE RISK OF INJURY TO BELTED FRONT OUTBOARD OCCUPANTS IN A HIGH ENERGYCRASH.
Corrective Summary:
INSTALL A CONTROLLED ROTATION BRACKET ON DRIVER AND PASSENGER SIDE FRONT SEAT BELT GUIDE LOOPS.
Notes:
SYSTEM: FRONT SHOULDER SAFETY BELT.VEHICLE DESCRIPTION: PASSENGER CARS.
CHEVROLET: LUMINA: WHEELS
-->| NHTSA Campaign Number: | 95V115000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1990 |
| Manufacturer Component Description: | WHEELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880401 - 19900301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 22361 |
| Date Owner Notified By Manufacturer: | 19950614 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950605 |
| Record Creation Date: | 19950613 |
Defect Summary:
CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH, THE WHEEL WILL COMPLETELY SEPARATE FROM THE VEHICLE.
Consequence Summary:
IF WHEEL SEPARATION OCCURS WHILE THE VEHICLE IS IN MOTION, LOSS OF STEERING AND BRAKE CONTROL OF THE VEHICLE OCCURS, AND A VEHICLE CRASH COULD RESULT WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSPECT THE MANUFACTURING DATE CODES STAMPED ON EACH WHEEL OF THE VEHICLE AND IF A WHEEL FALLS WITHIN THE SPECIFIED DATE CODE RANGE, THE DEALER WILL REPLACE THAT WHEEL ASSEMBLY.
Notes:
SYSTEM: WHEELS.VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH KELSEY HAYES STEELWHEELS; MODELS RPO PB9 14" AND PG1 15".NOTE: VEHICLES PREVIOUSLY INSPECTED THAT HAD LESS THAN FOUR WHEELS REPLACED IN RECALL CAMPAIGN 94V-041 ARE TO BE REINSPECTED.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME,SHOULD CONTACT CHEVROLET AT 1-800-222-1020; BUICK AT 1-800-521-7300; PONTIAC AT 1-800-762-2737; OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: WHEELS
-->| NHTSA Campaign Number: | 94V041000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1990 |
| Manufacturer Component Description: | WHEELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880401 - 19900301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 198163 |
| Date Owner Notified By Manufacturer: | 19940505 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950328 |
| Record Creation Date: | 19950406 |
Defect Summary:
CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH, THE WHEEL WILL COMPLETELY SEPARATE FROM THE VEHICLE.
Consequence Summary:
IF WHEEL SEPARATION OCCURS WHILE THE VEHICLE IS IN MOTION, LOSS OF STEERING AND BRAKE CONTROL OF THE VEHICLE OCCURS, AND A VEHICLE CRASH COULD RESULT WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSPECT THE MANUFACTURING CODES STAMPED ON EACH WHEEL OF THE VEHICLE AND IF A WHEEL FALLS WITHIN THE SPECIFIED DATE CODE RANGE, THE DEALER WILL REPLACE THAT WHEEL ASSEMBLY.
Notes:
SYSTEM: WHEELS.VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH KELSEY HAYES STEEL WHEELS; MODELS RPO PB6 14" AND RPO PG1 15".NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, PLEASE CONTACT CHEVROLET AT 1-800-222-1020; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: LUMINA: SEAT BELTS
-->| NHTSA Campaign Number: | 90V054000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUMINA |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880301 - 19900301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 673000 |
| Date Owner Notified By Manufacturer: | 19900723 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900314 |
| Record Creation Date: | 19900719 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
FRONT SHOULDER BELT GUIDE LOOP ATTACHMENT FASTENER MAY PULL THROUGH DOOR MOUNTED ANCHOR PLATE.
Consequence Summary:
SEAT BELT MAY NOT SUSTAIN LOADS REQUIRED BY FMVSS 210, AND IN A VEHICLE ACCIDENT, THE SEAT BELT MAY NOT PROPERLY RESTRAIN A PASSENGER, RESULTING IN INCREASED RISK OF GREATER INJURY TO AN OCCUPANT.
Corrective Summary:
REPLACE FRONT SHOULDER BELT GUIDE LOOP ATTACHMENT NUTS AND INSTALL NEW GUIDE COVER.
Notes:
SYSTEM: SEAT BELT ANCHORAGE; FMVSS 210.VEHICLE DESCRIPTION: PASSENGER CARS.
-- "CHEVROLET: LUV PICK UP: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
| NHTSA Campaign Number: | 79V254000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | LUV PICK UP |
| Model Year: | 1979 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19780901 - 19790401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15981 |
| Date Owner Notified By Manufacturer: | 19791208 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19791203 |
| Record Creation Date: | 19800111 |
Defect Summary:
THE FRONT SUSPENSION UPPER CONTROL ARM SHAFT ATTACHING BOLTS MAY LOOSEN ON THE INVOLVED VEHICLES. THE LOOSENED CONDITION OF THE CONTROL ARM CAN RESULT IN INCORRECT FRONT WHEEL ALIGNMENT AND A NOTICEABLE INCREASE IN STEERING EFFORT. IF THIS CONDITION IS NOT CORRECTED THE ATTACHING BOLTS MAY FALL OUT OR PULL THROUGH THE FRAME BRACKET. THE UNATTACHED CONTROL ARM SHAFT COULD CHAFE AGAINST THE BRAKE PIPE AND LEAD TO BRAKE PIPE FAILURE.
Corrective Summary:
DEALER WILL REPLACE THE FRONT SUSPENSION UPPER CONTROL ARM SHAFT ATTACHMENT ON ALL SUSPECT VEHICLES. IF THE CONTROL ARM HAS DETACHED FROM THE SHOCK TOWER, THE BRAKE PIPE WILL BE INSPECTED AND REPLACED IF DAMAGED.
Notes:
VEHICLE DESCRIPTION: TRUCKS.SYSTEM: SUSPENSION; ATTACHING BOLTS.CONSEQUENCES OF DEFECT: THIS DEFECT MAY RESULT IN LOSS OF BRAKE FLUID ANDDEGRADED BRAKING CAPABILITY LEADING TO A VEHICLE ACCIDENT.
" - --CHEVROLET: MALIBU: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
-->| NHTSA Campaign Number: | 08V634000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 8388 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20080814 - 20080919 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20081202 |
| Record Creation Date: | 20081203 |
Defect Summary:
GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE BLOWER WOULD NOT FUNCTION PROPERLY AND THE MODE SELECTOR WOULD REMAIN IN THE LAST KNOWN SETTING.
Consequence Summary:
IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08388.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-->| NHTSA Campaign Number: | 09V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 9041 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 276729 |
| Date Owner Notified By Manufacturer: | 20090315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090306 |
| Record Creation Date: | 20090306 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 102 & 114 |
Defect Summary:
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GENERAL MOTORS RECALL NO. 09041.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2007 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-->| NHTSA Campaign Number: | 11E009000 |
| Vehicle/Equipment Make: | TI GROUP AUTOMOTIVE SYSTEMS, LLC |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2007 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4887 |
| Date Owner Notified By Manufacturer: | 20110222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | TI GROUP AUTOMOTIVE SYSTEMS, LLC |
| Report Received Date: | 20110228 |
| Record Creation Date: | 20110228 |
Defect Summary:
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
Consequence Summary:
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
Corrective Summary:
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET AND REPLACEMENT FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 06V417000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 6102 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050801 - 20050831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 794 |
| Date Owner Notified By Manufacturer: | 20061106 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20061031 |
| Record Creation Date: | 20061101 |
Defect Summary:
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence Summary:
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Corrective Summary:
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Notes:
GM RECALL NO. 06102.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2006 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 05V486000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5091 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2351 |
| Date Owner Notified By Manufacturer: | 20051129 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051019 |
| Record Creation Date: | 20051019 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence Summary:
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Corrective Summary:
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO.05091.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-->| NHTSA Campaign Number: | 11E009000 |
| Vehicle/Equipment Make: | TI GROUP AUTOMOTIVE SYSTEMS, LLC |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2006 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4887 |
| Date Owner Notified By Manufacturer: | 20110222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | TI GROUP AUTOMOTIVE SYSTEMS, LLC |
| Report Received Date: | 20110228 |
| Record Creation Date: | 20110228 |
Defect Summary:
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
Consequence Summary:
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
Corrective Summary:
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET AND REPLACEMENT FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2005 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-->| NHTSA Campaign Number: | 11E009000 |
| Vehicle/Equipment Make: | TI GROUP AUTOMOTIVE SYSTEMS, LLC |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2005 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4887 |
| Date Owner Notified By Manufacturer: | 20110222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | TI GROUP AUTOMOTIVE SYSTEMS, LLC |
| Report Received Date: | 20110228 |
| Record Creation Date: | 20110228 |
Defect Summary:
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
Consequence Summary:
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
Corrective Summary:
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET AND REPLACEMENT FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE
-->| NHTSA Campaign Number: | 04V190000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4030 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000501 - 20040331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 65439 |
| Date Owner Notified By Manufacturer: | 20040616 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040419 |
| Record Creation Date: | 20040421 |
Defect Summary:
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
Consequence Summary:
UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04030.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MALIBU: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 04V094000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4011 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030801 - 20040131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 51715 |
| Date Owner Notified By Manufacturer: | 20040421 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040224 |
| Record Creation Date: | 20040301 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
Corrective Summary:
OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04011.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MALIBU: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 04V188000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4027 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030501 - 20040331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 84474 |
| Date Owner Notified By Manufacturer: | 20040507 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040416 |
| Record Creation Date: | 20040421 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
Consequence Summary:
IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
Corrective Summary:
DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO. 04027.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MALIBU: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-->| NHTSA Campaign Number: | 11E009000 |
| Vehicle/Equipment Make: | TI GROUP AUTOMOTIVE SYSTEMS, LLC |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2004 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4887 |
| Date Owner Notified By Manufacturer: | 20110222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | TI GROUP AUTOMOTIVE SYSTEMS, LLC |
| Report Received Date: | 20110228 |
| Record Creation Date: | 20110228 |
Defect Summary:
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
Consequence Summary:
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
Corrective Summary:
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET AND REPLACEMENT FUEL PUMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2003 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
-->| NHTSA Campaign Number: | 04V528000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4092 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:ACCELERATOR PEDAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20021101 - 20030531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 92863 |
| Date Owner Notified By Manufacturer: | 20041220 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20041101 |
| Record Creation Date: | 20041103 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 124 |
Defect Summary:
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IN HOT AMBIENT CONDITIONS, THE ACCELERATOR PEDAL ARM MAY STICK AT THE ATTACHMENT TO THE BRACKET AND NOT RETURN TO THE ENGINE IDLE POSITION WHEN THE OPERATOR LIFTS HIS FOOT FROM THE ACCELERATOR PEDAL.
Consequence Summary:
FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE ACCELERATOR PEDAL ARM AND REPLACE THE ACCELERATOR AND BRAKE PEDAL ASSEMBLY WITH A NEW ASSEMBLY, IF NECESSARY. THE RECALL BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Notes:
GMRECALL NO. 04092. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.
CHEVROLET: MALIBU: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2002 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 02V107000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 2015 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020201 - 20020228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 10168 |
| Date Owner Notified By Manufacturer: | 20020523 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020410 |
| Record Creation Date: | 20020415 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
Consequence Summary:
LIGHT INTENSITIES BELOW THE MINIMUM INTENSITY REQUIREMENTS CAUSE REDUCTION IN VISIBILITY DOWN THE ROAD FOR THE DRIVER OF THE VEHICLE AND INTENSITIES ABOVE THE MAXIMUM INTENSITY REQUIREMENTS CAUSE INCREASE IN GLARE FOR DRIVERS AHEAD OF, OR APPROACHING, THE VEHICLE.
Corrective Summary:
DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MALIBU: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 03V327000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 3043 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000323 - 20010531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 670740 |
| Date Owner Notified By Manufacturer: | 20040205 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030828 |
| Record Creation Date: | 20030904 |
Defect Summary:
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence Summary:
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 03043.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MALIBU: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 2001 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1999 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: STEERING:RACK AND PINION
-->| NHTSA Campaign Number: | 03V527000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 3062 |
| Manufacturer Component Description: | STEERING:RACK AND PINION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970601 - 19971031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 750283 |
| Date Owner Notified By Manufacturer: | 20040205 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20031211 |
| Record Creation Date: | 20031218 |
Defect Summary:
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence Summary:
IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 03062.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MALIBU: VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES
-->| NHTSA Campaign Number: | 01V068000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 1014 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970601 - 19980131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 129427 |
| Date Owner Notified By Manufacturer: | 20010814 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010308 |
| Record Creation Date: | 20010308 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence Summary:
REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MALIBU: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1998 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MALIBU: STEERING:RACK AND PINION
-->| NHTSA Campaign Number: | 03V527000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 3062 |
| Manufacturer Component Description: | STEERING:RACK AND PINION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19961001 - 19970731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 750283 |
| Date Owner Notified By Manufacturer: | 20040205 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20031211 |
| Record Creation Date: | 20031218 |
Defect Summary:
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence Summary:
IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 03062.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MALIBU: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 97V107000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1997 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970101 - 19970430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16099 |
| Date Owner Notified By Manufacturer: | 19970715 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970628 |
| Record Creation Date: | 19970630 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FASTENERS THAT SECURE THE PASSENGER AIR BAG MODULE TO THE INSTRUMENT PANEL TIE BAR WERE OMITTED.
Consequence Summary:
IF THE AIR BAG DEPLOYS, THE MODULE COULD SEPARATE FROM THE INSTRUMENT PANEL STRIKING AND INJURING AN OCCUPANT.
Corrective Summary:
DEALERS WILL INSPECT THE AIR BAG MODULE FOR THE PRESENCE OF THE FASTENERS AND, IF NECESSARY, INSTALL ANY FASTENERS THAT MAY HAVE BEEN OMITTED.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING JULY 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: MALIBU: VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES
-->| NHTSA Campaign Number: | 01V068000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 1014 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960101 - 19970731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 129427 |
| Date Owner Notified By Manufacturer: | 20010814 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010308 |
| Record Creation Date: | 20010308 |
Defect Summary:
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence Summary:
REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MALIBU: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1997 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 83V106000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1983 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820801 - 19830601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4667 |
| Date Owner Notified By Manufacturer: | 19831025 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19831013 |
| Record Creation Date: | 19831021 |
Defect Summary:
THE MASTER CYLINDER REAR BRAKE PIPE, WHICH CARRIES BRAKE FLUID TO THE REAR BRAKES, MAY DEVELOP A LEAK DUE TO EXTENDED CHAFING ON THE AIR CLEANER RESONATOR BRACKET.
Corrective Summary:
IF UPON INSPECTION THE DEALER FINDS THAT THERE IS INADEQUATE CLEARANCE, THE PIPE WILL BE REFORMED TO OBTAIN THE NECESSARY THREE QUARTER INCH SPACE. ONLY THOSE PIPES SHOWING SIGNS OF WEAR WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITH 5.7LITER DIESEL ENGINES.SYSTEM: SERVICE BRAKES; MASTER CYLINDER, REAR BRAKE PIPE.CONSEQUENCES OF DEFECT: BRAKE FLUID LEAKAGE WILL RESULT IN LOSS OF BRAKINGACTION AT THE REAR WHEELS. LOSS OF VEHICLE CONTROL AND AN ACCIDENT COULDRESULT, PARTICULARLY IN SITUATIONS WHERE MINIMUM STOPPING DISTANCE IS REQUIRED.
CHEVROLET: MALIBU: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1983 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: VEHICLE SPEED CONTROL:CABLES
-->| NHTSA Campaign Number: | 83V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1983 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19801001 - 19830401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19108 |
| Date Owner Notified By Manufacturer: | 19830810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830819 |
| Record Creation Date: | 19830906 |
Defect Summary:
ACCELERATOR PUMP LEVER RETAINING PIN MAY LOOSEN AFTER REPEATED HEAVY ACCELERATOR PEDAL APPLICATIONS. THIS COULD CAUSE THE THROTTLE TO BECOME STUCK IN THE OPEN POSITION.
Corrective Summary:
DEALER WILL INSTALL A SPECIAL COTTER PIN, TO RETAIN THE ACCELERATOR PUMP PIN, AND A SPRING CLIP THRUST WASHER ON THE ACCELERATOR PUMP LINK.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CLOSED LOOP QUADRAJETCARBURETORS AND POLICE CAR PACKAGES.SYSTEM: POWER TRAIN; ACCELERATOR PUMP LEVER RETAINING PIN.CONSEQUENCES OF DEFECT: VEHICLE SPEED WOULD NOT DECREASE EVEN AFTER THEACCELERATOR PEDAL IS NO LONGER DEPRESSED. LOSS OF ACCELERATOR CONTROL WITHOUTPRIOR WARNING COULD RESULT IN AN ACCIDENT.NOTE: IF THE FAILURE OCCURS BEFORE CORRECTIVE SERVICE CAN BE PERFORMED, DRIVERSHOULD SHIFT TO NEUTRAL GEAR AND APPLY BRAKES AS NECESSARY. VEHICLE SHOULD BEPULLED OUT OF TRAFFIC AND THE IGNITION SHOULD BE TURNED OFF AFTER A COMPLETESTOP.
CHEVROLET: MALIBU: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1982 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
-->| NHTSA Campaign Number: | 82V012000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1982 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810801 - 19811101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 79686 |
| Date Owner Notified By Manufacturer: | 19820218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19820103 |
| Record Creation Date: | 19820208 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATING CONDITIONS, THE GOVERNOR WEIGHT RETAINER IN THE INJECTION PUMP MAY FAIL. THE THROTTLE VALVE COULD STICK, PREVENTING RETURN TO IDLE AND SHUT DOWN OF THE ENGINE BY THE DRIVER.
Corrective Summary:
DEALER WILL REPLACE THE GOVERNOR WEIGHT ASSEMBLY IN THE INJECTION PUMP AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 5.7 V8 ENGINES.SYSTEM: FUEL; THROTTLE VALVE.CONSEQUENCES OF DEFECT: THIS COULD RESULT IN LOSS OF VEHICLE CONTROL AND AVEHICLE ACCIDENT.NOTE: IF THROTTLE STICKING OCCURS BEFORE THE VEHICLE HAS RECEIVED THE NECESSARYMODIFICATIONS, THE DRIVER SHOULD SHIFT THE TRANSMISSION TO NEUTRAL, APPLY THESERVICE BRAKES TO BRING THE VEHICLE TO A SAFE STOP, THE IGNITION SHOULD BETURNED OFF AND THE NEAREST DEALERSHIP SHOULD BE CALLED FOR ASSISTANCE.
CHEVROLET: MALIBU: VEHICLE SPEED CONTROL:CABLES
-->| NHTSA Campaign Number: | 83V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1982 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19801001 - 19830401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19108 |
| Date Owner Notified By Manufacturer: | 19830810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830819 |
| Record Creation Date: | 19830906 |
Defect Summary:
ACCELERATOR PUMP LEVER RETAINING PIN MAY LOOSEN AFTER REPEATED HEAVY ACCELERATOR PEDAL APPLICATIONS. THIS COULD CAUSE THE THROTTLE TO BECOME STUCK IN THE OPEN POSITION.
Corrective Summary:
DEALER WILL INSTALL A SPECIAL COTTER PIN, TO RETAIN THE ACCELERATOR PUMP PIN, AND A SPRING CLIP THRUST WASHER ON THE ACCELERATOR PUMP LINK.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CLOSED LOOP QUADRAJETCARBURETORS AND POLICE CAR PACKAGES.SYSTEM: POWER TRAIN; ACCELERATOR PUMP LEVER RETAINING PIN.CONSEQUENCES OF DEFECT: VEHICLE SPEED WOULD NOT DECREASE EVEN AFTER THEACCELERATOR PEDAL IS NO LONGER DEPRESSED. LOSS OF ACCELERATOR CONTROL WITHOUTPRIOR WARNING COULD RESULT IN AN ACCIDENT.NOTE: IF THE FAILURE OCCURS BEFORE CORRECTIVE SERVICE CAN BE PERFORMED, DRIVERSHOULD SHIFT TO NEUTRAL GEAR AND APPLY BRAKES AS NECESSARY. VEHICLE SHOULD BEPULLED OUT OF TRAFFIC AND THE IGNITION SHOULD BE TURNED OFF AFTER A COMPLETESTOP.
CHEVROLET: MALIBU: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1981 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1981 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MALIBU: VEHICLE SPEED CONTROL:CABLES
-->| NHTSA Campaign Number: | 83V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1981 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19801001 - 19830401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19108 |
| Date Owner Notified By Manufacturer: | 19830810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830819 |
| Record Creation Date: | 19830906 |
Defect Summary:
ACCELERATOR PUMP LEVER RETAINING PIN MAY LOOSEN AFTER REPEATED HEAVY ACCELERATOR PEDAL APPLICATIONS. THIS COULD CAUSE THE THROTTLE TO BECOME STUCK IN THE OPEN POSITION.
Corrective Summary:
DEALER WILL INSTALL A SPECIAL COTTER PIN, TO RETAIN THE ACCELERATOR PUMP PIN, AND A SPRING CLIP THRUST WASHER ON THE ACCELERATOR PUMP LINK.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CLOSED LOOP QUADRAJETCARBURETORS AND POLICE CAR PACKAGES.SYSTEM: POWER TRAIN; ACCELERATOR PUMP LEVER RETAINING PIN.CONSEQUENCES OF DEFECT: VEHICLE SPEED WOULD NOT DECREASE EVEN AFTER THEACCELERATOR PEDAL IS NO LONGER DEPRESSED. LOSS OF ACCELERATOR CONTROL WITHOUTPRIOR WARNING COULD RESULT IN AN ACCIDENT.NOTE: IF THE FAILURE OCCURS BEFORE CORRECTIVE SERVICE CAN BE PERFORMED, DRIVERSHOULD SHIFT TO NEUTRAL GEAR AND APPLY BRAKES AS NECESSARY. VEHICLE SHOULD BEPULLED OUT OF TRAFFIC AND THE IGNITION SHOULD BE TURNED OFF AFTER A COMPLETESTOP.
CHEVROLET: MALIBU: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 85V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1980 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1810000 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850429 |
| Record Creation Date: | 19850501 |
Defect Summary:
EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT. FRONT BRAKES WOULD REMAIN OPERATIONAL.
Corrective Summary:
ADD A PART TO PREVENT WHEEL CYLINDER FROM ROTATING.
Notes:
NOTE: OWNER NOTIFICATION WILL BEGIN AFTER SEPTEMBER 1, 1985 AND SHOULD BE COMPLETED BY SEPTEMBER 30, 1985.VEHICLE DESCRIPTION: MIDSIZE PASSENGER CARS AND SMALL TRUCKS. SYSTEM: REAR BRAKES.
CHEVROLET: MALIBU: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1980 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: VISIBILITY:GLASS, SIDE/REAR
-->| NHTSA Campaign Number: | 81V022000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1980 |
| Manufacturer Component Description: | VISIBILITY:GLASS, SIDE/REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790101 - 19791201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 67350 |
| Date Owner Notified By Manufacturer: | 19810313 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810211 |
| Record Creation Date: | 19810311 |
Defect Summary:
THE ELECTRO-CLEAR REAR WINDOW DEFOGGERS CONTAIN A DEFECT WHICH CAUSES THE GLASS TO SHATTER WITHOUT IMPACT DURING OR SOME TIME AFTER USE OF THE DEFOGGER. VERTICAL ELECTRICAL STRIPS MAY DETERIORATE AND CAUSE HOT SPOTS THAT CAN RESULT IN BREAKAGE OF THE REAR GLASS.
Corrective Summary:
VEHICLES WILL BE INSPECTED FOR PRESENCE OF A PARTICULAR WEATHERSTRIP. IF PRESENT, A LAYER OF A SPECIAL CONDUCTIVE EPOXY WILL BE ADDED TO THE VERTICAL BAR ON THE REAR WINDOW GLASS. THIS EPOXY IS A NEW CONDUCTIVE MATERIAL WHICH WILL NOT REACT WITH THE WEATHERSTRIP.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ELECTRO-CLEAR REAR WINDOWDEFOGGERS.SYSTEM: DEFOGGER; REAR WINDOW.CONSEQUENCES OF DEFECT: DRIVER DISTRACTION FROM THE EXPLOSION COULD RESULT IN AVEHICLE ACCIDENT. BROKEN OR HOT GLASS COULD CAUSE PERSONAL INJURY TO VEHICLEPASSENGERS, OTHER DRIVERS, AND NEARBY PEDESTRIANS.NOTE: OWNERS ARE ADVISED NOT TO USE REAR WINDOW DEFOGGER UNTIL VEHICLE ISINSPECTED.
CHEVROLET: MALIBU: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1980 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MALIBU: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 84V149000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1980 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19800701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3100000 |
| Date Owner Notified By Manufacturer: | 19841228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19841124 |
| Record Creation Date: | 19841127 |
Defect Summary:
REAR AXLE ASSEMBLY MAY HAVE AXLES THAT WERE IMPROPERLY MANUFACTURED. THIS CONDITION MAY RESULT IN SEPARATION OF THE AXLE SHAFT AND WHEEL ASSEMBLY FROM THE VEHICLE.
Corrective Summary:
THE DEALER WILL INSPECT THE REAR AXLE TO DETERMINE WHETHER IT WAS MANUFACTURED AT THE BUFFALO PLANT. IF SO, THEY WILL MAKE AXLE MEASUREMENTS AND IF NECESSARY REPLACE OR MODIFY AFFECTED AXLE COMPONENTS WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.SYSTEM: POWER TRAIN; REAR AXLE.CONSEQUENCES OF DEFECT: LOSS OF THE WHEEL ASSEMBLY COULD LEAD TO LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MALIBU: VEHICLE SPEED CONTROL:CABLES
-->| NHTSA Campaign Number: | 83V077000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1980 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL:CABLES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19801001 - 19830401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19108 |
| Date Owner Notified By Manufacturer: | 19830810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19830819 |
| Record Creation Date: | 19830906 |
Defect Summary:
ACCELERATOR PUMP LEVER RETAINING PIN MAY LOOSEN AFTER REPEATED HEAVY ACCELERATOR PEDAL APPLICATIONS. THIS COULD CAUSE THE THROTTLE TO BECOME STUCK IN THE OPEN POSITION.
Corrective Summary:
DEALER WILL INSTALL A SPECIAL COTTER PIN, TO RETAIN THE ACCELERATOR PUMP PIN, AND A SPRING CLIP THRUST WASHER ON THE ACCELERATOR PUMP LINK.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CLOSED LOOP QUADRAJETCARBURETORS AND POLICE CAR PACKAGES.SYSTEM: POWER TRAIN; ACCELERATOR PUMP LEVER RETAINING PIN.CONSEQUENCES OF DEFECT: VEHICLE SPEED WOULD NOT DECREASE EVEN AFTER THEACCELERATOR PEDAL IS NO LONGER DEPRESSED. LOSS OF ACCELERATOR CONTROL WITHOUTPRIOR WARNING COULD RESULT IN AN ACCIDENT.NOTE: IF THE FAILURE OCCURS BEFORE CORRECTIVE SERVICE CAN BE PERFORMED, DRIVERSHOULD SHIFT TO NEUTRAL GEAR AND APPLY BRAKES AS NECESSARY. VEHICLE SHOULD BEPULLED OUT OF TRAFFIC AND THE IGNITION SHOULD BE TURNED OFF AFTER A COMPLETESTOP.
CHEVROLET: MALIBU: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 85V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1979 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1810000 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850429 |
| Record Creation Date: | 19850501 |
Defect Summary:
EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT. FRONT BRAKES WOULD REMAIN OPERATIONAL.
Corrective Summary:
ADD A PART TO PREVENT WHEEL CYLINDER FROM ROTATING.
Notes:
NOTE: OWNER NOTIFICATION WILL BEGIN AFTER SEPTEMBER 1, 1985 AND SHOULD BE COMPLETED BY SEPTEMBER 30, 1985.VEHICLE DESCRIPTION: MIDSIZE PASSENGER CARS AND SMALL TRUCKS. SYSTEM: REAR BRAKES.
CHEVROLET: MALIBU: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
-->| NHTSA Campaign Number: | 79V196000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1979 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:HEAD RESTRAINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790401 - 19790401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 491 |
| Date Owner Notified By Manufacturer: | 19790907 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790828 |
| Record Creation Date: | 19791211 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
THE INVOVLED VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACTS". INCORRECT HEAD RESTRAINTS MAY HAVE BEEN INSTALLED.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, INSTALL NEW HEAD RESTRAINTS AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH BENCH SEATS.SYSTEM: INTERIOR; HEAD RESTRAINTS.CONSEQUENCES OF DEFECT: IN THE EVENT OF AN ACCIDENT IN WHICH A REAR SEATPASSENGER"S HEAD IMPACTS WITH THE FRONT SEAT HEAD RESTRAINT, THE POSSIBILITY OFHEAD INJURY TO THE REAR SEAT PASSENGER MAY BE INCREASED.
CHEVROLET: MALIBU: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1979 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: VISIBILITY:GLASS, SIDE/REAR
-->| NHTSA Campaign Number: | 81V022000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1979 |
| Manufacturer Component Description: | VISIBILITY:GLASS, SIDE/REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790101 - 19791201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 67350 |
| Date Owner Notified By Manufacturer: | 19810313 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810211 |
| Record Creation Date: | 19810311 |
Defect Summary:
THE ELECTRO-CLEAR REAR WINDOW DEFOGGERS CONTAIN A DEFECT WHICH CAUSES THE GLASS TO SHATTER WITHOUT IMPACT DURING OR SOME TIME AFTER USE OF THE DEFOGGER. VERTICAL ELECTRICAL STRIPS MAY DETERIORATE AND CAUSE HOT SPOTS THAT CAN RESULT IN BREAKAGE OF THE REAR GLASS.
Corrective Summary:
VEHICLES WILL BE INSPECTED FOR PRESENCE OF A PARTICULAR WEATHERSTRIP. IF PRESENT, A LAYER OF A SPECIAL CONDUCTIVE EPOXY WILL BE ADDED TO THE VERTICAL BAR ON THE REAR WINDOW GLASS. THIS EPOXY IS A NEW CONDUCTIVE MATERIAL WHICH WILL NOT REACT WITH THE WEATHERSTRIP.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ELECTRO-CLEAR REAR WINDOWDEFOGGERS.SYSTEM: DEFOGGER; REAR WINDOW.CONSEQUENCES OF DEFECT: DRIVER DISTRACTION FROM THE EXPLOSION COULD RESULT IN AVEHICLE ACCIDENT. BROKEN OR HOT GLASS COULD CAUSE PERSONAL INJURY TO VEHICLEPASSENGERS, OTHER DRIVERS, AND NEARBY PEDESTRIANS.NOTE: OWNERS ARE ADVISED NOT TO USE REAR WINDOW DEFOGGER UNTIL VEHICLE ISINSPECTED.
CHEVROLET: MALIBU: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1979 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MALIBU: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 84V149000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1979 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19800701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3100000 |
| Date Owner Notified By Manufacturer: | 19841228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19841124 |
| Record Creation Date: | 19841127 |
Defect Summary:
REAR AXLE ASSEMBLY MAY HAVE AXLES THAT WERE IMPROPERLY MANUFACTURED. THIS CONDITION MAY RESULT IN SEPARATION OF THE AXLE SHAFT AND WHEEL ASSEMBLY FROM THE VEHICLE.
Corrective Summary:
THE DEALER WILL INSPECT THE REAR AXLE TO DETERMINE WHETHER IT WAS MANUFACTURED AT THE BUFFALO PLANT. IF SO, THEY WILL MAKE AXLE MEASUREMENTS AND IF NECESSARY REPLACE OR MODIFY AFFECTED AXLE COMPONENTS WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.SYSTEM: POWER TRAIN; REAR AXLE.CONSEQUENCES OF DEFECT: LOSS OF THE WHEEL ASSEMBLY COULD LEAD TO LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MALIBU: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 77V181000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1978 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 636 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19771017 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE REAR BRAKE WHEEL CYLINDER RETAINER ON THE INVOLVED VEHICLES MAY NOT HAVE BEEN PROPERLY INSTALLED. SHOULD THE WHEEL CYLINDER RETAINER BECOME COMPLETELY DISENGAGED, THE WHEEL CYLINDER COULD MOVE OUTBOARD CAUSING A LOSS OF BRAKE FLUID AND A LOSS OF REAR BRAKING ACTION.
Corrective Summary:
THE DEALER WILL REPOSITION THE REAR WHEEL BRAKE CYLINDER RETAINERS, FREE OF CHARGE, ON ALL AFFECTED VEHICLES.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; REAR WHEEL BRAKE CYLINDER RETAINERS.CONSEQUENCES OF DEFECT: LOSS OF REAR BRAKING CAPABILITY CAN OCCUR WITHOUTWARNING AND AN ACCIDENT COULD RESULT.NOTE: LOSS OF BRAKING ACTION WILL BE SIGNALLED TO DRIVER BY THE WARNING LIGHTON THE DASH AND BY AN INCREASE IN BRAKE PEDAL TRAVEL AND INCREASED VEHICLESTOPPING DISTANCES.
CHEVROLET: MALIBU: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-->| NHTSA Campaign Number: | 78V139000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1978 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19780101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 333619 |
| Date Owner Notified By Manufacturer: | 19780619 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19780613 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE HUB PORTION OF THE FAN BLADE ASSEMBLY COULD CRACK DUE TO HIGH STRESS LEVELS GENERATED DURING ENGINE OPERATING CONDITIONS. EVENTUALLY, THE BLADE COULD BREAK APART AT THE HUB AND BLADE PIECES COULD BE PROPELLED INTO THE ENGINE. IF THE HOOD IS OPEN WHILE THE ENGINE IS RUNNING, THE FRAGMENTS WOULD BE FREE TO FLY FROM THE VEHICLE.
Corrective Summary:
DEALER WILL REPLACE THE FAN BLADE ASSEMBLY WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: ENGINE COOLING; FAN BLADE ASSEMBLY.CONSEQUENCES OF DEFECT: FAN FAILURE COULD RESULT IN DAMAGE TO COMPONENTS IN THEENGINE AREA, OR PERSONAL INJURY TO BYSTANDERS IF THE HOOD IS OPEN AT THE TIME.NOTE: THE VEHICLE SHOULD NOT BE SERVICED WITH THE HOOD OPEN AND THE ENGINERUNNING UNTIL THE DEFECT IS CORRECTED.
CHEVROLET: MALIBU: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 85V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1978 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1810000 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850429 |
| Record Creation Date: | 19850501 |
Defect Summary:
EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT. FRONT BRAKES WOULD REMAIN OPERATIONAL.
Corrective Summary:
ADD A PART TO PREVENT WHEEL CYLINDER FROM ROTATING.
Notes:
NOTE: OWNER NOTIFICATION WILL BEGIN AFTER SEPTEMBER 1, 1985 AND SHOULD BE COMPLETED BY SEPTEMBER 30, 1985.VEHICLE DESCRIPTION: MIDSIZE PASSENGER CARS AND SMALL TRUCKS. SYSTEM: REAR BRAKES.
CHEVROLET: MALIBU: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1978 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
-->| NHTSA Campaign Number: | 78V115000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1978 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:HEAD RESTRAINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19771001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1643 |
| Date Owner Notified By Manufacturer: | 19780526 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19780524 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
INCORRECT HEAD RESTRAINTS MAY HAVE BEEN INSTALLED ON THE INVOLVED VEHICLES. THIS FAILS TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACTS".
Corrective Summary:
DEALER WILL REPLACE INCORRECT HEAD RESTRAINTS WITH IMPROVED HEAD RESTRAINTS.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: INTERIOR; HEAD RESTRAINTS.CONSEQUENCES OF DEFECT: IN THE EVENT OF AN ACCIDENT, INADEQUATE HEAD RESTRAINTSCOULD RESULT IN SERIOUS HEAD INJURIES.
CHEVROLET: MALIBU: SUSPENSION:FRONT:WHEEL BEARING
-->| NHTSA Campaign Number: | 79V175000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1978 |
| Manufacturer Component Description: | SUSPENSION:FRONT:WHEEL BEARING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19780701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1896222 |
| Date Owner Notified By Manufacturer: | 19790824 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790723 |
| Record Creation Date: | 19791012 |
Defect Summary:
UNDER CERTAIN DRIVING CONDITIONS, THESE VEHICLES CAN EXPERIENCE TEMPERATURES IN THE FRONT WHEEL OUTER BEARING AREA WHICH CAN AFFECT THE WHEEL BEARING GREASE. THIS CAN RESULT IN INADEQUATE LUBRICATION OF THE BEARING. THIS CONDITION MAY BE FURTHER AGGRAVATED BY IMPROPER ADJUSTMENT OF THE FRONT WHEEL SPINDLE NUT.
Corrective Summary:
THE DEALER WILL INSTALL NEW FRONT WHEEL OUTER BEARINGS PACKED WITH GREASE AND THE SPINDLE WILL BE COATED WITH LUBRICANT. NEW GREASE RETAINER CAPS WILL ALSO BE INSTALLED TO MAINTAIN GREASE IN OUTER BEARING. THIS WILL BE DONE FREE OF CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; WHEELS; BEARING GREASE.CONSEQUENCES OF DEFECT: CONTINUED OPERATION OF THE VEHICLE ALONG WITHINADEQUATE LUBRICATION MAY CAUSE FAILURE OF THE FRONT WHEEL OUTER BEARING ANDTHE SPINDLE. LOSS OF VEHICLE CONTROL AND AN ACCIDENT MAY RESULT.NOTE: BEARING AND SPINDLE FAILURE MAY BE PRECEDED BY A NOTICEABLE VIBRATION ANDNOISE COMING FROM THE FRONT END OF THE VEHICLE.
CHEVROLET: MALIBU: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1978 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MALIBU: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 84V149000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1978 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19800701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3100000 |
| Date Owner Notified By Manufacturer: | 19841228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19841124 |
| Record Creation Date: | 19841127 |
Defect Summary:
REAR AXLE ASSEMBLY MAY HAVE AXLES THAT WERE IMPROPERLY MANUFACTURED. THIS CONDITION MAY RESULT IN SEPARATION OF THE AXLE SHAFT AND WHEEL ASSEMBLY FROM THE VEHICLE.
Corrective Summary:
THE DEALER WILL INSPECT THE REAR AXLE TO DETERMINE WHETHER IT WAS MANUFACTURED AT THE BUFFALO PLANT. IF SO, THEY WILL MAKE AXLE MEASUREMENTS AND IF NECESSARY REPLACE OR MODIFY AFFECTED AXLE COMPONENTS WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.SYSTEM: POWER TRAIN; REAR AXLE.CONSEQUENCES OF DEFECT: LOSS OF THE WHEEL ASSEMBLY COULD LEAD TO LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MALIBU CLASSIC: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 77V181000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU CLASSIC |
| Model Year: | 1978 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 636 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19771017 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE REAR BRAKE WHEEL CYLINDER RETAINER ON THE INVOLVED VEHICLES MAY NOT HAVE BEEN PROPERLY INSTALLED. SHOULD THE WHEEL CYLINDER RETAINER BECOME COMPLETELY DISENGAGED, THE WHEEL CYLINDER COULD MOVE OUTBOARD CAUSING A LOSS OF BRAKE FLUID AND A LOSS OF REAR BRAKING ACTION.
Corrective Summary:
THE DEALER WILL REPOSITION THE REAR WHEEL BRAKE CYLINDER RETAINERS, FREE OF CHARGE, ON ALL AFFECTED VEHICLES.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; REAR WHEEL BRAKE CYLINDER RETAINERS.CONSEQUENCES OF DEFECT: LOSS OF REAR BRAKING CAPABILITY CAN OCCUR WITHOUTWARNING AND AN ACCIDENT COULD RESULT.NOTE: LOSS OF BRAKING ACTION WILL BE SIGNALLED TO DRIVER BY THE WARNING LIGHTON THE DASH AND BY AN INCREASE IN BRAKE PEDAL TRAVEL AND INCREASED VEHICLESTOPPING DISTANCES.
CHEVROLET: MALIBU: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 78V138000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1977 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770101 - 19770401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 265068 |
| Date Owner Notified By Manufacturer: | 19780626 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19780613 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE REAR AXLE SHAFTS MAY CONTAIN A FLAW IN THE METAL. THIS FLAW COULD ALLOW THE SHAFT TO BREAK AND THE TIRE AND WHEEL ASSEMBLY TO SEPARATE.
Corrective Summary:
THE DEALER WILL REPLACE ONE OR BOTH REAR AXLE SHAFTS, IF NECESSARY, FREE OF CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; AXLE/SHAFT.CONSEQUENCES OF DEFECT: SHOULD SEPARATION OCCUR WHILE VEHICLE IS IN MOTION,LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING AND AN ACCIDENT COULD RESULT.NOTE: DRIVER SHOULD AVOID FAST CORNERING, RAPID ACCELERATION, OR ANY TYPE OFDRIVING WHICH MAY PRODUCE ABNORMALLY HEAVY LOADS ON THE REAR AXLE SHAFTS UNTILTHE VEHICLE CAN BE INSPECTED.
CHEVROLET: MALIBU: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1977 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1974 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MALIBU: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
-->| NHTSA Campaign Number: | 73V152000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MALIBU |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720801 - 19730601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3094 |
| Date Owner Notified By Manufacturer: | 19730712 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730716 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO.73-C-15, PONTIAC CAMPAIGN NO 73-C-6, BUICK CAMPAIGN NO73-C-2, GMC CAMPAIGN NO 73-C-20.POSSIBILITY THAT THE GASKET BETWEEN THEMASTER CYLINDER AND THEFORWARD SIDE OF THE DASH, AND THE BOOT WHICH COVERS THEREAR OPENING OF THE MASTER CYLINDER IN THE DRIVER'S COMPARTMENT WEREOMITTED INASSEMBLY.IF THIS CONDITION EXISTS IT COULD CAUSE CORROSION OF THE CYLINDERBORE AND DAMAGE PISTON SEAL RESULTINGIN LOSS OF BRAKE FLUID AND IMPAIREDBRAKING.(CORRECT BY INSPECTING AND REPLACING GASKET AND BOOT.)
--CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2007 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2006 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2005 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2005 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2005 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 04V287000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4049 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20040430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 47991 |
| Date Owner Notified By Manufacturer: | 20040628 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040623 |
| Record Creation Date: | 20040623 |
Defect Summary:
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Consequence Summary:
DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
Corrective Summary:
DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
Notes:
RECALL NO. 04049.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MONTE CARLO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2004 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2004 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2004 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE
-->| NHTSA Campaign Number: | 03V051000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3008 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020701 - 20021031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130 |
| Date Owner Notified By Manufacturer: | 20030311 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030214 |
| Record Creation Date: | 20030224 |
Defect Summary:
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence Summary:
THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Corrective Summary:
DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
Notes:
GM RECALL NO. 03008. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MONTE CARLO: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-->| NHTSA Campaign Number: | 03V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3039 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020301 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1707825 |
| Date Owner Notified By Manufacturer: | 20030820 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030715 |
| Record Creation Date: | 20030724 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence Summary:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 03039.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MONTE CARLO: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 02V222000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 2032 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020501 - 20020731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 133221 |
| Date Owner Notified By Manufacturer: | 20020815 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020809 |
| Record Creation Date: | 20020814 |
Defect Summary:
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence Summary:
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Corrective Summary:
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Notes:
GM RECALL NO. 02032. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MONTE CARLO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2003 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2003 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 09V116000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 9047 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1497516 |
| Date Owner Notified By Manufacturer: | 20090409 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090408 |
| Record Creation Date: | 20090408 |
Defect Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2003 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 02V222000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 2032 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020501 - 20020731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 133221 |
| Date Owner Notified By Manufacturer: | 20020815 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020809 |
| Record Creation Date: | 20020814 |
Defect Summary:
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence Summary:
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Corrective Summary:
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Notes:
GM RECALL NO. 02032. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MONTE CARLO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2002 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2002 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 09V116000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 9047 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1497516 |
| Date Owner Notified By Manufacturer: | 20090409 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090408 |
| Record Creation Date: | 20090408 |
Defect Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2002 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: AIR BAGS
-->| NHTSA Campaign Number: | 00V244000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 73 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000701 - 20000731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 580 |
| Date Owner Notified By Manufacturer: | 20001026 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000829 |
| Record Creation Date: | 20000825 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence Summary:
IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Corrective Summary:
DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Notes:
OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MONTE CARLO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2001 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 08E063000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2001 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3855 |
| Date Owner Notified By Manufacturer: | 20081016 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20081017 |
| Record Creation Date: | 20081020 |
Defect Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO DORMAN'S OE SOLUTIONS BRAND NAME, BALKAMP'S NAPA BRAND, AND THE PLATINUM BRAND STEERING SHAFTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 09V116000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 9047 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1497516 |
| Date Owner Notified By Manufacturer: | 20090409 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090408 |
| Record Creation Date: | 20090408 |
Defect Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: SEAT BELTS
-->| NHTSA Campaign Number: | 00V228003 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 67 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000501 - 20000531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 156305 |
| Date Owner Notified By Manufacturer: | 20000824 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000807 |
| Record Creation Date: | 20000822 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Notes:
OWNER NOTIFICATION BEGAN AUGUST 24, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; CHEVROLET AT 1-800-222-1020; GMC AT 1-800-462-8782; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR SATURN AT 1-800-553-6000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MONTE CARLO: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 2001 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 02V329000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 2061 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19990301 - 19990630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 272 |
| Date Owner Notified By Manufacturer: | 20021216 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20021209 |
| Record Creation Date: | 20021219 |
Defect Summary:
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence Summary:
THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Corrective Summary:
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
Notes:
GM RECALL NO. 02061. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
-->| NHTSA Campaign Number: | 01I014000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1999 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Date Owner Notified By Manufacturer: | 20010926 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010924 |
| Record Creation Date: | 20020107 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
Consequence Summary:
THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.
Corrective Summary:
DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.
Notes:
GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO MODIFY THE VEHICLE IF AN OWNER HAS EXPERIENCED A GREATER THAN EXPECTED REDUCTION OR DELAY IN BRAKING ON WET ROADS.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, CONCERNING THIS PROGRAM.
CHEVROLET: MONTE CARLO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1999 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 09V116000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 9047 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1497516 |
| Date Owner Notified By Manufacturer: | 20090409 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090408 |
| Record Creation Date: | 20090408 |
Defect Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
-->| NHTSA Campaign Number: | 01I014000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1998 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Date Owner Notified By Manufacturer: | 20010926 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010924 |
| Record Creation Date: | 20020107 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
Consequence Summary:
THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.
Corrective Summary:
DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.
Notes:
GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO MODIFY THE VEHICLE IF AN OWNER HAS EXPERIENCED A GREATER THAN EXPECTED REDUCTION OR DELAY IN BRAKING ON WET ROADS.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, CONCERNING THIS PROGRAM.
CHEVROLET: MONTE CARLO: STEERING:RACK AND PINION
-->| NHTSA Campaign Number: | 03V527000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 3062 |
| Manufacturer Component Description: | STEERING:RACK AND PINION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19971031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 750283 |
| Date Owner Notified By Manufacturer: | 20040205 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20031211 |
| Record Creation Date: | 20031218 |
Defect Summary:
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence Summary:
IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 03062.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MONTE CARLO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1998 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 09V116000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 9047 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1497516 |
| Date Owner Notified By Manufacturer: | 20090409 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090408 |
| Record Creation Date: | 20090408 |
Defect Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 09047.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
-->| NHTSA Campaign Number: | 01I014000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1997 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Date Owner Notified By Manufacturer: | 20010926 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010924 |
| Record Creation Date: | 20020107 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
Consequence Summary:
THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.
Corrective Summary:
DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.
Notes:
GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO MODIFY THE VEHICLE IF AN OWNER HAS EXPERIENCED A GREATER THAN EXPECTED REDUCTION OR DELAY IN BRAKING ON WET ROADS.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, CONCERNING THIS PROGRAM.
CHEVROLET: MONTE CARLO: STEERING:RACK AND PINION
-->| NHTSA Campaign Number: | 03V527000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 3062 |
| Manufacturer Component Description: | STEERING:RACK AND PINION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960401 - 19970731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 750283 |
| Date Owner Notified By Manufacturer: | 20040205 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20031211 |
| Record Creation Date: | 20031218 |
Defect Summary:
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence Summary:
IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 03062.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: MONTE CARLO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1997 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
-->| NHTSA Campaign Number: | 01I014000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1996 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Date Owner Notified By Manufacturer: | 20010926 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010924 |
| Record Creation Date: | 20020107 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
Consequence Summary:
THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.
Corrective Summary:
DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.
Notes:
GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO MODIFY THE VEHICLE IF AN OWNER HAS EXPERIENCED A GREATER THAN EXPECTED REDUCTION OR DELAY IN BRAKING ON WET ROADS.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, CONCERNING THIS PROGRAM.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 96V122000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1996 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960601 - 19960601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3591 |
| Date Owner Notified By Manufacturer: | 19960705 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960701 |
| Record Creation Date: | 19960708 |
Defect Summary:
THESE VEHICLES WERE ASSEMBLED WITH ONE OF THE FOUR BRAKE BOOSTER TABS NOT PROPERLY LOCATED IN THE FRONT OF DASH REINFORCEMENT ASSEMBLY.
Consequence Summary:
IF THIS CONDITION WERE PRESENT IN A SITUATION WHERE STOPPING DISTANCES WERE SMALL, A VEHICLE CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT FOR PROPER BOOSTER INSTALLATION. BOOSTERS FOUND TO BE IMPROPERLY LOCATED WILL BE REMOVED AND REINSTALLED PROPERLY.
Notes:
SYSTEM: BRAKES; HYDRAULIC; POWER ASSIST; BOOSTER. VEHICLE DESCRIPTION: PASSENGER VEHICLES. OWNER NOTIFICATION: OWNER NOTIFICATION IS EXPECTED TO BEGIN IN JULY 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: MONTE CARLO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
-->| NHTSA Campaign Number: | 01I014000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1995 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Date Owner Notified By Manufacturer: | 20010926 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010924 |
| Record Creation Date: | 20020107 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
Consequence Summary:
THE BRAKING COULD FEEL DELAYED MOMENTARILY WHEN LIGHT OR MODERATE FORCE IS APPLIED ON THE BRAKE PEDAL WHILE DRIVING ON WET ROADS OR AFTER GOING THROUGH A CAR WASH.
Corrective Summary:
DEALER WILL MODIFY THE FRONT FENDER LINERS TO REMOVE A PORTION OF THE CLOSEOUT PANELS IN THE FRONT WHEEL WELLS AT NO CHARGE TO THE CONSUMER. THIS SERVICE WILL BE AVAILABLE THROUGH AUGUST 2004.
Notes:
GM HAS DECIDED TO CONDUCT A CUSTOMER SATISFACTION CAMPAIGN TO MODIFY THE VEHICLE IF AN OWNER HAS EXPERIENCED A GREATER THAN EXPECTED REDUCTION OR DELAY IN BRAKING ON WET ROADS.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020, CONCERNING THIS PROGRAM.
CHEVROLET: MONTE CARLO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 97V065000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1995 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950201 - 19950228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 50709 |
| Date Owner Notified By Manufacturer: | 19970513 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970418 |
| Record Creation Date: | 19970501 |
Defect Summary:
THE CENTER REAR SEAT BELT ANCHOR PLATE EXHIBITS STRESS CRACKS.
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE SEAT BELT SYSTEM CAN FRACTURE AND INJURY TO THE SEAT OCCUPANT CAN OCCUR.
Corrective Summary:
DEALERS WILL REPLACE THE CENTER REAR SEAT BELT SYSTEM.
Notes:
OWNER NOTIFICATION BEGAN MAY 13, 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: MONTE CARLO: SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
-->| NHTSA Campaign Number: | 94V230000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1995 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19940801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 221 |
| Date Owner Notified By Manufacturer: | 19941208 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19941121 |
| Record Creation Date: | 19941130 |
Defect Summary:
A RIGHT-HAND LOWER CONTROL ARM TAPERED BALL JOINT MOUNTING HOLE WAS INCORRECTLY MACHINED. MOVEMENT WITHIN THIS ATTACHMENT CAN ALLOW THE BALL JOINT STUD TO FATIGUE AND FRACTURE.
Consequence Summary:
IF THE BALL JOINT FRACTURED WHILE THE VEHICLE WAS IN MOTION, LOSS OF STEERING CONTROL TO THE VEHICLE CAN OCCUR.
Corrective Summary:
DEALERS WILL REPLACE THE RIGHT-HAND LOWER CONTROL ARM AND BALL JOINT STUD ON ALL INVOLVED VEHICLES.
Notes:
SYSTEM: SUSPENSION; INDEPENDENT FRONT CONTROL ARM; LOWER; BALL JOINT.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF THE VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT CHEVROLET AT 1-800-222-1020. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: MONTE CARLO: VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING
-->| NHTSA Campaign Number: | 97V017000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1995 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19931001 - 19940930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 349331 |
| Date Owner Notified By Manufacturer: | 19970306 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970211 |
| Record Creation Date: | 19970226 |
Defect Summary:
SOME OF THESE VEHICLES HAVE A STRAINED OR SEPARATED WASHER/WIPER SWITCH POWER FEED WIRE.
Consequence Summary:
THIS CAN CAUSE THE WINDSHIELD WASHER/WIPER TO WORK INTERMITTENTLY AND COULD ULTIMATELY RESULT IN INOPERATIVE WIPERS. IF THIS WERE TO OCCUR IN A SEVERE WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE OLD DESIGNED WASHER/WIPER SWITCHES WITH A NEWLY DESIGNED SWITCH.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 1997. NOTES:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: MONTE CARLO: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: STRUCTURE
-->| NHTSA Campaign Number: | 97V058000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1991 |
| Manufacturer Campaign Number: | 97016 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900801 - 19901130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 676535 |
| Date Owner Notified By Manufacturer: | 19970611 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970408 |
| Record Creation Date: | 19970417 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence Summary:
IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Corrective Summary:
DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 1997.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: MONTE CARLO: STRUCTURE
-->| NHTSA Campaign Number: | 97V058000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1990 |
| Manufacturer Campaign Number: | 97016 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19890801 - 19900730 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 676535 |
| Date Owner Notified By Manufacturer: | 19970611 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970408 |
| Record Creation Date: | 19970417 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence Summary:
IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Corrective Summary:
DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 1997.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: MONTE CARLO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1988 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1987 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
-->| NHTSA Campaign Number: | 87V168000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1987 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870601 - 19870701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 11936 |
| Date Owner Notified By Manufacturer: | 19871125 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19871026 |
| Record Creation Date: | 19871104 |
Defect Summary:
MANUAL VALVE LINK IN THE TRANSMISSION MAY HAVE BEEN IMPROPERLY FORMED.
Consequence Summary:
THE VALVE LINK COULD SEPARATE RESULTING IN A GEARSELECTION DIFFERENT FROM WHAT THE DRIVER SELECTS. ALSO, CAR COULD BE STARTEDWITH TRANSMISSION IN GEAR ALLOWING VEHICLE TO MOVE IN AN UNANTICIPATEDDIRECTION.
Corrective Summary:
REPLACE THE MANUAL VALVE DETENT LEVER LINK.
Notes:
SYSTEM: TRANSMISSIONVEHICLE DESCRIPTION: PASSENGER CARS AND WAGONS WITH 200 4R TRANSMISSIONS.
CHEVROLET: MONTE CARLO: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
-->| NHTSA Campaign Number: | 86V131000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19860301 - 19860401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 106111 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860919 |
| Record Creation Date: | 19860930 |
Defect Summary:
THE PUSH PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS AND TRUCKS/ VANS.
CHEVROLET: MONTE CARLO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1986 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: EXTERIOR LIGHTING:HEADLIGHTS:SWITCH
-->| NHTSA Campaign Number: | 86V056000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19850901 - 19851101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 93317 |
| Date Owner Notified By Manufacturer: | 19860515 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19860428 |
| Record Creation Date: | 19860501 |
Defect Summary:
THE PUSH-PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. NOTE: ALSO, SEE NHTSA CAMPAIGN NUMBER 86V131000.
Corrective Summary:
REPLACE HEADLIGHT SWITCH AS NECESSARY.
Notes:
SYSTEM: HEADLIGHT SWITCH. VEHICLE DESCRIPTION: PASSENGER CARS, TRUCKS AND VANS.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1986 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1985 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1985 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 89V102000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1984 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830801 - 19880201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755897 |
| Date Owner Notified By Manufacturer: | 19890720 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890616 |
| Record Creation Date: | 19890725 |
Defect Summary:
A SMALL NYLON BUSHING IN THE CRUISE CONTROL SERVO BAIL MAY SLIP OUT OF PLACE, CAUSING INTERMITTENT AND UNEXPECTED INCREASES IN ENGINE SPEED OR DIESELING (ENGINE RUN ON WITH IGNITION OFF).
Consequence Summary:
SERVO ROD ASSEMBLY COULD CATCH ON ENGINE COMPONENTS ANDRESULT IN A STUCK THROTTLE WITH POTENTIAL FOR A VEHICLE CRASH.
Corrective Summary:
INSTALL A NEW BUSHING IN CRUISE CONTROL SERVO BAIL.
Notes:
SYSTEM:CRUISE CONTROL.VEHICLE DESCRIPTION:PASSENGER VEHICLES EQUIPPED WITH CRUISE CONTROL ANDCERTAIN GASOLINE AND DIESEL ENGINES.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1984 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: SEATS:FRONT ASSEMBLY:RECLINER
-->| NHTSA Campaign Number: | 84V011000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830701 - 19830901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 76586 |
| Date Owner Notified By Manufacturer: | 19840224 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840206 |
| Record Creation Date: | 19840222 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 207 |
Defect Summary:
SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Corrective Summary:
INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 83V106000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1983 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820801 - 19830601 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4667 |
| Date Owner Notified By Manufacturer: | 19831025 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19831013 |
| Record Creation Date: | 19831021 |
Defect Summary:
THE MASTER CYLINDER REAR BRAKE PIPE, WHICH CARRIES BRAKE FLUID TO THE REAR BRAKES, MAY DEVELOP A LEAK DUE TO EXTENDED CHAFING ON THE AIR CLEANER RESONATOR BRACKET.
Corrective Summary:
IF UPON INSPECTION THE DEALER FINDS THAT THERE IS INADEQUATE CLEARANCE, THE PIPE WILL BE REFORMED TO OBTAIN THE NECESSARY THREE QUARTER INCH SPACE. ONLY THOSE PIPES SHOWING SIGNS OF WEAR WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITH 5.7LITER DIESEL ENGINES.SYSTEM: SERVICE BRAKES; MASTER CYLINDER, REAR BRAKE PIPE.CONSEQUENCES OF DEFECT: BRAKE FLUID LEAKAGE WILL RESULT IN LOSS OF BRAKINGACTION AT THE REAR WHEELS. LOSS OF VEHICLE CONTROL AND AN ACCIDENT COULDRESULT, PARTICULARLY IN SITUATIONS WHERE MINIMUM STOPPING DISTANCE IS REQUIRED.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1983 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1982 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
-->| NHTSA Campaign Number: | 82V012000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1982 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810801 - 19811101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 79686 |
| Date Owner Notified By Manufacturer: | 19820218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19820103 |
| Record Creation Date: | 19820208 |
Defect Summary:
UNDER CERTAIN VEHICLE OPERATING CONDITIONS, THE GOVERNOR WEIGHT RETAINER IN THE INJECTION PUMP MAY FAIL. THE THROTTLE VALVE COULD STICK, PREVENTING RETURN TO IDLE AND SHUT DOWN OF THE ENGINE BY THE DRIVER.
Corrective Summary:
DEALER WILL REPLACE THE GOVERNOR WEIGHT ASSEMBLY IN THE INJECTION PUMP AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 5.7 V8 ENGINES.SYSTEM: FUEL; THROTTLE VALVE.CONSEQUENCES OF DEFECT: THIS COULD RESULT IN LOSS OF VEHICLE CONTROL AND AVEHICLE ACCIDENT.NOTE: IF THROTTLE STICKING OCCURS BEFORE THE VEHICLE HAS RECEIVED THE NECESSARYMODIFICATIONS, THE DRIVER SHOULD SHIFT THE TRANSMISSION TO NEUTRAL, APPLY THESERVICE BRAKES TO BRING THE VEHICLE TO A SAFE STOP, THE IGNITION SHOULD BETURNED OFF AND THE NEAREST DEALERSHIP SHOULD BE CALLED FOR ASSISTANCE.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1981 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1981 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 85V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1980 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1810000 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850429 |
| Record Creation Date: | 19850501 |
Defect Summary:
EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT. FRONT BRAKES WOULD REMAIN OPERATIONAL.
Corrective Summary:
ADD A PART TO PREVENT WHEEL CYLINDER FROM ROTATING.
Notes:
NOTE: OWNER NOTIFICATION WILL BEGIN AFTER SEPTEMBER 1, 1985 AND SHOULD BE COMPLETED BY SEPTEMBER 30, 1985.VEHICLE DESCRIPTION: MIDSIZE PASSENGER CARS AND SMALL TRUCKS. SYSTEM: REAR BRAKES.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1980 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1980 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MONTE CARLO: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 84V149000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1980 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19800701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3100000 |
| Date Owner Notified By Manufacturer: | 19841228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19841124 |
| Record Creation Date: | 19841127 |
Defect Summary:
REAR AXLE ASSEMBLY MAY HAVE AXLES THAT WERE IMPROPERLY MANUFACTURED. THIS CONDITION MAY RESULT IN SEPARATION OF THE AXLE SHAFT AND WHEEL ASSEMBLY FROM THE VEHICLE.
Corrective Summary:
THE DEALER WILL INSPECT THE REAR AXLE TO DETERMINE WHETHER IT WAS MANUFACTURED AT THE BUFFALO PLANT. IF SO, THEY WILL MAKE AXLE MEASUREMENTS AND IF NECESSARY REPLACE OR MODIFY AFFECTED AXLE COMPONENTS WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.SYSTEM: POWER TRAIN; REAR AXLE.CONSEQUENCES OF DEFECT: LOSS OF THE WHEEL ASSEMBLY COULD LEAD TO LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 85V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1979 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1810000 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850429 |
| Record Creation Date: | 19850501 |
Defect Summary:
EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT. FRONT BRAKES WOULD REMAIN OPERATIONAL.
Corrective Summary:
ADD A PART TO PREVENT WHEEL CYLINDER FROM ROTATING.
Notes:
NOTE: OWNER NOTIFICATION WILL BEGIN AFTER SEPTEMBER 1, 1985 AND SHOULD BE COMPLETED BY SEPTEMBER 30, 1985.VEHICLE DESCRIPTION: MIDSIZE PASSENGER CARS AND SMALL TRUCKS. SYSTEM: REAR BRAKES.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1979 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1979 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MONTE CARLO: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 84V149000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1979 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19800701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3100000 |
| Date Owner Notified By Manufacturer: | 19841228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19841124 |
| Record Creation Date: | 19841127 |
Defect Summary:
REAR AXLE ASSEMBLY MAY HAVE AXLES THAT WERE IMPROPERLY MANUFACTURED. THIS CONDITION MAY RESULT IN SEPARATION OF THE AXLE SHAFT AND WHEEL ASSEMBLY FROM THE VEHICLE.
Corrective Summary:
THE DEALER WILL INSPECT THE REAR AXLE TO DETERMINE WHETHER IT WAS MANUFACTURED AT THE BUFFALO PLANT. IF SO, THEY WILL MAKE AXLE MEASUREMENTS AND IF NECESSARY REPLACE OR MODIFY AFFECTED AXLE COMPONENTS WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.SYSTEM: POWER TRAIN; REAR AXLE.CONSEQUENCES OF DEFECT: LOSS OF THE WHEEL ASSEMBLY COULD LEAD TO LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MONTE CARLO: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
-->| NHTSA Campaign Number: | 79V142000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1979 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19781201 - 19790101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15328 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790606 |
| Record Creation Date: | 19791012 |
Defect Summary:
ON THE INVOLVED VEHICLES THE BRAKE STOPLIGHT AND CRUISE CONTROL SWITCH WHICH IS OPERATED BY THE BRAKE PEDAL MAY HAVE BEEN ASSEMBLED WITH AN INCORRECT LUBRICANT ON THE ACTUATING PLUNGER. THIS CAN CAUSE THE REAR BRAKE STOPLIGHTS TO BECOME INOPERATIVE AND THE CRUISE CONTROL, IF ACTIVATED, TO STAY ELECTRICALLY ENGAGED.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE BRAKE STOPLIGHT AND CRUISE CONTROL SWITCH AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: LIGHTING AND COMMUNICATIONS; SWITCH BUTTON RING, BRAKE LIGHTS.CONSEQUENCES OF DEFECT: WITH INOPERATIVE BRAKE LIGHTS, A VEHICLE APPROACHINGFROM THE REAR WOULD NOT BE AWARE THAT BRAKES WERE BEING APPLIED. ALSO, IF THECRUISE CONTROL FAILS TO AUTOMATICALLY DISENGAGE THROUGH BRAKE PEDAL OPERATION,VEHICLE MAY ACCELERATE WHEN THE BRAKE PEDAL IS RELEASED. EITHER CONDITION COULDRESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.NOTE: OWNER IS ADVISED NOT TO ENGAGE THE CRUISE CONTROL UNTIL IT HAS BEENINSPECTED BY DEALER.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 77V181000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1978 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 636 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19771017 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE REAR BRAKE WHEEL CYLINDER RETAINER ON THE INVOLVED VEHICLES MAY NOT HAVE BEEN PROPERLY INSTALLED. SHOULD THE WHEEL CYLINDER RETAINER BECOME COMPLETELY DISENGAGED, THE WHEEL CYLINDER COULD MOVE OUTBOARD CAUSING A LOSS OF BRAKE FLUID AND A LOSS OF REAR BRAKING ACTION.
Corrective Summary:
THE DEALER WILL REPOSITION THE REAR WHEEL BRAKE CYLINDER RETAINERS, FREE OF CHARGE, ON ALL AFFECTED VEHICLES.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SERVICE BRAKES; REAR WHEEL BRAKE CYLINDER RETAINERS.CONSEQUENCES OF DEFECT: LOSS OF REAR BRAKING CAPABILITY CAN OCCUR WITHOUTWARNING AND AN ACCIDENT COULD RESULT.NOTE: LOSS OF BRAKING ACTION WILL BE SIGNALLED TO DRIVER BY THE WARNING LIGHTON THE DASH AND BY AN INCREASE IN BRAKE PEDAL TRAVEL AND INCREASED VEHICLESTOPPING DISTANCES.
CHEVROLET: MONTE CARLO: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-->| NHTSA Campaign Number: | 78V139000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1978 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19780101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 333619 |
| Date Owner Notified By Manufacturer: | 19780619 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19780613 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE HUB PORTION OF THE FAN BLADE ASSEMBLY COULD CRACK DUE TO HIGH STRESS LEVELS GENERATED DURING ENGINE OPERATING CONDITIONS. EVENTUALLY, THE BLADE COULD BREAK APART AT THE HUB AND BLADE PIECES COULD BE PROPELLED INTO THE ENGINE. IF THE HOOD IS OPEN WHILE THE ENGINE IS RUNNING, THE FRAGMENTS WOULD BE FREE TO FLY FROM THE VEHICLE.
Corrective Summary:
DEALER WILL REPLACE THE FAN BLADE ASSEMBLY WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: ENGINE COOLING; FAN BLADE ASSEMBLY.CONSEQUENCES OF DEFECT: FAN FAILURE COULD RESULT IN DAMAGE TO COMPONENTS IN THEENGINE AREA, OR PERSONAL INJURY TO BYSTANDERS IF THE HOOD IS OPEN AT THE TIME.NOTE: THE VEHICLE SHOULD NOT BE SERVICED WITH THE HOOD OPEN AND THE ENGINERUNNING UNTIL THE DEFECT IS CORRECTED.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 85V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1978 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1810000 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850429 |
| Record Creation Date: | 19850501 |
Defect Summary:
EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT. FRONT BRAKES WOULD REMAIN OPERATIONAL.
Corrective Summary:
ADD A PART TO PREVENT WHEEL CYLINDER FROM ROTATING.
Notes:
NOTE: OWNER NOTIFICATION WILL BEGIN AFTER SEPTEMBER 1, 1985 AND SHOULD BE COMPLETED BY SEPTEMBER 30, 1985.VEHICLE DESCRIPTION: MIDSIZE PASSENGER CARS AND SMALL TRUCKS. SYSTEM: REAR BRAKES.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1978 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
-->| NHTSA Campaign Number: | 78V115000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1978 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:HEAD RESTRAINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19771001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1643 |
| Date Owner Notified By Manufacturer: | 19780526 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19780524 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 201 |
Defect Summary:
INCORRECT HEAD RESTRAINTS MAY HAVE BEEN INSTALLED ON THE INVOLVED VEHICLES. THIS FAILS TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACTS".
Corrective Summary:
DEALER WILL REPLACE INCORRECT HEAD RESTRAINTS WITH IMPROVED HEAD RESTRAINTS.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: INTERIOR; HEAD RESTRAINTS.CONSEQUENCES OF DEFECT: IN THE EVENT OF AN ACCIDENT, INADEQUATE HEAD RESTRAINTSCOULD RESULT IN SERIOUS HEAD INJURIES.
CHEVROLET: MONTE CARLO: SUSPENSION:FRONT:WHEEL BEARING
-->| NHTSA Campaign Number: | 79V175000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1978 |
| Manufacturer Component Description: | SUSPENSION:FRONT:WHEEL BEARING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19780701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1896222 |
| Date Owner Notified By Manufacturer: | 19790824 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790723 |
| Record Creation Date: | 19791012 |
Defect Summary:
UNDER CERTAIN DRIVING CONDITIONS, THESE VEHICLES CAN EXPERIENCE TEMPERATURES IN THE FRONT WHEEL OUTER BEARING AREA WHICH CAN AFFECT THE WHEEL BEARING GREASE. THIS CAN RESULT IN INADEQUATE LUBRICATION OF THE BEARING. THIS CONDITION MAY BE FURTHER AGGRAVATED BY IMPROPER ADJUSTMENT OF THE FRONT WHEEL SPINDLE NUT.
Corrective Summary:
THE DEALER WILL INSTALL NEW FRONT WHEEL OUTER BEARINGS PACKED WITH GREASE AND THE SPINDLE WILL BE COATED WITH LUBRICANT. NEW GREASE RETAINER CAPS WILL ALSO BE INSTALLED TO MAINTAIN GREASE IN OUTER BEARING. THIS WILL BE DONE FREE OF CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; WHEELS; BEARING GREASE.CONSEQUENCES OF DEFECT: CONTINUED OPERATION OF THE VEHICLE ALONG WITHINADEQUATE LUBRICATION MAY CAUSE FAILURE OF THE FRONT WHEEL OUTER BEARING ANDTHE SPINDLE. LOSS OF VEHICLE CONTROL AND AN ACCIDENT MAY RESULT.NOTE: BEARING AND SPINDLE FAILURE MAY BE PRECEDED BY A NOTICEABLE VIBRATION ANDNOISE COMING FROM THE FRONT END OF THE VEHICLE.
CHEVROLET: MONTE CARLO: SUSPENSION:REAR
-->| NHTSA Campaign Number: | 81V025000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1978 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19801201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5821160 |
| Date Owner Notified By Manufacturer: | 19810309 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810225 |
| Record Creation Date: | 19810306 |
Defect Summary:
THE BOLTS THAT ATTACH THE LOWER REAR CONTROL ARM TO THE FRAME MAY FRACTURE. THE REAR CONTROL ARM SUPPORTS AND POSITIONS THE REAR AXLE. FRACTURE OF THE BOLTS WOULD ALLOW THE CONTROL ARM TO DROP FREE.
Corrective Summary:
BOTH REAR CONTROL ARM ATTACHMENT BOLTS WILL BE REPLACED WITHOUT CHARGE.
Notes:
SYSTEM: SUSPENSION; REAR CONTROL ARM ATTACHING BOLTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.CONSEQUENCES OF DEFECT: IF THE FRACTURE OCCURS WHEN THE VEHICLE IS IN MOTION,IT COULD RESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MONTE CARLO: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 84V149000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1978 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770801 - 19800701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3100000 |
| Date Owner Notified By Manufacturer: | 19841228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19841124 |
| Record Creation Date: | 19841127 |
Defect Summary:
REAR AXLE ASSEMBLY MAY HAVE AXLES THAT WERE IMPROPERLY MANUFACTURED. THIS CONDITION MAY RESULT IN SEPARATION OF THE AXLE SHAFT AND WHEEL ASSEMBLY FROM THE VEHICLE.
Corrective Summary:
THE DEALER WILL INSPECT THE REAR AXLE TO DETERMINE WHETHER IT WAS MANUFACTURED AT THE BUFFALO PLANT. IF SO, THEY WILL MAKE AXLE MEASUREMENTS AND IF NECESSARY REPLACE OR MODIFY AFFECTED AXLE COMPONENTS WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND LIGHT TRUCKS.SYSTEM: POWER TRAIN; REAR AXLE.CONSEQUENCES OF DEFECT: LOSS OF THE WHEEL ASSEMBLY COULD LEAD TO LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
CHEVROLET: MONTE CARLO: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 78V138000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1977 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19770101 - 19770401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 265068 |
| Date Owner Notified By Manufacturer: | 19780626 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19780613 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE REAR AXLE SHAFTS MAY CONTAIN A FLAW IN THE METAL. THIS FLAW COULD ALLOW THE SHAFT TO BREAK AND THE TIRE AND WHEEL ASSEMBLY TO SEPARATE.
Corrective Summary:
THE DEALER WILL REPLACE ONE OR BOTH REAR AXLE SHAFTS, IF NECESSARY, FREE OF CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; AXLE/SHAFT.CONSEQUENCES OF DEFECT: SHOULD SEPARATION OCCUR WHILE VEHICLE IS IN MOTION,LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING AND AN ACCIDENT COULD RESULT.NOTE: DRIVER SHOULD AVOID FAST CORNERING, RAPID ACCELERATION, OR ANY TYPE OFDRIVING WHICH MAY PRODUCE ABNORMALLY HEAVY LOADS ON THE REAR AXLE SHAFTS UNTILTHE VEHICLE CAN BE INSPECTED.
CHEVROLET: MONTE CARLO: STEERING:WHEEL AND HANDLE BAR
-->| NHTSA Campaign Number: | 76V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1977 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55564 |
| Date Owner Notified By Manufacturer: | 19760830 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760907 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 77-C-1.POSSIBILITY THAT THE STEERING INTERMEDIATESHAFT MAY HAVE BEEN ASSEMBLED WITH COUPLING RETAINER LOCKING TABS NOT BENT OVERPROPERLY OR ONE OR MORE OF THE LOWER FLEXIBLE COUPLING RIVETS IMPROPERLYPEENED.IF EITHER OF THESE CONDITIONS EXISTS, THE INTERMEDIATE SHAFT ASSEMBLYCOULD SEPARATE CAUSING LOSS OF STEERING CONTROL, AND VEHICLE CRASH MAY OCCURWITHOUT PRIOR WARNING.(CORRECT BY INSPECTING, AND REPLACING SHAFT WHERENECESSARY).PASSENGER VEHICLE.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1977 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
-->| NHTSA Campaign Number: | 76V038000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16 |
| Date Owner Notified By Manufacturer: | 19760315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760311 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C09.POSSIBILITY THAT THE SERVICE BRAKE SYSTEM DOESNOT COMPLY WITH BRAKE PERFORMANCE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETYSTANDARD 105.THE FAILURE TO COMPLY IS DUE TO INSTALLATION OF INCORRECT BRAKECOMBINATION VALVE.IF THIS CONDITION EXISTS, IT WILL DECREASE THE STOPPINGABILITY AND COULD RESULT IN VEHICLE CRASH WITHOUT PRIOR WARNING IN A SITUATIONREQUIRING MINIMUM STOPPING DISTANCE.(CORRECT BY INSPECTING AND REPLACINGVALVE WHERE NECESSARY).
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1976 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: WHEELS
-->| NHTSA Campaign Number: | 76V098000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1976 |
| Manufacturer Component Description: | WHEELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 938 |
| Date Owner Notified By Manufacturer: | 19760706 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760702 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 76C17.POSSIBILITY THAT OPTIONAL POLYCAST WHEELS MAYHAVE MOLD RELEASE AGENT (WAX) ON THE CONICAL WHEEL LUG NUT SEATS.THIS WAXACTS AS A LUBRICANT AND SIGNIFICANTLY REDUCES THE FRICTION AS WHEEL LUG NUTSARE BEING TIGHTENED.CONSEQUENTLY, A HIGH CLAMPING FORCE IS APPLIED TO THEWHEEL WHEN THE LUG NUTS ARE TORQUED AND THE WHEEL MOUNTING SURFACES MAYCOLLAPSE.CRACKING, RESULTING IN LOOSENESS OR LOSS OF WHEEL MAY EVENTUALLYOCCUR.(CORRECT BY INSPECTING AND REPLACING WHEEL LUG NUTS, VALVE STEMS ANDBALANCE WHEELS).PASSENGER VEHICLE.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
-->| NHTSA Campaign Number: | 75V214000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 39278 |
| Date Owner Notified By Manufacturer: | 19751223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19751219 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C04, PONTIAC CAMPAIGN NO. 76C7, OLDSMOBILE CAMPAIGN NO.76C1, BUICK CAMPAIGN NO. 76C1.POSSIBILITY THAT THE COMBINATION VALVE, WHICHIS A PART OF THE HYDRAULIC SERVICE BRAKE SYSTEM MAY HAVE BEEN IMPROPERLYMANUFACTURED AND COULD MALFUNCTION.SHOULD THIS CONDITION OCCUR WHILE VEHICLEIS IN MOTION AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED.A VEHICLECRASH COULD OCCUR WITHOUT PRIOR WARNING.(CORRECT BY INSPECTING AND REPLACINGVALVE WHERE NECESSARY.) PASSENGER CARS AND LIGHT TRUCKS.
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
-->| NHTSA Campaign Number: | 75V032000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1975 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 220982 |
| Date Owner Notified By Manufacturer: | 19750220 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19750219 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE AND BUICK CAMPAIGN NO 75-C-7.CHEVROLET CAMPAIGN NO 75-C-08.PONTIAC CAMPAIGN NO 75-C-9.DATES OF MANUFACTURE FOR CHEVROLET, BUICK,OLDSMOBILE AND GMC ARE SEPT THRU NOV 1974.PONTIAC DATES ARE SEPT 1974 THRUJAN 1975.NO STATION WAGONS ARE INVOLVED.POSSIBILITY THAT THE REAR AXLE WASASSEMBLED WITH REAR AXLE SHAFT OUTER BEARING (REAR WHEEL BEARING) WITH THRUSTPLATES THAT WERE NOT HEAT TREATED.IF THE INNER OR OUTER THRUST PLATES OFTHESE BEARINGS ARE NOT HARDENED, THE ROLLERS CAN WEAR THROUGH AND ALLOW THEREAR AXLE SHAFT TO MOVE WITH RESPECT TO AXLE HOUSING.(CORRECT BY INSPECTINGAND REPLACING AXLE ASSEMBLIES WHERE NECESSARY.)
CHEVROLET: MONTE CARLO: SEAT BELTS:FRONT:RETRACTOR
-->| NHTSA Campaign Number: | 74V016000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1974 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:RETRACTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 26421 |
| Date Owner Notified By Manufacturer: | 19740128 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740125 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTORS CAMPAIGN NO 74-C-10.OLDSMOBILE CAMPAIGN NO 74-C-4.BUICKCAMPAIGN NO 74-C-3.PONTIAC CAMPAIGN NO 74-C-4.POSSIBILITY THAT THE FRONTSEAT LAP-BELT RETRACTOR MAY INTERMITTENTLY FAIL TO LOCK THE SEAT LAP-BELTWEBBING DUE TO WEAK LOCKING BAR SPRING.AS A RESULT, THE RETRACTOR MAY FAIL TOHOLD THE BELT IN POSITION DURING EXTREMELY HARD BRAKING ACTION OR UNDERACCIDENT CONDITIONS.THIS MAY CAUSE THE OCCUPANT TO SLIDE FORWARD ON THE SEATAND INCREASE THE POSSIBILITY OF INJURY.(CORRECT BY INSPECTING AND INSTALLINGNEW ASSIST SPRING WHERE NECESSARY.)
CHEVROLET: MONTE CARLO: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
-->| NHTSA Campaign Number: | 73V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1974 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19730801 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 782111 |
| Date Owner Notified By Manufacturer: | 19740109 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731227 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 74-C-09.PONTIAC 74-C-2.BUICK 74-C-2.OLDSMOBILE74-C-3.SPRINT 74-C-4.POSSIBILITY THAT THE FRONT UPPER CONTROL ARM INNERBUSHING RETAINER NUTS MAY LOOSEN AND COME OFF DURING NORMAL OPERATINGCONDITIONS.SHOULD THIS OCCUR, THE LOOSE CONTROL ARM MAY MOVE FORWARD ANDCONTACT THE UPPER CONTROL ARM MOUNTING BRACKET ON THE FRAME WHICH RESTRICTS ANYFURTHER FORWARD MOVEMENT.IF THIS VEHICLE IS OPERATED IN THIS CONDITION IT ISPOSSIBLE FOR THE CONTROL ARM CROSS SHAFT TO BREAK.(CORRECT BY INSPECTING ANDINSTALLING NEW BUSHING RETAINERS WHERE NECESSARY.)
CHEVROLET: MONTE CARLO: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1974 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: MONTE CARLO: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
-->| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: MONTE CARLO: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 70V032000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONTE CARLO |
| Model Year: | 1970 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16712 |
| Date Owner Notified By Manufacturer: | 19700326 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19700403 |
| Record Creation Date: | 19791012 |
Notes:
INCORRECT TIRE-INFORMATION DECAL MAY HAVE BEEN INSTALLED.(CORRECT BYINSTALLING WHERE NECESSARY.)
--CHEVROLET: MONZA: SUSPENSION:FRONT:WHEEL BEARING
| NHTSA Campaign Number: | 78V242000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1975 |
| Manufacturer Component Description: | SUSPENSION:FRONT:WHEEL BEARING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19750801 - 19760701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130965 |
| Date Owner Notified By Manufacturer: | 19790228 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19781106 |
| Record Creation Date: | 19791012 |
Defect Summary:
UNDER CERTAIN DRIVING CONDITIONS, INCLUDING EXTENDED SEVERE BRAKING, THE WHEEL BEARING AREA MAY ENCOUNTER TEMPERATURES THAT CAN CAUSE THE GREASE TO MIGRATE OUT OF THE BEARING AREA. THIS WILL REDUCE THE AMOUNT OF LUBRICATION AVAILABLE TO THE BEARINGS AND RESULT IN FRONT WHEEL BEARING FAILURE AND SPINDLE DAMAGE.
Corrective Summary:
THE DEALER WILL REPLACE THE FRONT WHEEL BEARINGS AND ASSOCIATED PARTS ON ALL INVOLVED VEHICLES FREE OF CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; FRONT WHEEL BEARING AND SPINDLE.CONSEQUENCES OF DEFECT: COMPLETE BEARING FAILURE AND SPINDLE DAMAGE COULD CAUSELOSS OF VEHICLE CONTROL AND AN ACCIDENT.NOTE: COMPLETE WHEEL BEARING FAILURE IS USUALLY PRECEDED BY A NOTICEABLE FRONTEND VIBRATION OR NOISE.
--CHEVROLET: MONZA: EQUIPMENT:MECHANICAL:CARRIER/RACK
| NHTSA Campaign Number: | 75V129000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT:MECHANICAL:CARRIER/RACK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 98631 |
| Date Owner Notified By Manufacturer: | 19750711 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19750714 |
| Record Creation Date: | 19791012 |
Notes:
HATCHBACK ONLY GENERAL MOTORS CAMPAIGN NO 75-C-12.POSSIBILITY THE STRENGTH OFTHE "J" BOLT (HOOK) FURNISHED MAY BE INADEQUATE IN THE EVENT OF A SEVEREFRONTAL COLLISION WHEN THE SPARE TIRE IS MOUNTED ON THE REAR COMPARTMENT FLOOR.IF SUCH A COLLISION OCCURS.THE "J" BOLT COULD STRAIGHTEN TO SUCH AN EXTENTTHAT THE SPARE TIRE AND WHEEL MAY BECOME LOOSE AND TRAVEL FORWARD INTO THEPASSENGER AREA OF THE VEHICLE, INCREASING THE POSSIBLITY OF OCCUPANT INJURY.(CORRECT BY INSPECTING AND REPLACING WITH HEAVIER DUTY "J" HOOK.)
--CHEVROLET: MONZA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: MONZA: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
| NHTSA Campaign Number: | 76V142000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 31 |
| Date Owner Notified By Manufacturer: | 19760916 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760914 |
| Record Creation Date: | 19791012 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 105 |
Notes:
GENERAL MOTORS CAMPAIGN NO 76C21.2 + 2 AND TOWN COUPE ONLY.POSSIBILITY THATAN INCORRECT COMBINATION BRAKE VALVE WAS INSTALLED, WHICH MAY CAUSE BRAKES TOFAIL TO COMPLY WITH THE FMVSS NO.105.THIS CONDITION MAY DECREASE THEBRAKING ABILITY AND INCREASE THE POSSIBILITY OF A VEHICLE CRASH WHEN A BRAKINGSITUATION REQUIRES MINIMUM STOPPING DISTANCE.(CORRECT BY INSPECTING ANDREPLACING VALVE WITH PROPER TYPE WHERE NECESSARY).PASSENGER VEHICLE.(2+2AND TOWN COUPE ONLU).
--CHEVROLET: MONZA: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
| NHTSA Campaign Number: | 76V023000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 34208 |
| Date Owner Notified By Manufacturer: | 19760218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760212 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C07.BUICK CAMPAIGN NO 76-C-3.PONTIAC CAMPAIGN NO76-C-12.OLDSMOBILE CAMPAIGN NO 76-C-4.POSSIBILITY THAT A MACHININGOPERATION ON THE FRONT BRAKE CALIPER REMOVED EXCESSIVE MATERIAL FROM A SURFACETHAT SERVES AS A REACTION AREA FOR THE DISC BRAKE SHOE.AS A RESULT, THE FRONTDISC BRAKE SHOES MAY NOT BE HELD IN PROPER POSITION BY THE BRAKE SHOE REACTIONAREA OF THE FRONT BRAKE CALIPERS WHEN THE BRAKES RECEIVE REPEATED HARDAPPLICATIONS.THIS ACTION MAY CAUSE BRAKE SHOE SUPPORT EAR TO FATIGUE ANDBRAKE SHOE TO SEPARATE FROM THE CALIPERS, FOLLOWED BY A LOSS OF FRONT BRAKINGACTION.(CORRECT BY INSPECTING AND INSTALLING ADDITIONAL REACTION TABS TO HOLDSHOE IN PROPER POSITION.
--CHEVROLET: MONZA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1976 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: MONZA: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
| NHTSA Campaign Number: | 76V018000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1976 |
| Manufacturer Component Description: | STEERING:GEAR BOX (OTHER THAN RACK AND PINION) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 20 |
| Date Owner Notified By Manufacturer: | 19760213 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760210 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C08.PONTIAC CAMPAIGN NO 76-C-10.BUICK CAMPAIGN NON/A.POSSIBILITY THAT THE WASHERS USED WITH THE BOLTS TO ATTACH THE STEERINGGEAR TO FRAME MAY NOT HAVE BEEN PROPERLY HARDENED, AND THEIR INSIDE DIAMETERMAY BE TOO LARGE.IF THIS CONDITION EXISTS, THE ATTACHING BOLT BOLT TORQUE MAYNOT BE MAINTAINED, CAUSING THE STEERING GEAR TO BECOME LOOSE AT THE FRAME.IFDRIVER DOES NOT HEED THIS CONDITION, IT COULD RESULT IN A VEHICLE CRASH.(CORRECT BY INSPECTING AND REPLACING AFFECTED WASHERS WHERE NECESSARY.)
--CHEVROLET: MONZA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1977 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: MONZA: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 79V081000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1977 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 172000 |
| Date Owner Notified By Manufacturer: | 19790525 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790330 |
| Record Creation Date: | 19791012 |
Defect Summary:
OPERATION OF THE VEHICLE IN A MANNER WHICH PRODUCES HARD BOTTOMING OUT OF THE FRONT SUSPENSION MAY CAUSE DEFORMATION OF THE LEFT ENGINE MOUNT SUPPORT STRUCTURE AND ALLOW THE ENGINE MOUNT BRACKET TO CONTACT THE STEERING PITMAN ARM OR STEERING LINKAGE.
Corrective Summary:
AN ENGINE MOUNT SUPPORT BRACKET REINFORCEMENT KIT WILL BE INSTALLED ON THE LEFT FRONT ENGINE MOUNT SUPPORT STRUCTURE WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH L-4 151 CID ENGINES.SYSTEM: SUSPENSION.CONSEQUENCES OF DEFECT: INCREASED STEERING EFFORT MAY BE REQUIRED WHICH CANCAUSE LOSS OF VEHICLE CONTROL AND AN ACCIDENT.NOTE: OVER A PERIOD OF TIME, CONTACT MAY BE FELT AND HEARD.
--CHEVROLET: MONZA: STEERING:WHEEL AND HANDLE BAR
| NHTSA Campaign Number: | 78V019000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1978 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19771101 - 19771201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 22268 |
| Date Owner Notified By Manufacturer: | 19780123 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19780124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE INTERMEDIATE SHAFT COUPLING ON THE INVOLVED VEHICLES MAY HAVE BEEN MACHINED OVERSIZED IN THE SERRATION AREA WHERE IT ATTACHES TO THE STEERING COLUMN. THIS WOULD PREVENT THE COUPLING FROM PROPERLY TIGHTENING ON THE SHAFT WHEN THE CLAMP AND PINCH BOLT WERE INSTALLED.
Corrective Summary:
DEALER WILL REPLACE THE SHAFT COUPLING, IF NECESSARY, WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: TRUCKS AND BUSES.SYSTEM: STEERING; SHAFT COUPLING.CONSEQUECES OF DEFECT: THE COUPLING MAY SLIP ON THE SHAFT WHEN THE STEERINGWHEEL IS TURNED. UNDER CONTINUED OPERATION, THE PINCH BOLT MAY BYPASS THE NOTCHIN THE STEERING SHAFT UNDER HIGH STEERING EFFORT. LOSS OF STEERING CONTROL ANDAN ACCIDENT MAY RESULT.NOTE: A RASPY NOISE, ACCOMPANIED BY INCREASED FREE PLAY IN THE STEERING WHEEL,MAY INDICATE THE DEFECT.
--CHEVROLET: MONZA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1978 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: MONZA: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 79V081000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1978 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 172000 |
| Date Owner Notified By Manufacturer: | 19790525 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790330 |
| Record Creation Date: | 19791012 |
Defect Summary:
OPERATION OF THE VEHICLE IN A MANNER WHICH PRODUCES HARD BOTTOMING OUT OF THE FRONT SUSPENSION MAY CAUSE DEFORMATION OF THE LEFT ENGINE MOUNT SUPPORT STRUCTURE AND ALLOW THE ENGINE MOUNT BRACKET TO CONTACT THE STEERING PITMAN ARM OR STEERING LINKAGE.
Corrective Summary:
AN ENGINE MOUNT SUPPORT BRACKET REINFORCEMENT KIT WILL BE INSTALLED ON THE LEFT FRONT ENGINE MOUNT SUPPORT STRUCTURE WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH L-4 151 CID ENGINES.SYSTEM: SUSPENSION.CONSEQUENCES OF DEFECT: INCREASED STEERING EFFORT MAY BE REQUIRED WHICH CANCAUSE LOSS OF VEHICLE CONTROL AND AN ACCIDENT.NOTE: OVER A PERIOD OF TIME, CONTACT MAY BE FELT AND HEARD.
--CHEVROLET: MONZA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1979 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: MONZA: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 79V151000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1979 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19780801 - 19790301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42977 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790613 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE CARBURETOR FUEL FEED HOSE MAY NOT HAVE BEEN PROPERLY POSITIONED DURING ASSEMBLY. AS A RESULT THE HOSE COULD COME IN CONTACT WITH OR BE TOO CLOSE TO THE ENGINE EMISSION EXHAUST SYSTEM GAS RECIRCULATION VALVE. THIS CAN CAUSE THE HOSE TO RUPTURE.
Corrective Summary:
THE DEALER WILL INSPECT THE FUEL FEED HOSE AND REPOSITION IT, IF NECESSARY. ALSO, ANY DAMAGED HOSE WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: FUEL; LINES, HOSES, NON-METALLIC.CONSEQUENCES OF DEFECT: A RUPTURED FUEL HOSE WOULD ALLOW FUEL LEAKAGE. IF ANIGNITION SOURCE IS PRESENT A FIRE COULD RESULT AND CAUSE AN ACCIDENT ANDPERSONAL INJURY.NOTE: UNTIL VEHICLE CAN BE SERVICED, DRIVER SHOULD BE ALERTED TO ANY ODOR OFGASOLINE OR INDICATIONS OF SMOKE FROM THE ENGINE COMPARTMENT. IF ANY OF THESECONDITIONS ARE OBSERVED, THE VEHICLE SHOULD BE BROUGHT TO A SAFE STOP OUT OFTRAFFIC. THE HOOD SHOULD NOT BE OPENED UNTIL THE ENGINE HAS COOLED OR DRIVERCOULD BURN FINGERS.
--CHEVROLET: MONZA: ELECTRICAL SYSTEM:WIRING
| NHTSA Campaign Number: | 79V141000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1979 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:WIRING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19790201 - 19790301 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4208 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19790506 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE ENGINE OIL PRESSURE SWITCH MAY CAUSE A RANDOM INTERNAL ELECTRICAL SHORT WHICH COULD RESULT IN THE ENGINE STARTING BY ITSELF WHEN THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION.
Corrective Summary:
DEALER WILL REPLACE THE OIL PRESSURE SWITCHES ON ALL SUSPECT VEHICLES AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: ELECTRICAL; WIRING.CONSEQUENCES OF DEFECT: IF THE TRANSMISSION SELECTOR LEVER IS IN REVERSE OR AFORWARD RANGE WHEN THE ENGINE STARTS BY ITSELF, THE VEHICLE COULD MOVE AND ANACCIDENT COULD OCCUR.
--CHEVROLET: MONZA: SEAT BELTS:FRONT:RETRACTOR
| NHTSA Campaign Number: | 81V060000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | MONZA |
| Model Year: | 1980 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:RETRACTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19800801 - 19800901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55238 |
| Date Owner Notified By Manufacturer: | 19810528 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19810519 |
| Record Creation Date: | 19810602 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
ON CERTAIN VEHICLES, THE SEAT BELT RETRACTORS IN THE REAR SEATING POSITIONS CONTAIN FIRST LOCK POSITIONS WHICH WILL NOT LOCK WHEN USED BY SMALLER PASSENGERS. THIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION".
Corrective Summary:
ALL OWNERS WILL BE SENT A PRE-PAID POSTAGE CARD THAT IS TO BE FILLED OUT AND SENT BACK. THE CARD WILL INDICATE WHETHER THE SEAT BELTS ARE FUNCTIONING PROPERLY. IF DEALER INSPECTS SEAT BELTS, THE SEAT BELT RETRACTORS WILL BE REPLACED, IF NECESSARY, WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: INTERIOR; SEAT BELT RETRACTORS.CONSEQUENCES OF DEFECT: IN THE EVENT OF A COLLISION, IF PASSENGERS ARE NOTSECURELY RESTRAINED, THE POSSIBILITY OF PERSONAL INJURY AND DEATH WOULD BEINCREASED.
-- --CHEVROLET: NOVA: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: NOVA: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
-- --CHEVROLET: NOVA: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: NOVA: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: NOVA: POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR
| NHTSA Campaign Number: | 69V069000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1969 |
| Manufacturer Component Description: | POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2057 |
| Date Owner Notified By Manufacturer: | 19690507 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19690516 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT SHIFT PATTERN DECAL WAS OMITTED IN PRODUCTION.AB- SENCE OFDECAL COULD RESULT IN SELEC- TION OF INCORRECT GEAR SHIFT POSITION.(CORRECTBY INSTALLING GEAR SHIFT PATTERN.)
CHEVROLET: NOVA: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
CHEVROLET: NOVA: VEHICLE SPEED CONTROL
| NHTSA Campaign Number: | 70V143000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1971 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12600 |
| Date Owner Notified By Manufacturer: | 19701125 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19701203 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT THROTTLE ROD TO THROTTLE LEVER RETAINING CLIP ON CARBURETORMAY BE INCORRECTLY INSTALLED.IF THIS CONDITION EXISTS, THROTTLE LEVER COULDBE HELD IN PARTIALLY OPEN POSITION.IF THIS OCCURS WHILE VEHICLE IS IN MOTION,VEHICLE WILL NOT SLOW DOWN WHEN DRIVER'S FOOT IS REMOVED FROM ACCELERATOR.(CORRECT BY REPLACING CLIP WITH IMPROVED DESIGN WHERE NECESSARY.)
CHEVROLET: NOVA: POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
| NHTSA Campaign Number: | 72V130000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1972 |
| Manufacturer Component Description: | POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720401 - 19720401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1082 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19720523 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT REAR AXLE SHAFT MAY CONTAIN MATERIAL FLAW THATCOULD RESULT INEARLY FAILURE.(CORRECT BY INSPECTING AND REPLACING SHAFT WHERE NECESSARY.)
CHEVROLET: NOVA: SUSPENSION:FRONT:CONTROL ARM:UPPER ARM
| NHTSA Campaign Number: | 72V290000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1973 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:UPPER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19721101 - 19721101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 330 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19721124 |
| Record Creation Date: | 19791012 |
Notes:
POSSIBILITY THAT LEFT FRONT UPPER CONTROL ARM ATTACHING NUT WAS IMPROPERLYTORQUED.CONDITION COULD RESULT IN NUT BECOMING LOOSE ALLOWING BOLT TO WORKAND EVENTUALLY BREAK, CAUSING LOSS OF STEERING CONTROL.(CORRECT BY INSPECTINGAND TORQUING PROPERLY WHERE NECESSARY.)
CHEVROLET: NOVA: STEERING:LINKAGES
| NHTSA Campaign Number: | 72V265000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1973 |
| Manufacturer Component Description: | STEERING:LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19721001 - 19721001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 544 |
| Date Owner Notified By Manufacturer: | 19721027 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19721031 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 73-C-1.(VEHILES EQUIPPED WITH OPTIONAL FRONT DISCBRAKES).POSSIBILITY THAT STEERING ARM TO CALIPER ANCHOR BRACKET ATTACHINGBOLTS WERE IMPROPERLY TORQUED.LOW TORQUE COULD CAUSE BOLT TO BREAK, IF THISOCCURS, BROKEN BOLT COULD COME OUTOF POSITION AND LODGE IN RIGHT HAND FRONTBRAKE ROTOR RESULTINGIN SUDDEN LOCKUP OF TIRE AND WHEEL ASSEMBLY.(CORRECT BYINSPECTING AND TORQUING BOLT TO SPECIFIED 60 TO 80 LB.FT.)
CHEVROLET: NOVA: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1973 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: NOVA: SEAT BELTS:FRONT:WARNING LIGHT/DEVICES
| NHTSA Campaign Number: | 72V305000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1973 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WARNING LIGHT/DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19720801 - 19721001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3225 |
| Date Owner Notified By Manufacturer: | 19721214 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19721211 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTORS CAMPAIGN NO (CHEVY) 73-C-07 (PONTIAC) 73-C-05 (OLDSMOBILE)73-C-3.VEHILES EQUIPPED WITH 3 SPEED TRANSMISSION AND COLUMN SHIFT.POSSIBILITY THAT SEAT BELT WARNING SYSTEM WILL NOT FUNCTION WITH VEHICLE INTHIRD GEAR DUE TO ROTATION OF SHIFT TUBE NOT ALWAYS MAKING CONTACT WITH SEATBELT WARNING SYSTEM RELAY.(CORRECT BY INSPECTING AND INSTALLING REDESIGNEDSHIFT ROD AND NEW SHIFT LEVERS.)
CHEVROLET: NOVA: SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE
| NHTSA Campaign Number: | 73V245000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1974 |
| Manufacturer Component Description: | SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19731001 - 19731001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12703 |
| Date Owner Notified By Manufacturer: | 19731212 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19731219 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTORS CAMPAIGN NO CHEVROLET 74-C-08.BUICK 74-C-1.POSSIBILITY THATTHE REAR SPRING "U" BOLT WHICH PARTIALLY SECURES THE REAR CHASSIS SPRINGS TOTHE REAR AXLE ASSEMBLY MAY HAVE BEEN BROKEN DURING FACTORY INSTALLATION.IFTHIS CONDITION EXISTS IT COULD RESULT IN FAILURE OF THE ANCHOR PLATE BRACKETWHICH WOULD ALLOW THE REAR SPRING TO DROP AWAY FROM THE AXLE ASSEMBLY.(CORRECT BY INSPECTING AND INSTALLING NEW "U" BOLT WHERE NECESSARY.)
CHEVROLET: NOVA: STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM
| NHTSA Campaign Number: | 74V034000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1974 |
| Manufacturer Component Description: | STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 260 |
| Date Owner Notified By Manufacturer: | 19740222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740226 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 74-C-12.EQUIPPED WITH OPTIONAL FRONT DISC BRAKES.POSSIBILITY THAT THE ATTACHING BOLTS ON THE STEERING ARM TO CALIPER ANCHORBRACKET WERE INSUFFICENTLY TORQUED.THIS LOW TORQUE COULD CAUSE BOLTS TOBREAK.IF THE BOLT BREAKS IT COULDCOME OUT OF ITS POSITION AND LODGE IN THERIGHT HAND FRONT BRAKE ROTOR RESULTING IN A SUDDEN LOCK-UP OF THE TIRE ANDWHEEL ASSEMBLY.(CORRECT BY INSPECTING AND RETORQUING BOLTS TO SPECIFIEDTORQUE.)
CHEVROLET: NOVA: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
| NHTSA Campaign Number: | 74V027000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1974 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1218387 |
| Date Owner Notified By Manufacturer: | 19740218 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740215 |
| Record Creation Date: | 19791012 |
Notes:
OLDSMOBILE CAMPAIGN NO 74-C-5.BUICK CAMPAIGN NO 73-C-3.GMC TRUCK CAMPAIGNNO 74-C-06.CHEVROLET CAMPAIGN NO 74-C-11.PONTIAC CAMPAIGN NO 74-C-5.POSSIBILITY THAT THE SINGLE DIAPHRAGM BRAKE VACUUM POWER BOOSTER WAS ASSEMBLEDWITH DEMENSIONAL DESCREPANCIES IN THE VACUUM POWER BOOSTER HOUSING WHICH MAYREDUCE THE TORQUE REQUIRED TO UNLOCK THE FRONT HALF OF THE HOUSING FROM THEREAR HALF.IF THIS CONDITION EXISTS, THE LOW UNLOCKING TORQUE COUPLED WITHOTHER VARIATIONS IN THE ASSEMBLY MAY CAUSE HOUSING TO ROTATE AND DISENGAGE FROMTHE LOCKING TABS RESULTING IN SEPARATION OF THE TWO HALVES OF THE BOOSTER ANDCOMPLETE LOSS OF BRAKES.(CORRECT BY INSPECTING AND STAKING THE HOUSING AT TWOPOINTS TO PRECLUDE ROTATION OF THE HOUSING.
CHEVROLET: NOVA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1974 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: NOVA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1975 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: NOVA: SEATS:FRONT ASSEMBLY:RECLINER
| NHTSA Campaign Number: | 74V162000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1975 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 358 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740926 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTORS CAMPAIGN NOS.OLDSMOBILE 75-C-4.CHEVROLET 75-C-02.TWO DOOREQUIPPED WITH BUCKET SEATS.POSSIBILITY THE OUTBOARD LOCK OF THE FRONT SEATBACK MAY REST ON THE HEAD OF THE STRIKER AND PREVENT FULL ENGAGEMENT OF THELOCK WHEN THE SEAT BACK IS IN THE NORMAL UPRIGHT POSITION.THIS IS DUE TO THESTRIKER BEING OF INSUFFICIENT LENGTH.IF THIS CONDITION EXISTS, AND THEVEHICLE IS INVOLVED IN A FRONTAL CRASH, IT COULD RESULT IN AN INCREASEDPOSSIBILITY OF INJURY TO THE OCCUPANT(S).(CORRECT BY INSPECTING ANDINSTALLING A NEW 3/8" LONGER STRIKER TO PROVIDE LOCKING ENGAGEMENT).
CHEVROLET: NOVA: STEERING:WHEEL AND HANDLE BAR
| NHTSA Campaign Number: | 75V094000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1975 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3069 |
| Date Owner Notified By Manufacturer: | 19750516 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19750521 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 75-C-13.BUICK CAMPAIGN NO 75-C-9.POSSIBILITY THATUNITS MAY HAVE BEEN ASSEMBLED WITH INSUFFICIENT TORQUE ON THE STEERING POTJOINT CLAMP BOLT/NUT WHICH SECURES THE INTERMEDIATE STEERING SHAFT TO THE UPPERSTEERING SHAFT.IF THIS CONDITION EXISTS, IT MAY ALLOW THE SHAFTS TO SEPARATEAND RESULT IN LOSS OF STEERING CONTROL.(CORRECT BY INSPECTING AND PROPERLYTORQUING THE STEERING CONNECTIONS WHREE NECESSARY.)
CHEVROLET: NOVA: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
| NHTSA Campaign Number: | 74V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1975 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 11962 |
| Date Owner Notified By Manufacturer: | 19740920 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19740923 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 75-C-01.BUICK CAMPAIGN NO 75-C-1.OLDSMOBILE CAMPAIGNNO 75-C-3.PONTIAC CAMPAIGN NO 75-C-1.POSSIBILITY THAT THE RIGHT AND LEFTSIDE FRONT SUSPENSION LOWER CONTROL ARM BRACKET ATTACHMENTS MAY HAVE BEENIMPROPERLY WELDED TO THE UNDERSIDE OF THE FRAME.IF THIS CONDITION EXISTS,SEPARATION OF THE WELD ATTACHMENTS WILL RESULT IN SIGNIFICANT STEERING CHANGEWHICH COULD CAUSE A LOSS OF STEERING CONTROL.(CORRECT BY INSPECTING ANDADDING AN ADDITIONAL WELD AT THE REAR MOUNTING BRACKETS).
CHEVROLET: NOVA: SUSPENSION:REAR
| NHTSA Campaign Number: | 77V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1977 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 31979 |
| Date Owner Notified By Manufacturer: | 19770922 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19770927 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE REAR AXLE SHAFTS ON THE INVOLVED VEHICLES MAY HAVE A FLAW IN THE METAL. AS A RESULT, THE SHAFT MAY BREAK, WHICH WOULD ALLOW THE TIRE AND WHEEL ASSEMBLY TO SEPARATE FROM THE VEHICLE.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, INSTALL ONE OR BOTH NEW REAR AXLE SHAFTS, WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; REAR AXLE.CONSEQUENCES OF DEFECT: IF THIS OCCURS WHILE THE VEHICLE IS IN MOTION, IT COULDRESULT IN LOSS OF VEHICLE CONTROL WITHOUT WARNING AND AN ACCIDENT.NOTE: AS A PRECAUTION, PRIOR TO HAVING VEHICLE INSPECTED, DRIVER SHOULD AVOIDFAST CORNERING, RAPID ACCELERATIONS, OR ANY TYPE OF DRIVING WHICH MAY IMPOSEEXCESSIVE LOADS ON THE REAR AXLE SHAFTS.
CHEVROLET: NOVA: STEERING:WHEEL AND HANDLE BAR
| NHTSA Campaign Number: | 76V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1977 |
| Manufacturer Component Description: | STEERING:WHEEL AND HANDLE BAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55564 |
| Date Owner Notified By Manufacturer: | 19760830 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19760907 |
| Record Creation Date: | 19791012 |
Notes:
GENERAL MOTOR CAMPAIGN NO 77-C-1.POSSIBILITY THAT THE STEERING INTERMEDIATESHAFT MAY HAVE BEEN ASSEMBLED WITH COUPLING RETAINER LOCKING TABS NOT BENT OVERPROPERLY OR ONE OR MORE OF THE LOWER FLEXIBLE COUPLING RIVETS IMPROPERLYPEENED.IF EITHER OF THESE CONDITIONS EXISTS, THE INTERMEDIATE SHAFT ASSEMBLYCOULD SEPARATE CAUSING LOSS OF STEERING CONTROL, AND VEHICLE CRASH MAY OCCURWITHOUT PRIOR WARNING.(CORRECT BY INSPECTING, AND REPLACING SHAFT WHERENECESSARY).PASSENGER VEHICLE.
CHEVROLET: NOVA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1977 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: NOVA: WHEELS:CENTER SECTION
| NHTSA Campaign Number: | 77V074000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1977 |
| Manufacturer Component Description: | WHEELS:CENTER SECTION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15246 |
| Date Owner Notified By Manufacturer: | 19770513 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19770516 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE CENTER (SPIDER) SECTION OF WHEELS INSTALLED ON THESE VEHICLES MAY HAVE BEEN MANUFACTURED FROM AN INCORRECT GRADE OF STEEL. THE CENTER SECTION MAY FATIGUE AND SEPARATE FROM THE WHEEL RIM.
Corrective Summary:
DEALER WILL INSPECT AND WILL REPLACE DEFECTIVE WHEELS WITH WHEELS MADE FROM THE CORRECT GRADE OF STEEL, WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: WHEELS; CENTER DISC SPIDER.CONSEQUENCES OF DEFECT: IF SEPARATION OCCURS DURING VEHICLE OPERATION, LOSS OFVEHICLE CONTROL AND AN ACCIDENT COULD RESULT.
CHEVROLET: NOVA: SUSPENSION:REAR
| NHTSA Campaign Number: | 77V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1978 |
| Manufacturer Component Description: | SUSPENSION:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 31979 |
| Date Owner Notified By Manufacturer: | 19770922 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19770927 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE REAR AXLE SHAFTS ON THE INVOLVED VEHICLES MAY HAVE A FLAW IN THE METAL. AS A RESULT, THE SHAFT MAY BREAK, WHICH WOULD ALLOW THE TIRE AND WHEEL ASSEMBLY TO SEPARATE FROM THE VEHICLE.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, INSTALL ONE OR BOTH NEW REAR AXLE SHAFTS, WITHOUT CHARGE TO OWNER.
Notes:
VEHICLE DESCRIPTION: PASSENGER VEHICLES.SYSTEM: SUSPENSION; REAR AXLE.CONSEQUENCES OF DEFECT: IF THIS OCCURS WHILE THE VEHICLE IS IN MOTION, IT COULDRESULT IN LOSS OF VEHICLE CONTROL WITHOUT WARNING AND AN ACCIDENT.NOTE: AS A PRECAUTION, PRIOR TO HAVING VEHICLE INSPECTED, DRIVER SHOULD AVOIDFAST CORNERING, RAPID ACCELERATIONS, OR ANY TYPE OF DRIVING WHICH MAY IMPOSEEXCESSIVE LOADS ON THE REAR AXLE SHAFTS.
CHEVROLET: NOVA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1978 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: NOVA: EQUIPMENT
| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | NOVA |
| Model Year: | 1979 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: PICK UP C&K SERIES: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 80V150000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | PICK UP C&K SERIES |
| Model Year: | 1981 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19800801 - 19800901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 364 |
| Date Owner Notified By Manufacturer: | 19801117 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19801114 |
| Record Creation Date: | 19801217 |
Defect Summary:
THE INVOLVED VEHICLES MAY HAVE BEEN ASSEMBLED WITHOUT THE RETAINER CLIP FOR THE BRAKE PEDAL PUSH ROD. THE ABSENCE OF THIS RETAINER CLIP COULD ALLOW THE BRAKE PEDAL TO DISENGAGE FROM THE MASTER CYCLINDER PUSH ROD.
Corrective Summary:
THE DEALER WILL INSPECT AND, IF NECESSARY, INSTALL THE RETAINER CLIP ON ALL SUSPECT VEHICLES WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: SERVICE BRAKES; BRAKE PEDAL PUSH ROD RETAINER CLIPS.CONSEQUENCES OF DEFECT: THIS MAY RESULT IN LOSS OF BRAKING ACTION. THISCONDITION COULD OCCUR WITHOUT WARNING WHILE THE VEHICLE IS IN MOTION, AND COULDRESULT IN AN ACCIDENT.
- --CHEVROLET: PRIZM: SUSPENSION
-->| NHTSA Campaign Number: | 10E002000 |
| Vehicle/Equipment Make: | RIDE CONTROL, LLC |
| Vehicle/Equipment Model: | PRIZM |
| Model Year: | 1998 |
| Manufacturer Component Description: | SUSPENSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12657 |
| Date Owner Notified By Manufacturer: | 20100315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | RIDE CONTROL, LLC |
| Report Received Date: | 20100211 |
| Record Creation Date: | 20100211 |
Defect Summary:
RIDE CONTROL IS RECALLING CERTAIN FRONT STRUT MOUNTS BRANDED AS GABRIEL RIDE CONTROL OR ARVINMERITOR, P/NOS. 142435, 142193, 142305, 142303, SOLD AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE AFFECTED FRONT STRUT MOUNTS DID NOT CONTAIN A WELD JOINT BETWEEN THE BEARING HOUSING AND THE RATE PLATE.
Consequence Summary:
THE ABSENCE OF THE WELD CAN ALLOW THE STRUT TO COME OUT OF ITS MOUNTING POSITION UNDER CERTAIN EXTREME DRIVING CONDITIONS WHICH COULD CAUSE DAMAGE TO SURROUNDING VEHICLE COMPONENTS INCREASING THE RISK OF A CRASH.
Corrective Summary:
RIDE CONTROL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED PARTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RIDE CONTROL AT 1-248-458-1396.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET GABRIEL RIDE CONTROL OR ARVINMERITOR FRONT STRUT MOUNTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS, NISSAN, OR TOYOTA.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
-CHEVROLET: PRIZM: SUSPENSION
-->| NHTSA Campaign Number: | 10E002000 |
| Vehicle/Equipment Make: | RIDE CONTROL, LLC |
| Vehicle/Equipment Model: | PRIZM |
| Model Year: | 1999 |
| Manufacturer Component Description: | SUSPENSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12657 |
| Date Owner Notified By Manufacturer: | 20100315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | RIDE CONTROL, LLC |
| Report Received Date: | 20100211 |
| Record Creation Date: | 20100211 |
Defect Summary:
RIDE CONTROL IS RECALLING CERTAIN FRONT STRUT MOUNTS BRANDED AS GABRIEL RIDE CONTROL OR ARVINMERITOR, P/NOS. 142435, 142193, 142305, 142303, SOLD AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE AFFECTED FRONT STRUT MOUNTS DID NOT CONTAIN A WELD JOINT BETWEEN THE BEARING HOUSING AND THE RATE PLATE.
Consequence Summary:
THE ABSENCE OF THE WELD CAN ALLOW THE STRUT TO COME OUT OF ITS MOUNTING POSITION UNDER CERTAIN EXTREME DRIVING CONDITIONS WHICH COULD CAUSE DAMAGE TO SURROUNDING VEHICLE COMPONENTS INCREASING THE RISK OF A CRASH.
Corrective Summary:
RIDE CONTROL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED PARTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RIDE CONTROL AT 1-248-458-1396.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET GABRIEL RIDE CONTROL OR ARVINMERITOR FRONT STRUT MOUNTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS, NISSAN, OR TOYOTA.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
-CHEVROLET: PRIZM: SUSPENSION
-->| NHTSA Campaign Number: | 10E002000 |
| Vehicle/Equipment Make: | RIDE CONTROL, LLC |
| Vehicle/Equipment Model: | PRIZM |
| Model Year: | 2001 |
| Manufacturer Component Description: | SUSPENSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12657 |
| Date Owner Notified By Manufacturer: | 20100315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | RIDE CONTROL, LLC |
| Report Received Date: | 20100211 |
| Record Creation Date: | 20100211 |
Defect Summary:
RIDE CONTROL IS RECALLING CERTAIN FRONT STRUT MOUNTS BRANDED AS GABRIEL RIDE CONTROL OR ARVINMERITOR, P/NOS. 142435, 142193, 142305, 142303, SOLD AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE AFFECTED FRONT STRUT MOUNTS DID NOT CONTAIN A WELD JOINT BETWEEN THE BEARING HOUSING AND THE RATE PLATE.
Consequence Summary:
THE ABSENCE OF THE WELD CAN ALLOW THE STRUT TO COME OUT OF ITS MOUNTING POSITION UNDER CERTAIN EXTREME DRIVING CONDITIONS WHICH COULD CAUSE DAMAGE TO SURROUNDING VEHICLE COMPONENTS INCREASING THE RISK OF A CRASH.
Corrective Summary:
RIDE CONTROL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED PARTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RIDE CONTROL AT 1-248-458-1396.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET GABRIEL RIDE CONTROL OR ARVINMERITOR FRONT STRUT MOUNTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS, NISSAN, OR TOYOTA.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
-CHEVROLET: PRIZM: SUSPENSION
-->| NHTSA Campaign Number: | 10E002000 |
| Vehicle/Equipment Make: | RIDE CONTROL, LLC |
| Vehicle/Equipment Model: | PRIZM |
| Model Year: | 2002 |
| Manufacturer Component Description: | SUSPENSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12657 |
| Date Owner Notified By Manufacturer: | 20100315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | RIDE CONTROL, LLC |
| Report Received Date: | 20100211 |
| Record Creation Date: | 20100211 |
Defect Summary:
RIDE CONTROL IS RECALLING CERTAIN FRONT STRUT MOUNTS BRANDED AS GABRIEL RIDE CONTROL OR ARVINMERITOR, P/NOS. 142435, 142193, 142305, 142303, SOLD AS REPLACEMENT EQUIPMENT FOR THE VEHICLES LISTED ABOVE. THE AFFECTED FRONT STRUT MOUNTS DID NOT CONTAIN A WELD JOINT BETWEEN THE BEARING HOUSING AND THE RATE PLATE.
Consequence Summary:
THE ABSENCE OF THE WELD CAN ALLOW THE STRUT TO COME OUT OF ITS MOUNTING POSITION UNDER CERTAIN EXTREME DRIVING CONDITIONS WHICH COULD CAUSE DAMAGE TO SURROUNDING VEHICLE COMPONENTS INCREASING THE RISK OF A CRASH.
Corrective Summary:
RIDE CONTROL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED PARTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2010. OWNERS MAY CONTACT RIDE CONTROL AT 1-248-458-1396.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET GABRIEL RIDE CONTROL OR ARVINMERITOR FRONT STRUT MOUNTS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS, NISSAN, OR TOYOTA.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
- --CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2007 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2006 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2005 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S-10: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 04V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S-10 |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4021 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030401 - 20040401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 183922 |
| Date Owner Notified By Manufacturer: | 20040604 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040318 |
| Record Creation Date: | 20040322 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
SOME OF THESE VEHICLES INCLUDE INCORRECT STATEMENTS ON ONE OF THE AIR BAG WARNING LABELS.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECT LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON JUNE 4, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04021.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S-10: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 04V132000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S-10 |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4021 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020901 - 20030930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 183922 |
| Date Owner Notified By Manufacturer: | 20040604 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040318 |
| Record Creation Date: | 20040322 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
SOME OF THESE VEHICLES INCLUDE INCORRECT STATEMENTS ON ONE OF THE AIR BAG WARNING LABELS.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECT LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON JUNE 4, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04021.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: SEAT BELTS
-->| NHTSA Campaign Number: | 00V228003 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 67 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000501 - 20000531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 156305 |
| Date Owner Notified By Manufacturer: | 20000824 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000807 |
| Record Creation Date: | 20000822 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Notes:
OWNER NOTIFICATION BEGAN AUGUST 24, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; CHEVROLET AT 1-800-222-1020; GMC AT 1-800-462-8782; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR SATURN AT 1-800-553-6000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1999 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
-->| NHTSA Campaign Number: | 98V177000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1998 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19980331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 354 |
| Date Owner Notified By Manufacturer: | 19980831 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980804 |
| Record Creation Date: | 19980814 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH ELECTRIC DRIVE. RAPID FOGGING OF THE INTERIOR GLASS CAN OCCUR WITHIN TWO MINUTES AFTER THE HEAT IS TURNED ON IF (1) THE OUTSIDE TEMPERATURE IS BETWEEN 35 AND 76 DEGREES FAHRENHEIT AND (2) WATER HAS COLLECTED ON THE HEAT EXCHANGER DURING PREVIOUS OPERATION OF THE AIR CONDITIONING.
Consequence Summary:
IF RAPID FOGGING WERE TO OCCUR DURING DRIVING, IT COULD OBSTRUCT THE DRIVER'S VISION INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
OWNERS ARE BEING PROVIDED WITH A CAUTION LABEL AND SUPPLEMENTAL INSERT FOR THEIR OWNER'S MANUAL ADVISING THEM TO FOLLOW A "STOP AND WAIT" PROCEDURE TO HELP AVOID WINDOW FOGGING WHILE DRIVING.
Notes:
OWNER NOTIFICATION BEGAN DURING AUGUST 1998.OWNERS WHO DO NOT RECEIVE THE CAUTION LABEL WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 00V220000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 43 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19980630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 14279 |
| Date Owner Notified By Manufacturer: | 20000913 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000811 |
| Record Creation Date: | 20000811 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE DAYTIME RUNNING LIGHTS BUILT WITH A CANDELA VALUE GREATER THAN 3,000 CANNOT BE MOUNTED HIGHER THAN 864MM ABOVE THE ROAD SURFACE.
Consequence Summary:
THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Corrective Summary:
DEALERS WILL INSTALL A REVISED WIRING HARNESS THAT CHANGES THE DRL'S FROM HIGH BEAM TO LOW BEAM DRL'S, AND INSTALL NEW LONG-LIFE LOW BEAM BULBS.
Notes:
OWNER NOTIFICATION BEGAN SEPTEMBER 13, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
-->| NHTSA Campaign Number: | 97V208001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1998 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970301 - 19971105 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 33973 |
| Date Owner Notified By Manufacturer: | 19971114 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19971125 |
| Record Creation Date: | 19971126 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE VEHICLES. AN ENGINE ELECTRICAL WIRING-HARNESS CLIP CAN MELT AND DRIP ONTO THE EXHAUST MANIFOLD.
Consequence Summary:
THE CLIP MATERIAL ON THE EXHAUST MANIFOLD CAN IGNITE AND SUBSEQUENTLY IGNITE OTHER COMBUSTIBLE COMPONENTS RESULTING IN A VEHICLE FIRE.
Corrective Summary:
DEALERS ARE CONTACTING OWNERS BY TELEPHONE TO HAVE THEIR VEHICLES TOWED TO THE DEALER AND ALTERNATE TRANSPORTATION PROVIDED TO THEM UNTIL THE DEALER CAN REROUTE THE ELECTRICAL WIRING-HARNESS.
Notes:
OWNER NOTIFICATION BEGAN NOVEMBER 14, 1997.OWNERS WHO HAVE NOT BEEN CONTACTED WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, AND GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 97V218000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1998 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970301 - 19970831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 19716 |
| Date Owner Notified By Manufacturer: | 19971215 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19971124 |
| Record Creation Date: | 19971203 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. A FATIGUE FRACTURE OF THE REAR AXLE RIGHT-HAND BRAKE PIPE CAN OCCUR CAUSING A SLOW BRAKE FLUID LEAK RESULTING IN A SOFT BRAKE PEDAL. IF THE BRAKE PIPE BREAKS, THE DRIVER WOULD EXPERIENCE A SUDDEN DROP IN THE BRAKE PEDAL, THE INSTRUMENT PANEL BRAKE LIGHT WOULD ILLUMINATE, AND THERE WOULD BE A LOSS OF REAR BRAKE PERFORMANCE.
Consequence Summary:
PARTIAL LOSS OF BRAKING AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED COULD RESULT IN A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE BRAKE PIPE.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING DECEMBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E065000 |
| Vehicle/Equipment Make: | AJ MOTORSPORT |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3593 |
| Date Owner Notified By Manufacturer: | 20060731 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AJ MOTORSPORT |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Notes:
THIS RECALL ONLY PERTAINS TO AJ MOTORSPORT AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1998 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1998 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 00V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 50 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19980331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 306 |
| Date Owner Notified By Manufacturer: | 20000728 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000616 |
| Record Creation Date: | 20000616 |
Defect Summary:
VEHICLE DESCRIPTION: ELECTRIC PICKUP TRUCKS. A CONDITION IN WHICH THE FUEL-FIRED HEATER FILL PIPE GROUND STRAP CONTACTS THE REAR PASSENGER SIDE BRAKE PIPE.
Consequence Summary:
THIS COULD WEAR OFF THE CORROSION PROTECTION ON THE BRAKE PIPE, LEADING TO PREMATURE CORROSION AND EVENTUAL LOSS OF BRAKE PIPE INTEGRITY. WHEN BRAKE PIPE INTEGRITY IS LOST, BRAKE FLUID LEAKAGE CAN OCCUR.
Corrective Summary:
DEALERS WILL RELOCATE THE GROUND STRAP ATTACHMENT, INSPECT THE BRAKE PIPE FOR WEAR, AND REPLACE THE BRAKE PIPE IF NECESSARY.
Notes:
OWNER NOTIFICATION BEGAN JULY 28, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: VISIBILITY:DEFROSTER/DEFOGGER SYSTEM
-->| NHTSA Campaign Number: | 98V177000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1997 |
| Manufacturer Component Description: | VISIBILITY:DEFROSTER/DEFOGGER SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19980331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 354 |
| Date Owner Notified By Manufacturer: | 19980831 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980804 |
| Record Creation Date: | 19980814 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH ELECTRIC DRIVE. RAPID FOGGING OF THE INTERIOR GLASS CAN OCCUR WITHIN TWO MINUTES AFTER THE HEAT IS TURNED ON IF (1) THE OUTSIDE TEMPERATURE IS BETWEEN 35 AND 76 DEGREES FAHRENHEIT AND (2) WATER HAS COLLECTED ON THE HEAT EXCHANGER DURING PREVIOUS OPERATION OF THE AIR CONDITIONING.
Consequence Summary:
IF RAPID FOGGING WERE TO OCCUR DURING DRIVING, IT COULD OBSTRUCT THE DRIVER'S VISION INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
OWNERS ARE BEING PROVIDED WITH A CAUTION LABEL AND SUPPLEMENTAL INSERT FOR THEIR OWNER'S MANUAL ADVISING THEM TO FOLLOW A "STOP AND WAIT" PROCEDURE TO HELP AVOID WINDOW FOGGING WHILE DRIVING.
Notes:
OWNER NOTIFICATION BEGAN DURING AUGUST 1998.OWNERS WHO DO NOT RECEIVE THE CAUTION LABEL WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: ELECTRICAL SYSTEM:BATTERY
-->| NHTSA Campaign Number: | 00V069200 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 25 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:BATTERY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19980331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 576 |
| Date Owner Notified By Manufacturer: | 20000323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000303 |
| Record Creation Date: | 20010117 |
Defect Summary:
VEHICLE DESCRIPTION: GENERATION 1 ELECTRIC LIGHT DUTY PICKUP TRUCKS. THESE VEHICLES WERE BUILT WITH A CHARGE PORT ASSEMBLY THAT COULD FAIL DURING A CHARGING EVENT.
Consequence Summary:
HEAT COULD BUILD UP WITHIN THE CHARGE PORT AND A FIRE COULD RESULT.
Corrective Summary:
DEALERS WILL REPLACE THE CHARGE PORT ASSEMBLY WITH A REDESIGNED CHARGE PORT ASSEMBLY.
Notes:
OWNER NOTIFICATION BEGAN MARCH 23, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: SEAT BELTS
-->| NHTSA Campaign Number: | 97V096001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1997 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960301 - 19970630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 586058 |
| Date Owner Notified By Manufacturer: | 19970922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970612 |
| Record Creation Date: | 19970821 |
Defect Summary:
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence Summary:
IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING SEPTEMBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960301 - 19970630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1997 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 97V146001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1997 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960301 - 19970330 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 146167 |
| Date Owner Notified By Manufacturer: | 19971020 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970911 |
| Record Creation Date: | 19970916 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence Summary:
BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING OCTOBER 1997.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1997 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 00V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 50 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19980331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 306 |
| Date Owner Notified By Manufacturer: | 20000728 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000616 |
| Record Creation Date: | 20000616 |
Defect Summary:
VEHICLE DESCRIPTION: ELECTRIC PICKUP TRUCKS. A CONDITION IN WHICH THE FUEL-FIRED HEATER FILL PIPE GROUND STRAP CONTACTS THE REAR PASSENGER SIDE BRAKE PIPE.
Consequence Summary:
THIS COULD WEAR OFF THE CORROSION PROTECTION ON THE BRAKE PIPE, LEADING TO PREMATURE CORROSION AND EVENTUAL LOSS OF BRAKE PIPE INTEGRITY. WHEN BRAKE PIPE INTEGRITY IS LOST, BRAKE FLUID LEAKAGE CAN OCCUR.
Corrective Summary:
DEALERS WILL RELOCATE THE GROUND STRAP ATTACHMENT, INSPECT THE BRAKE PIPE FOR WEAR, AND REPLACE THE BRAKE PIPE IF NECESSARY.
Notes:
OWNER NOTIFICATION BEGAN JULY 28, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: POWER TRAIN:MANUAL TRANSMISSION
-->| NHTSA Campaign Number: | 96V035000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1996 |
| Manufacturer Component Description: | POWER TRAIN:MANUAL TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950801 - 19960101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 24906 |
| Date Owner Notified By Manufacturer: | 19960216 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960222 |
| Record Creation Date: | 19960227 |
Defect Summary:
SOME OF THESE TRUCKS WERE BUILT WITH TRANSMISSIONS CONTAINING PARTS WHICH WERE NOT MACHINED TO GM'S SPECIFICATIONS.
Consequence Summary:
THESE TRANSMISSIONS COULD SEIZE AND LOCK THE REAR DRIVE WHEELS WHILE THE TRUCK IS BEING DRIVEN CAUSING A LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL INSPECT THE TRANSMISSION MAIN SHAFT OUTPUT TORQUE USING A SPECIAL TOOL. IF THE OUTPUT TORQUE DOES NOT MEET SPECIFICATIONS, THE TRANSMISSION WILL BE REPLACED.
Notes:
SYSTEM: POWER TRAIN; TRANSMISSION; 5 SPEED.VEHICLE DESCRIPTION: 2 WHEEL DRIVE PICKUP TRUCKS EQUIPPED WITH 2.2L ENGINES AND 5-SPEED MANUAL TRANSMISSIONS.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: SEAT BELTS
-->| NHTSA Campaign Number: | 97V096001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1996 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950301 - 19960830 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 586058 |
| Date Owner Notified By Manufacturer: | 19970922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970612 |
| Record Creation Date: | 19970821 |
Defect Summary:
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence Summary:
IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING SEPTEMBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 98V150001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 98043 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19960531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1557585 |
| Date Owner Notified By Manufacturer: | 19981215 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980701 |
| Record Creation Date: | 19990211 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence Summary:
THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 15, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960601 - 19960831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99I006000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1996 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2400000 |
| Date Owner Notified By Manufacturer: | 19991210 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: CERTAIN LIGHT DUTY PICKUP TRUCKS, SPORT UTILITY VEHICLES, OR MINIVANS EQUIPPED WITH 3-SENSOR ABS (ANTILOCK BRAKING SYSTEM) EBC4 UNITS.
Consequence Summary:
THESE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES DURING ABS STOPS ON CERTAIN MULTIPLE SURFACES, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL MODIFY THE COMPUTER PROGRAM WHICH OPERATES THE ABS UNIT ON SOME VEHICLES, OR REPLACE THE COMPUTER ON OTHERS TO IMPROVE THE PERFORMANCE OF THE ABS ON THESE SURFACES.
Notes:
ON VEHICLES WHICH REQUIRED THE COMPUTER PROGRAM TO BE MODIFIED, OWNER NOTIFICATION HAS BEGAN.FOR VEHICLES WHICH REQUIRE A NEW COMPUTER MODULE, GM HAS SCHEDULED OWNER NOTIFICATIION TO BEGIN DURING THE LAST WEEK OF MAY 2000.A PHASED MAILING WILL BE REQUIRED, WITH THE LAST MAILING SCHEDULED TO BE COMPLETED BY DECEMBER 2000.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 99041 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1125749 |
| Date Owner Notified By Manufacturer: | 20000531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence Summary:
IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Notes:
THE FIRST PHASE OF OWNER NOTIFICATION LETTERS BEGAN MAY 31, 2000,WITH THE LAST MAILING COMPLETED BY OCTOBER 2000. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 97V146001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1996 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950301 - 19960830 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 146167 |
| Date Owner Notified By Manufacturer: | 19971020 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970911 |
| Record Creation Date: | 19970916 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER PICKUP TRUCKS EQUIPPED WITH 4.3L ENGINES. THE FRONT BRAKE LINE CAN CONTACT THE LEFT-HAND SIDE OF THE ENGINE OIL PAN CAUSING THE BRAKE LINE TO WEAR TO THE POINT OF BRAKE FLUID LOSS DURING BRAKE APPLICATION.
Consequence Summary:
BRAKE FLUID LOSS CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE STOPPING DISTANCES RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE OIL PAN AND THE BRAKE LINE. IF THE CLEARANCE IS 6MM OR LESS, DEALERS WILL INSTALL AN ADDITIONAL BRAKE LINE CLIP AND IF THERE WAS CONTACT BETWEEN THE OIL PAN AND BRAKE LINE, THE FRONT BRAKE LINE WILL BE REPLACED.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING OCTOBER 1997.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1996 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: VISIBILITY:WINDSHIELD
-->| NHTSA Campaign Number: | 97V008001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1996 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960201 - 19960430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 55 |
| Date Owner Notified By Manufacturer: | 19970130 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970127 |
| Record Creation Date: | 19970203 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 212 |
Defect Summary:
THE TOP COAT PAINT SEVERELY PEELS DUE TO OVERBAKING OF THE POWDER PRIMER PRIOR TO THE TOP COAT APPLICATION. SINCE THE WINDSHIELD PRIMER AND ADHESIVE ADHERE TO THE TOP COAT PAINT ONTHE WINDSHIELD OPENING FLANGE, THE WINDSHIELD DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING."
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE WINDSHIELD MAY NOT STAY IN PLACE AS REQUIRED BY FMVSS NO. 212.
Corrective Summary:
ALL VEHICLES HAVE BEEN REPURCHASED. THIS CAMPAIGN IS 100%.
Notes:
OWNER NOTIFICATION BEGAN JANUARY 30, 1997.NOTE:OWNERS WHO DO NOT HAVE THEIR VEHICLE REPLACED OR THEIR PURCHASE PRICE REFUNDED SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: SEAT BELTS
-->| NHTSA Campaign Number: | 97V096001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1995 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940101 - 19950830 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 586058 |
| Date Owner Notified By Manufacturer: | 19970922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970612 |
| Record Creation Date: | 19970821 |
Defect Summary:
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence Summary:
IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Corrective Summary:
DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Notes:
OWNER NOTIFICATION:OWNER NOTIFICATION WILL BEGIN DURING SEPTEMBER 1997. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 98V150001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1995 |
| Manufacturer Campaign Number: | 98043 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19960531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1557585 |
| Date Owner Notified By Manufacturer: | 19981215 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980701 |
| Record Creation Date: | 19990211 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence Summary:
THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 15, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99I006000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1995 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 2400000 |
| Date Owner Notified By Manufacturer: | 19991210 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: CERTAIN LIGHT DUTY PICKUP TRUCKS, SPORT UTILITY VEHICLES, OR MINIVANS EQUIPPED WITH 3-SENSOR ABS (ANTILOCK BRAKING SYSTEM) EBC4 UNITS.
Consequence Summary:
THESE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES DURING ABS STOPS ON CERTAIN MULTIPLE SURFACES, INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL MODIFY THE COMPUTER PROGRAM WHICH OPERATES THE ABS UNIT ON SOME VEHICLES, OR REPLACE THE COMPUTER ON OTHERS TO IMPROVE THE PERFORMANCE OF THE ABS ON THESE SURFACES.
Notes:
ON VEHICLES WHICH REQUIRED THE COMPUTER PROGRAM TO BE MODIFIED, OWNER NOTIFICATION HAS BEGAN.FOR VEHICLES WHICH REQUIRE A NEW COMPUTER MODULE, GM HAS SCHEDULED OWNER NOTIFICATIION TO BEGIN DURING THE LAST WEEK OF MAY 2000.A PHASED MAILING WILL BE REQUIRED, WITH THE LAST MAILING SCHEDULED TO BE COMPLETED BY DECEMBER 2000.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1995 |
| Manufacturer Campaign Number: | 99041 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1125749 |
| Date Owner Notified By Manufacturer: | 20000531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence Summary:
IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Notes:
THE FIRST PHASE OF OWNER NOTIFICATION LETTERS BEGAN MAY 31, 2000,WITH THE LAST MAILING COMPLETED BY OCTOBER 2000. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: STEERING:GEAR BOX:SHAFT SECTOR
-->| NHTSA Campaign Number: | 96V195000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1995 |
| Manufacturer Component Description: | STEERING:GEAR BOX:SHAFT SECTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19950130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 144598 |
| Date Owner Notified By Manufacturer: | 19961008 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961008 |
| Record Creation Date: | 19961017 |
Defect Summary:
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence Summary:
THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Corrective Summary:
DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
Notes:
VEHICLE DESCRIPTION:POSTAL VEHICLES ONLY. OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING LATE OCTOBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-->| NHTSA Campaign Number: | 95V180000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1995 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940901 - 19941101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 73163 |
| Date Owner Notified By Manufacturer: | 19951004 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950922 |
| Record Creation Date: | 19950925 |
Defect Summary:
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence Summary:
IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Corrective Summary:
DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
Notes:
SYSTEM: ENGINE COOLING SYSTEM; FAN.VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND UTILITY VEHICLES EQUIPPED WITH AIR-C0NDITIONING AND 4.3L ENGINES.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1995 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 93V105000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1993 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19921201 - 19921201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 409 |
| Date Owner Notified By Manufacturer: | 19930715 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930621 |
| Record Creation Date: | 19930622 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
THE OUTBOARD REAR SAFETY BELT ASSEMBLY WILL NOT RELEASE THE WEBBING FROM THE RETRACTED POSITION. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS 209, "SEAT BELT ASSEMBLIES."
Consequence Summary:
IF THE OUTBOARD REAR SAFETY BELT ASSEMBLY WILL NOTRELEASE THE WEBBING FROM THE RETRACTED POSITION, SAFETY BELT USE FOR THE SEATOCCUPANT IS IMPOSSIBLE, INCREASING THE RISK OF INJURY IN AN ACCIDENT.
Corrective Summary:
REPLACE ANY BELT THAT DOES NOT FREELY EXTEND FROM THE RETRACTED POSITION.
Notes:
SYSTEM: INTERIOR SYSTEMS, FMVSS 209.VEHICLE DESCRIPTION: 2-DOOR COMPACT UTILITY TRUCKS WITH FOLDING REAR SEATS.
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1993 |
| Manufacturer Campaign Number: | 99041 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1125749 |
| Date Owner Notified By Manufacturer: | 20000531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence Summary:
IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Notes:
THE FIRST PHASE OF OWNER NOTIFICATION LETTERS BEGAN MAY 31, 2000,WITH THE LAST MAILING COMPLETED BY OCTOBER 2000. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: STEERING:GEAR BOX:SHAFT SECTOR
-->| NHTSA Campaign Number: | 96V195000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1993 |
| Manufacturer Component Description: | STEERING:GEAR BOX:SHAFT SECTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19950130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 144598 |
| Date Owner Notified By Manufacturer: | 19961008 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961008 |
| Record Creation Date: | 19961017 |
Defect Summary:
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence Summary:
THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Corrective Summary:
DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
Notes:
VEHICLE DESCRIPTION:POSTAL VEHICLES ONLY. OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING LATE OCTOBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1993 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1992 |
| Manufacturer Campaign Number: | 99041 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1125749 |
| Date Owner Notified By Manufacturer: | 20000531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence Summary:
IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Notes:
THE FIRST PHASE OF OWNER NOTIFICATION LETTERS BEGAN MAY 31, 2000,WITH THE LAST MAILING COMPLETED BY OCTOBER 2000. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: STEERING:GEAR BOX:SHAFT SECTOR
-->| NHTSA Campaign Number: | 96V195000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1992 |
| Manufacturer Component Description: | STEERING:GEAR BOX:SHAFT SECTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19950130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 144598 |
| Date Owner Notified By Manufacturer: | 19961008 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961008 |
| Record Creation Date: | 19961017 |
Defect Summary:
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence Summary:
THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Corrective Summary:
DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
Notes:
VEHICLE DESCRIPTION:POSTAL VEHICLES ONLY. OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING LATE OCTOBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-->| NHTSA Campaign Number: | 93V008000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1992 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880301 - 19911001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 215052 |
| Date Owner Notified By Manufacturer: | 19930115 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930114 |
| Record Creation Date: | 19930129 |
Defect Summary:
THE ENGINE COOLING FAN BLADES BREAK AS A RESULT OF FATIGUE AND/OR VEHICLE INDUCED STRESS.
Consequence Summary:
IF THE BLADE BREAKAGE OCCURS WHILE THE HOOD IS OPEN, APERSON WORKING UNDER THE HOOD OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCKAND INJURED BY THE BLADE SEGMENT.
Corrective Summary:
INSTALL A NEWLY DESIGNED FAN ASSEMBLY.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 2.5 L ENGINES WITHOUT AIR CONDITIONING.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1992 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: VISIBILITY:WINDSHIELD
-->| NHTSA Campaign Number: | 90V107000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1991 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900201 - 19900201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 181 |
| Date Owner Notified By Manufacturer: | 19900615 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19900604 |
| Record Creation Date: | 19900614 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 212 |
Defect Summary:
USE OF IMPROPER PRIMER ON METAL SURFACES OF WINDSHIELD AND SIDE WINDOW OPENINGS COULD CAUSE LOW ADHESION TO THE METAL SURFACE AND WOULD NOT PROVIDE RETENTION REQUIRED BY FMVSS 212.
Consequence Summary:
WINDSHIELD AND SIDE WINDOW GLASS WOULD NOT PREVENT THEEJECTION OF VEHICLE OCCUPANTS DURING A VEHICLE CRASH, WHICH CAUSES SERIOUSINJURIES AND FATALITIES.
Corrective Summary:
REMOVE AND REINSTALL GLASS USING PROPER PRIMER.
Notes:
SYSTEM: WINDSHIELD AND SIDE WINDOW MOUNTING; FMVSS 212.VEHICLE DESCRIPTION: UTILITY, PICKUP, AND EXTENDED CAB PICKUP TRUCKS.
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 99V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1991 |
| Manufacturer Campaign Number: | 99041 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1125749 |
| Date Owner Notified By Manufacturer: | 20000531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19990719 |
| Record Creation Date: | 19990721 |
Defect Summary:
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence Summary:
IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
Notes:
THE FIRST PHASE OF OWNER NOTIFICATION LETTERS BEGAN MAY 31, 2000,WITH THE LAST MAILING COMPLETED BY OCTOBER 2000. OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: S10: STEERING:GEAR BOX:SHAFT SECTOR
-->| NHTSA Campaign Number: | 96V195000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1991 |
| Manufacturer Component Description: | STEERING:GEAR BOX:SHAFT SECTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19950130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 144598 |
| Date Owner Notified By Manufacturer: | 19961008 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961008 |
| Record Creation Date: | 19961017 |
Defect Summary:
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence Summary:
THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Corrective Summary:
DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
Notes:
VEHICLE DESCRIPTION:POSTAL VEHICLES ONLY. OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING LATE OCTOBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-->| NHTSA Campaign Number: | 93V008000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1991 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880301 - 19911001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 215052 |
| Date Owner Notified By Manufacturer: | 19930115 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930114 |
| Record Creation Date: | 19930129 |
Defect Summary:
THE ENGINE COOLING FAN BLADES BREAK AS A RESULT OF FATIGUE AND/OR VEHICLE INDUCED STRESS.
Consequence Summary:
IF THE BLADE BREAKAGE OCCURS WHILE THE HOOD IS OPEN, APERSON WORKING UNDER THE HOOD OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCKAND INJURED BY THE BLADE SEGMENT.
Corrective Summary:
INSTALL A NEWLY DESIGNED FAN ASSEMBLY.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 2.5 L ENGINES WITHOUT AIR CONDITIONING.
CHEVROLET: S10: FUEL SYSTEM, GASOLINE:STORAGE
-->| NHTSA Campaign Number: | 91V108000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1991 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900101 - 19910201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 102885 |
| Date Owner Notified By Manufacturer: | 19910703 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19910621 |
| Record Creation Date: | 19910701 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 301 |
Defect Summary:
VEHICLES HAVE BEEN SHIPPED WITH THE FUEL TANK SENDER SEAL OUT OF POSITION.
Consequence Summary:
IN THE EVENT OF ROLLOVER ACCIDENT, AN OUT OF POSTIONSEAL COULD ALLOW FUEL SPILLAGE IN EXCESS OF THE AMOUNT PRESCRIBED BY FMVSS 301.SPILLED FUEL COULD IGNITE NEAR AN IGNITION SOURCE.
Corrective Summary:
REPLACE SENDER SEALS.
Notes:
SYSTEM: FUEL SYSTEMS; FMVSS 301.VEHICLE DESCRIPTION: LIGHT TRUCKS AND MULTI-PURPOSE VEHICLES.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
-->| NHTSA Campaign Number: | 90V193000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1991 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900801 - 19900801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 237 |
| Date Owner Notified By Manufacturer: | 19901127 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19901114 |
| Record Creation Date: | 19901129 |
Defect Summary:
NUTS USED TO ATTACH LOWER CONTROL ARMS, REAR SPRING AND SHACKLE, AND REAR SHOCK ABSORBERS DO NOT MEET SPECIFICATIONS AND COULD "STRIP".
Consequence Summary:
STRIPPING OF THE NUTS IN THE REAR SUSPENSION COULD REDUCECLAMP LOAD ON LOWER CONTROL ARM, WHICH COULD ALLOW THE ARM TO DETACH, RESULTINGIN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE LOWER CONTROL ARM ATTACHMENT NUTS AS WELL AS REAR SPRING AND SHACKLE, AND REAR SHOCK ABSORBER NUTS.
Notes:
SYSTEM: LOWER CONTROL ARM ATTACHING NUTS.VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1991 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1990 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: STEERING:GEAR BOX:SHAFT SECTOR
-->| NHTSA Campaign Number: | 96V195000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1990 |
| Manufacturer Component Description: | STEERING:GEAR BOX:SHAFT SECTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19950130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 144598 |
| Date Owner Notified By Manufacturer: | 19961008 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961008 |
| Record Creation Date: | 19961017 |
Defect Summary:
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence Summary:
THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Corrective Summary:
DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
Notes:
VEHICLE DESCRIPTION:POSTAL VEHICLES ONLY. OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING LATE OCTOBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-->| NHTSA Campaign Number: | 93V008000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1990 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880301 - 19911001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 215052 |
| Date Owner Notified By Manufacturer: | 19930115 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930114 |
| Record Creation Date: | 19930129 |
Defect Summary:
THE ENGINE COOLING FAN BLADES BREAK AS A RESULT OF FATIGUE AND/OR VEHICLE INDUCED STRESS.
Consequence Summary:
IF THE BLADE BREAKAGE OCCURS WHILE THE HOOD IS OPEN, APERSON WORKING UNDER THE HOOD OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCKAND INJURED BY THE BLADE SEGMENT.
Corrective Summary:
INSTALL A NEWLY DESIGNED FAN ASSEMBLY.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 2.5 L ENGINES WITHOUT AIR CONDITIONING.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1990 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1990 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1989 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: STEERING:GEAR BOX:SHAFT SECTOR
-->| NHTSA Campaign Number: | 96V195000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1989 |
| Manufacturer Component Description: | STEERING:GEAR BOX:SHAFT SECTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19950130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 144598 |
| Date Owner Notified By Manufacturer: | 19961008 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961008 |
| Record Creation Date: | 19961017 |
Defect Summary:
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence Summary:
THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Corrective Summary:
DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
Notes:
VEHICLE DESCRIPTION:POSTAL VEHICLES ONLY. OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING LATE OCTOBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
-->| NHTSA Campaign Number: | 93V008000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1989 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880301 - 19911001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 215052 |
| Date Owner Notified By Manufacturer: | 19930115 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930114 |
| Record Creation Date: | 19930129 |
Defect Summary:
THE ENGINE COOLING FAN BLADES BREAK AS A RESULT OF FATIGUE AND/OR VEHICLE INDUCED STRESS.
Consequence Summary:
IF THE BLADE BREAKAGE OCCURS WHILE THE HOOD IS OPEN, APERSON WORKING UNDER THE HOOD OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCKAND INJURED BY THE BLADE SEGMENT.
Corrective Summary:
INSTALL A NEWLY DESIGNED FAN ASSEMBLY.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 2.5 L ENGINES WITHOUT AIR CONDITIONING.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1989 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1989 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1988 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: STEERING:GEAR BOX:SHAFT SECTOR
-->| NHTSA Campaign Number: | 96V195000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1988 |
| Manufacturer Component Description: | STEERING:GEAR BOX:SHAFT SECTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19950130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 144598 |
| Date Owner Notified By Manufacturer: | 19961008 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961008 |
| Record Creation Date: | 19961017 |
Defect Summary:
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence Summary:
THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Corrective Summary:
DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
Notes:
VEHICLE DESCRIPTION:POSTAL VEHICLES ONLY. OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING LATE OCTOBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1988 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1988 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1987 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: STEERING:LINKAGES:TIE ROD ASSEMBLY
-->| NHTSA Campaign Number: | 87V021000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1987 |
| Manufacturer Component Description: | STEERING:LINKAGES:TIE ROD ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19870131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 60 |
| Date Owner Notified By Manufacturer: | 19870302 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19870225 |
| Record Creation Date: | 19870302 |
Defect Summary:
INNER TIE ROD TO RELAY ROD NUTS ON STEERING LINKAGE MAY BE IIMPROPERLY TORQUED AND NOT CRIMPED.
Consequence Summary:
LOSS OF ONE OR BOTH NUTS COULD LEAD TO INNER TIE RODDISENGAGEMENT, WHICH COULD RESULT IN LOSS OF STEERING CONTROL AND A TRUCKCRASH.
Corrective Summary:
REPLACE STEERING LINKAGE ASSEMBLY.
Notes:
SYSTEM: STEERING LINKAGE.VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS.
CHEVROLET: S10: STEERING:GEAR BOX:SHAFT SECTOR
-->| NHTSA Campaign Number: | 96V195000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1987 |
| Manufacturer Component Description: | STEERING:GEAR BOX:SHAFT SECTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19870101 - 19950130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 144598 |
| Date Owner Notified By Manufacturer: | 19961008 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961008 |
| Record Creation Date: | 19961017 |
Defect Summary:
THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
Consequence Summary:
THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
Corrective Summary:
DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
Notes:
VEHICLE DESCRIPTION:POSTAL VEHICLES ONLY. OWNER NOTIFICATION:OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING LATE OCTOBER 1996. NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1987 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1987 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 86V140000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1986 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19851101 - 19851201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 10064 |
| Date Owner Notified By Manufacturer: | 19861031 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19861021 |
| Record Creation Date: | 19861022 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 120 |
Defect Summary:
TIRE AND WHEEL INFORMATION ON CERTIFICATION LABEL MAY BE INCORRECT. CONSEQUENCE OF DEFECT: TRUCKS FAIL TO COMPLY WITH FMVSS 120.
Corrective Summary:
INSTALL CERTIFIED LABEL WITH CORRECT INFORMATION.
Notes:
SYSTEM: CERTIFICATION LABELS/FMVSS 120. VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1986 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1985 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1985 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1985 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1984 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: SEATS:FRONT ASSEMBLY:RECLINER
-->| NHTSA Campaign Number: | 84V011000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1984 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:RECLINER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19830701 - 19830901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 76586 |
| Date Owner Notified By Manufacturer: | 19840224 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840206 |
| Record Creation Date: | 19840222 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 207 |
Defect Summary:
SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.
Corrective Summary:
INSPECTION OF SEAT BACK LOCKS WILL BE PERFORMED. LOCKS THAT HAVE BENT, BROKEN OR MISSING HOOKS WILL BE REPLACED.
Notes:
VEHICLE DESCRIPTION: TWO DOOR PASSENGER VEHICLES AND LIGHT TRUCKS EQUIPPED WITHAR9 OR AV5 BUCKET SEATS.SYSTEM: INTERIOR SYSTEMS, SEAT BACK LOCKS.CONSEQUENCES OF DEFECT: THE SEAT MAY FOLD FORWARD IN A CRASH, AND WOULDINCREASE THE LIKELIHOOD OF INJURY TO THE SEAT OCCUPANT.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1984 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1984 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1983 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: POWER TRAIN:MANUAL TRANSMISSION:LUBRICANT
-->| NHTSA Campaign Number: | 84V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1983 |
| Manufacturer Component Description: | POWER TRAIN:MANUAL TRANSMISSION:LUBRICANT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820201 - 19820801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 35919 |
| Date Owner Notified By Manufacturer: | 19840726 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840618 |
| Record Creation Date: | 19840710 |
Defect Summary:
REAR WHEELS MAY LOCK SUDDENLY DUE TO INSUFFICIENT LUBRICATION BETWEEN MAINSHAFT AND FIRST GEAR.
Corrective Summary:
DEALER WILL REPLACE TRANSMISSION FLUID WITH A BLENDED FLUID AND IN ADDITION, WILL UPDATE THE MAINTENANCE SCHEDULE.
Notes:
VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH 5-SPEED MANUAL TRANSMISSIONS.SYSTEM: TRANSMISSION; LUBRICATION.CONSEQUENCES OF DEFECT: WHEN VEHICLE IS IN FIFTH GEAR, THE TRANSMISSION COULDLOCK THE REAR WHEELS, POSSIBLY RESULTING IN SUDDEN LOSS OF CONTROL AND ANACCIDENT.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1983 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1983 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E049000 |
| Vehicle/Equipment Make: | CK MOTORSPORT, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1982 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27176 |
| Date Owner Notified By Manufacturer: | 20060701 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | CK MOTORSPORT, INC. |
| Report Received Date: | 20060524 |
| Record Creation Date: | 20060605 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS
-->| NHTSA Campaign Number: | 85V048000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1982 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1810000 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19850429 |
| Record Creation Date: | 19850501 |
Defect Summary:
EXCESSIVE ENLARGEMENT OF THE WHEEL CYLINDER PILOT HOLE IN THE REAR BRAKE BACKING PLATE COULD ALLOW THE WHEEL CYLINDER TO ROTATE AND CAUSE LOSS OF BRAKE FLUID. CONSEQUENCE OF DEFECT: A LOSS OF BRAKE FLUID LEADS TO LOSS OF REAR BRAKE ACTION, CREATING THE POTENTIAL FOR AN ACCIDENT. FRONT BRAKES WOULD REMAIN OPERATIONAL.
Corrective Summary:
ADD A PART TO PREVENT WHEEL CYLINDER FROM ROTATING.
Notes:
NOTE: OWNER NOTIFICATION WILL BEGIN AFTER SEPTEMBER 1, 1985 AND SHOULD BE COMPLETED BY SEPTEMBER 30, 1985.VEHICLE DESCRIPTION: MIDSIZE PASSENGER CARS AND SMALL TRUCKS. SYSTEM: REAR BRAKES.
CHEVROLET: S10: POWER TRAIN:MANUAL TRANSMISSION:LUBRICANT
-->| NHTSA Campaign Number: | 84V073000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1982 |
| Manufacturer Component Description: | POWER TRAIN:MANUAL TRANSMISSION:LUBRICANT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19820201 - 19820801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 35919 |
| Date Owner Notified By Manufacturer: | 19840726 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19840618 |
| Record Creation Date: | 19840710 |
Defect Summary:
REAR WHEELS MAY LOCK SUDDENLY DUE TO INSUFFICIENT LUBRICATION BETWEEN MAINSHAFT AND FIRST GEAR.
Corrective Summary:
DEALER WILL REPLACE TRANSMISSION FLUID WITH A BLENDED FLUID AND IN ADDITION, WILL UPDATE THE MAINTENANCE SCHEDULE.
Notes:
VEHICLE DESCRIPTION: LIGHT TRUCKS EQUIPPED WITH 5-SPEED MANUAL TRANSMISSIONS.SYSTEM: TRANSMISSION; LUBRICATION.CONSEQUENCES OF DEFECT: WHEN VEHICLE IS IN FIFTH GEAR, THE TRANSMISSION COULDLOCK THE REAR WHEELS, POSSIBLY RESULTING IN SUDDEN LOSS OF CONTROL AND ANACCIDENT.
CHEVROLET: S10: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1982 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: S10: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | S10 |
| Model Year: | 1982 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: SILVERADO: STEERING:LINKAGES
| NHTSA Campaign Number: | 11V339000 |
| Vehicle/Equipment Make: | GENERAL MOTORS LLC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 11191 |
| Manufacturer Component Description: | STEERING:LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 739 |
| Date Owner Notified By Manufacturer: | 20110725 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS LLC |
| Report Received Date: | 20110628 |
| Record Creation Date: | 20110629 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2011CADILLAC ESCALADE, ESCALADE ESV; CHEVROLET SILVERADO HD, SILVERADO LD, SUBURBAN, TAHOE; AND GMC SIERRA HD, SIERRA LD, YUKON, AND YUKON XL VEHICLES. THE INTERMEDIATE STEERING SHAFT ATTACHING BOLTS MAY NOT HAVE BEEN TIGHTENED TO THE PROPER SPECIFICATION.
Consequence Summary:
THIS COULD ALLOW THE JOINTS TO SEPARATE, AND THE DRIVER COULD EXPERIENCE LOSS OF STEERING INCREASING THE RISK OF A CRASH.
Corrective Summary:
GM DEALERS WILL INSPECT AND ENSURE THAT THE INTERMEDIATE STEERING SHAFT BOLTS ARE TIGHTENED TO THE PROPER SPECIFICATION. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 13, 2011. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Notes:
GM'S SAFETY RECALL NO. 11191.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: SILVERADO 1500: SUSPENSION:REAR:AXLE:SPINDLE
| NHTSA Campaign Number: | 10V643000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO 1500 |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 100426 |
| Manufacturer Component Description: | SUSPENSION:REAR:AXLE:SPINDLE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1262 |
| Date Owner Notified By Manufacturer: | 20110111 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20101217 |
| Record Creation Date: | 20101222 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE EXT, CHEVROLET AVALANCHE, SILVERADO LD AND GMC SIERRA LD VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
GM SAFETY RECALL NO. 100426.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
-- CHEVROLET: SILVERADO 1500: SUSPENSION:REAR:AXLE:SPINDLE Go Back To 2011 GENERAL MOTORS CORP. Directory NHTSA Campaign Number: 11V007000 Vehicle/Equipment Make: GENERAL MOTORS CORP. Vehicle/Equipment Model: SILVERADO 1500 Model Year: 2011 Manufacturer Campaign Number: 10426A Manufacturer Component Description: SUSPENSION:REAR:AXLE:SPINDLE Manufacturers Involved in Recall: GENERAL MOTORS LLC Manufacturered: 20101118 - 20110103 Type of Report: V (Vehicle, Equipment or Tire) Potential Number of Units Affected: 30566 Date Owner Notified By Manufacturer: 20110111 Recall Initiated By: MFR Manufacturer Responsible For Recall: GENERAL MOTORS CORP. Report Received Date: 20110106 Record Creation Date: 20110111 Defect Summary: GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK. Consequence Summary: THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING. Corrective Summary: DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM. Notes: THIS RECALL CAMPAIGN IS AN EXPANSION TO 10V-643.GM'S SAFETY RECALL NO. 10426A.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV . -- --CHEVROLET: SILVERADO: EQUIPMENT
-->| NHTSA Campaign Number: | 10E043000 |
| Vehicle/Equipment Make: | MARATHON SEAT COVERS, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2010 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 294 |
| Date Owner Notified By Manufacturer: | 20100914 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | MARATHON SEAT COVERS, INC. |
| Report Received Date: | 20100903 |
| Record Creation Date: | 20100910 |
Defect Summary:
MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.
Consequence Summary:
AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
Corrective Summary:
MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET MARATHON SEAT COVERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON GENERAL MOTORS, FORD, CHRYSLER, TOYOTA, OR NISSAN VEHICLES.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SILVERADO: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 08V441000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 8048 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20070430 - 20071130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 857735 |
| Date Owner Notified By Manufacturer: | 20080912 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080828 |
| Record Creation Date: | 20080828 |
Defect Summary:
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence Summary:
THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08048. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2008 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT:ELECTRICAL
-->| NHTSA Campaign Number: | 07E066000 |
| Vehicle/Equipment Make: | CEQUENT ELECTRICAL PRODUCTS |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2007 |
| Manufacturer Component Description: | EQUIPMENT:ELECTRICAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 175 |
| Date Owner Notified By Manufacturer: | 20070905 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CEQUENT ELECTRICAL PRODUCTS |
| Report Received Date: | 20070828 |
| Record Creation Date: | 20070829 |
Defect Summary:
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence Summary:
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Corrective Summary:
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 08V441000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 8048 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050930 - 20070731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 857735 |
| Date Owner Notified By Manufacturer: | 20080912 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080828 |
| Record Creation Date: | 20080828 |
Defect Summary:
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence Summary:
THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08048. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SILVERADO: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2007 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2007 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 05V552000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5109 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050901 - 20050907 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 32068 |
| Date Owner Notified By Manufacturer: | 20060331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051207 |
| Record Creation Date: | 20051207 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence Summary:
A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Notes:
GM RECALL NO. 05109.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E064000 |
| Vehicle/Equipment Make: | TRADESONIC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2006 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4029 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | TRADESONIC |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Notes:
THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT:ELECTRICAL
-->| NHTSA Campaign Number: | 07E066000 |
| Vehicle/Equipment Make: | CEQUENT ELECTRICAL PRODUCTS |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2006 |
| Manufacturer Component Description: | EQUIPMENT:ELECTRICAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 175 |
| Date Owner Notified By Manufacturer: | 20070905 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CEQUENT ELECTRICAL PRODUCTS |
| Report Received Date: | 20070828 |
| Record Creation Date: | 20070829 |
Defect Summary:
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence Summary:
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Corrective Summary:
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
-->| NHTSA Campaign Number: | 05V455000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5086 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050701 - 20050831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 123592 |
| Date Owner Notified By Manufacturer: | 20051014 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051005 |
| Record Creation Date: | 20051006 |
Defect Summary:
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence Summary:
IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05086.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 06V289000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 6080 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050501 - 20060430 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 38439 |
| Date Owner Notified By Manufacturer: | 20060831 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060803 |
| Record Creation Date: | 20060803 |
Defect Summary:
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence Summary:
IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Notes:
GM RECALL NO. 06080.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: WHEELS:RIM
-->| NHTSA Campaign Number: | 06V307000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 6079 |
| Manufacturer Component Description: | WHEELS:RIM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20060401 - 20060531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3227 |
| Date Owner Notified By Manufacturer: | 20061107 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060811 |
| Record Creation Date: | 20060811 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES AND TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES HAVE AN INCOMPLETE TIRE RIM DESIGNATION ON THE CERTIFICATION/TIRE LABEL LOCATED ON THE DRIVER'S DOOR EDGE. IN ADDITION, THE LABEL MAY ALSO BE MISSING THE TIRE LOAD RATING ON THE LABEL. ALTHOUGH THIS INFORMATION IS NOT REQUIRED BY THE STANDARD, IF A TIRE OF A LESSER LOAD RATING IS INSTALLED, THE TIRE MAY NOT BE ABLE TO SUSTAIN THE LOADS ENCOUNTERED DURING USE.
Consequence Summary:
IF A CUSTOMER REPLACES A WHEEL AND ONLY RELIES ON THE RIM SIZE DESIGNATION THAT IS INDICATED ON THE LABEL, A WHEEL THAT IS OF A DIFFERENT RIM CONTOUR DESIGNATION MAY BE INSTALLED. IT MAY BE DIFFICULT OR IMPOSSIBLE TO MOUNT THE TIRE ON A WHEEL WITH THE WRONG CONTOUR. IF THE TIRE IS MOUNTED ON THE WHEEL WITH THE WRONG CONTOUR, THE WHEEL AND TIRE MAY NOT PERFORM AS INTENDED, WHICH COULD INCREASE THE RISK OF A CRASH.
Corrective Summary:
A LABEL THAT WILL CORRECT THE LABEL ORIGINALLY INSTALLED WILL BE MAILED TO CONSUMERS ALONG WITH INSTALLATION INSTRUCTIONS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL. THE RECALL BEGAON ON NOVEMBER 7, 2006. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2239, CHEVROLET AT 1-800-630-2438, AND GMC TRUCKS AT 1-866-996-9463.
Notes:
GM RECALL NO. 06079.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2006 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2006 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2006 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E023000 |
| Vehicle/Equipment Make: | ANZO USA, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2006 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 292000 |
| Date Owner Notified By Manufacturer: | 20060509 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ANZO USA, INC. |
| Report Received Date: | 20060313 |
| Record Creation Date: | 20060314 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: PARKING BRAKE
-->| NHTSA Campaign Number: | 05V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5042 |
| Manufacturer Component Description: | PARKING BRAKE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040401 - 20040831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 90242 |
| Date Owner Notified By Manufacturer: | 20050729 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence Summary:
IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05042.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E064000 |
| Vehicle/Equipment Make: | TRADESONIC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4029 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | TRADESONIC |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Notes:
THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT:ELECTRICAL
-->| NHTSA Campaign Number: | 07E066000 |
| Vehicle/Equipment Make: | CEQUENT ELECTRICAL PRODUCTS |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Component Description: | EQUIPMENT:ELECTRICAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 175 |
| Date Owner Notified By Manufacturer: | 20070905 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CEQUENT ELECTRICAL PRODUCTS |
| Report Received Date: | 20070828 |
| Record Creation Date: | 20070829 |
Defect Summary:
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence Summary:
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Corrective Summary:
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040224 - 20041102 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
-->| NHTSA Campaign Number: | 05V455000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5086 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050701 - 20050831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 123592 |
| Date Owner Notified By Manufacturer: | 20051014 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051005 |
| Record Creation Date: | 20051006 |
Defect Summary:
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence Summary:
IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05086.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 05V043000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5006 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040401 - 20040930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77411 |
| Date Owner Notified By Manufacturer: | 20050323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050208 |
| Record Creation Date: | 20050208 |
Defect Summary:
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence Summary:
IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05006.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 04V376000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 4066 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040625 - 20040726 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1103 |
| Date Owner Notified By Manufacturer: | 20040730 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040802 |
| Record Creation Date: | 20040805 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence Summary:
IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Notes:
GM RECALL NO. 04066.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATIONGM RECALL NO. 04066.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR
-->| NHTSA Campaign Number: | 05V055000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5023 |
| Manufacturer Component Description: | POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050101 - 20050228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 7194 |
| Date Owner Notified By Manufacturer: | 20050222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050214 |
| Record Creation Date: | 20050215 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 102 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence Summary:
THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Corrective Summary:
DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05023.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: STEERING:GEAR BOX:SHAFT SECTOR
-->| NHTSA Campaign Number: | 05V018000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5010 |
| Manufacturer Component Description: | STEERING:GEAR BOX:SHAFT SECTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20041201 - 20050131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3344 |
| Date Owner Notified By Manufacturer: | 20050126 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050121 |
| Record Creation Date: | 20050127 |
Defect Summary:
ON CERTAIN TRUCKS, THE BOLT THAT ATTACHES THE INTERMEDIATE STEERING SHAFT TO THE STEERING GEAR MAY NOT MEET SPECIFICATION. THE BOLT MAY FRACTURE RESULTING IN THE LOSS OF STEERING.
Consequence Summary:
IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REPLACE THE INTERMEDIATE STEERING SHAFT BOLT FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS MAY CONTACT GMC AT 1-866-996-9463 AND CHEVROLET AT 1-800-630-2438.
Notes:
GM RECALL NO.05010.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 06V289000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 6080 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040301 - 20050731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 38439 |
| Date Owner Notified By Manufacturer: | 20060831 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060803 |
| Record Creation Date: | 20060803 |
Defect Summary:
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence Summary:
IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Notes:
GM RECALL NO. 06080.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E023000 |
| Vehicle/Equipment Make: | ANZO USA, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2005 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 292000 |
| Date Owner Notified By Manufacturer: | 20060509 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ANZO USA, INC. |
| Report Received Date: | 20060313 |
| Record Creation Date: | 20060314 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 06V417000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 6102 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030901 - 20040131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 794 |
| Date Owner Notified By Manufacturer: | 20061106 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20061031 |
| Record Creation Date: | 20061101 |
Defect Summary:
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence Summary:
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Corrective Summary:
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Notes:
GM RECALL NO. 06102.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT
-->| NHTSA Campaign Number: | 04E022000 |
| Vehicle/Equipment Make: | DURAKON INDUSTRIES, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 8000 |
| Date Owner Notified By Manufacturer: | 20040331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DURAKON INDUSTRIES, INC. |
| Report Received Date: | 20040323 |
| Record Creation Date: | 20040330 |
Defect Summary:
AFTERMARKET PICKUP TRUCK OVER-THE-RAIL BEDLINERS MANUFACTURED FOR INSTALLATION ON 1999-2004 CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS. THE TOGGLE WING ASSEMBLY USED TO ATTACH THE BEDLINER TO THE TRUCK BED IS NOT ENGAGING FULLY IN THE STAKE POCKET OF THE PICKUP TRUCK.
Consequence Summary:
THE BEDLINER CAN BECOME DETACHED FROM THE PICKUP WHILE IT IS MOTION, POSSIBLY ENDANGERING FOLLOWING MOTORISTS OR PEDESTRIANS.
Corrective Summary:
DURAKON WILL ISSUE A PRESS RELEASE IN ATTEMPT TO NOTIFY CUSTOMERS THAT COULD HAVE PURCHASED THE DEFECTIVE BEDLINER. IF YOU PURCHASED EITHER A DURAKON ALLSTAR OF PATRIOT OVERRAIL BEDLINER SINCE AUGUST 1, 2003, FOR 1999 TO 2004 CHEVROLET SILVERADO OR GMC SIERRA TRUCKS, OR PURCHASED ONE OF THESE PICKUP TRUCKS WITH EITHER BRAND BEDLINER ALREADY INSTALLED, YOU SHOULD RETURN TO AN AUTHORIZED DURAKON DEALER SO THAT THE BEDLINER CAN BE INSPECTED AND, IF NECESSARY, REPAIRED WITH A NEWLY DESIGNED TOGGLE WING FASTENING SYSTEM, OR IF REQUIRED, REPLACED WITH A NEW BEDLINER FREE OF CHARGE. PLEASE CALL THE DURAKON HOTLINE AT 1-800-933-4200 TO FIND THE NEAREST AUTHORIZED DURAKON DEALER.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET OVERRAIL BEDLINERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS BY GENERAL MOTORS.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 04V225000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4038 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030801 - 20040331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 736 |
| Date Owner Notified By Manufacturer: | 20040909 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040511 |
| Record Creation Date: | 20040512 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Consequence Summary:
THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Corrective Summary:
TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04038.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 04V045000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4004 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030501 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 68875 |
| Date Owner Notified By Manufacturer: | 20040618 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 135 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence Summary:
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective Summary:
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: PARKING BRAKE
-->| NHTSA Campaign Number: | 05V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5042 |
| Manufacturer Component Description: | PARKING BRAKE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030401 - 20040831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 90242 |
| Date Owner Notified By Manufacturer: | 20050729 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence Summary:
IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05042.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E064000 |
| Vehicle/Equipment Make: | TRADESONIC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4029 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | TRADESONIC |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Notes:
THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT:ELECTRICAL
-->| NHTSA Campaign Number: | 07E066000 |
| Vehicle/Equipment Make: | CEQUENT ELECTRICAL PRODUCTS |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Component Description: | EQUIPMENT:ELECTRICAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 175 |
| Date Owner Notified By Manufacturer: | 20070905 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CEQUENT ELECTRICAL PRODUCTS |
| Report Received Date: | 20070828 |
| Record Creation Date: | 20070829 |
Defect Summary:
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence Summary:
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Corrective Summary:
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
-->| NHTSA Campaign Number: | 04V129000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4007 |
| Manufacturer Component Description: | STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030301 - 20031130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3662211 |
| Date Owner Notified By Manufacturer: | 20040918 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040317 |
| Record Creation Date: | 20040322 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence Summary:
ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Corrective Summary:
DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Notes:
GM RECALL NO. 04007.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030408 - 20040804 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 05V043000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5006 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040201 - 20040831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77411 |
| Date Owner Notified By Manufacturer: | 20050323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050208 |
| Record Creation Date: | 20050208 |
Defect Summary:
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence Summary:
IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05006.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 06V289000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 6080 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030301 - 20040831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 38439 |
| Date Owner Notified By Manufacturer: | 20060831 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060803 |
| Record Creation Date: | 20060803 |
Defect Summary:
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence Summary:
IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Notes:
GM RECALL NO. 06080.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E023000 |
| Vehicle/Equipment Make: | ANZO USA, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 292000 |
| Date Owner Notified By Manufacturer: | 20060509 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ANZO USA, INC. |
| Report Received Date: | 20060313 |
| Record Creation Date: | 20060314 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT
-->| NHTSA Campaign Number: | 04E022000 |
| Vehicle/Equipment Make: | DURAKON INDUSTRIES, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 8000 |
| Date Owner Notified By Manufacturer: | 20040331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DURAKON INDUSTRIES, INC. |
| Report Received Date: | 20040323 |
| Record Creation Date: | 20040330 |
Defect Summary:
AFTERMARKET PICKUP TRUCK OVER-THE-RAIL BEDLINERS MANUFACTURED FOR INSTALLATION ON 1999-2004 CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS. THE TOGGLE WING ASSEMBLY USED TO ATTACH THE BEDLINER TO THE TRUCK BED IS NOT ENGAGING FULLY IN THE STAKE POCKET OF THE PICKUP TRUCK.
Consequence Summary:
THE BEDLINER CAN BECOME DETACHED FROM THE PICKUP WHILE IT IS MOTION, POSSIBLY ENDANGERING FOLLOWING MOTORISTS OR PEDESTRIANS.
Corrective Summary:
DURAKON WILL ISSUE A PRESS RELEASE IN ATTEMPT TO NOTIFY CUSTOMERS THAT COULD HAVE PURCHASED THE DEFECTIVE BEDLINER. IF YOU PURCHASED EITHER A DURAKON ALLSTAR OF PATRIOT OVERRAIL BEDLINER SINCE AUGUST 1, 2003, FOR 1999 TO 2004 CHEVROLET SILVERADO OR GMC SIERRA TRUCKS, OR PURCHASED ONE OF THESE PICKUP TRUCKS WITH EITHER BRAND BEDLINER ALREADY INSTALLED, YOU SHOULD RETURN TO AN AUTHORIZED DURAKON DEALER SO THAT THE BEDLINER CAN BE INSPECTED AND, IF NECESSARY, REPAIRED WITH A NEWLY DESIGNED TOGGLE WING FASTENING SYSTEM, OR IF REQUIRED, REPLACED WITH A NEW BEDLINER FREE OF CHARGE. PLEASE CALL THE DURAKON HOTLINE AT 1-800-933-4200 TO FIND THE NEAREST AUTHORIZED DURAKON DEALER.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET OVERRAIL BEDLINERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS BY GENERAL MOTORS.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: SEAT BELTS:FRONT:ANCHORAGE
-->| NHTSA Campaign Number: | 04V225000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4038 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020601 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 736 |
| Date Owner Notified By Manufacturer: | 20040909 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040511 |
| Record Creation Date: | 20040512 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Consequence Summary:
THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Corrective Summary:
TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04038.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 04V045000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4004 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030501 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 68875 |
| Date Owner Notified By Manufacturer: | 20040618 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 135 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence Summary:
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective Summary:
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: PARKING BRAKE
-->| NHTSA Campaign Number: | 05V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 5042 |
| Manufacturer Component Description: | PARKING BRAKE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030401 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 90242 |
| Date Owner Notified By Manufacturer: | 20050729 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence Summary:
IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05042.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E064000 |
| Vehicle/Equipment Make: | TRADESONIC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 4029 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | TRADESONIC |
| Report Received Date: | 20060717 |
| Record Creation Date: | 20060717 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Corrective Summary:
TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Notes:
THIS RECALL ONLY PERTAINS TO TRADESONIC AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT:ELECTRICAL
-->| NHTSA Campaign Number: | 07E066000 |
| Vehicle/Equipment Make: | CEQUENT ELECTRICAL PRODUCTS |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Component Description: | EQUIPMENT:ELECTRICAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 175 |
| Date Owner Notified By Manufacturer: | 20070905 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CEQUENT ELECTRICAL PRODUCTS |
| Report Received Date: | 20070828 |
| Record Creation Date: | 20070829 |
Defect Summary:
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence Summary:
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Corrective Summary:
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
-->| NHTSA Campaign Number: | 04V129000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4007 |
| Manufacturer Component Description: | STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3662211 |
| Date Owner Notified By Manufacturer: | 20040918 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040317 |
| Record Creation Date: | 20040322 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence Summary:
ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Corrective Summary:
DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Notes:
GM RECALL NO. 04007.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020403 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: VISIBILITY:WINDSHIELD
-->| NHTSA Campaign Number: | 03V018000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3001 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20021027 - 20031028 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 110 |
| Date Owner Notified By Manufacturer: | 20030128 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030123 |
| Record Creation Date: | 20030205 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 212 |
Defect Summary:
CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." SOME OF THESE VEHICLES LACK A CONTINUOUS URETHANE BONDING BEAD BETWEEN THE BODY SURFACE AND THE WINDSHIELD.
Consequence Summary:
IN VEHICLES WITH THIS CONDITION, THE WINDSHIELD MAY NOT BE RETAINED IN ACCORDANCE WITH THE SAFETY STANDARD DURING A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REMOVE, RESEAL, AND REINSTALL THE WINDSHIELD. OWNER NOTIFICATION BEGAN ON JANUARY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03001. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E023000 |
| Vehicle/Equipment Make: | ANZO USA, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 292000 |
| Date Owner Notified By Manufacturer: | 20060509 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | ANZO USA, INC. |
| Report Received Date: | 20060313 |
| Record Creation Date: | 20060314 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET HEADLAMP ASSEMBLIES MANUFACTURED BY ANZO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: FUEL SYSTEM, OTHER:DELIVERY
-->| NHTSA Campaign Number: | 03V435000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 3053 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:DELIVERY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20011001 - 20020630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 395 |
| Date Owner Notified By Manufacturer: | 20031203 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20031103 |
| Record Creation Date: | 20031029 |
Defect Summary:
SOME 2WD AND 4WD PICKUP TRUCKS, CONVERTED TO EITHER DEDICATED OR BI-FUEL COMPRESSED NATURAL GAS (CNG) FUEL USAGE, WERE ASSEMBLED WITH A THROTTLE CABLE THAT CAN CONTACT AND RUB THROUGH THE FLEXIBLE PRESSURIZED FUEL LINE CREATING A PINHOLE LEAK OF NATURAL GAS TO THE ATMOSPHERE.
Consequence Summary:
A STRONG ODOR OF NATURAL GAS MAY BE DETECTED FROM INSIDE THE VEHICLE, POSSIBLY ACCOMPANIED BY A HISSING NOISE. IF THE NATURAL GAS WERE ACCIDENTALLY IGNITED, SERIOUS INJURY COULD RESULT.
Corrective Summary:
DEALERS WILL SECURE THE THROTTLE CABLE TO ELIMINATE THE POSSIBILITY OF CONTACT WITH THE CNG FUEL LINE. THE CNG FUEL LINE, THROTTLE CABLE, AND CRUISE CONTROL CABLE ARE ALSO TO BE INSPECTED AND REPLACED IF NECESSARY. OWNER NOTIFICATION BEGAN ON DECEMBER 11, 2003. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 03053.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SILVERADO: EQUIPMENT
-->| NHTSA Campaign Number: | 04E022000 |
| Vehicle/Equipment Make: | DURAKON INDUSTRIES, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 8000 |
| Date Owner Notified By Manufacturer: | 20040331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DURAKON INDUSTRIES, INC. |
| Report Received Date: | 20040323 |
| Record Creation Date: | 20040330 |
Defect Summary:
AFTERMARKET PICKUP TRUCK OVER-THE-RAIL BEDLINERS MANUFACTURED FOR INSTALLATION ON 1999-2004 CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS. THE TOGGLE WING ASSEMBLY USED TO ATTACH THE BEDLINER TO THE TRUCK BED IS NOT ENGAGING FULLY IN THE STAKE POCKET OF THE PICKUP TRUCK.
Consequence Summary:
THE BEDLINER CAN BECOME DETACHED FROM THE PICKUP WHILE IT IS MOTION, POSSIBLY ENDANGERING FOLLOWING MOTORISTS OR PEDESTRIANS.
Corrective Summary:
DURAKON WILL ISSUE A PRESS RELEASE IN ATTEMPT TO NOTIFY CUSTOMERS THAT COULD HAVE PURCHASED THE DEFECTIVE BEDLINER. IF YOU PURCHASED EITHER A DURAKON ALLSTAR OF PATRIOT OVERRAIL BEDLINER SINCE AUGUST 1, 2003, FOR 1999 TO 2004 CHEVROLET SILVERADO OR GMC SIERRA TRUCKS, OR PURCHASED ONE OF THESE PICKUP TRUCKS WITH EITHER BRAND BEDLINER ALREADY INSTALLED, YOU SHOULD RETURN TO AN AUTHORIZED DURAKON DEALER SO THAT THE BEDLINER CAN BE INSPECTED AND, IF NECESSARY, REPAIRED WITH A NEWLY DESIGNED TOGGLE WING FASTENING SYSTEM, OR IF REQUIRED, REPLACED WITH A NEW BEDLINER FREE OF CHARGE. PLEASE CALL THE DURAKON HOTLINE AT 1-800-933-4200 TO FIND THE NEAREST AUTHORIZED DURAKON DEALER.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET OVERRAIL BEDLINERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS BY GENERAL MOTORS.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: PARKING BRAKE
-->| NHTSA Campaign Number: | 05V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 5042 |
| Manufacturer Component Description: | PARKING BRAKE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010301 - 20020630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 90242 |
| Date Owner Notified By Manufacturer: | 20050729 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence Summary:
IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05042.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E075000 |
| Vehicle/Equipment Make: | GUIDE CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 17268 |
| Date Owner Notified By Manufacturer: | 20060831 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GUIDE CORPORATION |
| Report Received Date: | 20060828 |
| Record Creation Date: | 20060828 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN GUIDE REPLACEMENT HEADLAMPS, P/NOS. 16526133 AND 16526134, MANUFACTURED FROM JANUARY 1 TO JULY 11, 2006, SOLD FOR USE ON MY 1999-2002 CHEVROLET SILVERADO PICKUP TRUCKS. THE HEADLAMP FAIL TO COMPLY WITH THE PHOTOMETRY REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
TOO MUCH LIGHT IN CERTAIN POINTS OF THE HEADLAMP COULD CREATE A DISTRACTION, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
GUIDE CORPORATION WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT GUIDE AT 248-874-0355.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET GUIDE HEADLAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT:ELECTRICAL
-->| NHTSA Campaign Number: | 07E066000 |
| Vehicle/Equipment Make: | CEQUENT ELECTRICAL PRODUCTS |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EQUIPMENT:ELECTRICAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 175 |
| Date Owner Notified By Manufacturer: | 20070905 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CEQUENT ELECTRICAL PRODUCTS |
| Report Received Date: | 20070828 |
| Record Creation Date: | 20070829 |
Defect Summary:
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence Summary:
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Corrective Summary:
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
-->| NHTSA Campaign Number: | 04V129000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 4007 |
| Manufacturer Component Description: | STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001001 - 20020731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3662211 |
| Date Owner Notified By Manufacturer: | 20040918 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040317 |
| Record Creation Date: | 20040322 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence Summary:
ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Corrective Summary:
DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Notes:
GM RECALL NO. 04007.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 05V379000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 5068 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010101 - 20020831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1353718 |
| Date Owner Notified By Manufacturer: | 20050922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050829 |
| Record Creation Date: | 20050829 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Consequence Summary:
THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05068. GM REVISED THE INVOLVED VEHICLES BY AMENDING THE ORIGINAL 573 REPORT ON OCTOBER 4, 2005. GM REVISED THE ORIGINAL 573 REPORT ON DECEMBER 16, 2005, TO INCLUDE ADDITIONAL STATES AND VEHICLE POPULATION.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E057000 |
| Vehicle/Equipment Make: | MAXZONE AUTO PARTS CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12861 |
| Date Owner Notified By Manufacturer: | 20060710 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | MAXZONE AUTO PARTS CORPORATION |
| Report Received Date: | 20060623 |
| Record Creation Date: | 20060623 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 332-1182L-AS AND 332-1182R-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 1999-2000 CHEVROLET SILVERADOS. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
MAXZONE WILL NOTIFY OWNERS AND OFFER FOR REIMBURSEMENT ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 10, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E042000 |
| Vehicle/Equipment Make: | SABRY LEE, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15974 |
| Date Owner Notified By Manufacturer: | 20060510 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABRY LEE, INC. |
| Report Received Date: | 20060522 |
| Record Creation Date: | 20060522 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN EAGLE EYES REPLACEMENT HEADLAMPS, MODEL NOS. GM159-B001L AND GM159-B001R, SOLD FOR USE ON 1999-2002 CHEVROLET SILVERADO MODEL VEHICLES. THE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
THE HEADLAMPS HAVE DECREASED LIGHTING VISIBILITY WHICH COULD RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABRY LEE WILL NOTIFY OWNERS AND ISSUE FULL CREDIT. THE RECALL BEGAN ON MAY 10, 2006. OWNERS MAY CONTACT SABRY LEE AT 1-866-467-2279.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET EAGLE EYES HEADLAMP ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SILVERADO: EQUIPMENT
-->| NHTSA Campaign Number: | 04E022000 |
| Vehicle/Equipment Make: | DURAKON INDUSTRIES, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 8000 |
| Date Owner Notified By Manufacturer: | 20040331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DURAKON INDUSTRIES, INC. |
| Report Received Date: | 20040323 |
| Record Creation Date: | 20040330 |
Defect Summary:
AFTERMARKET PICKUP TRUCK OVER-THE-RAIL BEDLINERS MANUFACTURED FOR INSTALLATION ON 1999-2004 CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS. THE TOGGLE WING ASSEMBLY USED TO ATTACH THE BEDLINER TO THE TRUCK BED IS NOT ENGAGING FULLY IN THE STAKE POCKET OF THE PICKUP TRUCK.
Consequence Summary:
THE BEDLINER CAN BECOME DETACHED FROM THE PICKUP WHILE IT IS MOTION, POSSIBLY ENDANGERING FOLLOWING MOTORISTS OR PEDESTRIANS.
Corrective Summary:
DURAKON WILL ISSUE A PRESS RELEASE IN ATTEMPT TO NOTIFY CUSTOMERS THAT COULD HAVE PURCHASED THE DEFECTIVE BEDLINER. IF YOU PURCHASED EITHER A DURAKON ALLSTAR OF PATRIOT OVERRAIL BEDLINER SINCE AUGUST 1, 2003, FOR 1999 TO 2004 CHEVROLET SILVERADO OR GMC SIERRA TRUCKS, OR PURCHASED ONE OF THESE PICKUP TRUCKS WITH EITHER BRAND BEDLINER ALREADY INSTALLED, YOU SHOULD RETURN TO AN AUTHORIZED DURAKON DEALER SO THAT THE BEDLINER CAN BE INSPECTED AND, IF NECESSARY, REPAIRED WITH A NEWLY DESIGNED TOGGLE WING FASTENING SYSTEM, OR IF REQUIRED, REPLACED WITH A NEW BEDLINER FREE OF CHARGE. PLEASE CALL THE DURAKON HOTLINE AT 1-800-933-4200 TO FIND THE NEAREST AUTHORIZED DURAKON DEALER.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET OVERRAIL BEDLINERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS BY GENERAL MOTORS.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: PARKING BRAKE
-->| NHTSA Campaign Number: | 05V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 5042 |
| Manufacturer Component Description: | PARKING BRAKE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000401 - 20010731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 90242 |
| Date Owner Notified By Manufacturer: | 20050729 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence Summary:
IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05042.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E075000 |
| Vehicle/Equipment Make: | GUIDE CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 17268 |
| Date Owner Notified By Manufacturer: | 20060831 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GUIDE CORPORATION |
| Report Received Date: | 20060828 |
| Record Creation Date: | 20060828 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN GUIDE REPLACEMENT HEADLAMPS, P/NOS. 16526133 AND 16526134, MANUFACTURED FROM JANUARY 1 TO JULY 11, 2006, SOLD FOR USE ON MY 1999-2002 CHEVROLET SILVERADO PICKUP TRUCKS. THE HEADLAMP FAIL TO COMPLY WITH THE PHOTOMETRY REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
TOO MUCH LIGHT IN CERTAIN POINTS OF THE HEADLAMP COULD CREATE A DISTRACTION, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
GUIDE CORPORATION WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT GUIDE AT 248-874-0355.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET GUIDE HEADLAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT:ELECTRICAL
-->| NHTSA Campaign Number: | 07E066000 |
| Vehicle/Equipment Make: | CEQUENT ELECTRICAL PRODUCTS |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EQUIPMENT:ELECTRICAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 175 |
| Date Owner Notified By Manufacturer: | 20070905 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CEQUENT ELECTRICAL PRODUCTS |
| Report Received Date: | 20070828 |
| Record Creation Date: | 20070829 |
Defect Summary:
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence Summary:
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Corrective Summary:
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
-->| NHTSA Campaign Number: | 04V129000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 4007 |
| Manufacturer Component Description: | STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000401 - 20001031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3662211 |
| Date Owner Notified By Manufacturer: | 20040918 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040317 |
| Record Creation Date: | 20040322 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence Summary:
ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Corrective Summary:
DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
Notes:
GM RECALL NO. 04007.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 07V521000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 6083 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000101 - 20001130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 11974 |
| Date Owner Notified By Manufacturer: | 20071218 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20071107 |
| Record Creation Date: | 20071107 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN 8.1L V8 ENGINE, THE CRANKSHAFT POSITION CAN OPERATE INTERMITTENTLY OR FAIL COMPLETELY. IF THE SENSOR OPERATES INTERMITTENTLY, THE SES LIGHT MAY ILLUMINATE AND THE VEHICLE MAY RUN ROUGH. THE ENGINE MAY STALL, AND IF SO, MAY RE-START IMMEDIATELY OR AFTER A COOL DOWN PERIOD.
Consequence Summary:
IF THE SENSOR BECOMES COMPLETELY INOPERATIVE, THE ENGINE WILL QUIT RUNNING AND WILL NOT RE-START. EITHER OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE CRANKSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 06083.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 05V379000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 5068 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1353718 |
| Date Owner Notified By Manufacturer: | 20050922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050829 |
| Record Creation Date: | 20050829 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Consequence Summary:
THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05068. GM REVISED THE INVOLVED VEHICLES BY AMENDING THE ORIGINAL 573 REPORT ON OCTOBER 4, 2005. GM REVISED THE ORIGINAL 573 REPORT ON DECEMBER 16, 2005, TO INCLUDE ADDITIONAL STATES AND VEHICLE POPULATION.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E057000 |
| Vehicle/Equipment Make: | MAXZONE AUTO PARTS CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12861 |
| Date Owner Notified By Manufacturer: | 20060710 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | MAXZONE AUTO PARTS CORPORATION |
| Report Received Date: | 20060623 |
| Record Creation Date: | 20060623 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 332-1182L-AS AND 332-1182R-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 1999-2000 CHEVROLET SILVERADOS. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
MAXZONE WILL NOTIFY OWNERS AND OFFER FOR REIMBURSEMENT ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 10, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E042000 |
| Vehicle/Equipment Make: | SABRY LEE, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15974 |
| Date Owner Notified By Manufacturer: | 20060510 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABRY LEE, INC. |
| Report Received Date: | 20060522 |
| Record Creation Date: | 20060522 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN EAGLE EYES REPLACEMENT HEADLAMPS, MODEL NOS. GM159-B001L AND GM159-B001R, SOLD FOR USE ON 1999-2002 CHEVROLET SILVERADO MODEL VEHICLES. THE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
THE HEADLAMPS HAVE DECREASED LIGHTING VISIBILITY WHICH COULD RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABRY LEE WILL NOTIFY OWNERS AND ISSUE FULL CREDIT. THE RECALL BEGAN ON MAY 10, 2006. OWNERS MAY CONTACT SABRY LEE AT 1-866-467-2279.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET EAGLE EYES HEADLAMP ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 09E012000 |
| Vehicle/Equipment Make: | SABERSPORT |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 16270 |
| Date Owner Notified By Manufacturer: | 20090511 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABERSPORT |
| Report Received Date: | 20090407 |
| Record Creation Date: | 20090407 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SILVERADO: EQUIPMENT
-->| NHTSA Campaign Number: | 04E022000 |
| Vehicle/Equipment Make: | DURAKON INDUSTRIES, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 8000 |
| Date Owner Notified By Manufacturer: | 20040331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DURAKON INDUSTRIES, INC. |
| Report Received Date: | 20040323 |
| Record Creation Date: | 20040330 |
Defect Summary:
AFTERMARKET PICKUP TRUCK OVER-THE-RAIL BEDLINERS MANUFACTURED FOR INSTALLATION ON 1999-2004 CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS. THE TOGGLE WING ASSEMBLY USED TO ATTACH THE BEDLINER TO THE TRUCK BED IS NOT ENGAGING FULLY IN THE STAKE POCKET OF THE PICKUP TRUCK.
Consequence Summary:
THE BEDLINER CAN BECOME DETACHED FROM THE PICKUP WHILE IT IS MOTION, POSSIBLY ENDANGERING FOLLOWING MOTORISTS OR PEDESTRIANS.
Corrective Summary:
DURAKON WILL ISSUE A PRESS RELEASE IN ATTEMPT TO NOTIFY CUSTOMERS THAT COULD HAVE PURCHASED THE DEFECTIVE BEDLINER. IF YOU PURCHASED EITHER A DURAKON ALLSTAR OF PATRIOT OVERRAIL BEDLINER SINCE AUGUST 1, 2003, FOR 1999 TO 2004 CHEVROLET SILVERADO OR GMC SIERRA TRUCKS, OR PURCHASED ONE OF THESE PICKUP TRUCKS WITH EITHER BRAND BEDLINER ALREADY INSTALLED, YOU SHOULD RETURN TO AN AUTHORIZED DURAKON DEALER SO THAT THE BEDLINER CAN BE INSPECTED AND, IF NECESSARY, REPAIRED WITH A NEWLY DESIGNED TOGGLE WING FASTENING SYSTEM, OR IF REQUIRED, REPLACED WITH A NEW BEDLINER FREE OF CHARGE. PLEASE CALL THE DURAKON HOTLINE AT 1-800-933-4200 TO FIND THE NEAREST AUTHORIZED DURAKON DEALER.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET OVERRAIL BEDLINERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO AND GMC SIERRA PICKUP TRUCKS BY GENERAL MOTORS.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
-->| NHTSA Campaign Number: | 00X001000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | X (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 777873 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000523 |
| Record Creation Date: | 20000824 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1/2 TON LIGHT DUTY PICKUP TRUCKS. ON CERTAIN TRUCKS, FAILURE TO FOLLOW THE SERVICE PROCEDURE SET FORTH IN THE SERVICE MANUAL FOR REMOVAL OF THE FRONT BRAKE CALIPER CAN RESULT IN MOVEMENT OF THE FRONT BRAKE HOSE RELATIVE TO ITS KNUCKLE MOUNTING BRACKET. IF THIS MOVEMENT RESULTS IN INCREASED LENGTH BETWEEN THE BRACKET AND THE BANJO FITTING THAT ATTACHES TO THE BRAKE CALIPER, IT IS POSSIBLE FOR THE BRAKE HOSE TO COME IN CONTACT WITH THE WHEEL RIM.
Consequence Summary:
THIS CONTACT WITH THE WHEEL RIM COULD, IN TIME, CAUSE THE BRAKE HOSE TO BECOME WORN TO THE POINT THAT BRAKE FLUID LEAKAGE COULD OCCUR. IF THIS OCCURRED, LOSS OF FRONT BRAKES IS POSSIBLE.
Corrective Summary:
DEALERS WILL ATTACH A NOTICE LABEL TO THE FRONT BRAKE HOSES STATING THAT THE CALIPERS MUST BE SUPPORTED WHEN REMOVED.
Notes:
GM HAS DECIDED TO CONDUCT A SERVICE PROGRAM TO INSTALL A LABEL ON THE HOSE WITH WARNING AND RECOMMENDATIONS TO SUPPORT THE BRAKE CALIPERS WHEN REMOVING THEM.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.
CHEVROLET: SILVERADO: PARKING BRAKE
-->| NHTSA Campaign Number: | 05V161000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 5042 |
| Manufacturer Component Description: | PARKING BRAKE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980401 - 19990731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 90242 |
| Date Owner Notified By Manufacturer: | 20050729 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence Summary:
IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05042.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
-->| NHTSA Campaign Number: | 06V066000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 6019 |
| Manufacturer Component Description: | STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980301 - 19990731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 805368 |
| Date Owner Notified By Manufacturer: | 20060410 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060308 |
| Record Creation Date: | 20060308 |
Defect Summary:
CERTAIN PICKUP TRUCKS HAVE GALVANIZED-BRAIDED-STEEL TAILGATE SUPPORT CABLES USED TO SUPPORT THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION. OVER TIME THESE CABLES CAN CORRODE AND FRACTURE WHEN LOADS ARE APPLIED TO THEM.
Consequence Summary:
IF ONE CABLE FRACTURES, THE REMAINING CABLE MAY RETAIN THE TAILGATE IN A HORIZONTAL POSITION. IF BOTH CABLES FRACTURE, THE TAILGATE WOULD DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER. IF ANYONE IS SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED, THEY COULD FALL AND BE INJURED. ON VEHICLES WITHOUT A BUMPER, THE TAILGATE MAY DROP TO A LOWER POSITION.
Corrective Summary:
DEALERS WILL REPLACE THE GALVANIZED SUPPORT CABLES WITH STAINLESS STEEL SUPPORT CABLES. IN ADDITION, DEALERS ARE TO INSPECT THE TAILGATE HINGE AND REPLACE IT, IF NECESSARY. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 06019.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E075000 |
| Vehicle/Equipment Make: | GUIDE CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 17268 |
| Date Owner Notified By Manufacturer: | 20060831 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GUIDE CORPORATION |
| Report Received Date: | 20060828 |
| Record Creation Date: | 20060828 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN GUIDE REPLACEMENT HEADLAMPS, P/NOS. 16526133 AND 16526134, MANUFACTURED FROM JANUARY 1 TO JULY 11, 2006, SOLD FOR USE ON MY 1999-2002 CHEVROLET SILVERADO PICKUP TRUCKS. THE HEADLAMP FAIL TO COMPLY WITH THE PHOTOMETRY REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
TOO MUCH LIGHT IN CERTAIN POINTS OF THE HEADLAMP COULD CREATE A DISTRACTION, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
GUIDE CORPORATION WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT GUIDE AT 248-874-0355.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET GUIDE HEADLAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EQUIPMENT:ELECTRICAL
-->| NHTSA Campaign Number: | 07E066000 |
| Vehicle/Equipment Make: | CEQUENT ELECTRICAL PRODUCTS |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EQUIPMENT:ELECTRICAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 175 |
| Date Owner Notified By Manufacturer: | 20070905 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | CEQUENT ELECTRICAL PRODUCTS |
| Report Received Date: | 20070828 |
| Record Creation Date: | 20070829 |
Defect Summary:
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence Summary:
IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Corrective Summary:
ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
-->| NHTSA Campaign Number: | 98V242000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | STEERING:GEAR BOX (OTHER THAN RACK AND PINION) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980401 - 19980831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 8367 |
| Date Owner Notified By Manufacturer: | 19981006 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19981006 |
| Record Creation Date: | 19981007 |
Defect Summary:
VEHICLE DESCRIPTION: EXTENDED CAB 4-WHEEL DRIVE PICKUP TRUCKS. SOME OF THESE VEHICLES HAVE A LOWER THAN SPECIFIED TORQUE ON ALL THREE OF THE STEERING GEAR TO FRAME ATTACHMENT BOLTS. THE BOLTS CAN LOOSEN OVER TIME ALLOWING THE STEERING GEAR TO MOVE. THIS LOOSENING CAN RESULT IN SOME UNRESPONSIVE STEERING FEEL AND SOME NOISE TO THE DRIVER.
Consequence Summary:
IF THIS CONDITION IS IGNORED, THE STEERING GEAR TO FRAME CAN WEAR AND/OR FATIGUE THE ATTACHING BOLTS TO THE POINT OF BREAKAGE OR THE BOLTS BACKING OUT. IF ALL THE BOLTS BREAK OR BACK OUT, THE STEERING GEAR WOULD SEPARATE FROM THE FRAME RESULTING IN A LOSS OF STEERING CONTROL.
Corrective Summary:
DEALERS WILL RETORQUE THE STEERING GEAR TO FRAME BOLTS TO PROPER SPECIFICATIONS.
Notes:
OWNER NOTIFICATION BEGAN DURING OCTOBER 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACTCHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 05V379000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 5068 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980401 - 19990731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1353718 |
| Date Owner Notified By Manufacturer: | 20050922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050829 |
| Record Creation Date: | 20050829 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Consequence Summary:
THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05068. GM REVISED THE INVOLVED VEHICLES BY AMENDING THE ORIGINAL 573 REPORT ON OCTOBER 4, 2005. GM REVISED THE ORIGINAL 573 REPORT ON DECEMBER 16, 2005, TO INCLUDE ADDITIONAL STATES AND VEHICLE POPULATION.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E057000 |
| Vehicle/Equipment Make: | MAXZONE AUTO PARTS CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 12861 |
| Date Owner Notified By Manufacturer: | 20060710 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | MAXZONE AUTO PARTS CORPORATION |
| Report Received Date: | 20060623 |
| Record Creation Date: | 20060623 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 332-1182L-AS AND 332-1182R-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 1999-2000 CHEVROLET SILVERADOS. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
MAXZONE WILL NOTIFY OWNERS AND OFFER FOR REIMBURSEMENT ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 10, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 00V345000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 93 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980401 - 19990731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1383922 |
| Date Owner Notified By Manufacturer: | 20010205 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20001030 |
| Record Creation Date: | 20001030 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE A CLEARANCE CONDITION BETWEEN THE FRONT RIGHT-HAND BRAKE PIPE AND THE BODY CROSS SILL THAT COULD DECREASE TO THE POINT OF ALLOWING CONTACT DURING THE LIFE OF THE VEHICLE. IF CONTACT OCCURS AND THE BRAKE PIPE BECOMES DAMAGED, IN HALF OF THE BRAKE SYSTEM THERE CAN BE A LOSS OF BRAKE FLUID AND PRESSURE. THE BRAKE WARNING LAMP WILL BE ACTIVATED WHEN THE BRAKE FLUID LEVEL REACHES THE INDICATOR LIMIT.
Consequence Summary:
DURING BRAKING, THE PEDAL WILL BE LOWER THAN NORMAL AND STOPPING DISTANCES WILL BE LONGER. IF THIS OCCURS WHEN STOPPING DISTANCE IS LIMITED, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT THE FRONT RIGHT-HAND BRAKE PIPE FOR WEAR. IF THERE ARE SIGNS OF WEAR, THIS SECTION OF THE BRAKE PIPE WILL BE REPLACED WITH A NEW DESIGNED BRAKE PIPE SECTION. IF THERE ARE NOT SIGNS OF WEAR ON THE BRAKE PIPE, THE DEALER WILL INSTALL A SPACER CLIP TO ENSURE SUFFICIENT CLEARANCE BETWEEN THE BRAKE PIPE AND THE BODY CROSS SILL.
Notes:
OWNER NOTIFICATION BEGAN FEBRUARY 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 09E025000 |
| Vehicle/Equipment Make: | DOPE, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 42540 |
| Date Owner Notified By Manufacturer: | 20090728 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | DOPE, INC. |
| Report Received Date: | 20090511 |
| Record Creation Date: | 20090511 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Corrective Summary:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SILVERADO: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E060000 |
| Vehicle/Equipment Make: | AAI MOTORSPORTS USA, LLC |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 87745 |
| Date Owner Notified By Manufacturer: | 20060801 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | AAI MOTORSPORTS USA, LLC |
| Report Received Date: | 20060629 |
| Record Creation Date: | 20060629 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Corrective Summary:
AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Notes:
THIS RECALL ONLY PERTAINS TO AAI MOTORSPORTS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 06E042000 |
| Vehicle/Equipment Make: | SABRY LEE, INC. |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 15974 |
| Date Owner Notified By Manufacturer: | 20060510 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | SABRY LEE, INC. |
| Report Received Date: | 20060522 |
| Record Creation Date: | 20060522 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN EAGLE EYES REPLACEMENT HEADLAMPS, MODEL NOS. GM159-B001L AND GM159-B001R, SOLD FOR USE ON 1999-2002 CHEVROLET SILVERADO MODEL VEHICLES. THE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
THE HEADLAMPS HAVE DECREASED LIGHTING VISIBILITY WHICH COULD RESULT IN A VEHICLE CRASH.
Corrective Summary:
SABRY LEE WILL NOTIFY OWNERS AND ISSUE FULL CREDIT. THE RECALL BEGAN ON MAY 10, 2006. OWNERS MAY CONTACT SABRY LEE AT 1-866-467-2279.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET EAGLE EYES HEADLAMP ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON CHEVROLET SILVERADO VEHICLES MANUFACTURED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SILVERADO: EXTERIOR LIGHTING:HEADLIGHTS
-->| NHTSA Campaign Number: | 08E050000 |
| Vehicle/Equipment Make: | K2 MOTOR CORPORATION |
| Vehicle/Equipment Model: | SILVERADO |
| Model Year: | 1999 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1921 |
| Date Owner Notified By Manufacturer: | 20081217 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | K2 MOTOR CORPORATION |
| Report Received Date: | 20080811 |
| Record Creation Date: | 20080814 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Summary:
K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY HONDA, FORD, OR CHRYSLER LLC. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: SUBURBAN 1500: SUSPENSION:REAR:AXLE:SPINDLE
| NHTSA Campaign Number: | 11V007000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN 1500 |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 10426A |
| Manufacturer Component Description: | SUSPENSION:REAR:AXLE:SPINDLE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20101130 - 20110103 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 30566 |
| Date Owner Notified By Manufacturer: | 20110111 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20110106 |
| Record Creation Date: | 20110111 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
THIS RECALL CAMPAIGN IS AN EXPANSION TO 10V-643.GM'S SAFETY RECALL NO. 10426A.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: SUBURBAN 1500: STEERING:LINKAGES
| NHTSA Campaign Number: | 11V339000 |
| Vehicle/Equipment Make: | GENERAL MOTORS LLC |
| Vehicle/Equipment Model: | SUBURBAN 1500 |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 11191 |
| Manufacturer Component Description: | STEERING:LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 739 |
| Date Owner Notified By Manufacturer: | 20110725 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS LLC |
| Report Received Date: | 20110628 |
| Record Creation Date: | 20110629 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2011CADILLAC ESCALADE, ESCALADE ESV; CHEVROLET SILVERADO HD, SILVERADO LD, SUBURBAN, TAHOE; AND GMC SIERRA HD, SIERRA LD, YUKON, AND YUKON XL VEHICLES. THE INTERMEDIATE STEERING SHAFT ATTACHING BOLTS MAY NOT HAVE BEEN TIGHTENED TO THE PROPER SPECIFICATION.
Consequence Summary:
THIS COULD ALLOW THE JOINTS TO SEPARATE, AND THE DRIVER COULD EXPERIENCE LOSS OF STEERING INCREASING THE RISK OF A CRASH.
Corrective Summary:
GM DEALERS WILL INSPECT AND ENSURE THAT THE INTERMEDIATE STEERING SHAFT BOLTS ARE TIGHTENED TO THE PROPER SPECIFICATION. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 13, 2011. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Notes:
GM'S SAFETY RECALL NO. 11191.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: SUBURBAN: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 10V240000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2009 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1365070 |
| Date Owner Notified By Manufacturer: | 20100611 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100604 |
| Record Creation Date: | 20100604 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence Summary:
IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Corrective Summary:
DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 09V154000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 8411 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20080601 - 20080930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27188 |
| Date Owner Notified By Manufacturer: | 20090518 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090506 |
| Record Creation Date: | 20090506 |
Defect Summary:
GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.
Consequence Summary:
WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 08411.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SUBURBAN: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 10V240000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2008 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1365070 |
| Date Owner Notified By Manufacturer: | 20100611 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100604 |
| Record Creation Date: | 20100604 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence Summary:
IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Corrective Summary:
DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SUBURBAN: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 08V441000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 8048 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20070430 - 20071130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 857735 |
| Date Owner Notified By Manufacturer: | 20080912 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080828 |
| Record Creation Date: | 20080828 |
Defect Summary:
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence Summary:
THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08048. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SUBURBAN: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 10V240000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2007 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1365070 |
| Date Owner Notified By Manufacturer: | 20100611 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100604 |
| Record Creation Date: | 20100604 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence Summary:
IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Corrective Summary:
DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SUBURBAN: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 08V441000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 8048 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050901 - 20070730 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 857735 |
| Date Owner Notified By Manufacturer: | 20080912 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080828 |
| Record Creation Date: | 20080828 |
Defect Summary:
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence Summary:
THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08048. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: SUBURBAN: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 05V552000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5109 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050901 - 20050907 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 32068 |
| Date Owner Notified By Manufacturer: | 20060331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051207 |
| Record Creation Date: | 20051207 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence Summary:
A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Notes:
GM RECALL NO. 05109.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 05V103000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5039 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040201 - 20050310 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 707 |
| Date Owner Notified By Manufacturer: | 20050310 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050318 |
| Record Creation Date: | 20050318 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE PEDAL PUSHROD RETAINER MAY BE MISSING. IF THE RETAINER IS MISSING, THE BRAKE BOOSTER PUSHROD COULD DISENGAGE FROM THE BRAKE PEDAL.
Consequence Summary:
THIS COULD RESULT IN A LOSS OF BRAKES WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLES FOR THE BRAKE PEDAL PUSHROD RETAINER AND INSTALL ONE IF IT IS MISSING FREE OF CHARGE. THE MANUFACTURER BEGAN CONTACTING OWNERS BY TELEPHONE ON MARCH 10, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05039.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2005 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040224 - 20041102 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 05V043000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5006 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040401 - 20040930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77411 |
| Date Owner Notified By Manufacturer: | 20050323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050208 |
| Record Creation Date: | 20050208 |
Defect Summary:
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence Summary:
IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05006.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
-->| NHTSA Campaign Number: | 04V376000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 4066 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040625 - 20040726 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1103 |
| Date Owner Notified By Manufacturer: | 20040730 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040802 |
| Record Creation Date: | 20040805 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Consequence Summary:
IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT THE FUEL RAIL CROSSOVER TUBE AND, IF NECESSARY, REPLACE THE RETAINER SCREWS. OWNERS WERE NOTIFIED BY TELEPHONE ON JULY 30, 2004, WITH A FOLLOWUP OWNER LETTER BEGAN AUGUST 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. NOTE: THE GM BULLETIN LISTS THE TAHOE AND YUKON MODELS BECAUSE CANADIAN VEHICLES ARE INCLUDED IN THE BULLETIN. NO U.S. TAHOE OR YUKON VEHICLES ARE INCLUDED IN THE U.S. CAMPAIGN.
Notes:
GM RECALL NO. 04066.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATIONGM RECALL NO. 04066.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR
-->| NHTSA Campaign Number: | 05V055000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5023 |
| Manufacturer Component Description: | POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050101 - 20050228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 7194 |
| Date Owner Notified By Manufacturer: | 20050222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050214 |
| Record Creation Date: | 20050215 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 102 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence Summary:
THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Corrective Summary:
DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05023.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 06V289000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 6080 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040501 - 20050630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 38439 |
| Date Owner Notified By Manufacturer: | 20060831 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060803 |
| Record Creation Date: | 20060803 |
Defect Summary:
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence Summary:
IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Notes:
GM RECALL NO. 06080.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 04V045000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4004 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030501 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 68875 |
| Date Owner Notified By Manufacturer: | 20040618 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 135 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence Summary:
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective Summary:
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2004 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030408 - 20040804 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 05V043000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5006 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040201 - 20040831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 77411 |
| Date Owner Notified By Manufacturer: | 20050323 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050208 |
| Record Creation Date: | 20050208 |
Defect Summary:
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence Summary:
IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05006.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 06V289000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 6080 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030401 - 20040630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 38439 |
| Date Owner Notified By Manufacturer: | 20060831 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20060803 |
| Record Creation Date: | 20060803 |
Defect Summary:
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence Summary:
IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Notes:
GM RECALL NO. 06080.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
-->| NHTSA Campaign Number: | 03V037000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3004 |
| Manufacturer Component Description: | STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20021001 - 20021031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 107 |
| Date Owner Notified By Manufacturer: | 20030217 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030206 |
| Record Creation Date: | 20030212 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 214 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.
Consequence Summary:
AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03004. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 04V045000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4004 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030501 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 68875 |
| Date Owner Notified By Manufacturer: | 20040618 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 135 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence Summary:
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective Summary:
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2003 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020403 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
-->| NHTSA Campaign Number: | 03V019000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3002 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20030131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 5734 |
| Date Owner Notified By Manufacturer: | 20030220 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030127 |
| Record Creation Date: | 20030205 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, VEHICLES, DURING A 30 DEGREE LEFT ANGLE FRONTAL IMPACT OF SUFFICIENT SEVERITY, A TEAR COULD DEVELOP IN THE MID-FRAME CROSS MEMBER AT ITS ATTACHMENT TO THE LEFT FRAME RAIL. IF THE MID-FRAME CROSS MEMBER TEARS DURING FRONTAL IMPACT AND PRODUCES A SHARP EDGE, CONTACT OF THE SHARP EDGE WITH THE FUEL TANK COULD RESULT IN A PUNCTURE OF THE FUEL TANK AND POSSIBLE FUEL LEAKAGE.
Consequence Summary:
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A FUEL TANK SHIELD. OWNER NOTIFICATION BEGAN FEBRUARY 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03002.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: STRUCTURE
-->| NHTSA Campaign Number: | 03V094000 |
| Vehicle/Equipment Make: | SOUTHERN COMFORT CONVERSIONS |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2003 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000801 - 20030303 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3674 |
| Date Owner Notified By Manufacturer: | 20030307 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | SOUTHERN COMFORT CONVERSIONS |
| Report Received Date: | 20030307 |
| Record Creation Date: | 20030318 |
Defect Summary:
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence Summary:
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2002 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 05V379000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 5068 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010101 - 20020831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1353718 |
| Date Owner Notified By Manufacturer: | 20050922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050829 |
| Record Creation Date: | 20050829 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Consequence Summary:
THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05068. GM REVISED THE INVOLVED VEHICLES BY AMENDING THE ORIGINAL 573 REPORT ON OCTOBER 4, 2005. GM REVISED THE ORIGINAL 573 REPORT ON DECEMBER 16, 2005, TO INCLUDE ADDITIONAL STATES AND VEHICLE POPULATION.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: STRUCTURE
-->| NHTSA Campaign Number: | 03V094000 |
| Vehicle/Equipment Make: | SOUTHERN COMFORT CONVERSIONS |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2002 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000801 - 20030303 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3674 |
| Date Owner Notified By Manufacturer: | 20030307 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | SOUTHERN COMFORT CONVERSIONS |
| Report Received Date: | 20030307 |
| Record Creation Date: | 20030318 |
Defect Summary:
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence Summary:
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2001 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: ENGINE AND ENGINE COOLING
-->| NHTSA Campaign Number: | 07V521000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 6083 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000101 - 20001130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 11974 |
| Date Owner Notified By Manufacturer: | 20071218 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20071107 |
| Record Creation Date: | 20071107 |
Defect Summary:
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN 8.1L V8 ENGINE, THE CRANKSHAFT POSITION CAN OPERATE INTERMITTENTLY OR FAIL COMPLETELY. IF THE SENSOR OPERATES INTERMITTENTLY, THE SES LIGHT MAY ILLUMINATE AND THE VEHICLE MAY RUN ROUGH. THE ENGINE MAY STALL, AND IF SO, MAY RE-START IMMEDIATELY OR AFTER A COOL DOWN PERIOD.
Consequence Summary:
IF THE SENSOR BECOMES COMPLETELY INOPERATIVE, THE ENGINE WILL QUIT RUNNING AND WILL NOT RE-START. EITHER OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE CRANKSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 06083.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: STRUCTURE:BODY
-->| NHTSA Campaign Number: | 00V343000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 84 |
| Manufacturer Component Description: | STRUCTURE:BODY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20000531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 35659 |
| Date Owner Notified By Manufacturer: | 20001116 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20001025 |
| Record Creation Date: | 20001027 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.
Consequence Summary:
THESE GASES COULD FLOW INTO THE PASSENGER COMPARTMENT IF THE PLUG IS MISSING OR LOOSE AND COULD CAUSE POSSIBLE ILLNESS, UNCONSCIOUSNESS, OR DEATH.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLE FOR LOOSE OR MISSING WHEELHOUSE PLUGS AND INSTALL NEW PLUGS IF NECESSARY.
Notes:
OWNER NOTIFICATION BEGAN NOVEMBER 16, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
-->| NHTSA Campaign Number: | 05V155000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 5027 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 316508 |
| Date Owner Notified By Manufacturer: | 20051019 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050414 |
| Record Creation Date: | 20050419 |
Defect Summary:
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES WERE BUILT WITH FUEL MODULE RESERVOIR ASSEMBLIES THAT CONTAIN FUEL PUMP WIRES CONNECTORS MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.
Consequence Summary:
IF THE IGNITION CIRCUIT WIRE IS EXPOSED, THE FUEL PUMP FUSE WILL BLOW, DISABLING THE FUEL PUMP AND CAUSING AN ENGINE STALL OR NO-START CONDITION. IF SUFFICIENT HEAT IS CONDUCTED TO THE PASS-THROUGH CONNECTOR, A HOLE IN THE CONNECTOR MAY RESULT, WHICH MAY CAUSE A 'SERVICE ENGINE SOON' LIGHT TO BE ILLUMINATED DURING THE EMISSION SYSTEM DIAGNOSTIC ROUTINE. FUEL VAPOR AND IN SOME CASES LIQUID FUEL MAY LEAK OUT OF THE FUEL TANK THROUGH THE HOLE IN THE CONNECTOR BODY. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. ALSO IF THE IGNITION CIRCUIT OR GROUND WIRE IS EXPOSED AND SHORTS TO THE FUEL LEVEL SENDER CARD WIRES, INACCURATE FUEL LEVEL READINGS MAY RESULT.
Corrective Summary:
DEALERS WILL REMOVE THE FUEL TANK, AND REMOVE THE MODULE RESERVOIR ASSEMBLIES FROM THE TANK, AND INSTALL A NEW SERVICE KIT FREE OF CHARGE. AN INTERIM LETTER TO OWNERS WAS MAILED ON MAY 25, 2005. THE OWNERS WERE RE-NOTIFIED ON OCTOBER 19, 2005, SINCE PARTS ARE NOW AVAILABE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05027. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 05V379000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 5068 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1353718 |
| Date Owner Notified By Manufacturer: | 20050922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050829 |
| Record Creation Date: | 20050829 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Consequence Summary:
THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05068. GM REVISED THE INVOLVED VEHICLES BY AMENDING THE ORIGINAL 573 REPORT ON OCTOBER 4, 2005. GM REVISED THE ORIGINAL 573 REPORT ON DECEMBER 16, 2005, TO INCLUDE ADDITIONAL STATES AND VEHICLE POPULATION.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SEAT BELTS:FRONT:RETRACTOR
-->| NHTSA Campaign Number: | 01V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 1043 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:RETRACTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000901 - 20001031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 9196 |
| Date Owner Notified By Manufacturer: | 20010702 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010517 |
| Record Creation Date: | 20010522 |
Defect Summary:
VEHICLE DESCRIPTION: PICKUP AND UTILITY TRUCKS. SOME OF THESE VEHICLES HAVE AN INTERNAL COMPONENT IN THE OUTBOARD SEAT BELT RETRACTORS FOR THE 2ND AND 3RD ROW OF SEATS THAT COULD BE CRACKED. WITH REPEATED ACTUATION OF THE LOCKING MECHANISM, THE CRACK COULD SPREAD TO THE POINT SUCH THAT THE SEAT BELT WOULD NO LONGER LOCK.
Consequence Summary:
IN A CRASH, INCREASED OCCUPANT INJURY COULD RESULT FROM THE NO-LOCK CONDITION.
Corrective Summary:
DEALERS WILL INSPECT THE OUTBOARD SEAT BELTS FOR SPECIFIC LOT NUMBERS AND REPLACE THE BELTS IF NECESSARY. GM IS ENCLOSING AN INSPECTION PROCEDURE FOR THE OWNERS TO USE OR THEY CAN HAVE THEIR DEALERS DO THE INSPECTIONS. OWNER NOTIFICATION BEGAN JULY 2, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: STRUCTURE
-->| NHTSA Campaign Number: | 03V094000 |
| Vehicle/Equipment Make: | SOUTHERN COMFORT CONVERSIONS |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 2001 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000801 - 20030303 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3674 |
| Date Owner Notified By Manufacturer: | 20030307 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | SOUTHERN COMFORT CONVERSIONS |
| Report Received Date: | 20030307 |
| Record Creation Date: | 20030318 |
Defect Summary:
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence Summary:
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1999 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SEAT BELTS:FRONT:WEBBING
-->| NHTSA Campaign Number: | 00V122000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 44 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WEBBING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980901 - 19990531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 279132 |
| Date Owner Notified By Manufacturer: | 20001229 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000427 |
| Record Creation Date: | 20000502 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE RIGHT FRONT PASSENGER RESTRAINT SYSTEMS MAY NOT MEET THE NECK EXTENSION REQUIREMENTS.
Corrective Summary:
DEALERS WILL INSTALL A TRAY INSERT ON THE TOP OF THE PASSENGER SIDE OF THE INSTRUMENT PANEL. THE TRAY INSERT CORRECTS THE NONCOMPLIANCE.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 29, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, AND GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1998 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 98V033000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1998 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19971001 - 19971031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1137 |
| Date Owner Notified By Manufacturer: | 19980315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980217 |
| Record Creation Date: | 19980225 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. ONE OR BOTH FRONT BRAKE ROTOR/HUBS WERE BUILT WITH AN OUT-OF-SPECIFICATION GRAY IRON THAT CAN FAIL DURING THE LIFE OF THE VEHICLE.
Consequence Summary:
IF A DRIVER CONTINUES TO DRIVE WITH A CRACKED ROTOR, THE CRACKS COULD CONTINUE AROUND THE WHEEL MOUNTING BOLT CIRCLE AND ULTIMATELY RESULT IN A WHEEL SEPARATION.
Corrective Summary:
DEALERS WILL INSPECT THE ROTORS FOR A CORE DATE OF "287" AND, IF FOUND, REPLACE THE ROTOR.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
-->| NHTSA Campaign Number: | 03V093000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1998 |
| Manufacturer Campaign Number: | 3006 |
| Manufacturer Component Description: | VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970201 - 19980131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 507171 |
| Date Owner Notified By Manufacturer: | 20030424 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030307 |
| Record Creation Date: | 20030318 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence Summary:
IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03006. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1997 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960401 - 19970831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
-->| NHTSA Campaign Number: | 03V093000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1997 |
| Manufacturer Campaign Number: | 3006 |
| Manufacturer Component Description: | VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960501 - 19970831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 507171 |
| Date Owner Notified By Manufacturer: | 20030424 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030307 |
| Record Creation Date: | 20030318 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence Summary:
IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03006. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 96V057000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1996 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950501 - 19951101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 379004 |
| Date Owner Notified By Manufacturer: | 19960411 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960404 |
| Record Creation Date: | 19960417 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 124 |
Defect Summary:
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Notes:
SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL; FMVSS NO. 124. VEHICLE DESCRIPTION: PICKUP TRUCKS, CAB/CHASSIS, UTILITY AND MULTI-PURPOSE TRUCKS EQUIPPED WITH GASOLINE ENGINES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 98V150001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 98043 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19960531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1557585 |
| Date Owner Notified By Manufacturer: | 19981215 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980701 |
| Record Creation Date: | 19990211 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence Summary:
THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 15, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960601 - 19960930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
-->| NHTSA Campaign Number: | 95V026000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1995 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19941201 - 19950101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 13853 |
| Date Owner Notified By Manufacturer: | 19950224 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950216 |
| Record Creation Date: | 19950221 |
Defect Summary:
DUE TO A THIN CASE CASTING, AN EXTERNAL TRANSMISSION LEAK CAN OCCUR.
Consequence Summary:
THIS CONDITION CAN CAUSE TRANSMISSION OIL TO SPRAYONTO THE EXHAUST SYSTEM AND RESULT IN A POSSIBLE VEHICLE FIRE.
Corrective Summary:
DEALERS WILL INSPECT THE TRANSMISSION CASE ASSEMBLY FOR THE INVOLVED CASE CASTING. IF THE ASSEMBLY IS INVOLVED, THE TRANSMISSION WILL BE REPLACED.
Notes:
SYSTEM: AUTOMATIC TRANSMISSION; COOLING UNIT AND LINES.VEHICLE DESCRIPTION: PICKUP TRUCKS AND VANS EQUIPPED WITH 4L80-E AUTOMATIC TRANSMISSION.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-810-456-4547. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 96V057000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1995 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950501 - 19951101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 379004 |
| Date Owner Notified By Manufacturer: | 19960411 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960404 |
| Record Creation Date: | 19960417 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 124 |
Defect Summary:
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Notes:
SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL; FMVSS NO. 124. VEHICLE DESCRIPTION: PICKUP TRUCKS, CAB/CHASSIS, UTILITY AND MULTI-PURPOSE TRUCKS EQUIPPED WITH GASOLINE ENGINES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 95V139000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1995 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940301 - 19941001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 36641 |
| Date Owner Notified By Manufacturer: | 19950810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950726 |
| Record Creation Date: | 19950727 |
Defect Summary:
THE TRANSMISSION SHIFT-CABLE LOCK CLIP CAN BACK OUT OF ITS INSTALLED POSITION RESULTING IN A LOSS OF CABLE ADJUSTMENT. WHEN THE SHIFT LEVER IS PLACED IN THE "PARK" POSITION, THE "PARK" INDICATOR LIGHT MAY NOT ILLUMINATE.
Consequence Summary:
THE VEHICLE CAN MOVE UNINTENTIONALLY IF THE DRIVER DOES NOT NOTICE THAT THE INDICATOR LIGHT IS NOT ON AND DOES NOT APPLY THE PARKING BRAKE.
Corrective Summary:
DEALERS WILL ADJUST THE SHIFT CABLE AND INSTALL A LOCK CLIP.
Notes:
SYSTEM: POWERTRAIN; AUTOMATIC TRANSMISSION.VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH M30/MT1 AUTOMATIC TRANSMISSIONS.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME,SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 98V150001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1995 |
| Manufacturer Campaign Number: | 98043 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19960531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1557585 |
| Date Owner Notified By Manufacturer: | 19981215 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980701 |
| Record Creation Date: | 19990211 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence Summary:
THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 15, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1995 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950301 - 19960930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: SUBURBAN: AIR BAGS
-->| NHTSA Campaign Number: | 95V140000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1995 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940401 - 19950401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3651 |
| Date Owner Notified By Manufacturer: | 19950803 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950725 |
| Record Creation Date: | 19950727 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
THE VEHICLES HAVE BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) LABEL AND AN ENGINE START LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABEL.
Corrective Summary:
THE ENGINE START LABEL WILL BE REMOVED FROM THE STOWED SIDE OF THE SUN VISOR AND A NEW ENGINE START LABEL WILL BE INSTALLED ON THE HEADLINER IN THE SUN VISOR DEPRESSION. OWNERS WILL RECEIVE THE NEW LABEL AND CAN INSTALL THE LABEL THEMSELVES OR HAVE A DEALER INSTALL IT.
Notes:
SYSTEM: INTERIOR; PASSIVE RESTRAINTS; AIR BAG; FMVSS NO.208.VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND MULTI PURPOSE PASSENGER VEHICLES EQUIPPED WITH L56/L65 DIESEL ENGINES.NOTE: IF YOU DO NOT RECEIVE A NEW LABEL IN A REASONABLE TIME FREE OF CHARGE PLEASE CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1993 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 01I006000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1993 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19920301 - 19930731 |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 255770 |
| Date Owner Notified By Manufacturer: | 20010713 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010702 |
| Record Creation Date: | 20010719 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1992-1994 CHEVROLET AND GMC SUBURBANS EQUIPPED WITH VACUUM POWER-BRAKE ASSIST AND EBC4 ANTI-LOCK BRAKE (ABS) MODULES. THESE VEHICLES EXHIBIT POOR BRAKE SYSTEM PERFORMANCE.
Consequence Summary:
THIS COULD BE ATTRIBUTED TO BRAKE PEDAL FEEL.
Corrective Summary:
DEALERS WILL INSTALL A NEW BRAKE PEDAL PAD. IN ADDITION, DEALERS WILL INSPECT THE BRAKE-BOOSTER OUTPUT ROD AND REPLACE IT IF NECESSARY.
Notes:
GM HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO ADVISE OWNERS TO HAVE THE BRAKE PEDAL PAD REPLACED ON THEIR VEHICLES.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 93V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1992 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 341364 |
| Date Owner Notified By Manufacturer: | 19931108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930802 |
| Record Creation Date: | 19930726 |
Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 92V056000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1992 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19920301 - 19920331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 177 |
| Date Owner Notified By Manufacturer: | 19920409 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19920414 |
| Record Creation Date: | 19920423 |
Defect Summary:
THE PIVOT BOLT HOLDING THE BRAKE PEDAL TO ITS SUPPORT BRACKET MAY BE IMPROPERLY TIGHTENED AND MAY NOT HAVE ENGAGED THE LOCKING MATERIAL ON THE BOLT. THE BOLT CAN DISENGAGE FROM THE NUT.
Consequence Summary:
IF THE PIVOT BOLT DISENGAGES FROM THE NUT WHILE THEVEHICLE IS IN MOTION, THERE WILL BE A LOSS OF BRAKE CONTROL AND COULD RESULT INA VEHICLE ACCIDENT.
Corrective Summary:
DEALERS SHOULD INSPECT THE HAND STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO SPECIFICATION.
Notes:
SYSTEM: BRAKES.VEHICLE DESCRIPTION: CHEVROLET AND GMC LIGHT TRUCKS; MODEL NAMES SIERRA, YUKON,SUBURBAN, CREW CAB, AND 3500HD.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1992 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 01I006000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1992 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19910601 - 19920831 |
| Type of Report: | I (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 255770 |
| Date Owner Notified By Manufacturer: | 20010713 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010702 |
| Record Creation Date: | 20010719 |
Defect Summary:
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1992-1994 CHEVROLET AND GMC SUBURBANS EQUIPPED WITH VACUUM POWER-BRAKE ASSIST AND EBC4 ANTI-LOCK BRAKE (ABS) MODULES. THESE VEHICLES EXHIBIT POOR BRAKE SYSTEM PERFORMANCE.
Consequence Summary:
THIS COULD BE ATTRIBUTED TO BRAKE PEDAL FEEL.
Corrective Summary:
DEALERS WILL INSTALL A NEW BRAKE PEDAL PAD. IN ADDITION, DEALERS WILL INSPECT THE BRAKE-BOOSTER OUTPUT ROD AND REPLACE IT IF NECESSARY.
Notes:
GM HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO ADVISE OWNERS TO HAVE THE BRAKE PEDAL PAD REPLACED ON THEIR VEHICLES.OWNERS CAN CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782, CONCERNING THIS PROGRAM.
CHEVROLET: SUBURBAN: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 93V016000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1992 |
| Manufacturer Campaign Number: | 93-C-07 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861201 - 19920801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1702880 |
| Date Owner Notified By Manufacturer: | 19930313 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930201 |
| Record Creation Date: | 19930204 |
Defect Summary:
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
Consequence Summary:
THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.
Corrective Summary:
INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.
Notes:
SYSTEM: POWER TRAIN.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 5.0 L, 5.7 L, AND 7.4 L ENGINES AND 4L60,4L60-E, AND 3L80 AUTOMATIC TRANSMISSIONS.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 93V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1991 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 341364 |
| Date Owner Notified By Manufacturer: | 19931108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930802 |
| Record Creation Date: | 19930726 |
Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: SEATS
-->| NHTSA Campaign Number: | 96V226000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1991 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19900301 - 19910801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 32596 |
| Date Owner Notified By Manufacturer: | 19961122 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19961104 |
| Record Creation Date: | 19961114 |
Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL VETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULD ALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Notes:
VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITH KNOW TYPE RECLINDER MECHANISMS. OWNER NOTIFICATION:OWNER NOTIFICATION BEGAN DURING NOVEMBER 1996.NOTE:OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME PLEASE CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1991 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 93V016000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1991 |
| Manufacturer Campaign Number: | 93-C-07 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861201 - 19920801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1702880 |
| Date Owner Notified By Manufacturer: | 19930313 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930201 |
| Record Creation Date: | 19930204 |
Defect Summary:
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
Consequence Summary:
THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.
Corrective Summary:
INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.
Notes:
SYSTEM: POWER TRAIN.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 5.0 L, 5.7 L, AND 7.4 L ENGINES AND 4L60,4L60-E, AND 3L80 AUTOMATIC TRANSMISSIONS.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 93V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1990 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 341364 |
| Date Owner Notified By Manufacturer: | 19931108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930802 |
| Record Creation Date: | 19930726 |
Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1990 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 93V016000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1990 |
| Manufacturer Campaign Number: | 93-C-07 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861201 - 19920801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1702880 |
| Date Owner Notified By Manufacturer: | 19930313 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930201 |
| Record Creation Date: | 19930204 |
Defect Summary:
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
Consequence Summary:
THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.
Corrective Summary:
INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.
Notes:
SYSTEM: POWER TRAIN.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 5.0 L, 5.7 L, AND 7.4 L ENGINES AND 4L60,4L60-E, AND 3L80 AUTOMATIC TRANSMISSIONS.
CHEVROLET: SUBURBAN: SEATS
-->| NHTSA Campaign Number: | 93V187000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1990 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 604207 |
| Date Owner Notified By Manufacturer: | 19940120 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19931116 |
| Record Creation Date: | 19931129 |
Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT TRACKS, ANCHORS, AND SEATS.VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITHKNOB TYPE RECLINER MECHANISMS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE GMC SERVICE CENTER AT 1-313-456-4547 OR THE CHEVROLET SERVICE CENTERAT 1-800-222-1020. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 93V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1989 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 341364 |
| Date Owner Notified By Manufacturer: | 19931108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930802 |
| Record Creation Date: | 19930726 |
Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1989 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 93V016000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1989 |
| Manufacturer Campaign Number: | 93-C-07 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861201 - 19920801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1702880 |
| Date Owner Notified By Manufacturer: | 19930313 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930201 |
| Record Creation Date: | 19930204 |
Defect Summary:
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
Consequence Summary:
THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.
Corrective Summary:
INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.
Notes:
SYSTEM: POWER TRAIN.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 5.0 L, 5.7 L, AND 7.4 L ENGINES AND 4L60,4L60-E, AND 3L80 AUTOMATIC TRANSMISSIONS.
CHEVROLET: SUBURBAN: SEATS
-->| NHTSA Campaign Number: | 93V187000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1989 |
| Manufacturer Component Description: | SEATS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19840801 - 19910101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 604207 |
| Date Owner Notified By Manufacturer: | 19940120 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19931116 |
| Record Creation Date: | 19931129 |
Defect Summary:
THE RECLINER MECHANISM AND THE SEAT FRAME MAY HAVE FOAM AND/OR VINYL BETWEEN THEM, CREATING A "SOFT" JOINT. THIS "SOFT" JOINT RESULTS IN LOWER THAN SPECIFIED BOLT TORQUE WHICH LEADS TO JOINT LOOSENESS, CAUSING BOLT FATIGUE AND EVENTUAL BOLT FAILURE.
Consequence Summary:
IF BOLT FAILURE OCCURS TO THE DRIVER'S SEAT, IT WOULDALLOW THE SEAT BACK TO SUDDENLY RECLINE, AND COULD RESULT IN LOSS OF VEHICLECONTROL AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Corrective Summary:
DEALERS WILL REMOVE THE FOAM AND/OR VINYL FROM BETWEEN THE RECLINER MECHANISM AND THE SEAT FRAME "SOFT" JOINT AND REPLACE THE RECLINER BOLTS.
Notes:
SYSTEM: INTERIOR SYSTEMS; SEAT TRACKS, ANCHORS, AND SEATS.VEHICLE DESCRIPTION: VANS AND UTILITY VEHICLES EQUIPPED WITH BUCKET SEATS WITHKNOB TYPE RECLINER MECHANISMS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREEOF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASECONTACT THE GMC SERVICE CENTER AT 1-313-456-4547 OR THE CHEVROLET SERVICE CENTERAT 1-800-222-1020. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 93V119000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1988 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 341364 |
| Date Owner Notified By Manufacturer: | 19931108 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930802 |
| Record Creation Date: | 19930726 |
Defect Summary:
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence Summary:
SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Notes:
SYSTEM: BRAKES; HYDRAULIC; DISK ROTORS.VEHICLE DESCRIPTION: LIGHT TRUCKS AND VANS SOLD OR REGISTERED IN THE FOLLOWINGSTATES: CT, IL, IN, MA, ME, MI, NH, NJ, NY, OH, PA, RI, VT, AND WI.NOTES: THE VEHICLES INVOLVED CAN BE IDENTIFIED BY THE FOLLOWING: THE 5THCHARACTER OF THE VEHICLE IDENTIFICATION NUMBER MUST BE A "K" OR "L", AND THESEVENTH CHARACTER MUST BE "3","4","5","6", OR "9".IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPONSERVICE DATE, AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE AMOUNT OF TIMEAND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT ORNONCOMPLIANCE, PLEASE CONTACT YOUR NEAREST GMC TRUCK ZONE OFFICE. THE TELEPHONENUMBERS OF THE ZONE OFFICES ARE LISTED IN YOUR WARRANTY AND OWNER'S ASSISTANCEINFORMATION MANUALS. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETYADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1988 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 93V016000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1988 |
| Manufacturer Campaign Number: | 93-C-07 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19861201 - 19920801 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1702880 |
| Date Owner Notified By Manufacturer: | 19930313 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19930201 |
| Record Creation Date: | 19930204 |
Defect Summary:
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
Consequence Summary:
THE VENTED TRANSMISSION FLUID CAN CATCH FIRE IF EXPOSEDTO A SOURCE OF IGNITION.
Corrective Summary:
INSTALL A LONGER TRANSMISSION VENT HOSE ROUTED TO THE LEFT SIDE OF THE ENGINE COMPARTMENT OF THE VEHICLE.
Notes:
SYSTEM: POWER TRAIN.VEHICLE DESCRIPTION: LIGHT TRUCKS WITH 5.0 L, 5.7 L, AND 7.4 L ENGINES AND 4L60,4L60-E, AND 3L80 AUTOMATIC TRANSMISSIONS.
CHEVROLET: SUBURBAN: SEAT BELTS:FRONT:WEBBING
-->| NHTSA Campaign Number: | 89V010000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1988 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WEBBING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19880501 - 19880501 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 277 |
| Date Owner Notified By Manufacturer: | 19890308 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19890130 |
| Record Creation Date: | 19890206 |
Defect Summary:
DRIVERS SEAT AND/OR SHOULDER BELT LOCKING MECHANISM MAY NOT OPERATE.
Consequence Summary:
IN A CRASH, AFFECTED BELTS WOULD NOT LOCK, THEREBYINCREASING THE POSSIBILITY OF INJURY TO THE SEAT OCCUPANT.
Corrective Summary:
INSTALL A NEW DRIVERS SEAT BELT ASSEMBLY.
Notes:
SYSTEM: SEAT BELT.VEHICLE DESCRIPTION: VAN TYPE PASSENGER VEHICLE EQUIPPED WITH BUCKET SEATS ANDGRAY INTERIOR TRIM.
CHEVROLET: SUBURBAN: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1987 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: SUBURBAN: TRAILER HITCHES
-->| NHTSA Campaign Number: | 82V028000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1982 |
| Manufacturer Component Description: | TRAILER HITCHES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19810801 - 19810901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 148 |
| Date Owner Notified By Manufacturer: | 19820324 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19820329 |
| Record Creation Date: | 19820405 |
Defect Summary:
THE PLATFORM TRAILER HITCHES ON THE SUSPECT VEHICLES MAY NOT HAVE BEEN ASSEMBLED WITH SUFFICIENT HITCH-TO-ATTACHMENT BOLT CLAMP LOAD. IF THIS CONDITION EXISTS, THE TRAILER HITCH ATTACHING PARTS MAY LOOSEN AND BREAK.
Corrective Summary:
DEALER WILL INSPECT AND, IF NECESSARY, REPOSITION THE HITCH AND REAR BUMPER, RETORQUE THE ATTACHMENT BOLTS AND REPLACE THE EXISTING REAR HITCH-TO-FRAME BOLTS AT NO COST TO OWNER.
Notes:
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH ROP VR4 PLATFORM TRAILER HITCHES.SYSTEM: EQUIPMENT; TRAILER HITCHES & ATTACHMENTS.CONSEQUENCES OF DEFECT: IF THIS BREAKAGE OCCURS WHILE THE TRAILER IS BEINGTOWED, THE HITCH AND TRAILER COULD SEPARATE AND A VEHICLE ACCIDENT COULDRESULT.
CHEVROLET: SUBURBAN: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 80V150000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | SUBURBAN |
| Model Year: | 1981 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19800801 - 19800901 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 364 |
| Date Owner Notified By Manufacturer: | 19801117 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19801114 |
| Record Creation Date: | 19801217 |
Defect Summary:
THE INVOLVED VEHICLES MAY HAVE BEEN ASSEMBLED WITHOUT THE RETAINER CLIP FOR THE BRAKE PEDAL PUSH ROD. THE ABSENCE OF THIS RETAINER CLIP COULD ALLOW THE BRAKE PEDAL TO DISENGAGE FROM THE MASTER CYCLINDER PUSH ROD.
Corrective Summary:
THE DEALER WILL INSPECT AND, IF NECESSARY, INSTALL THE RETAINER CLIP ON ALL SUSPECT VEHICLES WITHOUT CHARGE.
Notes:
VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: SERVICE BRAKES; BRAKE PEDAL PUSH ROD RETAINER CLIPS.CONSEQUENCES OF DEFECT: THIS MAY RESULT IN LOSS OF BRAKING ACTION. THISCONDITION COULD OCCUR WITHOUT WARNING WHILE THE VEHICLE IS IN MOTION, AND COULDRESULT IN AN ACCIDENT.
--CHEVROLET: TAHOE: SUSPENSION:REAR:AXLE:SPINDLE
| NHTSA Campaign Number: | 11V007000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 10426A |
| Manufacturer Component Description: | SUSPENSION:REAR:AXLE:SPINDLE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20101130 - 20110103 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 30566 |
| Date Owner Notified By Manufacturer: | 20110111 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20110106 |
| Record Creation Date: | 20110111 |
Defect Summary:
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, COLORADO, EXPRESS, SILVERADO, SUBURBAN, TAHOE; AND GMC CANYON, SIERRA, SAVANA, YUKON AND YUKON XL VEHICLES. THE REAR AXLE CROSS PINS WERE NOT PROPERLY HEAT TREATED AND COULD FRACTURE AND BECOME DISPLACED WITHIN THE REAR AXLE. SHOULD THE PIN SHIFT OUT OF POSITION, IT COULD CREATE AN INTERFERENCE CONDITION AND CAUSE THE REAR AXLE TO LOCK.
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO MAINTAIN DIRECTIONAL CONTROL OF THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.
Corrective Summary:
DEALERS WILL INSTALL A NEW REAR AXLE CROSS PIN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
THIS RECALL CAMPAIGN IS AN EXPANSION TO 10V-643.GM'S SAFETY RECALL NO. 10426A.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: TAHOE: STEERING:LINKAGES
| NHTSA Campaign Number: | 11V339000 |
| Vehicle/Equipment Make: | GENERAL MOTORS LLC |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2011 |
| Manufacturer Campaign Number: | 11191 |
| Manufacturer Component Description: | STEERING:LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 739 |
| Date Owner Notified By Manufacturer: | 20110725 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS LLC |
| Report Received Date: | 20110628 |
| Record Creation Date: | 20110629 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2011CADILLAC ESCALADE, ESCALADE ESV; CHEVROLET SILVERADO HD, SILVERADO LD, SUBURBAN, TAHOE; AND GMC SIERRA HD, SIERRA LD, YUKON, AND YUKON XL VEHICLES. THE INTERMEDIATE STEERING SHAFT ATTACHING BOLTS MAY NOT HAVE BEEN TIGHTENED TO THE PROPER SPECIFICATION.
Consequence Summary:
THIS COULD ALLOW THE JOINTS TO SEPARATE, AND THE DRIVER COULD EXPERIENCE LOSS OF STEERING INCREASING THE RISK OF A CRASH.
Corrective Summary:
GM DEALERS WILL INSPECT AND ENSURE THAT THE INTERMEDIATE STEERING SHAFT BOLTS ARE TIGHTENED TO THE PROPER SPECIFICATION. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 13, 2011. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Notes:
GM'S SAFETY RECALL NO. 11191.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
--CHEVROLET: TAHOE: EQUIPMENT
-->| NHTSA Campaign Number: | 10E043000 |
| Vehicle/Equipment Make: | MARATHON SEAT COVERS, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2010 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 294 |
| Date Owner Notified By Manufacturer: | 20100914 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | MARATHON SEAT COVERS, INC. |
| Report Received Date: | 20100903 |
| Record Creation Date: | 20100910 |
Defect Summary:
MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.
Consequence Summary:
AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
Corrective Summary:
MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET MARATHON SEAT COVERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON GENERAL MOTORS, FORD, CHRYSLER, TOYOTA, OR NISSAN VEHICLES.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: TAHOE: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 10V240000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2009 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1365070 |
| Date Owner Notified By Manufacturer: | 20100611 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100604 |
| Record Creation Date: | 20100604 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence Summary:
IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Corrective Summary:
DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 09V154000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2009 |
| Manufacturer Campaign Number: | 8411 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20080601 - 20080930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 27188 |
| Date Owner Notified By Manufacturer: | 20090518 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20090506 |
| Record Creation Date: | 20090506 |
Defect Summary:
GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.
Consequence Summary:
WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.
Notes:
GM RECALL NO. 08411.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: TAHOE: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 10V240000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2008 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1365070 |
| Date Owner Notified By Manufacturer: | 20100611 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100604 |
| Record Creation Date: | 20100604 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence Summary:
IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Corrective Summary:
DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: TAHOE: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 08V441000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2008 |
| Manufacturer Campaign Number: | 8048 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20070430 - 20071130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 857735 |
| Date Owner Notified By Manufacturer: | 20080912 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080828 |
| Record Creation Date: | 20080828 |
Defect Summary:
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence Summary:
THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08048. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: TAHOE: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 10V240000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2007 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1365070 |
| Date Owner Notified By Manufacturer: | 20100611 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20100604 |
| Record Creation Date: | 20100604 |
Defect Summary:
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence Summary:
IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Corrective Summary:
DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Notes:
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: TAHOE: ELECTRICAL SYSTEM
-->| NHTSA Campaign Number: | 08V441000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2007 |
| Manufacturer Campaign Number: | 8048 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050901 - 20070730 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 857735 |
| Date Owner Notified By Manufacturer: | 20080912 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20080828 |
| Record Creation Date: | 20080828 |
Defect Summary:
GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Consequence Summary:
THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Corrective Summary:
DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Notes:
GM RECALL NO. 08048. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: TAHOE: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 05V552000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5109 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050901 - 20050907 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 32068 |
| Date Owner Notified By Manufacturer: | 20060331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051207 |
| Record Creation Date: | 20051207 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence Summary:
A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Notes:
GM RECALL NO. 05109.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
-->| NHTSA Campaign Number: | 05V455000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5086 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050701 - 20050831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 123592 |
| Date Owner Notified By Manufacturer: | 20051014 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051005 |
| Record Creation Date: | 20051006 |
Defect Summary:
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence Summary:
IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05086.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2006 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 06V417000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 6102 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050601 - 20050630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 794 |
| Date Owner Notified By Manufacturer: | 20061106 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20061031 |
| Record Creation Date: | 20061101 |
Defect Summary:
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence Summary:
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Corrective Summary:
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Notes:
GM RECALL NO. 06102.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
-->| NHTSA Campaign Number: | 05V103000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5039 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040201 - 20050310 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 707 |
| Date Owner Notified By Manufacturer: | 20050310 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050318 |
| Record Creation Date: | 20050318 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE PEDAL PUSHROD RETAINER MAY BE MISSING. IF THE RETAINER IS MISSING, THE BRAKE BOOSTER PUSHROD COULD DISENGAGE FROM THE BRAKE PEDAL.
Consequence Summary:
THIS COULD RESULT IN A LOSS OF BRAKES WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLES FOR THE BRAKE PEDAL PUSHROD RETAINER AND INSTALL ONE IF IT IS MISSING FREE OF CHARGE. THE MANUFACTURER BEGAN CONTACTING OWNERS BY TELEPHONE ON MARCH 10, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05039.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2005 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040224 - 20041102 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR
-->| NHTSA Campaign Number: | 05V055000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5023 |
| Manufacturer Component Description: | POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050101 - 20050228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 7194 |
| Date Owner Notified By Manufacturer: | 20050222 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050214 |
| Record Creation Date: | 20050215 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 102 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence Summary:
THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Corrective Summary:
DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05023.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2005 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 04V045000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4004 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030501 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 68875 |
| Date Owner Notified By Manufacturer: | 20040618 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 135 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence Summary:
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective Summary:
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2004 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030408 - 20040804 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2004 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2004 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
-->| NHTSA Campaign Number: | 03V037000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3004 |
| Manufacturer Component Description: | STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20021001 - 20021031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 107 |
| Date Owner Notified By Manufacturer: | 20030217 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030206 |
| Record Creation Date: | 20030212 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 214 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.
Consequence Summary:
AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 03004. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: SERVICE BRAKES, HYDRAULIC
-->| NHTSA Campaign Number: | 04V045000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4004 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030501 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 68875 |
| Date Owner Notified By Manufacturer: | 20040618 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 135 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence Summary:
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Corrective Summary:
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 04004.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2003 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 05V163000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 5037 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020403 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1359824 |
| Date Owner Notified By Manufacturer: | 20050721 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050422 |
| Record Creation Date: | 20050422 |
Defect Summary:
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence Summary:
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Corrective Summary:
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05037.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2003 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2003 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: STRUCTURE
-->| NHTSA Campaign Number: | 03V094000 |
| Vehicle/Equipment Make: | SOUTHERN COMFORT CONVERSIONS |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2003 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000801 - 20030303 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3674 |
| Date Owner Notified By Manufacturer: | 20030307 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | SOUTHERN COMFORT CONVERSIONS |
| Report Received Date: | 20030307 |
| Record Creation Date: | 20030318 |
Defect Summary:
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence Summary:
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
-->| NHTSA Campaign Number: | 02V253000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 2039 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:HEAD RESTRAINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010201 - 20020228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 558904 |
| Date Owner Notified By Manufacturer: | 20021108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020917 |
| Record Creation Date: | 20020917 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH REARWARD FOLDING HEAD RESTRAINTS ON THE SECOND ROW SEATS, TWO POTENTIAL PINCH POINTS EXIST ON EACH OF THE FOLDING HEAD RESTRAINTS WHEN THE RESTRAINTS ARE FOLDED REARWARD AS THE SEATBACK IS FOLDED DOWN.
Consequence Summary:
IF A PERSON WERE TO INSERT THEIR FINGER(S) INTO THE PINCH POINT WHEN THE HEAD RESTRAINT FOLDS, IT COULD TRAP AND PINCH THE FINGER(S) CAUSING INJURY.
Corrective Summary:
DEALERS WILL INSTALL PROTECTIVE COVERS OVER THE PINCH POINTS. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR CADILLAC AT 1-800-458-8006.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2002 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 05V379000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 5068 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010101 - 20020831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1353718 |
| Date Owner Notified By Manufacturer: | 20050922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050829 |
| Record Creation Date: | 20050829 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Consequence Summary:
THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05068. GM REVISED THE INVOLVED VEHICLES BY AMENDING THE ORIGINAL 573 REPORT ON OCTOBER 4, 2005. GM REVISED THE ORIGINAL 573 REPORT ON DECEMBER 16, 2005, TO INCLUDE ADDITIONAL STATES AND VEHICLE POPULATION.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2002 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: STRUCTURE
-->| NHTSA Campaign Number: | 03V094000 |
| Vehicle/Equipment Make: | SOUTHERN COMFORT CONVERSIONS |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2002 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000801 - 20030303 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3674 |
| Date Owner Notified By Manufacturer: | 20030307 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | SOUTHERN COMFORT CONVERSIONS |
| Report Received Date: | 20030307 |
| Record Creation Date: | 20030318 |
Defect Summary:
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence Summary:
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
-->| NHTSA Campaign Number: | 02V253000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 2039 |
| Manufacturer Component Description: | SEATS:FRONT ASSEMBLY:HEAD RESTRAINT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 558904 |
| Date Owner Notified By Manufacturer: | 20021108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020917 |
| Record Creation Date: | 20020917 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH REARWARD FOLDING HEAD RESTRAINTS ON THE SECOND ROW SEATS, TWO POTENTIAL PINCH POINTS EXIST ON EACH OF THE FOLDING HEAD RESTRAINTS WHEN THE RESTRAINTS ARE FOLDED REARWARD AS THE SEATBACK IS FOLDED DOWN.
Consequence Summary:
IF A PERSON WERE TO INSERT THEIR FINGER(S) INTO THE PINCH POINT WHEN THE HEAD RESTRAINT FOLDS, IT COULD TRAP AND PINCH THE FINGER(S) CAUSING INJURY.
Corrective Summary:
DEALERS WILL INSTALL PROTECTIVE COVERS OVER THE PINCH POINTS. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR CADILLAC AT 1-800-458-8006.
Notes:
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2001 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: STRUCTURE:BODY
-->| NHTSA Campaign Number: | 00V343000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 84 |
| Manufacturer Component Description: | STRUCTURE:BODY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20000531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 35659 |
| Date Owner Notified By Manufacturer: | 20001116 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20001025 |
| Record Creation Date: | 20001027 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.
Consequence Summary:
THESE GASES COULD FLOW INTO THE PASSENGER COMPARTMENT IF THE PLUG IS MISSING OR LOOSE AND COULD CAUSE POSSIBLE ILLNESS, UNCONSCIOUSNESS, OR DEATH.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLE FOR LOOSE OR MISSING WHEELHOUSE PLUGS AND INSTALL NEW PLUGS IF NECESSARY.
Notes:
OWNER NOTIFICATION BEGAN NOVEMBER 16, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: SERVICE BRAKES, HYDRAULIC:ANTILOCK
-->| NHTSA Campaign Number: | 05V379000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 5068 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000301 - 20010731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1353718 |
| Date Owner Notified By Manufacturer: | 20050922 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050829 |
| Record Creation Date: | 20050829 |
Defect Summary:
CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.
Consequence Summary:
THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05068. GM REVISED THE INVOLVED VEHICLES BY AMENDING THE ORIGINAL 573 REPORT ON OCTOBER 4, 2005. GM REVISED THE ORIGINAL 573 REPORT ON DECEMBER 16, 2005, TO INCLUDE ADDITIONAL STATES AND VEHICLE POPULATION.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: SEAT BELTS:FRONT:RETRACTOR
-->| NHTSA Campaign Number: | 01V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2001 |
| Manufacturer Campaign Number: | 1043 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:RETRACTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000901 - 20001031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 9196 |
| Date Owner Notified By Manufacturer: | 20010702 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010517 |
| Record Creation Date: | 20010522 |
Defect Summary:
VEHICLE DESCRIPTION: PICKUP AND UTILITY TRUCKS. SOME OF THESE VEHICLES HAVE AN INTERNAL COMPONENT IN THE OUTBOARD SEAT BELT RETRACTORS FOR THE 2ND AND 3RD ROW OF SEATS THAT COULD BE CRACKED. WITH REPEATED ACTUATION OF THE LOCKING MECHANISM, THE CRACK COULD SPREAD TO THE POINT SUCH THAT THE SEAT BELT WOULD NO LONGER LOCK.
Consequence Summary:
IN A CRASH, INCREASED OCCUPANT INJURY COULD RESULT FROM THE NO-LOCK CONDITION.
Corrective Summary:
DEALERS WILL INSPECT THE OUTBOARD SEAT BELTS FOR SPECIFIC LOT NUMBERS AND REPLACE THE BELTS IF NECESSARY. GM IS ENCLOSING AN INSPECTION PROCEDURE FOR THE OWNERS TO USE OR THEY CAN HAVE THEIR DEALERS DO THE INSPECTIONS. OWNER NOTIFICATION BEGAN JULY 2, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: EXTERIOR LIGHTING
-->| NHTSA Campaign Number: | 06E026000 |
| Vehicle/Equipment Make: | PRO-A MOTORS, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2001 |
| Manufacturer Component Description: | EXTERIOR LIGHTING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 61944 |
| Date Owner Notified By Manufacturer: | 20060403 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | PRO-A MOTORS, INC. |
| Report Received Date: | 20060323 |
| Record Creation Date: | 20060323 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Notes:
THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: WHEELS:CAP/COVER/HUB
-->| NHTSA Campaign Number: | 07E106000 |
| Vehicle/Equipment Make: | FEDERAL-MOGUL CORPORATION |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2001 |
| Manufacturer Component Description: | WHEELS:CAP/COVER/HUB |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130000 |
| Date Owner Notified By Manufacturer: | 20080207 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | FEDERAL-MOGUL CORPORATION |
| Report Received Date: | 20071217 |
| Record Creation Date: | 20071219 |
Defect Summary:
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Consequence Summary:
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Corrective Summary:
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Notes:
THIS RECALL ONLY PERTAINS TO REPLACEMENT NATIONAL, CARQUEST WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS OR FORD.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: STRUCTURE
-->| NHTSA Campaign Number: | 03V094000 |
| Vehicle/Equipment Make: | SOUTHERN COMFORT CONVERSIONS |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 2001 |
| Manufacturer Component Description: | STRUCTURE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20000801 - 20030303 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3674 |
| Date Owner Notified By Manufacturer: | 20030307 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | SOUTHERN COMFORT CONVERSIONS |
| Report Received Date: | 20030307 |
| Record Creation Date: | 20030318 |
Defect Summary:
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence Summary:
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1999 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: SEAT BELTS:FRONT:WEBBING
-->| NHTSA Campaign Number: | 00V122000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1999 |
| Manufacturer Campaign Number: | 44 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:WEBBING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19980901 - 19990531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 279132 |
| Date Owner Notified By Manufacturer: | 20001229 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20000427 |
| Record Creation Date: | 20000502 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
IN THE EVENT OF A VEHICLE CRASH, THE RIGHT FRONT PASSENGER RESTRAINT SYSTEMS MAY NOT MEET THE NECK EXTENSION REQUIREMENTS.
Corrective Summary:
DEALERS WILL INSTALL A TRAY INSERT ON THE TOP OF THE PASSENGER SIDE OF THE INSTRUMENT PANEL. THE TRAY INSERT CORRECTS THE NONCOMPLIANCE.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 29, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, AND GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1999 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1998 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
-->| NHTSA Campaign Number: | 98V033000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1998 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19971001 - 19971031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1137 |
| Date Owner Notified By Manufacturer: | 19980315 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980217 |
| Record Creation Date: | 19980225 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. ONE OR BOTH FRONT BRAKE ROTOR/HUBS WERE BUILT WITH AN OUT-OF-SPECIFICATION GRAY IRON THAT CAN FAIL DURING THE LIFE OF THE VEHICLE.
Consequence Summary:
IF A DRIVER CONTINUES TO DRIVE WITH A CRACKED ROTOR, THE CRACKS COULD CONTINUE AROUND THE WHEEL MOUNTING BOLT CIRCLE AND ULTIMATELY RESULT IN A WHEEL SEPARATION.
Corrective Summary:
DEALERS WILL INSPECT THE ROTORS FOR A CORE DATE OF "287" AND, IF FOUND, REPLACE THE ROTOR.
Notes:
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1998 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
-->| NHTSA Campaign Number: | 97V142000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1998 |
| Manufacturer Component Description: | STEERING:GEAR BOX (OTHER THAN RACK AND PINION) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19970401 - 19970815 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3957 |
| Date Owner Notified By Manufacturer: | 19970820 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19970829 |
| Record Creation Date: | 19970829 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY EXTENDED-CAB PICKUP TRUCKS AND 4-DOOR UTILITY TRUCKS. THE LOWER STEERING SHAFT TO STEERING GEAR PINCH BOLT IS "FINGER LOOSE" OR MISSING ALLOWING THE BOLT TO LOOSEN AND FALL OUT. THE STEERING SHAFT YOKE CAN WEAR CAUSING AN OFF CENTER STEERING WHEEL.
Consequence Summary:
RELATIVE MOVEMENT BETWEEN THE CHASSIS AND CAB CAN CAUSE THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR. THIS CONDITION CAN RESULT IN A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS ARE ARRANGING TO HAVE THE VEHICLES INVOLVED TOWED TO THE DEALERSHIP AND ALTERNATE TRANSPORTATION IS BEING ARRANGED FOR OWNERS. DEALERS WILL THEN INSPECT THE VEHICLE FOR THE PRESENCE OF A PINCH BOLT AND TORQUE THIS BOLT TO PROPER SPECIFICATIONS.
Notes:
OWNER NOTIFICATION BEGAN AUGUST 20, 1997. OWNERS WHO HAVE NOT BEEN CONTACTED BY THEIR DEALER SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782 AS SOON AS POSSIBLE.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1997 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1997 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 96V057000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1996 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950501 - 19951101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 379004 |
| Date Owner Notified By Manufacturer: | 19960411 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960404 |
| Record Creation Date: | 19960417 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 124 |
Defect Summary:
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Notes:
SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL; FMVSS NO. 124. VEHICLE DESCRIPTION: PICKUP TRUCKS, CAB/CHASSIS, UTILITY AND MULTI-PURPOSE TRUCKS EQUIPPED WITH GASOLINE ENGINES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1996 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 98V150001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 98043 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19960531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1557585 |
| Date Owner Notified By Manufacturer: | 19981215 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980701 |
| Record Creation Date: | 19990211 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence Summary:
THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 15, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1996 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19960601 - 19960930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1996 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: VEHICLE SPEED CONTROL
-->| NHTSA Campaign Number: | 96V057000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1995 |
| Manufacturer Component Description: | VEHICLE SPEED CONTROL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19950501 - 19951101 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 379004 |
| Date Owner Notified By Manufacturer: | 19960411 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19960404 |
| Record Creation Date: | 19960417 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 124 |
Defect Summary:
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Corrective Summary:
DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Notes:
SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL; FMVSS NO. 124. VEHICLE DESCRIPTION: PICKUP TRUCKS, CAB/CHASSIS, UTILITY AND MULTI-PURPOSE TRUCKS EQUIPPED WITH GASOLINE ENGINES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: TAHOE: POWER TRAIN:AUTOMATIC TRANSMISSION
-->| NHTSA Campaign Number: | 95V139000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1995 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940301 - 19941001 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 36641 |
| Date Owner Notified By Manufacturer: | 19950810 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950726 |
| Record Creation Date: | 19950727 |
Defect Summary:
THE TRANSMISSION SHIFT-CABLE LOCK CLIP CAN BACK OUT OF ITS INSTALLED POSITION RESULTING IN A LOSS OF CABLE ADJUSTMENT. WHEN THE SHIFT LEVER IS PLACED IN THE "PARK" POSITION, THE "PARK" INDICATOR LIGHT MAY NOT ILLUMINATE.
Consequence Summary:
THE VEHICLE CAN MOVE UNINTENTIONALLY IF THE DRIVER DOES NOT NOTICE THAT THE INDICATOR LIGHT IS NOT ON AND DOES NOT APPLY THE PARKING BRAKE.
Corrective Summary:
DEALERS WILL ADJUST THE SHIFT CABLE AND INSTALL A LOCK CLIP.
Notes:
SYSTEM: POWERTRAIN; AUTOMATIC TRANSMISSION.VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH M30/MT1 AUTOMATIC TRANSMISSIONS.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME,SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: TAHOE: FUEL SYSTEM, GASOLINE
-->| NHTSA Campaign Number: | 06E043000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1995 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 88303 |
| Date Owner Notified By Manufacturer: | 20061018 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20060519 |
| Record Creation Date: | 20060522 |
Defect Summary:
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Consequence Summary:
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Corrective Summary:
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET FRAM FUEL FILTERS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 98V150001 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1995 |
| Manufacturer Campaign Number: | 98043 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940801 - 19960531 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1557585 |
| Date Owner Notified By Manufacturer: | 19981215 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19980701 |
| Record Creation Date: | 19990211 |
Defect Summary:
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence Summary:
THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Notes:
OWNER NOTIFICATION BEGAN DECEMBER 15, 1998.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: VISIBILITY:WINDSHIELD WIPER/WASHER
-->| NHTSA Campaign Number: | 03V159000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1995 |
| Manufacturer Campaign Number: | 3023 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940401 - 19951130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1755876 |
| Date Owner Notified By Manufacturer: | 20030619 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030428 |
| Record Creation Date: | 20030430 |
Defect Summary:
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence Summary:
IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TAHOE: EQUIPMENT
-->| NHTSA Campaign Number: | 07E088000 |
| Vehicle/Equipment Make: | HONEYWELL INTERNATIONAL, INC. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1995 |
| Manufacturer Component Description: | EQUIPMENT |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 121680 |
| Date Owner Notified By Manufacturer: | 20071108 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | HONEYWELL INTERNATIONAL, INC. |
| Report Received Date: | 20071024 |
| Record Creation Date: | 20071030 |
Defect Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence Summary:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TAHOE: AIR BAGS
-->| NHTSA Campaign Number: | 95V140000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1995 |
| Manufacturer Component Description: | AIR BAGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940401 - 19950401 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3651 |
| Date Owner Notified By Manufacturer: | 19950803 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950725 |
| Record Creation Date: | 19950727 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 208 |
Defect Summary:
THE VEHICLES HAVE BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) LABEL AND AN ENGINE START LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABEL.
Corrective Summary:
THE ENGINE START LABEL WILL BE REMOVED FROM THE STOWED SIDE OF THE SUN VISOR AND A NEW ENGINE START LABEL WILL BE INSTALLED ON THE HEADLINER IN THE SUN VISOR DEPRESSION. OWNERS WILL RECEIVE THE NEW LABEL AND CAN INSTALL THE LABEL THEMSELVES OR HAVE A DEALER INSTALL IT.
Notes:
SYSTEM: INTERIOR; PASSIVE RESTRAINTS; AIR BAG; FMVSS NO.208.VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS AND MULTI PURPOSE PASSENGER VEHICLES EQUIPPED WITH L56/L65 DIESEL ENGINES.NOTE: IF YOU DO NOT RECEIVE A NEW LABEL IN A REASONABLE TIME FREE OF CHARGE PLEASE CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
CHEVROLET: TAHOE: SEAT BELTS:REAR
-->| NHTSA Campaign Number: | 95V081000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TAHOE |
| Model Year: | 1995 |
| Manufacturer Component Description: | SEAT BELTS:REAR |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19940401 - 19941201 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 8323 |
| Date Owner Notified By Manufacturer: | 19950503 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19950424 |
| Record Creation Date: | 19950501 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 210 |
Defect Summary:
VEHICLES FAIL TO CONFORM TO FMVSS NO. 210, "SEAT BELT ANCHORAGES." THE CENTER REAR SEAT LAP BELT WAS IMPROPERLY ROUTED.
Consequence Summary:
CONSEQUENCE OF NON-COMPLIANCE: THE OCCUPANT OF THIS SEAT WILL NOT BE PROPERLY RESTRAINED IN THE EVENT OF A VEHICLE CRASH.
Corrective Summary:
INSTRUCTIONS FOR REROUTING THE CENTER REAR SEAT LAP BELT WILL BE SENT TO THE VEHICLE OWNERS. IF THE OWNER PREFERS, THEY CAN TAKE THEIR VEHICLE TO THEIR DEALER AND HAVE IT REROUTED FREE OF CHARGE BY THE DEALER.
Notes:
SYSTEM: INTERIOR; SEAT BELTS; LAP; FMVSS NO. 210.VEHICLE DESCRIPTION: LIGHT DUTY 4-WHEEL DRIVE, 2-DOOR MULTI-PURPOSE VEHICLE.NOTE: IF YOU DO NOT RECEIVE A LETTER WITH INSTRUCTIONS WITHIN A REASONABLETIME, PLEASE CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETYHOTLINE AT 1-800-424-9393.
--CHEVROLET: TOWNSMAN: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TOWNSMAN |
| Model Year: | 1965 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: TOWNSMAN: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TOWNSMAN |
| Model Year: | 1966 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
-- --CHEVROLET: TOWNSMAN: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TOWNSMAN |
| Model Year: | 1967 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: TOWNSMAN: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TOWNSMAN |
| Model Year: | 1968 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: TOWNSMAN: ENGINE AND ENGINE COOLING:ENGINE
| NHTSA Campaign Number: | 71V235000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TOWNSMAN |
| Model Year: | 1969 |
| Manufacturer Component Description: | ENGINE AND ENGINE COOLING:ENGINE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 6682084 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711229 |
| Record Creation Date: | 19810612 |
Defect Summary:
THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.
Consequence Summary:
UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.
Notes:
SYSTEM: ENGINE.VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT TRUCKS AND VANS.
--CHEVROLET: TOWNSMAN: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TOWNSMAN |
| Model Year: | 1971 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: TOWNSMAN: STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS
| NHTSA Campaign Number: | 73V013000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TOWNSMAN |
| Model Year: | 1972 |
| Manufacturer Component Description: | STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19700801 - 19720701 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 3707064 |
| Date Owner Notified By Manufacturer: | 19730206 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19730124 |
| Record Creation Date: | 19791012 |
Defect Summary:
THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.
Consequence Summary:
INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Corrective Summary:
INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.
Notes:
SYSTEM: STEERING.VEHICLE DESCRIPTION: PASSENGER CARS.
--CHEVROLET: TOWNSMAN: SEAT BELTS:FRONT:ANCHORAGE
| NHTSA Campaign Number: | 71V182000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TOWNSMAN |
| Model Year: | 1972 |
| Manufacturer Component Description: | SEAT BELTS:FRONT:ANCHORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 475 |
| Date Owner Notified By Manufacturer: | 19711011 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19711013 |
| Record Creation Date: | 19791012 |
Notes:
ALL STATION WAGONS.POSSIBILITY THAT THIRD SEAT LAP BELTS MAYNOT BE LONGENOUGH TO MEET REQUIREMENT OF SAFETY STANDARD NO. 208.(CORRECT BYINSPECTING AND REPLACING WITH BELT OF PROP ER LENGTH WHERE NECESSARY.)
--CHEVROLET: TOWNSMAN: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE
| NHTSA Campaign Number: | 75V214000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TOWNSMAN |
| Model Year: | 1976 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 39278 |
| Date Owner Notified By Manufacturer: | 19751223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 19751219 |
| Record Creation Date: | 19791012 |
Notes:
CHEVROLET CAMPAIGN NO 76C04, PONTIAC CAMPAIGN NO. 76C7, OLDSMOBILE CAMPAIGN NO.76C1, BUICK CAMPAIGN NO. 76C1.POSSIBILITY THAT THE COMBINATION VALVE, WHICHIS A PART OF THE HYDRAULIC SERVICE BRAKE SYSTEM MAY HAVE BEEN IMPROPERLYMANUFACTURED AND COULD MALFUNCTION.SHOULD THIS CONDITION OCCUR WHILE VEHICLEIS IN MOTION AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED.A VEHICLECRASH COULD OCCUR WITHOUT PRIOR WARNING.(CORRECT BY INSPECTING AND REPLACINGVALVE WHERE NECESSARY.) PASSENGER CARS AND LIGHT TRUCKS.
-- --CHEVROLET: TRAILBLAZER: STRUCTURE:BODY
| NHTSA Campaign Number: | 02V273000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 2045 |
| Manufacturer Component Description: | STRUCTURE:BODY |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020201 - 20020930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 46 |
| Date Owner Notified By Manufacturer: | 20021004 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20021004 |
| Record Creation Date: | 20021009 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES ARE MISSING WELDS ON THE REAR FLOOR PLAN.
Consequence Summary:
IN A CRASH, MISSING WELDS COULD DEGRADE PERFORMANCE OF THE THIRD ROW SEAT AND SAFETY BELT ANCHORAGE AND OCCUPANTS COULD RECEIVE GREATER INJURIES.
Corrective Summary:
DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF MISSING WELDS ARE FOUND, GM WILL EXCHANGE THE VEHICLE FOR AN EQUIVALENT VEHICLE OR PROVIDE A REFUND OF THE PURCHASE PRICE. OWNER NOTIFICATION BEGAN OCTOBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
GM RECALL NO. 02045.ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: EXTERIOR LIGHTING:BRAKE LIGHTS
| NHTSA Campaign Number: | 04V527000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 4087 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001001 - 20020630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 871473 |
| Date Owner Notified By Manufacturer: | 20041122 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20041101 |
| Record Creation Date: | 20041103 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence Summary:
AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04087. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
| NHTSA Campaign Number: | 01V283000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 1061 |
| Manufacturer Component Description: | POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010801 - 20010828 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 895 |
| Date Owner Notified By Manufacturer: | 20010906 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010905 |
| Record Creation Date: | 20010918 |
Defect Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES (4 WHEEL-DRIVE). SOME OF THESE VEHICLES WERE BUILT WITH A RANGE SHIFT COLLAR IN THE TRANSMISSION TRANSFER CASE THAT CONTAINS CRACKS.
Consequence Summary:
THIS CONDITION COULD RESULT IN A COMPLETE FRACTURE OF THE RANGE SHIFT COLLAR AND SUBSEQUENT LOSS OF VEHICLE FORWARD AND REVERSE GEARS, AND THE INABILITY TO MAINTAIN "PARK" POSITION. THIS INCREASES THE RISK OF A VEHICLE CRASH RESULTING FROM UNINTENDED MOVEMENT OF A PARKED VEHICLE.
Corrective Summary:
DEALERS WILL REPLACE THE TRANSFER CASES AND UPDATE THE CONTROL MODULE CALIBRATION. OWNER NOTIFICATION BEGAN SEPTEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: POWER TRAIN:AUTOMATIC TRANSMISSION
| NHTSA Campaign Number: | 03V075000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 3012 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001001 - 20020630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 511167 |
| Date Owner Notified By Manufacturer: | 20030529 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030306 |
| Record Creation Date: | 20030317 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 114 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN ADDITION, THESE VEHICLES HAVE AN OVERRIDE THAT CAN ALLOW THE TRANSMISSION TO BE SHIFTED OUT OF PARK WITH THE IGNITION IN THE OFF POSITION.
Consequence Summary:
THESE OVERRIDES ARE NOT PERMITTED UNLESS THE VEHICLE HAS A LOCKING STEERING COLUMN.
Corrective Summary:
DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 03012. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
| NHTSA Campaign Number: | 03V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 3039 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001001 - 20020630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1707825 |
| Date Owner Notified By Manufacturer: | 20030820 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030715 |
| Record Creation Date: | 20030724 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence Summary:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 03039.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: EXTERIOR LIGHTING:HEADLIGHTS
| NHTSA Campaign Number: | 06E025000 |
| Vehicle/Equipment Make: | POLI-AUTO, INC. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:HEADLIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1450 |
| Date Owner Notified By Manufacturer: | 20060502 |
| Recall Initiated By: | OVSC |
| Manufacturer Responsible For Recall: | POLI-AUTO, INC. |
| Report Received Date: | 20060321 |
| Record Creation Date: | 20060321 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 108 |
Defect Summary:
CERTAIN POLI-AUTO COMBINATION HEADLAMP ASSEMBLIES, P/NOS. 11-728, 11-728D, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708P, 11-735, 11-725, 11-726, 11-716 (P&C), 11-721-1, 11-733, 11-729, 11-730, AND 11-732, SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence Summary:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Corrective Summary:
POLI-AUTO WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE HEADLAMPS AT ITS ORIGINAL PURCHASE PRICE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2006. OWNERS MAY CONTACT POLI-AUTO AT 305-477-1356.
Notes:
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TRAILBLAZER: FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 02V121000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010901 - 20020228 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 136511 |
| Date Owner Notified By Manufacturer: | 20020920 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020823 |
| Record Creation Date: | 20020829 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES, A FUEL FILTER FITTING CAN BECOME DISCONNECTED. IF THIS WERE TO OCCUR WHILE ATTEMPTING TO START THE ENGINE, A NO-START CONDITION WOULD RESULT AND FUEL WOULD BE PUMPED OUT THE FUEL FILTER ONTO THE GROUND.
Consequence Summary:
IF THE FITTING BECOMES DISCONNECTED WHILE THE VEHICLE IS IN MOTION, THE ENGINE WOULD STOP DUE TO INADEQUATE FUEL SUPPLY AND CAUSE A LOSS OF POWER STEERING ASSIST. IF AN IGNITION SOURCE WERE PRESENT, FUEL LEAKAGE FROM A DISCONNECTED FUEL FILTER FITTING COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE FUEL FILTER QUICK CONNECT RETAINERS. OWNER NOTIFICATION BEGAN SEPTEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: AIR BAGS:FRONTAL
| NHTSA Campaign Number: | 02V222000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 2032 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020501 - 20020731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 133221 |
| Date Owner Notified By Manufacturer: | 20020815 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020809 |
| Record Creation Date: | 20020814 |
Defect Summary:
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence Summary:
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Corrective Summary:
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Notes:
GM RECALL NO. 02032. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: VISIBILITY:WINDSHIELD WIPER/WASHER
| NHTSA Campaign Number: | 04V046000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 4005 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001001 - 20020630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 581394 |
| Date Owner Notified By Manufacturer: | 20040706 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence Summary:
DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04005.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
| NHTSA Campaign Number: | 01V334000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 01064/01065 |
| Manufacturer Component Description: | POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20010101 - 20010831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 78004 |
| Date Owner Notified By Manufacturer: | 20011106 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20011017 |
| Record Creation Date: | 20011031 |
Defect Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE CALIBRATION OF THE TRANSFER CASE CONTROL MODULE COULD CAUSE INSUFFICIENT HIGH SPEED GEAR ENGAGEMENT.
Consequence Summary:
IF THE GEAR IS NOT ENGAGED, THE VEHICLE CAN ROLL WHEN THE TRANSMISSION IS IN "PARK" AND A CRASH COULD RESULT WITHOUT WARNING.
Corrective Summary:
DEALERS WILL UPDATE THE TRANSFER CASE CONTROL MODULE CALIBRATION TO INCREASE GEAR ENGAGEMENT. OWNER NOTIFICATION BEGAN NOVEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
| NHTSA Campaign Number: | 01V126000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 1034 |
| Manufacturer Component Description: | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 19990701 - 19990731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 30476 |
| Date Owner Notified By Manufacturer: | 20010404 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20010412 |
| Record Creation Date: | 20010424 |
Defect Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CIRCUMSTANCES THE FRONT LOWER CONTROL ARM BRACKETS MAY FRACTURE. THIS FRACTURE COULD RESULT IN SEPARATION OF THE FRONT LOWER CONTROL ARM FROM THE FRAME.
Consequence Summary:
A SEPARATION COULD RESULT IN LOSS OF VEHICLE CONTROL, RESULTING IN A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CONTROL ARM BRACKETS. OWNER NOTIFICATION BEGAN BY TELEPHONE ON APRIL 4, 2001. THE FOLLOWUP LETTER TO CONSUMERS WAS MAILED MAY 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR GMC AT 1-800-462-8782.
Notes:
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: SEAT BELTS
| NHTSA Campaign Number: | 04V201000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 4037 |
| Manufacturer Component Description: | SEAT BELTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001001 - 20020131 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 261801 |
| Date Owner Notified By Manufacturer: | 20040624 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040428 |
| Record Creation Date: | 20040429 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 209 |
Defect Summary:
CERTAIN LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." ONE OF THE TWO SENSORS IN THE DRIVER'S AND FRONT PASSENGER'S SEAT BELT RETRACTORS COULD BE INOPERATIVE. THE SEAT BELT RETRACTORS WILL LOCK WHEN THE BELT WEBBING IS EXTRACTED DURING A CRASH; HOWEVER, THE MECHANISM THAT LOCKS THE SEAT BELT RETRACTOR WHEN THE VEHICLE DECELERATES QUICKLY, SUCH AS HEAVY BRAKING, MAY NOT OPERATE AS INTENDED.
Consequence Summary:
IF THIS WERE TO OCCUR, THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, AND COULD RESULT IN INJURY TO THE OCCUPANT.
Corrective Summary:
DEALERS WILL INSPECT THE DRIVER AND FRONT PASSENGER SAFETY BELT RETRACTORS, AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION BEGAN ON JUNE 24, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 04037.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
| NHTSA Campaign Number: | 03V096000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2002 |
| Manufacturer Campaign Number: | 3013 |
| Manufacturer Component Description: | ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20001001 - 20030331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 314300 |
| Date Owner Notified By Manufacturer: | 20030529 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030319 |
| Record Creation Date: | 20030321 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 101 & 208 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARDS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION" AND NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE AN INTERMITTENT CONDITION DURING VEHICLE START-UP IN WHICH THE INSTRUMENT PANEL CLUSTER MAY NOT PROPERLY POWER UP, RESULTING IN MOST OF THE DISPLAYS, TELLTALE LIGHTS, AND FUNCTIONS (EXCEPT THE SERVICE ENGINE LIGHT, TURN SIGNAL INDICATORS, AND THE INSTRUMENT PANEL CLUSTER BACKLIGHTING) BEING INOPERATIVE.
Consequence Summary:
THESE VEHICLES DO NOT COMPLY WITH THE STANDARD.
Corrective Summary:
DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER. OWNER NOTIFICATION BEGAN MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE
| NHTSA Campaign Number: | 03V051000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3008 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020701 - 20021031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130 |
| Date Owner Notified By Manufacturer: | 20030311 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030214 |
| Record Creation Date: | 20030224 |
Defect Summary:
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence Summary:
THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Corrective Summary:
DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
Notes:
GM RECALL NO. 03008. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: EXTERIOR LIGHTING:BRAKE LIGHTS
| NHTSA Campaign Number: | 04V527000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4087 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 871473 |
| Date Owner Notified By Manufacturer: | 20041122 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20041101 |
| Record Creation Date: | 20041103 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence Summary:
AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04087. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: POWER TRAIN:AUTOMATIC TRANSMISSION
| NHTSA Campaign Number: | 03V075000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3012 |
| Manufacturer Component Description: | POWER TRAIN:AUTOMATIC TRANSMISSION |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20020930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 511167 |
| Date Owner Notified By Manufacturer: | 20030529 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030306 |
| Record Creation Date: | 20030317 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 114 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN ADDITION, THESE VEHICLES HAVE AN OVERRIDE THAT CAN ALLOW THE TRANSMISSION TO BE SHIFTED OUT OF PARK WITH THE IGNITION IN THE OFF POSITION.
Consequence Summary:
THESE OVERRIDES ARE NOT PERMITTED UNLESS THE VEHICLE HAS A LOCKING STEERING COLUMN.
Corrective Summary:
DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR HUMMER AT 1-866-486-6376.
Notes:
GM RECALL NO. 03012. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
| NHTSA Campaign Number: | 03V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3039 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1707825 |
| Date Owner Notified By Manufacturer: | 20030820 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030715 |
| Record Creation Date: | 20030724 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence Summary:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 03039.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: AIR BAGS:FRONTAL
| NHTSA Campaign Number: | 02V222000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 2032 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020501 - 20020731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 133221 |
| Date Owner Notified By Manufacturer: | 20020815 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20020809 |
| Record Creation Date: | 20020814 |
Defect Summary:
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence Summary:
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Corrective Summary:
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Notes:
GM RECALL NO. 02032. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: VISIBILITY:WINDSHIELD WIPER/WASHER
| NHTSA Campaign Number: | 04V046000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 4005 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD WIPER/WASHER |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020401 - 20021130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 581394 |
| Date Owner Notified By Manufacturer: | 20040706 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040204 |
| Record Creation Date: | 20040206 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence Summary:
DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective Summary:
DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04005.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
| NHTSA Campaign Number: | 03V151000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3025 |
| Manufacturer Component Description: | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020701 - 20020930 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 44653 |
| Date Owner Notified By Manufacturer: | 20030529 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030423 |
| Record Creation Date: | 20030424 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH A LEFT-FRONT BRAKE PIPE WITH A CIRCUMFERENTIAL SCORE AT A RANDOM LOCATION ALONG THE LENGTH OF THE PIPE AS THE RESULT OF THE MANUFACTURING PROCESS. IF THE BRAKE PIPE PARTIALLY OR FULLY FRACTURED, BRAKE PEDAL TRAVEL WOULD IMMEDIATELY INCREASE AND FRONT BRAKE PERFORMANCE WOULD BE REDUCED.
Consequence Summary:
IF BRAKING PERFORMANCE IS REDUCED, A CRASH COULD OCCUR.
Corrective Summary:
DEALERS WILL REPLACE THE LEFT-FRONT BRAKE PIPE. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-8006.
Notes:
GM RECALL NO. 03025.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: EXTERIOR LIGHTING:TURN SIGNAL
| NHTSA Campaign Number: | 05V198000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 5044 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:TURN SIGNAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030401 - 20030731 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 286478 |
| Date Owner Notified By Manufacturer: | 20050804 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050505 |
| Record Creation Date: | 20050505 |
Defect Summary:
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 05044.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TRAILBLAZER: EXTERIOR LIGHTING:BRAKE LIGHTS
| NHTSA Campaign Number: | 04V527000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4087 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:BRAKE LIGHTS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030401 - 20030831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 871473 |
| Date Owner Notified By Manufacturer: | 20041122 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20041101 |
| Record Creation Date: | 20041103 |
Defect Summary:
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence Summary:
AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 04087. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: TRAILBLAZER: EXTERIOR LIGHTING:TURN SIGNAL
| NHTSA Campaign Number: | 05V198000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 5044 |
| Manufacturer Component Description: | EXTERIOR LIGHTING:TURN SIGNAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030401 - 20031130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 286478 |
| Date Owner Notified By Manufacturer: | 20050804 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050505 |
| Record Creation Date: | 20050505 |
Defect Summary:
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Consequence Summary:
THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Corrective Summary:
DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 05044.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TRAILBLAZER: AIR BAGS:FRONTAL
| NHTSA Campaign Number: | 06V417000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 6102 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20040801 - 20050630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 794 |
| Date Owner Notified By Manufacturer: | 20061106 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20061031 |
| Record Creation Date: | 20061101 |
Defect Summary:
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence Summary:
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Corrective Summary:
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Notes:
GM RECALL NO. 06102.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TRAILBLAZER: VISIBILITY:WINDSHIELD
| NHTSA Campaign Number: | 05V035000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 5002 |
| Manufacturer Component Description: | VISIBILITY:WINDSHIELD |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20041103 - 20041207 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 17815 |
| Date Owner Notified By Manufacturer: | 20050310 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20050203 |
| Record Creation Date: | 20050203 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 212 |
Defect Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING.' THE WINDSHIELD URETHANE BEAD MAY NOT HAVE ADHERED TO THE BODY IN CERTAIN AREAS DURING THE CURE PROCESS.
Consequence Summary:
IF A CRASH OCCURS, THE WINDSHIELD MAY NOT BE RETAINED, INCREASING THE RISK OF INJURY TO A VEHICLE OCCUPANT.
Corrective Summary:
DEALERS WILL REPLACE THE WINDSHIELD FREE OF CHARGE. THE RECALL BEGAN ON MARCH 10, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, OR GMC AT 1-866-996-9463.
Notes:
GM RECALL NO. 05002.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TRAILBLAZER: EQUIPMENT:OTHER:LABELS
| NHTSA Campaign Number: | 05V552000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5109 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050901 - 20050907 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 32068 |
| Date Owner Notified By Manufacturer: | 20060331 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051207 |
| Record Creation Date: | 20051207 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 110 |
Defect Summary:
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence Summary:
A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Notes:
GM RECALL NO. 05109.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TRAILBLAZER: AIR BAGS:FRONTAL
| NHTSA Campaign Number: | 06V417000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 6102 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050701 - 20051130 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 794 |
| Date Owner Notified By Manufacturer: | 20061106 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20061031 |
| Record Creation Date: | 20061101 |
Defect Summary:
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence Summary:
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Corrective Summary:
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Notes:
GM RECALL NO. 06102.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: TRAILBLAZER: STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
| NHTSA Campaign Number: | 05V455000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | TRAILBLAZER |
| Model Year: | 2006 |
| Manufacturer Campaign Number: | 5086 |
| Manufacturer Component Description: | STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20050701 - 20050831 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 123592 |
| Date Owner Notified By Manufacturer: | 20051014 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20051005 |
| Record Creation Date: | 20051006 |
Defect Summary:
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence Summary:
IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Corrective Summary:
DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Notes:
GM RECALL NO. 05086.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
--CHEVROLET: VENTURE: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2005 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: VENTURE: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-->| NHTSA Campaign Number: | 04V597000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2005 |
| Manufacturer Campaign Number: | 4110 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 717302 |
| Date Owner Notified By Manufacturer: | 20050531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20041222 |
| Record Creation Date: | 20041222 |
Defect Summary:
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence Summary:
IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Corrective Summary:
DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 04110.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: VENTURE: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2005 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: VENTURE: EQUIPMENT:OTHER:LABELS
-->| NHTSA Campaign Number: | 04V177000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4022 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:LABELS |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20031001 - 20040331 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 31301 |
| Date Owner Notified By Manufacturer: | 20040723 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20040408 |
| Record Creation Date: | 20040420 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 213 |
Defect Summary:
CERTAIN MINIVANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 213, "CHILD RESTRAINT SYSTEMS." THESE VEHICLES DO NOT HAVE TEXT AND FORMATTING ON THE WARNING LABEL ATTACHED TO THE AVAILABLE SECOND-ROW INTEGRAL CHILD RESTRAINT AS SPECIFIED BY AMENDMENTS TO THE STANDARD.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH REPLACEMENT LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON JULY 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Notes:
GM RECALL NO. 04022.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: VENTURE: FUEL SYSTEM, GASOLINE:STORAGE
-->| NHTSA Campaign Number: | 07V349000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 6230 |
| Manufacturer Component Description: | FUEL SYSTEM, GASOLINE:STORAGE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20030601 - 20031231 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 20594 |
| Date Owner Notified By Manufacturer: | 20071204 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20070808 |
| Record Creation Date: | 20070808 |
Defect Summary:
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence Summary:
A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Summary:
DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
Notes:
GM RECALL NO. 06230.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: VENTURE: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
-->| NHTSA Campaign Number: | 07E021000 |
| Vehicle/Equipment Make: | DELPHI |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2004 |
| Manufacturer Component Description: | FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 742 |
| Date Owner Notified By Manufacturer: | 20070427 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DELPHI |
| Report Received Date: | 20070312 |
| Record Creation Date: | 20070312 |
Defect Summary:
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Consequence Summary:
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Corrective Summary:
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
CHEVROLET: VENTURE: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
-->| NHTSA Campaign Number: | 04V597000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2004 |
| Manufacturer Campaign Number: | 4110 |
| Manufacturer Component Description: | LATCHES/LOCKS/LINKAGES:DOORS:LATCH |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 717302 |
| Date Owner Notified By Manufacturer: | 20050531 |
| Recall Initiated By: | ODI |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20041222 |
| Record Creation Date: | 20041222 |
Defect Summary:
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence Summary:
IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Corrective Summary:
DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 04110.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: VENTURE: STEERING
-->| NHTSA Campaign Number: | 09E005000 |
| Vehicle/Equipment Make: | DORMAN PRODUCTS, INC. |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2004 |
| Manufacturer Component Description: | STEERING |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Type of Report: | E (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 979 |
| Date Owner Notified By Manufacturer: | 20090223 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | DORMAN PRODUCTS, INC. |
| Report Received Date: | 20090217 |
| Record Creation Date: | 20090217 |
Defect Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.
Notes:
THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV .
CHEVROLET: VENTURE: AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE
-->| NHTSA Campaign Number: | 03V051000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3008 |
| Manufacturer Component Description: | AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020701 - 20021031 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 130 |
| Date Owner Notified By Manufacturer: | 20030311 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030214 |
| Record Creation Date: | 20030224 |
Defect Summary:
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence Summary:
THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Corrective Summary:
DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
Notes:
GM RECALL NO. 03008. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: VENTURE: EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
-->| NHTSA Campaign Number: | 03V250000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 3039 |
| Manufacturer Component Description: | EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL |
| Manufacturers Involved in Recall: | GENERAL MOTORS LLC |
| Manufacturered: | 20020301 - 20030630 |
| Type of Report: | V (Vehicle, Equipment or Tire) |
| Potential Number of Units Affected: | 1707825 |
| Date Owner Notified By Manufacturer: | 20030820 |
| Recall Initiated By: | MFR |
| Manufacturer Responsible For Recall: | GENERAL MOTORS CORP. |
| Report Received Date: | 20030715 |
| Record Creation Date: | 20030724 |
| Regulation Part Number: | 571 |
| Federal Motor Vehicle Safety Standard Number: | 225 |
Defect Summary:
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence Summary:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Corrective Summary:
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Notes:
GM RECALL NO. 03039.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
CHEVROLET: VENTURE: AIR BAGS:FRONTAL
-->| NHTSA Campaign Number: | 02V222000 |
| Vehicle/Equipment Make: | GENERAL MOTORS CORP. |
| Vehicle/Equipment Model: | VENTURE |
| Model Year: | 2003 |
| Manufacturer Campaign Number: | 2032 |